Chassis

Service

Water pump repair kit for Citron, Peugeot, Renault: 56643701

Technical info no. R205

Applies to make/model:
Citron: Peugeot: Renault:
Xantia I,II, 3.0 V6, XM 3.0. V6 24V 406 3.0 24V, 605 3.0 24V Espace III 3.0 V6, Laguna I,I 3.0 24V, Safrane II 3.0 24V
Applies to part no.: No. RUVILLE ref. OE ref. 1. 2. 3. 4. (new) 65986 (old) 65995 none 0829.C5, 9467557280 1201.A6, 9640344280 1201.F2, 9635018180

Applies to engines:

This modication applies to models built before 12.1999. Toothed belt tensioner (OE 0823.07, 9617067480) has been replaced by toothed belt tensioner 56643 (OE 0829.C5, 9467557280). Water pump 65986 (OE 1201.A6, 9640344280) has been replaced by water pump 65995 (OE 1201.F2, 9635018180). Explanation: The remodelled toothed belt tensioner can not be attached to the old water pump 65986 (OE 1201.A6, 9640344280). Remedy: Installation of the water pump 65995 (OE 1201.F2, 9635018180). The water pump design conforms to the new design of the toothed belt tensioner 56643, which is why both parts must be replaced at once. These modications are in line with the requirements of the OE manufacturers. Parts included in the water pump repair kit 56643701: New belt tensioner 56643 and water pump 65995 (including mounting parts).
XFZ (ES9J4), L7X 727, 700, 701, 713
Important note: Adhere to the manufacturers specications at all times!
A technical modication of the belt drive design on vehicles with V6 engine mandates that during normal water pump maintenance or toothed belt replacement, all belt drive components must be replaced!
The corresponding spare parts can be found in our online catalogue at www.ruville.de.
EGON VON RUVILLE GmbH Billbrookdeich Hamburg
Tel.: +73344-0 Fax: +73344-199 info@ruville.de www.ruville.de
TIR206/0.1/11.2008/PDF-GB
Subject to change. Copyright 2008 EGON VON RUVILLE GmbH.

Te c h n i c a l S e r v i c e s B u l l e t i n

Information

The condenser fitted to the new Citroen C5 2008>, with technical reference code CA1542, measures 3mm less in width to 817824 (CA1458). Valeo Service can confirm that both condensers are interchangeable. 817824 reference is maintained but technical code CA1458 is replaced by CA1542. New application for 817824 Citroen New Con.
Technical drawing of CA1458

T.S.B. No.:

AC No. 6 / 08

PRODUCT:

Cimate Control
Citroen C5 Facelift 2004>2008, Citroen New C5 2008>,Citroen C6 3.0i V6 24V Auto, Peugeot 407 (all except 2.2 HDi)

PART No.:

817824
Technical drawing of CA1542

SUBJECT:

Change to technical reference code

June 2008

www.valeoservice.com

Partner of

www.exponentia.org
Enabling a better automotive world
Technical Services Bulletin
The cause of the failure is incorrectly diagnosed as a collapsed/failed bearing, however the real cause of the bearing failure is due to thermal damage caused by a preload fault. When the diaphragm fingers are worn to excess and the bearing face does not have a contact point on the diaphragm fingers, the outer race of the bearing will contact the fingers. This causes the outer race of the bearing to turn, resulting in the carrier becoming hot and subsequently melting. (Image 2).
Image 2 Contact with the fingers is made at this point, resulting in thermal bluing.
Outer race will turn causing carrier to become hot and subsequently melt.
The rear of the bearing will also display evidence of a heavy contact from the release fork seating pads. Heavy impressions can clearly be seen at the point the bearing locates onto the fork. (Image 3)
Heavy/deep impression from fork pads.

Image 3

This is the result of a heavy contact being applied to the bearing from the release fork being partially seized due to worn pivot point bushes and worn release arm cross shaft. A thorough examination of the release mechanism should be carried prior to the refitting of the gearbox. This Issue is addressed in TSB CL005/08. Clutches returned to Valeo that clearly exhibit evidence of bearing preload will not be accepted under warranty.
Valeo Service Providing technical excellence to the independent aftermarket www.valeoservice.com
Valeo Service (UK) Ltd, Heming Road, Washford, Redditch, Worcestershire, B98 0DZ Tel : Fax : 01527 523732