BMW Motorrad Maintenance schedule R 1200 C / R 850 C
BMW Maintenance Service every 10000 km/6,000 miles BMW Inspection at 1000 km/ 600 miles BMW Inspection every 20 000/ 12,000 miles km BMW Annual Service

Customer

Licence No.

Mileage

Job Order No.

Mechanics signature

Use BMW MoDiTeC to read stored error codes from fault memory Change engine oil, warmed to normal operating temperature, replace oil filter
when used exclusively in short-distance operation, or at outside temperatures below 0C (32 F), or no later than every 3 months, or every 3,000 km/1,800 miles *)
Change oil in gearbox, with oil warmed to normal operating temperature

at least every 2 years

Change oil in rear wheel drive while at regular operating temperature
every km (miles) or at least every 2 years

Replace fuel filter

Standard replacement interval is 40,000 km/25,000 miles, with substandard fuel quality every 20,000 km/12,000 miles
Check battery electrolyte level, top up with distilled water as necessary Battery terminals, clean and grease as necessary Replace intake air filter element
Replace air filter every 10,000 km/6,000 miles when vehicle is exposed to high levels of dirt and dust, or more frequently as indicated *)
Check front/rear circuit brake fluid Check operation of brake system, inspect for leaks; repair/replace as indicated Check brake pads and discs for wear, replace as required Change brake fluid annually Check clutch operating fluid level Change clutch hydraulic circuit fluid

*) *) *)

Check rear lug bolts to ensure they are tight Check rear wheel bearing play by tilting wheel Check swing arm bearings (no play), adjust as required Check operation of side stand switch Grease the side stand pivot Replace poly-V-belt Inspect spark plugs Replace spark plugs Retorque cylinder heads Check valve clearance and adjust as necessary Check throttle cable for ease of motion, inspect for abrasion and bends, replace as indicated Check cable free travel Check synchronisation and eliminate leaks *) Final inspection with operation assessment and road safety check: Condition of tyres and wheels, rims and spokes if applicable, tyre pressures Clutch, shift mechanism, hand and foot brakes, steering Lighting and signal indicators, warning and indicator lamps, instruments Optional equipment Conduct road test as required
*) Write up on separate invoice; Not part of standard service procedure BMW recommends Castrol
Replace poly-V-belt every 60,000 km/35,000 miles

UX-VS-2, 07.2001