ORDER No.0154 I0

AUTOMOTIVE ELECTRONICS

HONDA CQ-EH9160A
AM/FM MPX ELECTRONIC TUNING RADIO with Stereo Cassette Tape Player and 6-Disc CD Changer
PART No. : 39100-S6M-A100 ID CORD : 1TJ2 VEHICLE : ACURA RSX DESTINATION : North America PRODUCED AFTER : Apr., 2001

Specification*

General Power Supply DC 12V (11V - 16V), Test Voltage 13.2V Negative Ground Current Consumption Output Voltage Output Impedance Less than 1.0A (at VOL. MAX) More than 400mVrms 1.5k Weight** AM Radio Frequency Range Usable Sensitivity 530 - 1,710kHz 24dB/V (S/N 20dB) * Specifications and the design are subject to possible modification without notice due to improvements. ** Dimensions and Weight shown are approximate. FM Stereo Radio Frequency Range Usable Sensitivity 87.75 - 107.9MHz 6dB/V (S/N 30dB) Doldy noise reduction manufactured under license from Dolby Laboratories Licensing Corporation. Dolby and the double-D symbol are trade marks of Dolby Laboratories Licensing Corporation. Cassette Player Reproduction System Tape Speed Wow and Flutter Signal to Noise Ratio 4-Track, 2-Program Stereo 4.76cm/sec. Less than 0.2% (WRMS) More than 40dB 2.4kg Dimensions** (WHD) 180102165mm CD Player Signal to Noise Ratio Total Harmonic Distortion Channel Separation More than 70dB (IHF-A) Less than 0.4% More than 50dB (IHF-A)

HONDA / CQ-EH9160A

CONTENTS
1 FEATUERS 2 LASER PRODUCTS 3 REAR VIEW 4 FRONT VIEW AND FUNCTIONS 5 WIRING CONNECTIONS 6 BLOCK DIAGRAM (Main, Display, Tape Block) 7 BLOCK DIAGRAM (CD Servo Block) 8 TERMINALS DESCRIPTION 9 ALIGNMENT INSTRUCTIONS 10 ALIGNMENT POINTS 11 CD DISC CENTERING ALIGNMENT 12 PACKAGE AND IC BLOCK DIAGRAM 13 REPLACEMENT PARTS LIST 14 EXPLODED VIEW (Unit) 15 CD CHANGER PARTS LIST 16 EXPLODED VIEW (CD Deck-1) 17 EXPLODED VIEW (CD Deck-2) 18 EXPLODED VIEW (CD Deck-3) 19 TAPE PLAYER PARTS 20 EXPLODED VIEW (Tape Deck) 21 WIRING DIAGRAM 22 SCHEMATIC DIAGRAM (1) 23 SCHEMATIC DIAGRAM (2)

1 FEATUERS

PLL (Phase Locked Loop) synthesized tuning. 18-station preset (12-FM, 6-AM). 6-Disc CD changer (in dash board). Dolby noise reduction. Electronic control of power and sound. Correspondence with BOSE Amp. Anti-Theft function.

3 REAR VIEW

2 LASER PRODUCTS
4 FRONT VIEW AND FUNCTIONS

5 WIRING CONNECTIONS

6 BLOCK DIAGRAM (Main, Display, Tape Block)
7 BLOCK DIAGRAM (CD Servo Block)

8 TERMINALS DESCRIPTION

Pin No. 59 60

Main Block

Port BEEP IDC-ST/SP EVOL CLK EVOL DATA SEC-LED VOL A VOL B LCD-CLK LCD-DI LCD-DO RESET XT2 XT1 VSS X2 X1 REGOFF REGC VDD VOL C VOL D LCD-CE BOSE SEC-CS SEC-CLK SEC-DI SEC-DO SET-SEC1 SET-SEC2 SET-TIME P.CONT ACC CNT AMPCNT LCD ON TUNER +B PLL-CE PLL-DO PLL-CLK PLL-DI VSS VDD AREA ST-IND CA.PON CM.PON M2 M1A M1B T.IN MSM A/B M2F EQ(MTL) F/R DOLBY T.LOAD MS(PL/FF) MS REMO3/4 BUSOUT Description Beep output CD.C start/stop Electronic volume clock Electronic volume data Security LED on/off Rotary encoder data Rotary encoder data Shift clock for LCD data LCD data LCD data Reset input Crystal oscillator terminal Crystal oscillator terminal Ground Crystal oscillator terminal Crystal oscillator terminal (Connecting to VDD) (Connecting to VDD) +5V power supply Rotary encoder data Rotary encoder data LCD driver enable (VDD pull-up) Security ROM chip select Data shift clock for security ROM Serial data Serial data (Ground pull-down) (Ground pull-down) (VDD Pull-up) COM8V power switch ACC 5V power switch Amp power control LCD illumi. on/off Motor antenna power PLL chip select PLL data Shift clock for PLL data PLL data Ground +5V power supply (Ground pull-down) FM stereo detection Tape power control Tape power control Main motor control Loading motor control Loading motor control Tape-in detection MS gain contrl Tape side detection Main motor control Metal tape mode selection Tape head change Dolby NR on/off Tape loading detection MS mode selection MS detection (VDD pull-up) Not used I/O O O O O O I I O O I I I I O I O O I O O O O O O O O O I I O O O O O I O I O O O O I O I (V) 0 4.0 4.9 0.5 0.5.4.9 2.4 0.2.3 1.8 4.9 4.9 4.9 4.8 0.4.0 4.9 4.8 4.9 4.9 4.9 4.5.4.0.3 4.9 4.0 4.0 4.4.4.9 -

IC601 : C2CBHG000069

99 100
NAVI-IN NC NC NAVI-MUTE BIT1 END.A END.B BIT2 EQ BIT3 NC NC IC/VPP REMO SW.A SW.B F-MUTE R-MUTE NC VSM AMP MUTE AVDD AVREF1 AVSS NC NC ACC-DET TAPE EJ BUS.IN GAIN IDCEJECT BAT-DET EJ.INH IDC-SI RXD TXD IDC-CLK IDC-SO CD-RESET CDON
(ACC5V pull-up) No connection No connection Navi mute control Tape mode switch Tape end signal Tape end signal Tape mode switch Metal/Normal switchl Tape mode switch No connection No connection (Connecting to ground) Remote control signal CD.C mute Not used Front mute Rear mute No connection Phase diff. level detection Not used +5V power supply Analog reference voltage Ground (Connecting to ground) No connection ACC level detection Tape eject SW Not used (+5V pull-up) CD disc eject SW Battery level detection Tape/Disc eject SW CD.C serial data Not used Not used Shift clock for CD.C data CD.C data CD.C reset CD.C controller enable

O I I I I I I O O O O I I I I I I I O O O O O
4.4.6 1.5 2.4 4.5.0.6 4.9 5.0 4.5 4.6 4.8 4.8 4.7 4.5 4.4 4.4.9 4.9 1.2 4.9 4.9
Note : Voltage measuerments are with respect to ground, with a voltmeter (Internal resistance : 10M ohms.)
Pin No. 1, 4-40 41-45-49 50-59 60

Display Block

Port S1, 2 S3 S4-40 COM1-3 S41 KS2-6 KI1-4 KI5 TEST VDD VDD1 VDD2 VSS OSC Description Disc LED on/off Not used LCD segment data LCD common LCD segment data Key strobe Key data (Connecting to ground) (Connecting to ground) +5V power supply LCD angle LCD angle Ground Oscillator terminal I/O O O O O O I (V) 0 2.5 2.5 2.5 0.5.1 3.3 1.3.9

IC901 : YEAMLC75853

DO CE CL DI
Key data output LCD driver chip enable Shift clock for LCD data LCD data input

O I I I

Pin No. 15 16-22,51 52-56 57-63

CD Servo Block

Port VDD D0 D1 /WE /RAS D2 D3 /CAS0 /CAS1 A8 A7 A6 A5 A4 A9 A0 A3 VSS2 VDD2 TVD PC ECS TRD FOD FBAL TBAL VREF FE TE RFENV OFT /RFDET BDO LDON ARF IREF DRF DSLF DSLF2 PLLF VCOF AVDD2 AVSS2 OUTL AVSS1 OUTR AVDD1 FLAG FCLK TX MCLK MDATA MLD Description +5V power supply D-RAM data D-RAM data D-RAM data write D-RAM row address strobe D-RAM data D-RAM data D-RAM columun address strobe D-RAM columun address strobe D-RAM address D-RAM address D-RAM address D-RAM address D-RAM address D-RAM address D-RAM address D-RAM address Ground +5V power supply Not used Traverse motor control Not used Spindle motor control Tracking coil drive Focus coil drive Focus balance Tracking balance Refence voltage Focus error Tracking error RF envelope Off track signal RF detecting signal Drop-out signal Laser on signal RF signal Reference current input Bias for DSL Loop filter for DSL Loop filter for DSL Loop filter for PLL Not used +5V power supply Ground L channel output Ground R channel output +5V power supply (Connecting to ground) Flag output Frame clock Not used Not used Clock for I/F command Date for I/F command I/F command load I/O I/O I/O O O I/O I/O O O O O O O O O O O O O O O O O I I I I I I I O I I I I/O I/O I/O O O O O I I I (V) 5.0 2.3 1.8 4.9 3.4 0.3.0.6 1.1 0.1.1 0.4 1.0 5.0 2.5 2.4 2.5 2.4 1.9 3.0 2.5 2.5 2.5 2.4.5 2.5 1.2 2.4 2.5 2.2 1.4 5.2.2.3 4.1.0 3.1 5.0

IC201 : MN662783RPW

BLKCK SQCK SUBQ DMUTE STAT /RST CSEL PMCK SMCK SUBC SBCK /CLDCK /TEST X1 X2 VDD1 VSS1
Subcode block clock Ext.clock for sub code-Q Code for sub. code-Q Mute input Status signal Reset input (Connecting to ground) Clock output Clock output Serial data of sub code Shift clock for SUBC Not used (Connecting to VDD) Crystal oscillator Crystal oscillator +5V power supply Ground

O I O I O I O O O I -

0 5.0 3.5.0 5.2.5 2.0.6 5.0 0.4 3.2 5.0 0

IC301 : MN1873260AB4

Pin No. 39 40-Port VDD OSC2 OSC1 VSS XI XO CM VREFH SW13 SW12 SW11 SW10 SW4 SW3 SW2 SW1 VREFL /RESET SCKM SIM SOM SQCK SUBQ CD.ON BLKCK P.ON MUTE SENS CLVS FLOCK TLOCK VMI HMI HVMUTE SW9 SW8 SW7 SW6 SW5 Description +5V power supply Crystal oscillator Crystal oscillator Ground (Connecting to ground) Not used (Connecting to ground) Reference voltage Shuter SW Horizontal origin Clump SW Play SW Shuter SW Tray origin SW Inner SW Outer SW (Connecting to Ground) Reset input (Ground pull-down) Clock for serial data CD changer serial data CD changer serial data Ext. clock for sub. code-Q Code for sub. code-Q Not used (Ground pull-down) CD changer start/stop Not used Sub. code block clock In operation CPU Mute output (Ground pull-down) Servo status Servo status Focus servo lock Tracking servo lock Horizontal motor control Vertical motor control H/V motor mute (Ground pull-down) Disc-in (B) SW Disc-in (L) SW Disc-in (F) SW Disc push SW Tray hight SW I/O I I I I I I I I I I I I O O I I I O O O O O O O O O I I I I I (V) 5.0 2.2 2.5.0 4.9 4.0 4.4.8 4.4.5.0 1.3 4.3 5.0 1.5.5.0 5.0 5.0 0.2.4.5

