ADJUSTMENT INSTRUCTIONS

Safety Precautions

1. It is safe to adjust after using insulating transformer between the power supply line and chassis input to prevent the risk of electric shock and protect the instrument. 2. Never disconnect leads while the TV receiver is on. 3. Don't short any portion of circuits while power is on. 4. The adjustment must be done by the correct appliances. 5. Unless otherwise noted, set the line voltage to 230Vac 10%, 50Hz. 5. The adjustment of TVshould be performed after warming up for 15 minutes.
L VCO Adjustment (For SECAM-L MODEL)
Test Point Adjust : TP1 : VR122

Test Equipment required

1. 2. 3. 4. 5. RF signal generator (with pattern generator) DC Power Supply Multimeter (volt meter) Oscilloscope Color analyzer
1) Connect the measuring equipment to the Main Board as shown in Fig.1. 2) Set RF frequency and output level of RF SIGNAL GENERATOR as shown Table 1. 3) Turn on S1,S3 and off S2. 2) Adjust VR122 so that the DC Voltage may be 2.4 0.05Vdc.
RF AGC (Automatic Gain Control) Adjustment
Test Point Adjust : TP 2(J15) : VR121
Multimeter or Oscilloscope 1
1) Input PAL-B/G 05 CH. 2) Connect Multimeter to TP2(J15),AGC adjustment point. 3) Adjust VR121 until the voltage of Multimeter becomes 2.5 0.1V.
IC102(KI7805) R108 9V PowerSupply 5V 4.7 Kohm Sohm S2 Q122 JP3 L104 R144 TP1(VCO)

IC101 TDA4470

Screen Voltage Adjustment
0.01uF 7 JP1 38.9MHz (B/G,D/K,I,L) 34.25MHz (SECAM-L')

Test Point Adjust

: CPT Face : Screen Control of FBT

JPohm S1 VR122

Fig. 1 : Connection Diagram of Equipment for PIF Adjustment
1) Tune the RF Modulator to receive a PAL or SECAM signal. 2) Press MIX button on remote controller for Service to get into the Screen Adjust Mode. 3) Adhere the Color Analyzer on the White window of CPT face. 4) Adjust Screen Volume of FBT so that the luminance of White window is FL.
Focus Adjustment PIF (Picture Intermediate Frequency) Adjustment
Test Point Adjust : TP1 : L104 1) Tune the TV set to receive a digital pattern. 2) Adjust the upper Focus volume of FBT for the best focus of vertical line B. 3) Adjust the lower Focus volume of FBT for the best focus of area A. 4) Repeat above step 2) and 3) for the best overall focus. Test Point Adjust : Observing Display : Focus control of FBT
1) Connect the measuring equipment to the Main Board as shown in Fig.1. 2) Set RF frequency and output level of RF SIGNAL GENERATOR as shown Table 1. 3) Turn off S1 and S3 and on S2. 4) Adjust L104 so that the DC voltage may be 2.4 0.05Vdc. System B/G,D/K/I,SECAM-L SECAM-L Frequency 38.9MHz 34.25MHz Modulation OFF OFF Output level 10mVp-p 10mVp-p Adjust L104 VR122

(Table 1)

EP (East-west Parabolar) Adjust so that middle portion of the outermost left and right vertical line looks like parallel with vertical lines of the CPT.
EC (East-west Coner) Adjust so that the vertical line at every 4 corners of the screen looks like parallel with the vertical lines of the CPT. ET (East-west Trapezium) Adjust to make the length of top horizontal line same with it of the bottom horizontal line. POP (POP Position) Adjust until the distance between POP and main picture becomes about 1mm.

Fig. 2

Deflection Data Adjustment (Line SVC-2)
NOTE : How to enter into the Line Service Mode with a remocon. 1.Power off. 2.Press the Red button. 3.Press the Green button. 4.Press the Yellow button. 5.Press the Cyan button. 6.Press the OK button. 7.Power On.
Menu VS VA VL SC HS EW ET
Range 0600H~0900H 0050H~00CFH 0025H~00BFH 0000H~009FH 0000H~003FH 0400H~0EFFH 0700H~08FFH 06E0H~0840H 06A0H~0AFFH 0790H~08E0H 0790H~08E0H

(Table 2)

29 Flat 07D0001 00D9 001E 0A9D 07FF 0850 000B

29 S-Flat

1. Preparation for Deflection Adjustment
1) At SVC mode, press the Yellow colored button the SVC remocon. And then,deflection data adjustment OSD(SVC2 mode) will be displayed. 2) Press Channel UP/DOWN button for desirous function Adjustment. 3) Press Volume UP/DOWN button to adjust the data. 4) Tune the TV set to receive a PAL B/G Digital pattern.

EP ES EC POP P

VL (Vertical Linearity) Adjust so that the boundary line between upper and lower half is in accord with geometric horizontal center of the CPT. VA (Vertical Amplitude) Adjust so that the circle of a digital circle pattern may be located within the effective screen of the CPT. SC (Vertical S Correction) Adjust so that all distance between each horizontal lines are to be the same. VS (Vertical Shift) Adjust so that the horizontal center line of a digital circle pattern is in accord with geometric horizontal center of the CPT. HS (Horizontal Shift) Adjust so that the vertical center line of a digital circle pattern is in accord with geometric vertical center of the CPT. EW (Horizontal Width) Adjust to that a digital circle pattern looks like exact circle.

White Balance Adjustment.(LINE SVC 1)
NOTE : This adjustment should be performed after screen voltage adjustment. 1) Tune the TV set to receive an 100% white pattern. 2) Press the Yellow button on remote controller in the SVC Mode. 3) Press PSM (RED) button on remote controller. (Standard picture) 4) Press PR+ or PR- button for desirous function adjustment. 5) Adjust Low Light status of CR and CB with VOL+ or VOLat CG:50 until X=268 8,Y=273 8. 6) Adjust High Light status of RG and BGB with VOL+ or VOL- at CG:370 until X=268 8,Y=273 8. 7) Repeat above step 5) and 6) until each status of High Light and Low Light for X=288 8,Y=with color analyzer(color temperature 9000oK).

- 10 -

Menu CR CG CB RG GG BG

Range 0 ~ ~ ~ ~ ~ ~ 511

(Table 3)

DATA 370 370

SVC Data & PSM,SSM Data.
Table 1. ABL Data (LINE SVC-3)
Menu DVCO IBRM WDRM BCLTH BCLTM BCLGA SVGA SVDEL SVD1 LDLY HBST HBSO 0~01FF 0~01FF 0~1FFH 0~3FFH 0~7FFH 0~1FFH 0~1FFH 00C0065 000B 0001 00FRange 29 Flat 29 S-Flat
Table 2. SOUND PRE-SCALER (LINE SVC-4)
Menu FP NP SP S1 VOL S2 VOL Range 0~127 0~127 0~127 0~127 0~127 DATA 001E 0042 0042

Table 3. PSM Data

Mode CONTRAST BRIGHT COLOR SHARPNESS STANDARD DYNAMIC MILD GAME 40 30

- 11 -

OPTION Adjustment (LINE-SERVICE OPTION)

Table 4. OPTION Function

Menu OPTION GAME TEXT TOP Option 1 ACMS CH+AU EYE TURBO SCART A2 ST I II SV MONO VOL Option 2 H-PH DGS TILT 200PRO AV2 HOTEL Option 3 KEY SYS M-VOL Option 4 OSD T-LAN H/Phone Degaussing TILT China Only Back:JACK(2EA) HOTEL X Back:JACK(1EA) X X China,Australia EYE Turbo Search SCART STEREO I/II MONO Middle East Africa,India VOL. X X X X X X Normal VOL. 1 GAME TEXT TOP 0 X X X Australia Only

- 12 -

Trouble Shooting
Q05, IC851, IC802(3), IC856. 3.3V ICP(V)01.

pin 32 of IC01. 0V

IC01, FR403, FR413, D405, D406, IC301, ICP(V)01.
IC852(3), IC854(5), FR406, D408, D858, Q856.

ICP(V)01. 33V

F854, D861, R405. (OPTION)

D850, L853, T402.

Q401, Q402, T401.

pin4 18V

F(P)801, SW(P)801, T1111, T801, R802, DB801.

T802, R809, D802.

ICP(V)01.

CPT PCB ASSY.

ICP(V)01, Q124
FR403, FR413, D405, D406.

IC301, D301.

at pin 44 of ICP(V)01. 3V

P502A.

at pin 12 of IC01.

QP(QV)02, ICP(V)01.

at pin 41~43 of ICP(V)01.

ICP(V)01, QP(V)04~06.

Q2902~2910, VM COIL.

IC302.

FR402, D404, IC302.

Q302, Q303.

D401, D402, C405.
pin 10 of IC601(SOUND AMP).
ICN01. ICN01. * AM Sound(for FRENCH) ICN01. 8 ICN01. 5V Q601, IC01. NORMAL Check/Replace XN01, ICN01. Check the Waveform at pin 44 of ICN01. P605(6)A, ICN02. IC601. 1, 3 ICN02.

F851, FB853, D850.

IC601, QN01~02, P605(6)A.
NO Check the voltage at pin 3 of IC101.
XN01, ICN01. Z102, Z103, IC101.

Z102, IC101.

NO PIP
No 7 Check/Replace ICP101. Check I2C Bus. No 12 L102 Check CP131.
Is there video signal at pin 13 of ICP101? Yes Is there video signal at pin 28 of ICP102? Yes

F854, D861, R104, ZD101.

Abnormal Check/Replace ICP102. Check I2C BUS.
Check pins15~18 of ICP102.

ICP(V)01

Normal Abnormal Check pins45~48 of ICP01. Normal Check RP108, 109, 110, 112, 114, CP17~19. Check/Replace ICP01.

15 IC01 ICP(V)01, Q124.

Check/Replace IC01, IC02. Check I2C BUS.
PREAMP. LOCAL KEY ST-BY 5V 3.3 V REG IC04 (OPTION) 13V 9V 9V REG IC852/3 5V REG IC851 TILT HIC181
IR 28 S-VIDEO SEL. SDA SCL

EYE SENSOR

AC_IN 110~240V

H/P V3 Y/V3 C

AV3-IN

S-Video IN

ST_BY(2W) POWER
TVTXT(MICOM + TEXT) SDA5555/5521 IC01
TXT RGB 38/39/40/41 CVBS 12
AUDIO AMP LA4282 IC601 RGB OUT
59 34/37/38/39 VM & RGB H-out 50 Va 31 EW SCL 4 SDA EXT.RGB_IN 45/46/47/48 RGB Y/C IN & V1/2/3/4 60/61/62/63/64 41/42/43/44 TXT RGB SDA0 SCL0
CPT DRIVE AMP. TDA6101Q * 3 IC901/2/3