BDO DQSY /RST STAT DMUTE XE P.DOWN MLD MDATA MCLK SPMT MUTE12 MUTE4 LDOI TRV SYNC
Drop-out signal Not used Reset output Status signal Mute output Not used Power down signal No connection I/F command load Data for I/F command Clock for I/F command Spindle mute Focus/Tracking mute Loading motor mute Loading motor control Forced traverse control Not used
I O I O O O O O O O O I/O I/O -
0 5.0 2.0 5.0 3.1 4.1 5.4.8 2.5 2.4 -

9 ALIGNMENT INSTRUCTIONS

9.1. Alignment Conditions
Balance, Fader Control : center Power Supply Voltage : DC13.2V Output Impedance : 4 Output Power : 0.5W Note : Do not align the FM/AM package block. When the package block is necessary, it will be supplied already aligned at the factory. Bass, Treble Control : Center Dolby NR: OFF

Step (1) (2)

Dolby NR Alignment
Alignment Item DOLBY NR Rch DOLBY NR Lch Test Tape RFKZ0038 RFKZ0038 VTVM Connection TP201 TP301 Adjust VR201 VR301 Remarks Adjust for 388mV 1.0dB Adjust for 388mV 1.0dB

10 ALIGNMENT POINTS

11 CD DISC CENTERING ALIGNMENT
This adjustment is for assuring that compact discs will be placed in the center of the turntable. <Adjustment Condition / Jig> Power Supply Voltage : 13.2V Test Disc : TCD-784M
<Adjustment Procedures> 1. Attach the adjusting screw to the upper chassis (See Figure 1.). 2. Insert the test CD (TCD-784M) into the disc No.1 position and play it. 3. After checking whether the disc is centered on the turntable, turn the adjusting screw unit it is in the center. <Check Items> Check that the disc is correctly centered. Check that the disc is securely clamped. Check that no abnormal noise is produced when clamping the disc. [Directions of Turning the Adjusting Screw] CD stops before its proper position : Turn the screw counterclockwise. CD overruns : Turn the screw clockwise.
4. After the adjustment, lock the screw.
12 PACKAGE AND IC BLOCK DIAGRAM

12.1. Main Block

PK50 : YEP0PTA514B0

IC602 : MN1382KTX

IC205 : C0JBAS000030

IC201 : C1BB00000284

IC611 : YEAMLC72135C

IC702 : AN8065SE1

IC603 : YEAMS29130AD

IC961 : AN6277NK

IC701 : YEAMA61W12ST

12.2. Tape Block

IC1 : YEAMCXA2565Q

12.3. CD Servo Block

IC101 : YEAMBA6354BF

IC603 : YEAMT4W53FUL

IC601 : YEAMBA5971FP

IC202 : C3ABMB000010

IC501 : YEAMPC358G2T

IC401 : YEAMBA6792FY

13 REPLACEMENT PARTS LIST
Notes : 1. Be sure to make your orders of replacement parts according to this list. 2. Important safety notice: Components, identified by mark have special characteristics important for safety. When replacing any of these components, use only manufacturers specified parts. 3. Location keys in the remarks column indicates the general location of the parts shown in the exploded drawing, as in a road map. 4. The marking (RTL) indicates that Retention Time is limited for this item. After the discontinuation of assembly in production, the item will continue to be available for a specific period of time. The retention period of availability is dependent on the type of assembly, and in accordance with the laws governing part and product retention. After the end of this period, the assembly will no longer be available. 5. "MCC" marks in remarks column are indicated supply parts of Matsushita Communication Industrial Corp. of America (MCC).
Ref. Part No. No. [E6857A] Main Block ICs and TRANSISTORs IC201 C1BB00000284 IC202 C0ABCB000038 IC205 C0JBAS000030 IC302 C0ABCB000038 IC601 C2CBHG000069 IC602 MN1382KTX IC603 C3EBCG000037 IC611 YEAMLC72135C IC612 C0ABBB000179 IC701 YEAMA61W12ST IC702 AN8065SE1 IC770 C0ABBB000179 IC921 C0ABBB000179 IC961 AN6277NK PK50 YEP0PTA514B0 Q51 YEANC114EKTX Q276 YEANC323TKT Q277 YEANC323TKT Q278 YEANA124EKTX Q376 YEANC323TKT Q377 YEANC323TKT Q378 YEANA124EKTX Q441 YEANC323TKT Q442 YEANA124EKTX Q541 YEANC323TKT Q602 B1GBCFJN0005 Q704 2SB1398QTA Q705 B1GBCFJN0005 Q707 2SD2139TA Q721 YEANBP1F3PT Q722 YEANBP1F3PT Q731 2SB1398QTA Q732 B1GBCFJN0005 Q745 B1BBAC000007 Q751 2SB1398QTA Q752 B1GDJEGJ0002 Q753 YEAN2SD1856 Q754 2SD0601AHR Q755 YEANBP1F3PT Q756 YEANC114EKTX Q757 2SB1398QTA Part Name & Description Remarks
Ref. No. Q758 Q772 Q773 Q774 Q921 Q922
Part No. B1GDJEGJ0002 2SD1119TX 2SB1398QTA B1GBCFJN0005 B1ACJC000004 B1GBCFJN0005
Part Name & Description Transistor Transistor Transistor Transistor Transistor Transistor

Remarks

DIODEs D103 D155 D230 D258 D259 D278 D279 D358 D359 D378 D379 D601 D701 D702 D703 D704 D706 D707 D741 D751 D752 D772 D911 D961
MA142WKTX MA4X159A0L MA4X159A0L MA153TX MA153TX MA153TX MA153TX MA153TX MA153TX MA153TX MA153TX MA142WATX YEADZSA5A27F YEADSR1544TL YEADEC10DS1 MA158TX YEADRD91M1T2 YEADRD47M2T1 YEADRD56M3T1 YEADRD91M2T1 MA142WKTX B0BC9R900009 MA151KTX MA142WATX

Part Name & Description Ceramic, 0.22F 16WV Electrolytic, 82F 10WV Ceramic, 0.22F 16WV Electrolytic, 82F 10WV Electrolytic, 220F 10WV Electrolytic, 220F 10WV Ceramic, 0.22F 16WV Ceramic, 0.01F 50WV Ceramic, 0.1F 16WV Electrolytic, 330F 6.3WV Electrolytic, 1000F 5WV Ceramic, 0.1F 16WV Ceramic, 0.1F 16WV Electrolytic, 2200F 16WV Ceramic, 0.1F 16WV Ceramic, 0.1F 50WV Ceramic, 0.01F 100WV Ceramic, 0.01F 50WV Ceramic, 0.01F 50WV Electrolytic, 220F 10WV Electrolytic, 10F 16WV Ceramic, 0.01F 50WV Ceramic, 0.1F 16WV Ceramic, 0.1F 16WV Ceramic, 0.1F 16WV Electrolytic, 4.7F 25WV Ceramic, 0.1F 16WV Ceramic, 0.1F 16WV Ceramic, 0.1F 16WV Electrolytic, 47F 10WV Electrolytic, 100F 10WV Electrolytic, 47F 16WV Ceramic, 0.01F 50WV Electrolytic, 220F 10WV Ceramic, 0.01F 50WV Electrolytic, 100F 6.3WV Ceramic, 0.1F 16WV Electrolytic, 220F 10WV Electrolytic, 22F 6.3WV Ceramic, 0.1F 16WV Ceramic, 0.1F 16WV Ceramic, 0.027F 50WV Ceramic, 0.01F 50WV Electrolytic, 47F 16WV Electrolytic, 22F 6.3WV Ceramic, 0.01F 50WV Electrolytic, 220F 10WV Ceramic, 0.01F 50WV Electrolytic, 10F 16WV Electrolytic, 2.2F 50WV Ceramic, 0.1F 16WV Electrolytic, 100F 16WV Electrolytic, 220F 10WV Ceramic, 0.01F 50WV Ceramic, 0.01F 50WV Ceramic, 0.01F 50WV Ceramic, 0.1F 16WV Ceramic, 0.001F 50WV Ceramic, 0.001F 50WV Ceramic, 0.001F 50WV Ceramic, 0.01F 50WV Ceramic, 0.001F 50WV Ceramic, 0.001F 50WV Ceramic, 0.001F 50WV Ceramic, 0.001F 50WV
RESISTORs R51 ERJ6GEYJ123 R52 ERJ6GEYJ272 R53 ERJ6GEYJ334 R54 ERJ6GEYJ153 R55 ERJ6GEYJ682
Chip, Chip, Chip, Chip, Chip,
12k 1/10W 2.7k 1/10W 330k 1/10W 15k 1/10W 6.8k 1/10W
Ref. No. R56 R57 R58 R60 R61 R62 R63 R64 R65 R66 R155 R156 R157 R158 R207 R208 R209 R210 R230 R248 R249 R250 R251 R252 R253 R254 R255 R256 R257 R258 R259 R260 R262 R268 R269 R270 R271 R272 R273 R274 R275 R276 R277 R278 R279 R282 R307 R308 R309 R310 R330 R348 R349 R350 R351 R352 R353 R354 R355 R356 R357 R358 R359 R360 R362 R368 R369 R370 R371 R372 R373 R374 R375
Part No. ERJ6GEYJ183 ERJ6GEYJ103 ERJ6GEYJ183 ERJ6GEYJ683 ERJ6GEYJ104 ERJ6GEYJ101 ERJ6GEYJ123 ERJ6GEYJ823 ERJ6GEYJ123 ERJ6GEYJ104 ERJ6GEYJ272 ERJ6GEYJ272 ERJ6GEYJ103 ERJ6GEYJ103 ERJ6GEYJ682 ERJ6GEYJ822 ERJ6GEYJ203 ERJ6GEYJ203 ERJ6GEYJ103 ERJ6GEYJ562 ERJ6GEYJ102 ERJ6GEYJ103 ERJ6GEYJ105 ERJ6GEYJ104 ERJ6GEYJ103 ERJ6GEYJ100 ERJ6GEYJ153 ERJ6GEYJ682 ERJ6GEYJ103 ERJ6GEYJ153 ERJ6GEYJ100 ERJ6GEYJ103 ERJ6GEYJ104 ERJ6GEYJ562 ERJ6GEYJ102 ERJ6GEYJ103 ERJ6GEYJ103 ERJ6GEYJ104 ERJ6GEYJ103 ERJ6GEYJ100 ERJ6GEYJ153 ERJ6GEYJ682 ERJ6GEYJ103 ERJ6GEYJ153 ERJ6GEYJ100 ERJ6GEYJ104 ERJ6GEYJ682 ERJ6GEYJ822 ERJ6GEYJ203 ERJ6GEYJ203 ERJ6GEYJ103 ERJ6GEYJ562 ERJ6GEYJ102 ERJ6GEYJ103 ERJ6GEYJ105 ERJ6GEYJ104 ERJ6GEYJ103 ERJ6GEYJ100 ERJ6GEYJ153 ERJ6GEYJ682 ERJ6GEYJ103 ERJ6GEYJ153 ERJ6GEYJ100 ERJ6GEYJ103 ERJ6GEYJ104 ERJ6GEYJ562 ERJ6GEYJ102 ERJ6GEYJ103 ERJ6GEYJ103 ERJ6GEYJ104 ERJ6GEYJ103 ERJ6GEYJ100 ERJ6GEYJ153

CONNECTORs CN701 YEAEMX5P20L CN901 K1KA10B00162 CN902 K1KA10B00162 CN921 YEAEK623214S CN961 YEAE9604S17S CN962 YEAE0110TKAG
Connector, Connector, Connector, Connector, Connector, Connector,

20P 10P 10P 14P 17P 10P

DIODEs D951 D952

YEADBR3668S B3AGA0000064

Diode Diode
COILs J601 L51 L52 L53 L601 L602 L603 L604 L605 L606 L701 L921
YELTBLM21A10 YELT03N1R8JT YELT03NR82JT YELT03N3R3JT YELT03N5R6KT J0JCC0000030 YELTBLM21A10 YELTBLM21A10 YELT03N5R6KT J0JCC0000030 G0B750J00001 YELT03N330JT
Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil
CAPACITORs C900 YECUS1C104KX C901 YECUS1H473KX C902 YECUS1H473KX C903 YECUS1H821JM C955 YECUS1H103KX
Ceramic, Ceramic, Ceramic, Ceramic, Ceramic,
0.1F 16WV 0.047F 50WV 0.047F 50WV 820PF 50WV 0.01F 50WV
CRYSTALs XL601 YEXL49U1258T

Crystal

RESISTORs R941 ERJ8GEYJ100V R942 ERJ8GEYJ100V R943 ERJ8GEYJ120V R944 ERJ8GEYJ150V R945 ERJ8GEYJ150V R946 ERJ8GEYJ120V R947 ERJ8GEYJ6R8V R948 ERJ8GEYJ6R8V R949 ERJ8GEYJ121V R951 ERJ8GEYJ271V R952 ERJ8GEYJ121V
Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip,
10 1/8W 10 1/8W 12 1/8W 15 1/8W 15 1/8W 12 1/8W 6.8 1/8W 6.8 1/8W 120 1/8W 270 1/8W 120 1/8W
Ref. No. R953 R954 R955 R956 R957 R958 R959 R960 R961 R962 R963
Part No. ERJ6GEYJ472 ERJ6GEYJ472 ERJ6GEYJ220 ERJ6GEYJ472 ERJ6GEYJ683 ERJ6GEYJ472 ERJ6GEYJ472 ERJ8GEYJ561V ERJ8GEYJ561V ERJ6GEYJ473 ERJ6GEYJ102
Part Name & Description Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, 4.7k 1/10W 4.7k 1/10W 22 1/10W 4.7k 1/10W 68k 1/10W 4.7k 1/10W 4.7k 1/10W 560 1/8W 560 1/8W 47k 1/10W 1k 1/10W
CONNECTORs CJ901 K1MQ10A00009 CJ902 K1MQ10A00009 CN922 YEAE5280714 CN923 K1MN15B00014
Connector, Connector, Connector, Connector,

10P 10P 14P 15P

SWITCHEs SW901 EVQPVF05K SW902 EVQPVF05K SW903 EVQPVF05K SW904 EVQPVF05K SW905 EVQPVF05K SW906 EVQPVF05K SW907 EVQPVF05K SW909 EVQPVF05K SW910 EVQPVF05K SW911 EVQPVF05K SW912 EVQPVF05K SW913 EVQPVF05K SW914 EVQPVF05K SW915 EVQPVF05K SW916 EVQPVF05K SW917 EVQPVF05K SW918 EVQPVF05K
Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch

Ref. No. CNP3 CNP38 39

Part No. K9ZZ00000231 K9ZZ00000757 YEFA131587 YEFA031717A YEFA05781 YEFA09720 YEFA09721 YEFA07521A YEFC027254B YEFE136695 YEFE136695 YGFF011017 YEFK06512 YEFK06985 YEFV021795 YEFV012057 YEFX0214941 YEFX0214942 YEFX0214940A YEFX0214202 YEFX0212830 YEP0PT6857A0 YEP0PT8861B0 YEJT01089 YEJT03131 YEJT03009 YEJT03015 YEJT03038 YEJT03207 XTB2+6GFX YEJS06219A XTB3+6FFX XTB3+5FFX

Part Name & Description Connector, 15P Connector, 14P Case, LCD Upper Cover Bottom Cover Side Plate (L) Side Plate (R) Front Cover Escucheon Assy Knob, VOL. Knob Heat Sink Holder, LED Holder, LCD Optical Shade Insulator Bracket Bracket Bracket, Deck Bracket, IC701 Bracket, Q753 PCB w/Component PCB w/Component Tapping Screw, Tapping Screw, Screw Tapping Screw, Screw Tapping Screw, Tapping Screw, M2x6mm Screw Tapping Screw, M3x6mm Screw, M3x5mm

RTL RTL

LCD LCD901

L5AAALC00020

COILs L923

YELTBMHS800T

LAMPs PL901 PL902 PL903 PL904 PL905 PL906 PL907 PL908
YEALHSIR043 YEALHSIR043 YEALHSIR043 YEALHSIR043 YEALHSIR043 YEALHSIR043 YEALHSIR043 YEALHSIR043
Pilot Pilot Pilot Pilot Pilot Pilot Pilot Pilot
Lamp Lamp Lamp Lamp Lamp Lamp Lamp Lamp
VARIABLE RESISTORs VR901 K9AA015B0013 VR902 K9AA015B0013
Variablr resistor Variablr resistor
Mechanical Parts MISCELLANEOUS ANT51 YEAA10064 AT1 YEFX0213797 AT2 YEFX0213797 AT3 YEFX0213919 AT5 YEAT03346A CNP1 YEAES17A050A
Antenna Receplacle Bracket Bracket Terminal Terminal Connector, 17P

14 EXPLODED VIEW (Unit)

15 CD CHANGER PARTS LIST
15.1. ICs and Transistors

SERVO BLOCK [E8586C]

Ref. No. IC101 IC201 IC202 IC301 IC401 IC501 IC601 IC602 IC603 Q101 Part No. YEAMBA6354BF MN662783RPW C3ABMB000010 MN1873260AB4 YEAMBA6792FY YEAMPC358G2T YEAMBA5971FP C0JBAS0051 YEAMT4W53FUL 2SB766ATX Part Name & Description IC IC IC IC IC IC IC IC IC Transistor Remarks

[E2685A]

Ref. No. Q1 Q2 Q3 Part No. PN147 PN147 PN147 IC IC IC Part Name & Description Remarks
Ref. No. C202 C203 C204 C205 C206 C207 C208 C209 C210 C211 C301 C302 C305 C401 C402 C403 C501 C503 C504 C601 C602 C603 C604 C605
Part No. YECUS1H123KX YECUS1C334KX YECUS1C104KX YECSW1C106MS ECEV0JA470SR YECUS1C104KX YECUS1C104KX YECSW1C106MS YECUS1C104KX YECUS1A105KX YECUS1C104KX YECSW1C106MS YECUS1H103KX YECUS1C104KX ECEV1CA470SP YECUS1C104KX YECUS1C104KX YECUS1E273KX YECUS1E393KX YECUS1C104KX ECEV1CA470SP YECUS1C104KX YECUS1C104KX YECUZ1H821KX
Part Name & Description Ceramic, 0.012F 50WV Ceramic, 0.33F 16WV Ceramic, 0.1F 16WV Tantalum, 10F 16WV Electrolytic, 47F 6.3WV Ceramic, 0.1F 16WV Ceramic, 0.1F 16WV Tantalum, 10F 16WV Ceramic, 0.1F 16WV Ceramic, 1F 10WV Ceramic, 0.1F 16WV Tantalum, 10F 16WV Ceramic, 0.01F 50WV Ceramic, 0.1F 16WV Electrolytic, 47F 16WV Ceramic, 0.1F 16WV Ceramic, 0.1F 16WV Ceramic, 0.027F 25WV Ceramic, 0.039F 25WV Ceramic, 0.1F 16WV Electrolytic, 47F 16WV Ceramic, 0.1F 16WV Ceramic, 0.1F 16WV Ceramic, 820pF 50WV

Part No. ERJ6GEYJ471 ERJ6GEYJ471 ERJ6GEYJ471 ERJ6GEYJ471 ERJ6GEYJ471 ERJ6GEYJ473 ERJ6GEYJ473 ERJ6GEYJ473 ERJ6GEYJ473 ERJ6GEYJ473 ERJ6GEYJ473 ERJ6GEYJ222 ERJ6GEYJ222 ERJ6GEYJ101 ERJ6GEYJ103 ERJ6GEYJ103 ERJ6GEYJ222 ERJ6GEYJ103 ERJ6GEYJ123 ERJ6GEYJ103 ERJ6GEYJ273 ERJ6GEYJ103 ERJ6GEYJ183 ERJ6GEYJ393 ERJ6GEYJ103 ERJ6GEYJ472 ERJ6GEYJ472
Part Name & Description Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, 470 1/10W 470 1/10W 470 1/10W 470 1/10W 470 1/10W 47k 1/10W 47k 1/10W 47k 1/10W 47k 1/10W 47k 1/10W 47k 1/10W 2.2k 1/10W 2.2k 1/10W 100 1/10W 10k 1/10W 10k 1/10W 2.2k 1/10W 10k 1/10W 12k 1/10W 10k 1/10W 27k 1/10W 10k 1/10W 18k 1/10W 39k 1/10W 10k 1/10W 4.7k 1/10W 4.7k 1/10W

15.7. Mechanical parts

MISCELLANEOUS
Ref. No. FXPart No. YEAE012348A YEAP2683 YEATSD00405 YEFA011711G YEFA011713A YEFA011714D YEFA011716 YEFA011718A YEFA011720B YEFA011722A YEFA011724B YEFS04707 YEFV011897 YEFW04158 YEFW04159A YEFW04161A YEFW04167 YEFW05389 YEFW062351 YEFW062461B YEFX003872 YEFX003873 YEFX003874 YEFX003875 YEFX003877 YEFX003878A YEFX003879 YEFX003882A YEFX003883B YEFX003884 YEFX003885 YEFX0031057 YEFX003891A YEFX0031003 YEFX003894 YEFX003895A YEFX003896 YEFX003897A YEFX003898 YEFX003899B YEFX003929 YEFX003931 YEFX003932A YEFX0052269 YEFX0052272 YEFX0052274B YEFX0052275A YEFX0052276A YEFX0052277 YEFX0052278 YEFX0052279 YEFX0052494 YEFX0052447 YEFX0052284 YEFX0052285A YEFX0052287A YEFX0052288A YEFX0052289A YEFX0052290A YEFX0052291B YEFX0052292A YEFX0052335 Part Name & Description Cord w/Connector Suspension FPC Terminal Upper Chassis Assy Side Chassis (R) Side Chassis (L) Assy Suspension Chassis Assy Suspension Chassis(Bottom) Assy Swing Chassis Assy Stocker Plate Assy Main Chassis Assy Damper Insulator Bearing Roller Shaft Holder(L) Feed Screw Housing Disc Collar Stocker Cam Ring Disc Roller Shaft Roller Shaft Assy Elevator Gear(1) Elevator Gear(2) Elevator Gear(3) Elevator Gear(4) Traverse Gear(2) Traverse Gear(3) Traverse Gear(4) Stocker Cam Gear(1) Stocker Cam Gear(2) Stocker Cam Gear(3) Disc Hold Gear Load Gear Push Gear(1) Push Gear(2) Horizontal Cam Gear(1) Horizontal Cam Gear(2) Horizontal Gear(1) Horizontal Gear(2) Horizontal Gear(3) Horizontal Gear(4) Horizontal Cam Gear(3) Horizontal Gear(5) Push Cam Gear FPC Hold Spring Guide Spring(B) Suspension Lock Spring Swing Spring Stocker Spring(1) Stocker Spring(2) Thrust Spring Sencer Lever Spring Damper Spring Balance Spring(1) Push Spring Spring Roller Hold Spring(L) Roller Hold Spring(R) Push Lever Spring Feeder Spring Push Plate Spring Change Spring Guide Spring(F) Remarks (4-A) (1-E) (1-F) (3-B) (1-C) (4-A) (1-D) (1-D) (3-D) (4-F) (3-D) (4-D) (2-F) (3-D) (2-B) (1-E) (2-B) (4-E) (3-F) (2-A) (2-B) (3-F) (2-F) (3-F) (3-E) (3-E) (2-F) (2-D) (2-D) (1-D) (3-F) (3-E) (2-F) (3-E) (2-F) (3-F) (3-B) (3-B) (3-B) (3-D) (2-E) (3-E) (3-E) (3-E) (3-D) (3-E) (3-D) (2-D) (3-B) (2-D) (1-B) (3-D) (3-D) (4-D) (4-E) (4-D) (4-E) (1-E) (1-E) (1-F) (4-D) (3-D) (3-A) (4-B) (2-B) (2-B) (4-E) (4-B) (3-B) (1-D) (2-B)