5V 5V REG IC854/5

EEPROM 24C16 IC02
POWER CTL. STR-F6656 IC801

SOUND Vcc TUNER 33V B+

VCD PROCESSOR VDP3120

PIP or VCD BOARD

RF/V1/V2/V3 13V

V_DY VA

Block Diagram
SDA0 SCL0 EXT. RGB V2(MNT) OUT

PIP IC SDA9489

A/V S/W CXA2040Q
VERTICAL AMP LA7845/40 IC301

ICN02 TDA2822M

HP Amp. 24/25 21/22

SOUND BOARD

KIA4558

-14V HV

K3958M / K6263K(w/M) RF OUT OTHER L (M) V1(TV) OUT SAW I L9654M L/L S/W 28 SiF2 SiF1 K9350M / K9253M(w/M) SAW SAW 6 ViF 14 V_SW 24 FM

5V 33V

A3_IN 47 44
Sound Processor MSP3410D/3460G ICN01
A1_OUT A1_IN A2_OUT A2_IN 40 39
HDT H-OUT LA7016 DYNAMIC FOCUS

FOCUS V/M

FBT T402

SCREEN 210V

SDA SCL 23 5V
25 VIF/SIF IC101 TDA4470 AM S_SW V_SW AM

GAME SOUND FM

R(0) L(0) R(I) L(I)
R(0) L(0) R(I) L(I) AV1_SCART/PHONE AV2_SCART/PHONE

D-FOCUS BOARD

Video Audio C
P/No : 3854VA0071A-S1 2000.06.15
P/No : 3854VA0071A-S2 2000.06.15

EXPLODED VIEW

104 520

- 14 -

EXPLODED VIEW PARTS LIST
LOCA. NO PART NO DESCRIPTIONS
The components identified by mark critical for safety. Replace only with part number specified.
343-B52A 112-C28G 120-C77K 6140VC2001G 170-844J 3106V00073H 5020V00226A 320-062J 320-062C 5020V00227A 3809V00099D 6871VSM728B 6871VMM635F 6871VSM819A 6871VSM589A 6871VSM842A 332-229B 1PTF0403116 174-009U 174-224G
SUPPORTER,PCB CPT SET,A66EAK071*11(PHILIPS)28 SPEAKER,GENERAL C122P02K145E 8 OHM COIL,DEGAUSSING CU 28 50TURN 14 OHM. LEAD SET,CPT EARTH CABINET UNIT MA LOCAL BUTTON,CONTROL 4KEY SPRING,KNOB SPRING,KNOB BUTTON,POWER BACK COVER ASSY MA LOCAL PWB ASSY,CPT 28 PHILPS,STV5109 SE PWB ASSY,MAIN 007A PWB ASSY,007A VCD W/O(PIP,SVHS & S PWB ASSY,STRO MC007A RF ST.W/ H_PHONE PWB ASSY,CURRENT HARMONICS STANDARD SCREW DRAWING ASSY,HEXAGON HEAD SPECIAL SCREW,TAP TITE(P) D4.0 L16.0 MSWR3/FZB CORD,POWER(W/HOLD,HOUSING)L=350,4.0 POWER CORD ASSY

- 15 -

The components identified by mark are critical for safety. Replace only with part number specified.

REPLACEMENT PARTS LIST

DESCRIPTION LOCA. NO D852 D853 PART NO 0DD060009AC 0DD060009AC 0DD060009AC 0DD060009AC 0DD414809ED 0DD414809ED 0DD420000BB 0DR060009AA 0DD414809ED 0DD414809ED 0DD414809ED 0DD414809ED 0DD414809ED 0DD414809ED 0DD400309AD 0DD414809ED 0DD414809ED 0DD414809ED 0DD560000AA 0DD414809ED 0DD414809ED 0DD414809ED 4930V00048A 0DZ820009AH 0DZ330009BA 0DZ330009CC 0DZ680009BB 0DZ680009BB 0DZ180009BE 0DZ560009AH 0DZ180009BE 0DZ510009AB 0DZ510009AB 0DZ180009BE DESCRIPTION DIODE,TVR06J 0.6A/600V 250NS DIODE,TVR06J 0.6A/600V 250NS DIODE,TVR06J 0.6A/600V 250NS DIODE,TVR06J 0.6A/600V 250NS DIODE,1N4148 TA DIODE,1N4148 TA DIODE,D4L20U SHINDENGEN DIODE,RECTIFIER TVR06J TP DIODE,1N4148 TA DIODE,1N4148 TA DIODE,1N4148 TA DIODE,1N4148 TA DIODE,1N4148 TA DIODE,1N4148 TA DIODE,RECTIFIER IN4003A RECT K-ROHM TP DIODE,1N4148 TA DIODE,1N4148 TA DIODE,1N4148 TA DIODE,RECTIFIER D5SB60 BRIDGE(5A/600V) DIODE,1N4148 TA DIODE,1N4148 TA DIODE,1N4148 TA HOLDER,DIODE LED ASSY DIODE,ZENER MTZJ8.2B TP ROHM-K DIODE,ZENER HZT33(TP) HITACHI DIODE,ZENER MTZJ3.3B TP ROHM-K DIODE,ZENER MTZJ6.8B TP ROHM-K DIODE,ZENER MTZJ6.8B TP ROHM-K DIODE,ZENER GDZJ18B TP GRANDE D DIODE,ZENER GDZJ5.6B TP GRANDE DIODE,ZENER GDZJ18B TP GRANDE D DIODE,ZENER MTZ5.1B,TP(52MM),RO DIODE,ZENER MTZ5.1B,TP(52MM),RO DIODE,ZENER GDZJ18B TP GRANDE D