15.5. Connectors

Ref. No. CN1 CN101 CN301 CN401 CN402 CN501 Part No. YEAE5220715 YEAE5220715 YEAE5227112 YEAE5220706 YEAE5326102 YEAE5227110 Part Name & Description Connector, Connector, Connector, Connector, Connector, Connector, 15P 15P 12P 6P 2P 10P Remarks
Ref. No. JD1 Part No. YEAE5227106 Part Name & Description Connector, 6P Remarks

15.6. Electric Parts

SWITCHES
Ref. No. SW1 SW1 SW10 SW11 SW12 SW13 Part No. ESE102MH4 ESE102MH4 ESE102MH4 ESE102MH4 ESE102MH4 ESE102MH4 Part Name & Description Switch Switch Switch Switch Switch Switch Remarks

CRYSTAL

Ref. No. XL301 Part No. YEXLSTCC737T Part Name & Description Crystal OSC Remarks

CERAMIC FILTERS

Ref. No. XL201 Part No. H2D169500001 Part Name & Description Ceramic Filter Remarks
Ref. No. L101 Part No. YELTLM41P750 Part Name & Description Coil Remarks

Ref. No. 141

Part No. YEFX0052366 YEFX0052495 YEFX0052449A YEFX0052445 YEFX018552 YEFX018553D YEFX018595 YEFX018556A YEFX018596 YEFX018638 YEFX018600 YEFX0461903A YEFX0461905A YEFX0461914B YEFX0461917 YEFX0461918 YEFX0461919A YEFX0461922D YEFX0461924C YEFX0461926A YEFX0461931A YEFX0462062B YEFX219129 YEFX0462002C YEFX0462003B YEFX0462026 YEFS02342 YEFX0462029 YEFX206135C YEFX206136D YEFX206137A YEFX206138C YEFX206139E YEFX206140 YEFX206141A YEFX206143 YEFX206144 YEFX218296 YEFX218299 YEFX219124A YEFX219126D YEFX233504A YEFX233505A YEFX233506 YEFX234192 YEFX249486 YEFX9992184 YEFX9992237 YEFX9991903 YEJT03220 YEP0FX3384 YEP0FX3633 YEP0FX3661S YEP0FX3660S YEP0FX3662S YEP0FX3663S YEFX9992192A YEFX9992193 YEFX0052448 YEFX218308 YEFX0031053 YEFX0031054 YEFX014040 YEP0PT8586A2 YEP0PT2682A0 YEP0PT2684A0 YEP0PT2685A0
Part Name & Description Stocker Thrust Spring Damper Spring (R ) Damper Spring (L) Lock Spring Travese Motor Bracket Assy Guide(F) Bracket Guide(B) Bearing Bracket Stopper Plate Gear Bracket Assy Elevator Motor Bracket Guide Lever (B) Assy Guide Lever (F) Assy Senser Cover Stocker Rack Senser Lever(B) Sneser Lever(FA) Feeder Plate Push Lever Rack Lever Push Lever Escape Lever(1) Guide (F) Guide Cam Plate(F) Guide Cam (B) Plate Assy Lever Guide Plate Assy Felt Feeder Guide Plate Assy Guide(BL) Guide(BU) Guide(FL) Guide(FU) Disc Guide Traverse Guide FPC Guide Disc Guide(S) Disc Guide(U) Disc Roller Disc Roller Guide (B) Base Assy Guide Base (F) Assy Stocker Tray Housing Disc Holder(L) Disc Holder(U) Elevator Cam Feeder Arm Assy Suspension Balancer (1) Stocker Tray Feed Screw Guide Feed Screw Assy Optical Pick-up Assy Spindle Motor Assy Horizontal Motor Assy Vertical Motor Assy Loading Motor Assy Traverse Motor Assy Suspension Balancer Suspension Balancer (3) Balance Spring (B) Roller Load Gear (2) Load Gear (3) Retaining Ring, 2mm PCB w/Component PCB w/Component PCB w/Component PCB w/Component

VARIABLE RESISTORS

Ref. No. VR201, 301 Part No. EVNDXAA00B13 Part Name & Description Variable Resistor Remarks
Ceramic, 0.012F 50WV Ceramic, 0.033F 25WV Ceramic, 0.1F 16WV Electrolytic, 22F 16WV Electrolytic, 33F 10WV Ceramic, 0.01F 100WV Ceramic, 0.033F 25WV Electrolytic, 0.33F 50WV Ceramic, 0.0047F 50WV Electrolytic, 10F 16WV Ceramic, 0.0047F 50WV Ceramic, 0.33F 25WV

19.7. Mechanical Parts

Ref. No. Part No. YGFX0052472 YGFX0052454 YGFX0462100 YGFX0462104 YGFA011830 YGFX234194 YGFX0052427 YGFX209271 YGFX0052471 YGJW04131 YGFX0052475 YGFX0031035 YGFA011827 YGFX0052444 YGP0PT8790A0 YGP9FZ2973 YGFX0462105 YGFX0052478 YGFX0052477 YGFX239470 YGFX0462097 YGFX0031031 YGP0FX3845 YGFX0052474 YGFX218305 YGFX0031033 YGFX0462102 YGFW062600 YGFX218306 YGFX213213 YGFX0031001 YEFX003753B YGFX014075 YGFX003970 YGJT03250 YGFX0052446 YGFX0031030 YGP0FX3846 YGFX030102 YGFX0031026 Part Name & Description Lock Plate Spring Spring Cassette Holder (U) Assy Cassette Holder(L) Head Chassis Assy Cam Back Tension Spring Reel (R) Assy Holding Spring Washer Lack Plate Spring Lack Plate Main Chassis Assy EQ Lever Spring Dolby P.C.B. Assy Head Assy Lever Vibration-proof Spring Spring Cassette Guid Plate PRO Change Plate Idler Gear Plate (F) Assy Main Motor Assy Lack Return Spring Pinch Roller (F) Assy Idler Gear Plate (R) Assy Lack Return Link Lack Return Link Shaft Pinch Roller (R) Assy Flywheel Assy Drive Gear (2) Play Idler Gear Lock Ling Gear Gear Shaft Idler Gear Plate Spring Worm Gear Loading Motor Assy Worm Gear Stopper Drive Gear (3) Remarks
Ref. Part No. No. C1 to 3 YECUS1H471JM Part Name & Description Ceramic, 470PF 50WV Remarks

19.4. Resistors

Ref. No. R201,R207 R301,R307 R402 R403 R404 R405 R406 R408 R409 R501 Part No. ERJ6GEYJ683 ERJ8GEYJ181V ERJ6GEYJ683 ERJ6GEYJ181 ERJ6GEYJ183 ERJ6GEYJ473 ERJ8GEYJ334V ERJ8GEYJ392V ERJ6GEYJ273 ERJ8GEYJ223V ERJ6GEYJ273 ERJ6GEYJ472 Part Name & Description Chip, 68k 1/10W Chip, 180 1/8W Chip, 68k 1/10W Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, 180 1/10W 18k 1/10W 47k 1/10W 330k 1/8W 3.9k 1/8W 27k 1/10W 22k 1/8W 27k 1/10W 4.7k 1/10W Remarks
Ref. No. R1,2 R3 R4 to 6 R7, 8 Part No. ERJ8GEYJ683V ERJ6GEYJ472 ERJ8GEYJ472V ERJ8GEYJ821V Part Name & Description Chip, Chip, Chip, Chip, 68k 1/8W 4.7k 1/10W 4.7k 1/8W 820 1/8W Remarks

ORDER No. AED0109021

AUTOMOTIVE ELECTRONICS
AUDI CQ-EA1070L CQ-EA1071L CQ-EA1072L CQ-EA1073L CQ-EA1074L
AM/FM MPX ELECTRONIC TUNING RADIO with Stereo Cassette Tape Player and CD Changer
DESTINATION : Europe PRODUCED AFTER (CQ-EA1070L) : Oct., 2000 PRODUCED AFTER (CQ-EA1071L) : Jan., 2001 PRODUCED AFTER (CQ-EA1072L-74L) : Apr., 2001 [Note] See the next page about PART No. and VECLE.

Specification*

General Power Supply DC 12V (11V - 16V), Test Voltage 14.4V Negative Ground Current Consumption Power Output Speaker Impedance Less than 2.5A (0.5W4ch) 12W2ch 4 ICD Player Signal to Noise Ratio Channel Separation LW Radio Frequency Range Usable Sensitivity 153 - 279kHz 18dB/V (S/N 20dB) Dimensions** Weight** 179(W)110(H)163(D)mm 3.1kg More than 60dB (IHF-A) More than 50dB (IHF-A) Tape Player Signal to Noise Ratio Wow and Fuluter 55dB (IHF-A) Less than 0.3%
MW Radio Frequency Range Usable Sensitivity 531 - 1,602kHz 14dB/V (S/N 20dB)
* Specifications and the design are subject to possible modification without notice due to improvements. ** Dimensions and Weight shown are approximate. Dolby noise reduction manufactured under license from Dolby Laboratories Licensing Corporation.
FM Stereo Radio Frequency Range Usable Sensitivity 87.5 - 108.0MHz 12dB/V (S/N 30dB)
are trade marks of Dolby Dolby and the double-D symbol Laboratories Licensing Corporation.
2001 Matsushita Communication Industrial Co., Ltd. All rights reserved. Unauthorized copying and distribution is a violation of law.
AUDI / CQ-EA1070L / CQ-EA1071L / CQ-EA1072L / CQ-EA1073L / CQ-EA1074L

CONTENTS

1 PART No. AND VEHICLE 2 FEATUERS 3 LASER PRODUCTS 4 FRONT VIEW AND FUNCTIONS 5 REAR VIEW AND CONNECTORS 6 WIRING CONNECTION 7 BLOCK DIAGRAM 8 TERMINALS DESCRIPTION 9 PACKAGE AND IC BLOCK DIAGRAM 10 CD DISC CENTERING ALIGNMENT 11 REPLACEMENT PARTS LIST EXPLODED VIEW (Unit) 13 CD CHANGER PARTS LIST 14 EXPLODED VIEW (CD Deck-1) 15 EXPLODED VIEW (CD Deck-2) 16 EXPLODED VIEW (CD Deck-3) 17 TAPE PLAYER PARTS 18 EXPLODED VIEW (Tape Deck) 19 WIRING DIAGRAM 20 SCHEMATIC DIAGRAM -SCHEMATIC DIAGRAM -2

1 PART No. AND VEHICLE

[PART No.] (CQ-EA1070L) : 8E195 (CQ-EA1071L) : 4D195H (CQ-EA1072L) : 4B195H (CQ-EA1073L) : 8L195H (CQ-EA1074L) : 8Z095H [VEHICLE] (CQ-EA1070L) : AUDI A4 (CQ-EA1071L) : AUDI A8 (CQ-EA1072L) : AUDI A6 (CQ-EA1073L) : AUDI A3 (CQ-EA1074L) : AUDI A2

3 LASER PRODUCTS

2 FEATUERS
PLL (Phase Locked Loop) synthesized tuning. 12-FM, 12-AM presets with preset scan Dolby noise reduction. NCD-8 CD player. CD Changer control.
4 FRONT VIEW AND FUNCTIONS
5 REAR VIEW AND CONNECTORS

6 WIRING CONNECTION

7 BLOCK DIAGRAM

7.1. Main Block

Tuner / Display Block

AMP Block

CD Servo Block

8 TERMINALS DESCRIPTION

Pin No. 61

Main Block

Port Descriptions I/O (V) O O O O O O O O O I O O O O O O O O I I I I I I I I I I I I I I O I O O I I I I I O I O O FM (V) 4.2 4.8 4.4.4.4.8 4.8 4.0 2.0 4.8 0.9 AM (V) 4.2 4.8 4.4.4.4.8 4.8 4.0 3.0 4.8 0.6 CD (V) 4.1.2 4.8 4.4.4.4.8 4.8 4.0 3.0 4.8 0.6 TP (v) 4.1.2 4.8 4.4.4.4.8 4.8 4.0 3.0 4.8 0.6

IC701 : C2CBKA000001

/RSTOUT NMI VSS VDD ILL1 ILL2 TUNER1.ON TUNER2.ON LCD.ADR LCDRST LCD.CS LCD/E2.CLK
Not used (Connecting to GND) GND +5V power supply Illumi control Iiiumi. control Radio power on/off Radio power on/off LCD address LCD reset LCD selection LCD/SEC. data shift clock LCD/E2.DT. LCD/SEC. serial data IN E2.DT.OUT Security data E2.CS Security IC selection AUDIO.ON Audio power on/off VSS GND VDD +5V power supply I2C.DATA DSP/AF.SW data I2C.CLK Data shift clock F/E.DATA Tuner control data F/E.CLK Data shift clock F/E.STP Tuner control F/E.ENA Tuner pack enable VSS GND VDD +5V power supply FIELD.1 Field strength detection N.C.1.1 Noise level detection PHOTO Photo sensor data MP.1 FM multipath interference DEV.1 FM deviation ANT.V ANT1 current intensity IF.V ANT2 current intensity FIELD.2 Field strength detection VA.REF +5V power suooly VA.GND GND NC.1.2 Noise level detection MP.2 FM multipath interference 6.1V DET +B level detection +B MONI. +B level detection VSS GND VDD +5V power supply BAT.DET +B level detection P.SW Power switch T.MUTE Tape mute T.LOAD Tape loading CD.A.MUT/C CD start/stop D.SW1 STBY Power Amp stand-by LCD.MONI LCD RDS.CLK RDS data shift clock VSS GND VDD +5V power supply DAB.RX0 Not used DAB.TX0 Not used RDS2.CLK RDS data shift clock RDS2.DATA RDS data RDS.DATA RDS data PLL.DI PLL data PLL.DO PLL data PLLCLK PLL clock CDC.REMO CD CH remote data

1.2 0.8 1.9 1.6 2.0 2.3 2.3 2.3 0.5 0.5 0.5 0.0 1.2 1.2 1.2 1.2 4.8 4.8 4.8 4.0 4.8 2.4.8 4.8 4.8 4.0 4.8 4.8 1.4.8 2.5 2.4 1.2.4.8 4.7 2.4.8 4.6 4.3 4.0 4.8 4.3 1.4.8 2.5 2.4 1.0 4.6 2.4.8 4.7 4.5 4.0 4.8 4.4 1.4.8 2.5 2.4 1.0.2 4.8 2.4.8 4.8 4.7 4.0 4.8 4.7 1.4.8 2.5 2.4 1.0

Pin No. 128

I/O (V) CDC.DATA CD CH data I KLIN.OUT K-LINE data O KLIN.IN K-LINE data I PLL.CE PLL chip enable O CDC.CLK CD CH clock I BOSE BOSE Amp connection I VDD +5V power supply VSS GND N.CNTR NAVI. control I EXT.AMP.ON Ext Amp power control O CAN.N.ERR CAN-BUS error I CAN.EN CAN-BUS driver enable O CAN.STB BUS data strobe O CAN.RX CAN-BUS data I CAN.TX CAN-BUS data O CD.RST CD reset O VDD +5V power supply VSS GND /RD Not used /WR/WRL Not used /READY Not used ALE Not used /EA (+5V pull-up) MUTE Mute O KO.0 Key scan O KO.1 Key scan O KO.2 Key scan O KO.3 Key scan O KO.4 Key scan O BIT.1 Tape mode SW I BIT.2 Tape mode SW I VDD +5V power supply VSS GND BIT.3 Tape mode SW I KI.0 Key data I KO.5 Key scan O EN.B Tape end detection I A/B.IN Tape A/B side detection I AF.MUTE AF mute O NC No connection NC No connection M2 Tape main motor control O M2F Tape main motor control O T.IN Tape detection I F.IN Tape control O EN.A Tape end detection I KI.1 Key data I KI.2 Key data I KI.3 Key data I VDD +5V power supply VSS GND KI.4 Key data I R.IN Tape control O CD.SIMO CD serial data O CD STP/STA CD start/stop O CD.SOMI CD serial data I CD.SCKM CD data shift clock O CD.ON CD power control O CC.ON Tape power control O VDD +5V power supply VSS GND XTAL2 Crystal oscillator XTAL1 Crystal osillator VSS GND XTAL3 Crystal oscillator XTAL4 Crystal oscillator /RSTIN Reset input I

Descriptions

FM (V) 4.8 4.8 4.4.8 4.0 4.4.0 4.8 4.8 4.8 4.4.8 4.4.0.4.0 4.8 4.8 4.8 4.2.2 2.1.4.7
AM (V) 4.4.4.8 4.6 4.4.6 4.4.8 1.9 2.4.8 4.4.8 4.8 0.8 0.8 0.8 0.8 0.0 4.0.0 0.6 0.7 0.7 4.0.4.8 4.8 4.4.2.2 2.1.4.7
CD (V) 4.8 4.8 4.4.8 4.8 4.4.7 4.8 4.0 2.2 2.4 4.8 4.4.8 4.8 0.8 0.7 0.7 0.7 0.0 4.0.0 0.7 4.0.0 4.8 4.3 4.8 4.4.2.2 2.1.4.7
TP (v) 4.8 4.8 4.4.8 4.6 4.4.6 4.8 4.0 4.8 4.8 4.5 4.4.8 4.8 0.8 0.8 0.8 0.8 0.8 4.8 4.8 4.0.4.8 4.8 4.0 0.7 0.7 0.7 4.0.0 4.8 4.8 4.8 4.2.2 2.1.4.7
Note : Voltage measuerments are with respect to ground, with a voltmeter (internal resistance : 10M ohms). 9

Pin No. 15 16-22,51 52-56 57-75 76
Port VDD D0 D1 /WE /RAS D2 D3 /CAS0 /CAS1 A8 A7 A6 A5 A4 A9 A0 A3 VSS2 VDD2 TVD PC ECS TRD FOD FBAL TBAL VREF FE TE RFENV OFT /RFDET BDO LDON ARF IREF DRF DSLF DSLF2 PLLF VCOF AVDD2 AVSS2 OUTL AVSS1 OUTR AVDD1 FLAG FCLK TX MCLK MDATA MLD BLKCK SQCK SUBQ DMUTE STAT /RST CSEL PMCK SMCK SUBC SBCK /CLDCK /TEST Descriptions +5V power supply D-RAM data D-RAM data D-RAM data write D-RAM row address strobe D-RAM data D-RAM data D-RAM columun address strobe D-RAM columun address strobe D-RAM address D-RAM address D-RAM address D-RAM address D-RAM address D-RAM address D-RAM address D-RAM address Ground +5V power supply Not used Traverse motor control Not used Spindle motor control Tracking coil drive Focus coil drive Focus balance Tracking balance Refence voltage Focus error Tracking error RF envelope Off track signal RF detecting signal Drop-out signal Laser on signal RF signal Reference current input Bias for DSL Loop filter for DSL Loop filter for DSL Loop filter for PLL Not used +5V power supply Ground L channel output Ground R channel output +5V power supply (Connecting to ground) Flag output Frame clock Not used Not used Clock for I/F command Date for I/F command I/F command load Subcode block clock Ext.clock for sub code-Q Code for sub. code-Q Mute input Status signal Reset input (Connecting to ground) Clock output Clock output Serial data of sub code Shift clock for SUBC Not used (Connecting to VDD) I/O Vol. (V) 5.0 I/O 2.3 I/O 1.8 O 4.9 O 3.4 I/O 0.8 I/O 0 O 3.9 O 0 O 0.6 O 1.1 O 0.7 O 0 O 1.1 O 0.4 O 1.0 O 5.0 O 2.5 O 2.4 O 2.5 O 2.4 O 1.9 O 3.0 I 2.5 I 2.5 I 2.5 I 2.5 I 0 I 0 I 0 O 4.5 I 2.5 I 1.2 I 2.4 I/O 2.5 I/O 2.2 I/O 1.4 5.O 2.O 2.3 4.O 0 O 0 I 1.0 I 3.1 I 5.0 O 0 I 5.0 O 3.8 I 0 O 5.0 I 5.O 2.5 O 2.5 O 0 I 0.6 5.0

IC201 : MN662783RPW

Pin No. 79 80

Port X1 X2 VDD1 VSS1

Descriptions Crystal oscillator Crystal oscillator +5V power supply Ground
I/O Vol. (V) 0.4 3.2 5.0 0