LOCA. NO

PART NO
D850 ICV01 ICN01 IC01 IC02 ICV02 ICN02 IC03 ICN03 IC04 ICN05 IC101 IC102 IC301 IC302 IC601 IC801 IC803 IC851 IC853 IC855 IC856 IC901 Q07 Q08 0ISK100300A 0IIT312000A 0IIT341000J 0ISM555000B 0ICTMIH001A 0ICTMIH002A 0IAL241610B 0IFA754207A 0ISG282200A 0IFA752700A 0IKE780500Q 0ISG111733B 0IFA753307A 0ITF447000A 0IKE780500Q 0ISA784070A 0IKE455800E 0ISA428200A 0ISK665613B 0ILI817000G 0IKE780500Q 0ISH092100B 0ISS278050A 0ISK140000A 0ISG510900A 0IFA270000A 0IFA270000A IC,SLA1003 SIP12 BK DIODE MODULE( IC,VDP3120B 64P SDIP BK VCD IC (5 IC,MSP3410D-C5 52P SDIP BK MULTI IC,SDA555XFL 52DIP ST FLASH MEMOR IC,SDA5555-A006(LG8003-28A) W/TXT from2001.2 IC,SDA5525-A004(LG8003-29A) W/O TXT from2001.2 IC,AT24C16-10PC-2.7 8PIN DIP ST E IC,KA75420ZTA(KA7542ZTA) 3P,TO-92 IC,TDA2822M 8D DUAL AUDIO AMP(1W) IC,KA75270Z 3 TP RE-SET IC MC-007 IC,KIA7805API 3P TO-220 ST REGULA IC,LD1117V33C 3SIP ST REGULATOR IC,KA75330ZTA(KA7533ZTA) 3P,TO-92 IC,TDA4470M 28P,SDIP BK VIF+SIF IC,KIA7805API 3P TO-220 ST REGULA IC,LA7840 7S VERTICAL IC,KIA4558 8DIP DUAL OP AMP IC,LA4282 12S 2CHX10W AUDIO AMP IC,STR-F6656(LF1352) 5P,SIP BK ST IC,LTV817M-VB 4P,DIP BK PHOTO COU IC,KIA7805API 3P TO-220 ST REGULA IC,PQ09RD21 4SIP ST REGULATOR IC,KA278R05 4P,TO-220F BK LOW DRO IC,SE140N 3P 130V ERROR AMP IC,STV5109 15SIP ST RGB DRIVE IC,2N7000TA TO-92, 3P TP LEVEL SH IC,2N7000TA TO-92, 3P TP LEVEL SH
D854 D855 D856 D857 D859 D861 D863 D864 D865 D901 D902 D903 D904 D905 D906 D907 DB801 DV01 DV02 DV03 LD01 ZDN01 ZD101 ZD201 ZD202 ZD203 ZD301 ZD302 ZD303
D01 D02 D03 D04 D101 D301 D302 D401 D402 D403 D404 D405 D406 D407 D408 D412 D601 D602 D802 D803 D804 D851 0DD414809ED 0DD414809ED 0DD414809ED 0DD414809ED 0DD414809ED 0DD150009CE 0DD247109AA 0DD410000AC 0DD410000AD 0DD150009CA 0DR150009AB 0DR150009AB 0DR150009AB 0DD414809ED 0DD100009AE 0DD414809ED 0DD414809ED 0DD414809ED 0DR060009AA 0DD100009AM 0DD414809ED 0DD060009AC DIODE,1N4148 TA DIODE,1N4148 TA DIODE,1N4148 TA DIODE,1N4148 TA DIODE,1N4148 TA DIODE,RECTIFIER GP15J TP(1.5A/600V) DIODE,DETECTOR 1S2471DETECT SW DIODE,RECTIFIER RU4DS,LF-L1 DIODE,RECTIFIER RU4AM,LF-L1 DIODE,RECTIFIER RGP15J,TP(52MM) DIODE,RECTIFIER RGP15G TP DIODE,RECTIFIER RGP15G TP DIODE,RECTIFIER RGP15G TP DIODE,1N4148 TA DIODE,RECTIFIER RU1A V(1) TP DIODE,1N4148 TA DIODE,1N4148 TA DIODE,1N4148 TA DIODE,RECTIFIER TVR06J TP DIODE,RECTIFIER EU1ZV(1) TP DIODE,1N4148 TA DIODE,TVR06J 0.6A/600V 250NS