IC301 : MN1873260AB4

Pin No. 39 40-64 Port VDD OSC2 OSC1 VSS XI XO CM VREFH SW13 SW12 SW11 SW10 SW4 SW3 SW2 SW1 VREFL /RESET SCKM SIM SOM SQCK SUBQ CD.ON BLKCK P.ON MUTE SENS CLVS FLOCK TLOCK VMI HMI HVMUTE SW9 SW8 SW7 SW6 SW5 BDO DQSY /RST STAT DMUTE XE P.DOWN MLD MDATA MCLK SPMT MUTE12 MUTE4 LDOI TRV SYNC Descriptions +5V power supply Crystal oscillator Crystal oscillator Ground (Connecting to ground) Not used (Connecting to ground) Reference voltage Shuter SW Horizontal origin Clump SW Play SW Shuter SW Tray origin SW Inner SW Outer SW (Connecting to Ground) Reset input (Ground pull-down) Clock for serial data CD changer serial data CD changer serial data Ext. clock for sub. code-Q Code for sub. code-Q Not used (Ground pull-down) CD changer start/stop Not used Sub. code block clock In operation CPU Mute output (Ground pull-down) Servo status Servo status Focus servo lock Tracking servo lock Horizontal motor control Vertical motor control H/V motor mute (Ground pull-down) Disc-in (B) SW Disc-in (L) SW Disc-in (F) SW Disc push SW Tray hight SW Drop-out signal Not used Reset output Status signal Mute output Not used Power down signal No connection I/F command load Data for I/F command Clock for I/F command Spindle mute Focus/Tracking mute Loading motor mute Loading motor control Forced traverse control Not used I/O Vol. (V) 5.0 2.2 2.I 5.0 I 4.9 I 4.9 I 0 I 0 I 4.9 I 0 I 4.8 I 4.I 4.I 5.0 I 1.3 O 4.3 O 5.0 I 1.I 5.0 I 0 O 5.0 O 5.O 0 O 5.0 O 0.2 O 0 O 2.5 O 0 O I 0 I 0 I 0 I 0 I 4.5 I 0 O 5.0 I 2.1 O 0 O 0 O 5.0 O 3.1 O 4.1 O 5.0 O 0 O 4.8 I/O 2.5 I/O 2.4 -

9 PACKAGE AND IC BLOCK DIAGRAM

9.1. Main Block

IC105 : YEAMLC72146T

PA101 : J3CCAB000001

IC205, 382 : YEAMPC4570T1

PA102 : YEAU03SMX01

ICIC281 : C1BA00000311

IC101, 103 : AN6564NST1

IC705 : YEAMS2922ADF IC102, 104, 204 : C0ABCB000005
IC704 : MN1382QTX IC715 : MN1382JP

IC710 : YEAMLB1930MT

IC706 : YEAM2951MT IC713 : C0EBM0000005

IC707 : C1EB00000039

IC881 : C1EB00000042

IC601 : YEAMBA5971FP

IC101 : YEAMBA6354BF

IC202 : C3ABMB000010

IC401 : YEAMBA6792FY

IC501 : YEAMPC358G2T

IC603 : YEAMT4W53FUL
10 CD DISC CENTERING ALIGNMENT
This adjustment is for assuring that compact discs will be placed in the center of the turntable. <Adjustment Condition / Jig> Power Supply Voltage : 13.2V Test Disc : TCD-784M
<Adjustment Procedures> 1. Attach the adjusting screw to the upper chassis (See Figure 1.). 2. Insert the test CD (TCD-784M) into the disc No.1 position and play it. 3. After checking whether the disc is centered on the turntable, turn the adjusting screw unit it is in the center. <Check Items> Check that the disc is correctly centered. Check that the disc is securely clamped. Check that no abnormal noise is produced when clamping the disc. [Directions of Turning the Adjusting Screw] CD stops before its proper position : Turn the screw counterclockwise. CD overruns : Turn the screw clockwise.
4. After the adjustment, lock the screw.
11 REPLACEMENT PARTS LIST
Notes : 1. Be sure to make your orders of replacement parts according to this list. mark 2. Important safety notice: Components, identified by have special characteristics important for safety. When replacing any of these components, use only manufacturers specified parts. 3. Location keys in the remarks column indicates the general location of the parts shown in the exploded drawing, as in a road map. 4. The marking (RTL) indicates that Retention Time is limited for this item. After the discontinuation of assembly in production, the item will continue to be available for a specific period of time. The retention period of availability is dependent on the type of assembly, and in accordance with the laws governing part and product retention. After the end of this period, the assembly will no longer be available. 5. "A", "B", C, D or E marks in remarks column are indicated as follows : A : CQ-EA1070L B : CQ-EA1071L C : CQ-EA1072L D : CQ-EA1073L E : CQ-EA1074L

Ref. Part No. Part Name & Description No. [E6802B] Main/Amp Block ICs and TRANSISTORs IC101 AN6564NST1 IC IC102 C0ABCB000005 IC IC103 AN6564NST1 IC IC104 C0ABCB000005 IC IC105 YEAMLC72146T IC IC106 YEAMBU1923F IC IC107 C0DBAHE00007 IC IC201 YEAMTA7705FL IC IC202 C0ABCB000005 IC IC203 YEAMPC4570T1 IC IC204 C0ABCB000005 IC IC205 YEAMPC4570T1 IC IC281 C1BA00000311 IC IC382 YEAMPC4570T1 IC IC401 C0ABBA000022 IC IC701 C2CBKA000001 IC IC702 C2HBZY000007 IC IC703 C1BB00000408 IC IC704 MN1382QTX IC IC705 YEAMS2922ADF IC IC706 YEAM2951MT IC IC707 C1EB00000039 IC IC708 YEAMC14584BE IC IC709 YEAM74HC126F IC IC710 YEAMLB1930MT IC IC711 C3BBGC000005 IC IC712 C3BBGC000005 IC IC713 C0EBM0000005 IC IC715 MN1382JP IC IC717 C0DBEMF00001 IC IC718 C0CBABA00006 IC IC719 YEAMT7SH00UL IC IC720 YEAMT7SH00UL IC IC881 C1EB00000042 IC Remarks
Ref. No. IC882 IC883 IC884 IC885 IC887 PA101 PA102 Q106 Q108 Q109 Q110 Q111 Q112 Q201 Q202 Q203 Q301 Q302 Q303 Q401 Q403 Q404 Q405 Q406 Q407 Q701 Q702 Q705 Q706 Q708 Q710 Q712 Q713 Q726 Q727 Q728 Q883 Q884 Q885 Q887 Q888 Q889 Q890 Q892 Q893 Q894 Q895 Q896
Part No. C0DBZHZ00007 C0DBAHE00007 YEAMPC2410HF C0DAAHF00004 AN7805F J3CCAC000001 YEAU03SMX01 YEANFP1F3PT1 B1GBCFNN0004 2SB1440TX YEANFP1F3PT1 YEANC114YKX B1GBCFNN0004 YEANC323TKT YEANC323TKT YEANC323TKT YEANC323TKT YEANC323TKT YEANC323TKT B1BBAC000007 B1ABBD000004 YEANC3518ZT1 2SD1328STTX YEANC114YKX YEANC114YKX B1ABCF000042 B1GDCFJJ0008 YEANA144EKTX YEANC3661TA YEAN2SK536TB YEANC114YKX YEANFP1F3PT1 YEANFP1F3PT1 YEANC114YKX 2SB1398QTA B1GBCFNN0004 YEANC3518ZT1 2SD1328STTX 2SD1328STTX 2SB1193 YEANC114YKX 2SB1446TA YEANHQ1F3PT1 YEANC3518ZT1 YEANHQ1F3PT1 B1GBCFJJ0002 2SB1073TX 2SB1073TX
Part Name & Description IC IC IC IC IC Electronic Tuner Electronic Tuner Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor Transistor

Remarks

DIODEs D101 D102 D103 D104 D105 D106 D108 D109 D110 D111 D201 D202 D203 D204 D303 D304 D401 D402 D403 D404 D405 D406
MA153ATW YEADRD43M2T2 MA153ATW MA153ATW YEADRD43M2T2 MA153ATW YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 MA8068MTX YEADRB051L40 MAZ816000L MAZ816000L MAZ816000L MAZ816000L MA8051MTX MA8051MTX YEAD1SS355T1 YEAD1SS355T1 MA2J72900L YEAD1SS355T1
Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode
Ref. No. D409 D410 D709 D710 D711 D712 D723 D724 D725 D726 D727 D731 D732 D733 D736 D738 D741 D881 D884 D885 D886 D887 D888 D889 D891 D892 D893 D894 D895 D896 D897
Part No. MAZ33600ML MAZ33600ML YEADEC10DS1 MA2J72900L YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 B0BC5R600014 YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 MA151WKTW MA151WA YEAD1SS355T1 YEADDSM3MA2T MAZ80620HL YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 MA151WKTW YEAD1SS355T1 MAZ816000L MAZ816000L MA8056LMHTX MA8056LMHTX MA8056LMHTX MA8056LMHTX

Part Name & Description Chip, 150 1/10W Chip, 1k 1/4W Chip, 1.0 1/10W Chip, 1.0 1/10W Chip, 10k 1/16W Chip, 10k 1/16W Chip, 10k 1/10W Chip, 0 1/10W Chip, 4.7 1/8W Chip, 4.7 1/8W Chip, 1k 1/10W Chip, 180 1/10W Chip, 180 1/16W Chip, 100k 1/10W Chip, 10k 1/10W Chip, 2.2k 1/8W Chip, 10k 1/10W Chip, 12k 1/10W Metal Oxid, 82 1W Chip, 18 1/2W Chip, 18 1/2W Chip, 1k 1/16W Chip, 1.8 1/4W Carbon, 10k 1/16W Chip, 3.3k 1/10W Chip, 10k 1/16W Chip, 1k 1/10W Chip, 2.2 1/10W Carbon, 27k 1/16W Chip, 1.2k 1/10W Chip, 120k 1/16W Chip, 1k 1/8W Chip, 1k 1/8W Chip, 1k 1/8W Chip, 0 1/10W Chip, 0 1/10W Chip, 0 1/10W Chip, 0 1/10W Chip, 0 1/10W
CONNECTORs CN701 K1KA18B00029 CN702 K1KA18B00029 CN705 K1MR16A00013 CN706 K1MR16A00013 CN707 YEAE5280610 CN708 YEAE5280607 CN709 YEAE5280605 CN711 K1MN15A00007 CN881 YEAE012805 CP627 MGCAE00009 CP628 MGCAE00010 CP629 CP630 CP701 CP702 CP703 CP704 MGCAE00011 MGCAE00012 K1MQ18A00002 K1MQ18A00002 K1KA14B00082 K1KA14B00082
Connector, 18P Connector, 18P Connector, 16P Connector, 16P Connector, 10P Connector, 7P Connector, 5P Connector, 15P Connector Flexible Connector (Tape), 7P Flexible Connector (Tape), 10P Flexible Connector (CD), 15P Flexible Connector (CD), 15P Connector, 18P Connector, 18P Connector, 14P Connector, 14P
COILs L101 L102 L108 L109 L110 L111 L112 L401 L402 L403
G0E000000039 G1C102M00003 J0JCC0000012 J0JCC0000012 J0JCC0000012 G1C5R6JA0005 J0JCC0000030 ELER102KA YELT03N4R7KT J0JCC0000012
Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil
Ref. No. L404 L405 L406 L701 L702 L703 L704 L705 L706 L707 L708 L709 L710 L711 L712 L713 L721 L725 L726 L727 L729 L730 L732 L733 L734 L791 L881 L882 L883 R879
Part No. G0B102K00003 YELT45N4R7KT YELT03NR15JT J0JCC0000012 J0JCC0000030 J0JCC0000030 J0JCC0000012 J0JCC0000012 J0JCC0000012 J0JCC0000012 J0JCC0000030 J0JCC0000012 J0JCC0000012 J0JCC0000012 J0JCC0000012 J0JCC0000030 J0JCC0000012 J0JCC0000030 J0JCC0000030 J0JCC0000030 J0JCC0000030 J0JCC0000012 J0JCC0000012 J0JCC0000012 G0B102K00003 J0JCC0000012 YETQ014T162 J0JCC0000012 J0JCC0000030 J0JCC0000012
Part Name & Description Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil Coil