ZD401 ZD402 ZD901

TRANSISTOR
Q02 Q03 Q04 Q05 Q06 Q123 Q125 Q126 Q201 Q221 Q301 Q302 Q303 Q401 Q402 Q601 Q851 0TR945009AA 0TR102009AB 0TR945009AA 0TR102009AB 0TR126609AA 0TR733009AA 0TR319709AB 0TR945009AA 0TR733009AA 0TR733009AA 0TR945009AA 0TR205900AB 0TR127409AB 0TR258100AA 0TR223800AA 0TR733009AA 0TR945009AA TR,KSC945C-Y TP SAMSUNG TR,KRC102M,TP(KRC1202),KEC TR,KSC945C-Y TP SAMSUNG TR,KRC102M,TP(KRC1202),KEC TR,KTA1266-TP-Y (KTA1015) KEC TR,KSA733C-Y TP SAMSUNG TO-92 TR,KTC3197,TP(KTC388A),KEC TR,KSC945C-Y TP SAMSUNG TR,KSA733C-Y TP SAMSUNG TO-92 TR,KSA733C-Y TP SAMSUNG TO-92 TR,KSC945C-Y TP SAMSUNG TR,KTD2059-Y TO-220IS KEC TR,KTA1274-Y TO-92L TP KEC TR,2SD2581 BK SANYO TO3P TR,KTC2238A-Y TR,KSA733C-Y TP SAMSUNG TO-92 TR,KSC945C-Y TP SAMSUNG

- 16 -

For Capacitor & Resistors, the charactors at 2nd and 3rd digit in the P/No. means as follows;
CC, CX, CK, CN : Ceramic CQ : Polyestor CE : Electrolytic
RD : Carbon Film RS : Metal Oxide Film RN : Metal Film RF : Fusible
The components identified by mark are critical for safety. Replace only with part number specified. LOCA. NO C106 C108 C109 C110 C112 C113 C115 C121 C122 C125 C126 C127 C128 C129 C130 C131 C132 C134 C135 C136 C137 C138 C139 C140 C141 C147 C148 C149 C183 C201 C202 C203 C204 C205 C206 C207 C208 C209 C221 C222 C223 C224 C225 C226 C227 C228 C229 C230 C241 C244 C245 C249 PART NO 0CX3300K409 0CE106DF618 0CE335DK618 0CN1040K949 0CN1020K519 0CE476DD618 0CN1030F679 0CN1030F679 0CN1030F679 0CN1040K949 0CN1030F679 181-007H 0CE106DF618 0CN1030F679 0CSZVTA001F 0CN1030F679 0CN1030F679 0CE476DD618 0CN1040K949 0CE226DF618 181-007H 0CN1040K949 0CE104DK618 0CN1030F679 0CE107DD618 0CX4700K409 0CX4700K409 0CE106DF618 0CE108DF618 0CE227DF618 0CN1010K519 0CN4710K519 0CN4710K519 0CN1010K519 0CN4710K519 0CN4710K519 0CE226DF618 0CE226DF618 0CE476DF618 0CE227DF618 0CN1010K519 0CN4710K519 0CN4710K519 0CN1010K519 0CN4710K519 0CN4710K519 0CE226DF618 0CE226DF618 0CX4700K409 0CN1010K519 0CN1010K519 0CN1030F679 DESCRIPTION 33P 50V J SL TA52 10UF STD 16V M FL TP5 3.3UF STD 50V 20% FL TP 5 0.1M 50V Z F TA52 1000P 50V K B TA52 47UF STD 10V 20% FL TP 5 10000P 16V M Y TA52 10000P 16V M Y TA52 10000P 16V M Y TA52 0.1M 50V Z F TA52 10000P 16V M Y TA52 MPE ECQ-V1H474JL3(TR), 50V 0.4 10UF STD 16V M FL TP5 10000P 16V M Y TA52 TAP684K035BRS(AMMO)35V 0.68UFK 10000P 16V M Y TA52 10000P 16V M Y TA52 47UF STD 10V 20% FL TP 5 0.1M 50V Z F TA52 22UF STD 16V M FL TP5 MPE ECQ-V1H474JL3(TR), 50V 0.4 0.1M 50V Z F TA52 0.1000UF STD 50V M FL TP5 10000P 16V M Y TA52 100UF STD 10V M FL TP5 47P 50V J SL TA52 47P 50V J SL TA52 10UF STD 16V M FL TP5 1000UF STD 16V M FL TP5 220UF STD 16V M FL TP5 100P 50V K B TA52 470P 50V K B TA52 470P 50V K B TA52 100P 50V K B TA52 470P 50V K B TA52 470P 50V K B TA52 22UF STD 16V M FL TP5 22UF STD 16V M FL TP5 47UF STD 16V M FL TP5 220UF STD 16V M FL TP5 100P 50V K B TA52 470P 50V K B TA52 470P 50V K B TA52 100P 50V K B TA52 470P 50V K B TA52 470P 50V K B TA52 22UF STD 16V M FL TP5 22UF STD 16V M FL TP5 47P 50V J SL TA52 100P 50V K B TA52 100P 50V K B TA52 10000P 16V M Y TA52

LOCA. NO Q852 Q853 Q857 Q901 QN01 QN02 QV01 QV02 QV03 QV07 QV08 QV09 QV10 QV11 QV12 QV13 QV14 QV15
PART NO 0TR322709AA 0TR945009AA 0TR320209AA 0TR126609AA 0TR150400BA 0TR150400BA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR387500AA 0TR150400BA 0TR387500AA 0TR387500AA 0TR150400BA 0TR387500AA 0TR387500AA 0TR150400BA
DESCRIPTION TR,KTC3227-Y,TP(KTC1627A),KEC TR,KSC945C-Y TP SAMSUNG TR,KTC3202-TP-Y (KTC1959)KEC TR,KTA1266-TP-Y (KTA1015) KEC TR,CHIP 2SA1504S(ASY) KEC TR,CHIP 2SA1504S(ASY) KEC TR,CHIP 2SC3875S(ALY) KEC TR,CHIP 2SC3875S(ALY) KEC TR,CHIP 2SC3875S(ALY) KEC TR,CHIP 2SC3875S(ALY) KEC TR,CHIP 2SC3875S(ALY) KEC TR,CHIP 2SA1504S(ASY) KEC TR,CHIP 2SC3875S(ALY) KEC TR,CHIP 2SC3875S(ALY) KEC TR,CHIP 2SA1504S(ASY) KEC TR,CHIP 2SC3875S(ALY) KEC TR,CHIP 2SC3875S(ALY) KEC TR,CHIP 2SA1504S(ASY) KEC

CAPACITOR

C01 C02 C03 C04 C05 C06 C08 C09 C10 C11 C12 C14 C17 C18 C19 C20 C21 C22 C24 C25 C26 C27 C29 C30 C31 C32 C33 C34 C101 C103 C104 C105 0CE476DD618 0CN1030F679 0CX6200K409 0CX6200K409 0CN1030F679 0CE107DD618 0CN1030F679 0CN1030F679 0CE106DK618 0CE106DK618 181-007D 0CN1040K949 0CN1010K519 0CE476DF618 0CE475DK618 0CE476DD618 0CE107DD618 0CN1030F679 0CE225DK618 0CN1020K519 0CC3300K415 0CC3300K415 0CN1030F679 0CE106DK618 0CE106DK618 0CN1030F679 0CN1030F679 0CN1030F679 0CE476DK618 0CN1030F679 0CE227DD618 0CX3300K409 47UF STD 10V 20% FL TP 5 10000P 16V M Y TA52 62P 50V J SL TA52 62P 50V J SL TA52 10000P 16V M Y TA52 100UF STD 10V M FL TP5 10000P 16V M Y TA52 10000P 16V M Y TA52 10UF STD 50V M FL TP5 10UF STD 50V M FL TP5 MPE ECQ-V1H154JL3(TR), 50V 0.1 0.1M 50V Z F TA52 100P 50V K B TA52 47UF STD 16V M FL TP5 4.7UF STD 50V 20% FL TP 5 47UF STD 10V 20% FL TP 5 100UF STD 10V M FL TP5 10000P 16V M Y TA52 2.2UF STD 50V 20% FL TP 5 1000P 50V K B TA52 33P 33P 50V 50V J NP0 TP J NP0 TP
10000P 16V M Y TA52 10UF STD 50V M FL TP5 10UF STD 50V M FL TP5 10000P 16V M Y TA52 10000P 16V M Y TA52 10000P 16V M Y TA52 47UF STD 50V M FL TP5 10000P 16V M Y TA52 220UF STD 10V M FL TP5 33P 50V J SL TA52

- 17 -

The components identified by mark are critical for safety. Replace only with part number specified. LOCA. NO C302 C303 C304 C305 C306 C307 C308 C309 C310 C311 C401 C402 C403 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C416 C417 C419 C420 C421 C422 C517 C518 C519 C520 C601 C602 C603 C604 C605 C606 C607 C608 C609 C610 C611 C612 C613 C614 C802 C803 C804 C806 PART NO 0CQ3341N401 0CE107BK618 0CQ6821N509 0CQ1021N509 0CQ1031N509 0CQ1031N509 0CE476DJ618 0CN4710K519 0CQ1031N509 0CQ1031N509 0CE474DK618 0CE475DK618 0CK2220W515 181-014P 181-091G 181-010A 0CE5651K652 0CK2220W515 0CE106BR618 181-013Z 0CK6810W515 0CE107DJ618 181-091P 0CE108BH618 181-009R 0CK2710W515 0CE108DH618 181-010B 0CK2710W515 0CE106DR618 0CQ1531N509 0CQ1531N509 0CQ1531N509 0CN1030F679 0CE107DH618 0CE684DK618 0CQ5621N509 0CE107DH618 0CE684DK618 0CQ5621N509 0CE107DH618 0CQ1041N509 0CE477DJ618 0CQ1041N509 0CE477DJ618 0CN1040K949 0CE477DK618 0CE477DH618 0CQZVBK002D 181-091G 181-001F 181-011C DESCRIPTION 0.33U 100V J POLY F5

10UF STD 250V M FL TP5 0.015U 100V K POLY 0.015U 100V K POLY 0.015U 100V K POLY 10000P 16V M Y TA52 100UF STD 25V M FL TP5 0.68UF STD 50V 20% FL TP 0.0056U 100V K POLY 100UF STD 25V M FL TP5 0.68UF STD 50V 20% FL TP 0.0056U 100V K POLY 100UF STD 25V M FL TP5 0.1U 100V K POLY
470UF STD 35V 20% FL TP 0.1U 100V K POLY
470UF STD 35V 20% FL TP 0.1M 50V Z F TA52 470UF STD 50V 20% FL TP 470UF STD 25V M FL TP5 A.C 275V 0.47UF K (S=22. DE0907-486 R 471K 2KV T CE 400V 220UF M LUG (85) PP 1600V 0.0015UF J