Ref. No. Q635 Q636 Q639 Q640 Q651
Part No. YEANC114YKX YEANC114YKX YEANSFH320T B1ABCF000044 YEAN2SK536TB
Part Name & Description Transistor Transistor Transistor Transistor Transistor
CRYSTALs XL101 H0D720400003 XL102 YEXL49U0433T XL700 H0D419400009 XL701 H0A327200019 XL702 H0D889400001
Crystal Crystal Crystal Crystal Crystal

LAMP Z101

YEAL02012T
THERMISTOR R842 D4ZZ00000015 R890 YERT7AR4R7MT

Thermistor Thermistor

NETWORK CR503 CR504 CR505 CR506 CR507 CR508 CR509 CR510 CR511 CR512
RESISTORs EXBV8V102JV EXBV8V102JV EXBV8V102JV EXBV8V102JV EXBV8V102JV EXBV8V102JV EXBV8V102JV EXBV8V102JV EXBV8V102JV EXBV8V102JV
Network Network Network Network Network Network Network Network Network Network
Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor Resistor

FILTER CS881

YECCL55S222T

Filter

[E8856B] Display Block ICs and TRANSISTORs Q631 YEANC114YKX Transistor Q632 YEANC114YKX Transistor Q633 YEANFP1F3PT1 Transistor Q634 YEANFP1F3PT1 Transistor
DIODEs D501 D502 D503 D504 D505 D506 D507 D508 D509 D510 D511 D512 D513 D514 D515 D516 D517 D518 D519 D520 D521 D522 D523 D524 D525 D526 D527 D528 D529 D530 D531 D532 D533 D534 D535 D536 D537 D538 D539 D540 D541 D542 D543 D544 D545 D546 D547 D548 D549 D550 D551 D552 D553 D554 D555 D556 D557 D558 D559 D560 D561 D562 D563 D564 D565
YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEADLST676T YEAD1SS355T1
Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode Diode
Ref. No. D566 D567 D568 D569 D651 D652 D702 D703 D704 D705 D706 D707
Part No. YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 YEADLST676T YEAD1SS355T1 MA8056LMHTX YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1 YEAD1SS355T1

SWITCHEs SW631 K0H1BA000368 SW632 K0H1BA000368 SW633 K0H1BA000368 SW637 K0H1BA000368 SW638 K0H1BA000368 SW639 K0H1BA000368 SW640 K0H1BA000368 SW643 K0H1BA000368 SW644 K0H1BA000368 SW645 K0H1BA000368 SW646 K0H1BA000368 SW647 K0H1BA000368 SW649 K0H1BA000368 SW650 K0H1BA000368 SW651 K0H1BA000368 SW652 K0H1BA000368 SW653 K0H1BA000368 SW655 K0H1BA000368 SW656 K0H1BA000368 SW657 K0H1BA000368 SW658 K0H1BA000368 SW659 K0H1BA000368
Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch Switch

LCD LCD651 COIL L651

L5DAAMD00001

J0JCC0000012

VARIABLE RESISTORs VR681 EVQBS506215B VR682 EVQBS406115B
Variablr resistor Variablr resistor
THERMISTOR TH651 D4CC21040005

Thermistor

Mechanical Parts MISCELLANEOUS FS881 K5Y103200001 ANT101 YEAA10087 ANT102 K1ZZ00001151 AT1 YEATMGCFZMGCFXMGCFA00033C 4 MGCFSYEFK06919A 6 MGCFVMGCFVMGCFXMGCFF00003
Fuse, 10A Antenna Receplacle Antenna Receplacle Terminal, GND Side Plate (L) Assy Bracket Front Plate Felt Pad Holder, LCD LCD Diffuse Sheet LCD Diffuse Sheet Holder, LCD Guide

A,C,D,E

Ref. No. 39 39
Part No. MGCFA00029A MGCFX00007A YEFM031083 MGCFX00012 MGCFF00002A MGCFF00004A MGCFZ00004 YEFF011054 MGCFF00003 MGCFX00014 MGCFX00009 YEFS011772 MGCFA00030B MGCFA00034A YEP0PT6802Z0 YEP0PT6802Y0 MGCFS00017 MGCFC00013C MGCFC00020B MGCFC00023B MGCFC00027B MGCFC00030B MGCFE00004C MGCFE00084B YEFR07129A YEFR07125A MGCFX00004 YEFX0213919 MGCFS00024 MGCFX00008 YEP0PT8856Z0 YEP0PT8856V0
Part Name & Description Upper Cover Bracket, CD Deck Laser Seal Spring Heat Sink Heat Sink Side Plate (R) Assy IC Heat Sink Guide Bracket, ANT Bracket, Tape Deck (R) Pad Bottom Cover Shield Case PCB w/Compnent PCB w/Compnent Felt Pad Escucheon Assy Escucheon Assy Escucheon Assy Escucheon Assy Escucheon Assy Knob Assy Knob Assy Rubber Contact (R) Rubber Contact (L) Plate Bracket, GND Pad Bracket, Tape Deck (F) PCB w/Compnent PCB w/Compnent

A,C,D,E B

RTL A,C,D,E RTL, B B A B C D E A,C,D,E B

RTL, A RTL B,C,D,E

YEJT03120 YEJT03131 YEJT03007 XSB26+4FX YEJS06017 YEJS06093 XTB2+6GFX XTB3+8JFX XTB3+6FFX XTB3+5FFX XTB3+8FFX XYN26+C10FX XSN5+16FX

[E2682]

Ref. No. D1 Part No. 0N1004 LED Part Name & Description Remarks

[E2684]

Ref. No. D1 D2 D3 Part No. LN01201C LN01201C LN01201C LED LED LED Part Name & Description Remarks

13.3. Capacitors

Ref. No. C100 C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C118 C120 C122 Part No. ECEV1CA470SP YECUS1C104KX YECUS1C104KX F3H0J1070005 YECUS1C104KX F3E0J475A001 YECUS1E273KX YECUS1H152KX YECUS1H472KX YECUS1H102KX YECUS1H102KX YECSW1C106MS YECUS1C104KX YECUS1C104KX YECSW1C106MS YECUS1H102KX YECUS1H102KX YECUS1H391JM YECUS1H561JM YECUS1C104KX Part Name & Description Electrolytic, 47F 16WV Ceramic, 0.1F 16WV Ceramic, 0.1F 16WV Tantalum, 100F 6.3WV Ceramic, 0.1F 16WV Ceramic, 4.7F 6.3WV Ceramic, 0.027F 25WV Ceramic, 0.0015F 50WV Ceramic, 0.0047F 50WV Ceramic, 0.001F 50WV Ceramic, 0.001F 50WV Tantalum, 10F 16WV Ceramic, 0.1F 16WV Ceramic, 0.1F 16WV Tantalum, 10F 16WV Ceramic, 0.001F 50WV Ceramic, 0.001F 50WV Ceramic, 390PF 50WV Ceramic, 560PF 50WV Ceramic, 0.1F 16WV Remarks
Ref. No. R317 R318 R319 R320 R321 R322 R324 R325 R326 R327 R328 R401 R402 R501 R502 R503 R504 R505 R601 R602 R603 R604 R605 R606 R607 R608 R609
Part No. ERJ6GEYJ471 ERJ6GEYJ471 ERJ6GEYJ471 ERJ6GEYJ471 ERJ6GEYJ471 ERJ6GEYJ473 ERJ6GEYJ473 ERJ6GEYJ473 ERJ6GEYJ473 ERJ6GEYJ473 ERJ6GEYJ473 ERJ6GEYJ222 ERJ6GEYJ222 ERJ6GEYJ101 ERJ6GEYJ103 ERJ6GEYJ103 ERJ6GEYJ222 ERJ6GEYJ103 ERJ6GEYJ123 ERJ6GEYJ103 ERJ6GEYJ273 ERJ6GEYJ103 ERJ6GEYJ183 ERJ6GEYJ393 ERJ6GEYJ103 ERJ6GEYJ472 ERJ6GEYJ472
Part Name & Description Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, Chip, 470 1/10W 470 1/10W 470 1/10W 470 1/10W 470 1/10W 47k 1/10W 47k 1/10W 47k 1/10W 47k 1/10W 47k 1/10W 47k 1/10W 2.2k 1/10W 2.2k 1/10W 100 1/10W 10k 1/10W 10k 1/10W 2.2k 1/10W 10k 1/10W 12k 1/10W 10k 1/10W 27k 1/10W 10k 1/10W 18k 1/10W 39k 1/10W 10k 1/10W 4.7k 1/10W 4.7k 1/10W

13.7. Mechanical parts

MISCELLANEOUS
Ref. No. 27 Part No. YEAE012348A YEAP2683 YEATSD00405 YEFA011711G YEFA011713A YEFA011714D YEFA011716 YEFA011718A YEFA011720B YEFA011722A YEFA011858B YEFS04688 YEFS04691 YEFV011897 YEFW04158 YEFW04159A YEFW04161A YEFW04167 YEFW05389 YEFW062351 YEFW062461B YEFX003872 YEFX003873 YEFX003874 YEFX003875 YEFX003877 YEFX003878A YEFX003879 YEFX003882A YEFX003883B YEFX003884 YEFX0031007 YEFX0031057 YEFX003891A YEFX0031003 YEFX003894 YEFX003895A YEFX003896 YEFX003897A YEFX003898 YEFX003899B YEFX003929 YEFX003931 YEFX003932A YEFX0052269 YEFX0052272 YEFX0052274B YEFX0052275A YEFX0052276A YEFX0052277 YEFX0052278 YEFX0052279 YEFX0052280 YEFX0052281A YEFX0052284 YEFX0052285A YEFX0052499 YEFX0052527 YEFX0052289A YEFX0052290A YEFX0052291B YEFX0052292A Part Name & Description Cord w/Connector Suspension FPC Terminal Upper Chassis Assy Side Chassis (R) Side Chassis (L) Assy Suspension Chassis Assy Suspension Chassis(Bottom) Assy Swing Chassis Assy Stocker Plate Assy Main Chassis Assy Damper Damper Insulator Bearing Roller Shaft Holder(L) Feed Screw Housing Disc Collar Stocker Cam Ring Disc Roller Shaft Roller Shaft Assy Elevator Gear(1) Elevator Gear(2) Elevator Gear(3) Elevator Gear(4) Traverse Gear(2) Traverse Gear(3) Traverse Gear(4) Stocker Cam Gear(1) Stocker Cam Gear(2) Stocker Cam Gear(3) Disc Hold Gear Load Gear Push Gear(1) Push Gear(2) Horizontal Cam Gear(1) Horizontal Cam Gear(2) Horizontal Gear(1) Horizontal Gear(2) Horizontal Gear(3) Horizontal Gear(4) Horizontal Cam Gear(3) Horizontal Gear(5) Push Cam Gear FPC Hold Spring Guide Spring(B) Suspension Lock Spring Swing Spring Stocker Spring(1) Stocker Spring(2) Thrust Spring Sencer Lever Spring Damper Spring Balance Spring(1) Push Spring Spring Roller Hold Spring(L) Roller Hold Spring(R) Push Lever Spring Feeder Spring Push Plate Spring Change Spring Remarks (4-A) (1-E) (1-F) (3-B) (1-C) (4-A) (1-D) (1-D) (3-D) (4-F) (3-E) (4-D) (4-D) (2-F) (3-D) (2-B) (1-E) (2-B) (4-E) (3-F) (2-A) (2-B) (3-F) (2-F) (3-F) (3-E) (3-E) (2-F) (2-D) (2-D) (1-D) (3-F) (3-E) (2-F) (3-E) (2-F) (3-F) (3-B) (3-B) (3-B) (3-D) (2-E) (3-E) (3-E) (3-E) (3-D) (3-E) (3-D) (2-D) (3-B) (2-D) (1-B) (3-D) (3-D) (4-D) (4-E) (4-D) (4-E) (1-E) (1-E) (1-F) (4-D) (3-D) (3-A) (4-B) (2-B) (2-B) (4-E) (4-B) (3-B) (1-D)