- 18 -

The components identified by mark are critical for safety. Replace only with part number specified. LOCA. NO FB803 FB852 FB853 FB902 FB903 PART NO 125-022K 125-022K 125-022K 125-022K 125-022K DESCRIPTION CORE (CIRC),FERRITE 1UH TAPING CORE (CIRC),FERRITE 1UH TAPING CORE (CIRC),FERRITE 1UH TAPING CORE (CIRC),FERRITE 1UH TAPING CORE (CIRC),FERRITE 1UH TAPING
LOCA. NO CN24 CN29 CN30 CN32 CN34 CN35 CN36 CN37 CN38 CN39 CN40 CN41 CN42 CN43 CN44 CN45 CN46 CN47 CN49 CN50 CN53 CN54 CN59 CV06 CV10 CV11 CV12 CV14 CV16 CV20 CV29 CV31 CV36 CV38 CV40 CV41 CV42 CV43 CV44 CV45 CV46 CV63
PART NO 0CE476DF618 0CE106DF618 0CE106DF618 0CE107DF618 0CE106DF618 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CE106DF618 0CK224DF56A 0CK224DF56A 0CE106DF618 0CX5600K409 0CE107DF618 0CE106DF618 0CE335DK618 0CQ3321N509 0CQ3331N509 0CE106DF618 0CE335DK618 0CE106DF618 0CE476DF618 0CE106DF618 0CE106DF618 0CE106DF618 181-007H 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CK224DF56A 0CE226DF618
DESCRIPTION 47UF STD 16V M FL TP5 10UF STD 16V M FL TP5 10UF STD 16V M FL TP5 100UF STD 16V M FL TP5 10UF STD 16V M FL TP5 220000PF 2012 16V 10% R/ 220000PF 2012 16V 10% R/ 220000PF 2012 16V 10% R/ 220000PF 2012 16V 10% R/ 220000PF 2012 16V 10% R/ 220000PF 2012 16V 10% R/ 220000PF 2012 16V 10% R/ 220000PF 2012 16V 10% R/ 220000PF 2012 16V 10% R/ 220000PF 2012 16V 10% R/ 220000PF 2012 16V 10% R/ 220000PF 2012 16V 10% R/ 10UF STD 16V M FL TP5 220000PF 2012 16V 10% R/ 220000PF 2012 16V 10% R/ 10UF STD 16V M FL TP5 56P 50V J SL TA52 100UF STD 16V M FL TP5 10UF STD 16V M FL TP5 3.3UF STD 50V 20% FL TP 0.0033U 100V K POLY 0.033U 100V K POLY 10UF STD 16V M FL TP5 3.3UF STD 50V 20% FL TP 10UF STD 16V M FL TP5 47UF STD 16V M FL TP5 10UF STD 16V M FL TP5 10UF STD 16V M FL TP5 10UF STD 16V M FL TP5 MPE ECQ-V1H474JL3(TR), 50V 0.4 220000PF 2012 16V 10% R/TP X7R 220000PF 2012 16V 10% R/TP X7R 220000PF 2012 16V 10% R/TP X7R 220000PF 2012 16V 10% R/TP X7R 220000PF 2012 16V 10% R/TP X7R 220000PF 2012 16V 10% R/TP X7R 22UF STD 16V M FL TP5

COIL & TRANSFORMER

J29 J51 J122 L01 L02 L101 L102 L103 L104 L122 L123 L126 L201 L202 L203 L204 L221 L222 L223 L224 L241 L242 L245 L246 L401 L403 L851 L853 L901 LN01 LN03 LN05 LN06 LN07 LN08 LV01 LV02 LV03 LV05 T401 T402 T801 T802 T803 0LA0102K119 0LA0182K119 0LA1000K119 0LA1000K119 0LA0102K119 150-C01D 0LA1000K139 0LA0102K119 150-E11G 0LA0681K119 150-C01C 0LA0102K119 0LA0102K119 0LA0102K119 0LA0102K119 0LA0102K119 0LA0102K119 0LA0102K119 0LA0102K119 0LA0102K119 0LA0102K119 0LA0102K119 0LA0102K119 0LA0102K119 150-717K 150-L02Z 0LA1000K139 150-C02F 0LA0102K139 0LA0102K119 0LA1000K119 0LA1000K119 0LA0102K119 0LA0102K119 0LA0102K119 0LA0102K119 0LA0102K119 0LA0471K119 0LA0471K119 151-C02F 6174Z-6012T 6170VZ0008A 6170VMCB01F 151-D02G INDUCTOR,10UH K INDUCTOR,18UH K INDUCTOR,100UH K INDUCTOR,100UH K INDUCTOR,10UH K COIL,CHOKE 0.55UH INDUCTOR,100UH K INDUCTOR,10UH K 2 COIL,IFT 38.9MHZ 1PF INDUCTOR,6.8UH K COIL,CHOKE 0.48UH INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K COIL,CHOKE 1.1UH COIL,LINEARITY 27 0.45 64.5 INDUCTOR,100UH K COIL,CHOKE 82UH R1217 INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,100UH K INDUCTOR,100UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,10UH K INDUCTOR,4.7UH K INDUCTOR,4.7UH K TRANSFORMER,H-DRIVE,EI-19,BULK FBT,FTMPN51 -T6012T TRANSFORMER,TS4841 30500UH TRANSFORMER,SMPS EER5345 290UH 150V TRANSFORMER,STAND-BY EER3541 0UH

- 21 -

The components identified by mark are critical for safety. Replace only with part number specified. LOCA. NO R913 R914 R915 R916 R917 R918 R919 R920 R921 R922 R924 R925 R930 R931 R932 RN01 RN02 RN03 RN11 RN14 RN17 RN18 RN19 RN20 RN21 RN22 RN23 RV02 RV03 RV06 RV07 RV15 RV16 RV34 VR121 PART NO 0RD0562F609 0RD0562F609 0RD4701F609 0RD4701F609 0RD4701F609 0RCZVTA002B 0RCZVTA002B 0RCZVTA002B 0RD3001F609 0RD3301F609 0RD8200F609 0RD5100F609 0RS6802K607 0RS6802K607 0RS6802K607 0RD1000F609 0RD1000F609 0RD1002F609 0RD0271H609 0RD0271H609 0RD0912F609 0RD1001F609 0RD1001F609 0RD1001F609 0RD1001F609 0RD1001F609 0RD1001F609 0RD1000F609 0RD1000F609 0RD1002F609 0RD1002F609 0RD2201F609 0RD1001F609 0RD3300F609 180-F03H DESCRIPTION 56 OHM 1/6 W 5.00% TAOHM 1/6 W 5.00% TA52 4.7K OHM 1/6 W 5.00% TA52 4.7K OHM 1/6 W 5.00% TA52 4.7K OHM 1/6 W 5.00% TA52 1.0K OHM 1/2W 10% TA52 PILKOR( 1.0K OHM 1/2W 10% TA52 PILKOR( 1.0K OHM 1/2W 10% TA52 PILKOR( 3K OHM 1/6 W 5.00% TA52 3.3K OHM 1/6 W 5.00% TAOHM 1/6 W 5.00% TAOHM 1/6 W 5.00% TA52 68K OHM 2 W 5.00% TA62 68K OHM 2 W 5.00% TA62 68K OHM 2 W 5.00% TAOHM 1/6 W 5.00% TAOHM 1/6 W 5.00% TA52 10K OHM 1/6 W 5.00% TA52 2.7 OHM 1/2 W 5.00% TA52 2.7 OHM 1/2 W 5.00% TAOHM 1/6 W 5.00% TA52 1K OHM 1/6 W 5.00% TA52 1K OHM 1/6 W 5.00% TA52 1K OHM 1/6 W 5.00% TA52 1K OHM 1/6 W 5.00% TA52 1K OHM 1/6 W 5.00% TA52 1K OHM 1/6 W 5.00% TAOHM 1/6 W 5.00% TAOHM 1/6 W 5.00% TA52 10K OHM 1/6 W 5.00% TA52 10K OHM 1/6 W 5.00% TA52 2.2K OHM 1/6 W 5.00% TA52 1K OHM 1/6 W 5.00% TAOHM 1/6 W 5.00% TA52 EVN-DJAA03 B103 SEMI-FIX(H) TA F853 JK201 JK202 JK203 PA01 RL801 RL802 SK901 TH801 TU101 VD801 A1 A2
LOCA. NO T801 X01 XN01 XV01 Z101 Z102
PART NO 150-F06T 156-A01L 156-A02R 6202VDB007B 6200VQS001Q 6200VQS001D
DESCRIPTION FILTER(CIRC),LINE SQE3535 20MH CRYSTAL,HC49U SUNNY RADIAL 6.000MHZ 30 CRYSTAL,HC49U KJE RADIAL 18.432MHZ 30P CRYSTAL,HC49U SUNNY RADIAL 20.250MHZ FILTER,SAW OFWK3958M 38.9MHZ FILTER,SAW OFWK9260M 38.9MHZ(SIF

ACCESSORIES

3828VA0250G 6710V00026F MANUAL,OWNERS ES LG SP/PO 026C/F/H/J REMOTE CONTROLLER(W/O PIP)

MISCELLANEOUS

0FT4001B53C 303-F62A 131-096D 6612VMH001A 6612VMH001A 6613V00006A 6726VV0006H 6920VB1001E 6920VB1001E 6620VBC001A 163-054F 6700VPF005D 164-003K FUSE,TIME LAG 4000MA 250V 5.2X20 COVER,TUNER FUSE,FAST BLOE 3000MA 125V 2.5X7.6 JACK,SCART UPJ-R1-018 RGB 21 PI JACK,SCART UPJ-R1-018 RGB 21 PI JACK ASSY,3P+EAR(PJ6062A) PRE-AMP,TSOP2238NN1 VISHAY 38KHZ MC00A RELAY,DC SDT-S-105LMR OEG 5V 0.05A 250V RELAY,DC SDT-S-105LMR OEG 5V 0.05A 250V SOCKET,CPT 29.1 PHI SINGLE(PCS629-03A) THERMISTOR,PTCJ502P84D140M290Q TUNER,TAEC-G023D VARISTOR,SVC621D-14A 620V 0% UL/C

SPARK GAP

SG901 SG902 SG903 165-004A 165-004A 165-004A SPARK GAP,AG20PT 152F-L3N/S-23 SPARK GAP,AG20PT 152F-L3N/S-23 SPARK GAP,AG20PT 152F-L3N/S-23

SWITCH

sci.electronics.repair: LG TV CE28H86T

LG TV CE28H86T

Source: http://sci.techarchive.net/Archive/sci.electronics.repair/200410/1170.html
From: rik (rik.viaene_at_pandora.be) Date: 10/14/04
Date: Thu, 14 Oct 2004 17:54:54 GMT
I got a LG tv picture is stretched out ( to big to fit on screen ) Found C410 10uF/250V bad. Replaced C410 with new and tested tv the thing thats happens now is C410 becomes very hot and start to smoke. any help is welcome Thanks in advance Rik