13.5. Connectors

Ref. No. CN1 CN101 CN301 CN401 CN402 CN501 Part No. YEAE5220715 YEAE5220715 YEAE5227112 YEAE5220706 YEAE5326102 YEAE5227110 Part Name & Description Connector, Connector, Connector, Connector, Connector, Connector, 15P 15P 12P 6P 2P 10P Remarks
Ref. No. JD1 Part No. YEAE5227106 Part Name & Description Connector, 6P Remarks

13.6. Electric Parts

SWITCHES
Ref. No. SW1 SW1 SW10 SW11 SW12 SW13 Part No. ESE102MH4 ESE102MH4 ESE102MH4 ESE102MH4 ESE102MH4 ESE102MH4 Part Name & Description Switch Switch Switch Switch Switch Switch Remarks

CRYSTAL

Ref. No. XL301 Part No. YEXLSTCC737T Part Name & Description Crystal OSC Remarks

CERAMIC FILTERS

Ref. No. XL201 Part No. H2D169500001 Part Name & Description Ceramic Filter Remarks
Ref. No. L101 Part No. YELTLM41P750 Part Name & Description Coil Remarks

Ref. No. 141

Part No. YEFX0052335 YEFX0052366 YEFX0052368 YEFX0052369A YEFX0052445 YEFX018552 YEFX018553D YEFX018595 YEFX018556A YEFX018596 YEFX018598 YEFX018600 YEFX0461903A YEFX0461905A YEFX0461914B YEFX0461917 YEFX0461918 YEFX0461919A YEFX0461922D YEFX046211B YEFX0461926A YEFX0461931A YEFX0462062B YEFX219129 YEFX0462002C YEFX0462003B YEFX0462026 YEFS02342 YEFX0462029 YEFX206135C YEFX206136D YEFX206137A YEFX206138C YEFX206139E YEFX206140 YEFX206141A YEFX206143 YEFX206144 YEFX218296 YEFX218299 YEFX219124A YEFX219126D YEFX233504A YEFX233521 YEFX233506 YEFX234192 YEFX249486 YEFX9991900A YEFX9992237 YEFX9991903A YEJT03220 YEP0FX3384 YEP0FX3633 YEP0FX3661S YEP0FX3660S YEP0FX3662S YEP0FX3663S YEFX218308 YEFX0031053 YEFX0031054 YEFX014040 YEP0PT8586A2 YEP0PT2682A0 YEP0PT2684A0 YEP0PT2685A0
Part Name & Description Guide Spring(F) Stocker Thrust Spring Damper Spring (R ) Damper Spring (L) Lock Spring Travese Motor Bracket Assy Guide(F) Bracket Guide(B) Bearing Bracket Stopper Plate Gear Bracket Assy Elevator Motor Bracket Guide Lever (B) Assy Guide Lever (F) Assy Senser Cover Stocker Rack Senser Lever(B) Sneser Lever(FA) Feeder Plate Push Lever Rack Lever Push Lever Escape Lever(1) Guide (F) Guide Cam Plate(F) Guide Cam (B) Plate Assy Lever Guide Plate Assy Felt Feeder Guide Plate Assy Guide(BL) Guide(BU) Guide(FL) Guide(FU) Disc Guide Traverse Guide FPC Guide Disc Guide(S) Disc Guide(U) Disc Roller Disc Roller Guide (B) Base Assy Guide Base (F) Assy Stocker Tray Housing Disc Holder(L) Disc Holder(U) Elevator Cam Feeder Arm Assy Suspension Balancer Stocker Tray Feed Screw Guide Feed Screw Assy Optical Pick-up Assy Spindle Motor Assy Horizontal Motor Assy Vertical Motor Assy Loading Motor Assy Traverse Motor Assy Roller Load Gear Load Gear Retaining Ring, 2mm PCB w/Component PCB w/Component PCB w/Component PCB w/Component
Remarks (2-B) (4-E) (3-F) (4-D) (4-D) (3-A) (2-E) (3-E) (3-D) (3-D) (1-D) (2-D) (3-F) (3-D) (3-E) (1-F) (4-F) (2-E) (1-F) (2-B) (3-A) (3-F) (4-E) (3-A) (2-B) (1-B) (1-B) (2-D) (4-A) (2-B) (1-B) (1-B) (2-B) (2-B) (2-A) (1-D) (1-D) (2-D) (3-B) (2-A) (2-B) (1-B) (2-B) (4-D) (3-F) (4-E) (2-E) (1-A) (1-D) (4-D) (1-E) (1-D) (1-E) (1-E) (4-A) (3-F) (3-C) (2-E) (1-A) (2-B) (2-C) (2-C) RTL RTL RTL RTL

Ref. No. 173 174

Part No. YEJS06097A YEJS06173 YEJS06220 YEJT03216 XQN14+C18FX XQN17+A2FX XQN2+A2FX XQN2+C25FX XSB2+3FX XSB26+3FX XYN2+C3FX XYN2+C4FX XSB2+4FX XYN2+J5FX XYN2+C6FX XYN2+J8FX XQN2+C2FX YEJT03129 YEJS06244 YEJS06242
Part Name & Description Screw, 2mm * 2.5mm Screw Screw Tapping Screw Screw Screw Screw Screw Screw, 2mm * 3mm Screw, 2.6mm * 3mm Screw, 2mm * 3mm Screw, 2mm * 4mm Screw, 2mm * 4mm Screw, 2mm * 5mm Screw, 2mm * 6mm Screw, 2mm * 8mm Screw, 2mm * 2mm Tapping Screw, 2mm * 4mm Screw Screw

Ref. No. 152 153

Part No. XUC2V YEJE01044 XUC15V YEFX014047
Part Name & Description Retaining Retaining Retaining Retaining Ring, 2mm Ring Ring, 1.5mm Ring
14 EXPLODED VIEW (CD Deck-1)
15 EXPLODED VIEW (CD Deck-2)
16 EXPLODED VIEW (CD Deck-3)

17 TAPE PLAYER PARTS

Ref. Part No. Part Name & Description No. [E8927A] Tape Reel Block RESISTORs J1 ERJ8GEY0R00V Chip, 0 1/8W J2 ERJ8GEY0R00V Chip, 0 1/8W J3 ERJ8GEY0R00V Chip, 0 1/8W J4 ERJ8GEY0R00V Chip, 0 1/8W J5 ERJ8GEY0R00V Chip, 0 1/8W J6 ERJ8GEY0R00V Chip, 0 1/8W J7 ERJ8GEY0R00V Chip, 0 1/8W J8 ERJ8GEY0R00V Chip, 0 1/8W R1 ERJ8GEYJ683V Chip, 68k 1/8W R2 ERJ8GEYJ683V Chip, 68k 1/8W R3 ERJ8GEYJ472V Chip, 4.7k 1/8W R4 ERJ8GEYJ472V Chip, 4.7k 1/8W R5 ERJ8GEYJ472V Chip, 4.7k 1/8W R6 ERJ8GEYJ472V Chip, 4.7k 1/8W R7 ERJ8GEYJ821V Chip, 820 1/8W R8 ERJ8GEYJ821V Chip, 820 1/8W Remarks

CONNECTOR CN2 YEAE012406

Connector, 10P
SWITCHEs SW4 K0F111B00047 SW5 K0G131E00001

Switch Rotary Switch

[E8928] SW Block DIODE D1 B0EANM000002

Ref. No. 66 67

Part No. YGFX0462105 YGFX0052478 YGFX0052477 YGFX239470 YGFX0462097 YGFX0031031 YGP0FX3845 YGFX0052474 YGFX218305 YGFX0031033 YGFX0462102 YGFW062600 YGFX218306 YGFX213213 YGFX0031001 YGFX0031004A YGFX014075 YGFX003970 YGJT03250 YGFX0052446 YGFX0031030 YGP0FX3846 YGFX030102 YGFX0031026 YGFA011851 YGP0PT8927A0 YGFX209270 YGFX0052473 YGFX003971 YEFR03083 YGFX0031029 YEJE01004 YEJE01036 YGFW062546 XYN2+C8FX YEJT03167 YEJS06097A YGJT03271
Part Name & Description Lever Vibration-proof Spring Spring Cassette Guid Plate PRO Change Plate Idler Gear Plate (F) Assy Main Motor Assy Lack Return Spring Pinch Roller (F) Assy Idler Gear Plate (R) Assy Lack Return Link Lack Return Link Shaft Pinch Roller (R) Assy Flywheel Assy Drive Gear (2) Lack Return Gear Lock Ling Gear Gear Shaft Idler Gear Plate Spring Worm Gear Loading Motor Assy Worm Gear Stopper Drive Gear (3) Drive Chassis Assy Reel P.C.B. Assy Reel (F) Assy Pinch Roller Spring PRO Change Gear Belt Drive Gear E-Ring E-Ring Screw Screw, 2 x 8mm Screw, Screw, 2 x 2.5mm Screw,

CAPACITOR C1 F1K1E334A022

Ceramic, 0.33F 25WV

RESISTOR R2 ERDS2TJ472

Carbon, 4.7k 1/4W

CONNECTOR CN1 YEAE012405

Connector, 7P

SWITCHEs SW2 YEAS07174 SW3 YEAS08042

Switch Switch

Mechanical Parts MISCELLANEOUS 1 YGFXYGFXYGFXYGFXYGFAYGFXYGFXYGFXYGFXYGJWYGFXYGFXYGFAYGFXYGP0PT8928AYGP9FZ2993
Lock Plate Spring Spring Cassette Holder (U) Assy Cassette Holder(L) Head Chassis Assy Cam Back Tension Spring Reel (R) Assy Holding Spring Washer Lack Plate Spring Lack Plate Main Chassis Assy EQ Lever Spring SW P.C.B. Assy Head Assy
18 EXPLODED VIEW (Tape Deck)

20 SCHEMATIC DIAGRAM -1

20.1. Display Block

20.2. Tape Block

<Tape Head>

E-2702

B-Lch B-Rch A-Rch A-Lch VREF 4

B-Rch 3 A-Rch 2 A-Lch 1

E-8927A
4 BITEQ 6 M1B 7 5V TEM1A 9 TETE1
R1 68K R2 68K R3 4.7K R4 4.7K R5 4.7K

R6 4.7K

Loadig Motor
SW3 SW1 SW2 C1 0.33 D1 10DS1

R2 4.7K

CN0V 2 T/I 3 GND 4 T/L 5 A/B 6 M2+ 7 M2F

DC MOTOR

To Main P.C.B E-6802Ba CN708

E-8928

To Main P.C.B E-6802Ba CN707

1 BITGND 3 BIT2

R8 820

R7 820

To Main P.C.B E-6802Ba CN709

21 SCHEMATIC DIAGRAM -2

21.1. AMP / Memory / Relay Block

21.2. Tuner Block

21.3. Main Block

21.4. CD Servo Block

Printed in Japan (K)

2001. 9

(Recycled Paper)
To Main P.C.B. E-8856Bb CN752