ORDER NO.

RRV2106

FILE-TYPE COMPACT DISC PLAYER

PD-F958

Refer to the service manual RRV2085 for PD-F958/KUXQ/CA.
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Type Model Power Requirement PD-F958 MYXQ MVXQ O O AC220-230V AC220-230V Remarks

CONTENTS

1. SAFETY INFORMATION. 2 2. CONTRAST OF MISCELLANEOUS PARTS.. 3 3. SCHEMATIC DIAGRAM. 8 4. PCB CONNECTION DIAGRAM.. 11
PIONEER ELECTRONIC CORPORATION 4-1, Meguro 1-Chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS SERVICE, INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER ELECTRONIC (EUROPE) N.V. Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER ELECTRONIC CORPORATION 1999
TZZR FEB. 1999 Printed in Japan

1. SAFETY INFORMATION

This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician.
IMPORTANT THIS PIONEER APPARATUS CONTAINS LASER OF CLASS 1. SERVICING OPERATION OF THE APPARATUS SHOULD BE DONE BY A SPECIALLY INSTRUCTED PERSON. LASER DIODE CHARACTERISTICS MAXIMUM OUTPUT POWER: 7 mw WAVELENGTH: nm
LABEL CHECK for (PD-F958/MYXQ and PD-F958/MVXQ types) PD-F958/MYXQ only

Additional Laser Caution

1. Laser Interlock Mechanism The position of the switch (S651) for detecting loading state is detected by the system microprocessor, and the design prevents laser diode oscillation when the switch (S651) is not on CLMP terminal side (CLMP signal is OFF or high level). Thus, the interlock will no longer function if the switch (S651) is deliberatery set to CLMP terminal side. (low level) The interlock also does not function in the test mode *. Laser diode oscillation will continue, if pin 33 of CXA1782CQ (IC151) on the MOTHER BOARD ASSY is connected to GND, or pin 22 of IC301 (LDON) is connected to low level (ON), or else the terminals of Q151 are shorted to each other (fault condition). 2. When the cover is opened, close viewing of the objective lens with the naked eye will cause exposure to a Class 1 laser beam.

PD-F958/MVXQ only

* : Refer to page 29. on the service manual RRV2085.
2. CONTRAST OF MISCELLANEOUS PARTS
NOTES : Parts marked by NSP are generally unavailable because they are not in our Master Spare Parts List. mark found on some component parts indicates the importance of the safety factor of the part. The Therefore, when replacing, be sure to use parts of identical designation. Reference Nos. indicate the pages and Nos. in the service manual for the base model. When ordering resistors, first convert resistance values into code form as shown in the following examples. Ex. 1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J = 5%, and K = 10%). 560 = 1 = 561... RD1/4PU 1 J 47k = 3 = 473.. RD1/4PU 3 J 0.5 = R50... RN2H K 1 = 1R0... RS1P K Ex. 2 When there are 3 effective digits (such as in high precision metal film resistors). 5.62k = 1 = 5621.. RN1/4PC F
7 CONTRAST OF PD-F958/KUXQ/CA, MYXQ and MVXQ
PD-F958/ MYXQ, MVXQ and KUXQ/CA are constructed the same except for the following:
Ref. No. Mark Symbol and Description KUXQ/CA type EXTERIOR
P6-1 P6-2 P6-3 P6-4 MAIN BOARD ASSY POWER BOARD ASSY DISPLAY BOARD ASSY SWITCH BOARD ASSY HEADPHONE BOARD ASSY Cord Stopper AC Power Cord Fuse(T5A) (For AC power cord) Foot Assy Rear Base Display Window Operation Panel Headphone Knob LED Lens 65 Label Caution Label (HE) Caution Label Caution Label Sheet PWZ3895 PWZ3900 PWZ3904 PWZ3907 Not used CM-22C PDG1064 Not used REC1263 PNA2452 PAM1772 PNW2869 Not used Not used ORW1069 Not used Not used Not used Not used PWZ3896 PWZ3901 PWZ3905 PWZ3908 PWZ3910 CM-22B PDG1003 Not used Not used PNA2453 PAM1773 PNW2870 PAC1707 PNW2019 Not used PRW1233 VRW1094 Not used PEC1038 PWZ3897 PWZ3901 PWZ3905 PWZ3908 PWZ3910 CM-22B PDG1055 PEK1003 Not used PNA2454 PAM1773 PNW2870 PAC1707 PNW2019 Not used Not used Not used PRW1018 PEC1038

Part No. Remarks MYXQ type MVXQ type

NSP NSP

P6-10 P6-12 P6-14 P6-18 P6-47 P6-50

No.3 No.4

No.5 No.6 No.7 No.8

PACKING

P3-5 P3-7 NSP Warranty Card Operating Instructions (French/German/Italian/ Dutch/Swedish/Spanish/Portuguese) Packing Case Rear Spacer Index Label 100 Jacket File Polyethlene Bag (115X270X0.03) ARY7023 Not used ARY7022 PRD1036 ARY7022 Not used
PHG2337 Not used Not used Not used Not used
PHG2338 Not used PRW1406 PHN1049 Not used
PHG2339 PHC1090 PRW1406 PHN1049 Z21-013

No.9 No.10 No.11 No.12

Note :
The numbers in the remarks column correspond to the numbers on the exploded diagram, Refer to "EXPLODED VIEWS".

PD-F958 EXPLODED VIEWS

PACKING SECTION
Operating lnstructions No.10 Protecter (FL) No.11 Protecter (RL)
PD-F958/MVXQ only No.9 Control Cable No.12
Protecter (FR) Protecter (RR)

Packing Case

EXTERIOR and FRONT PANEL SECTION

Cord Stopper

AC Power Cord No.2

Fuse Holder

PD-F958/MYXQ only No.6 No.5

Rear Base

Under Base No.4

Operation Panel

lnsulator No.1 Screw (IBZ30P080FZK)
CONTRAST OF PCB ASSEMBLIES

H MAIN BOARD ASSY

PWZ3896, PWZ3897 and PWZ3895 are constructed the same except for the following:
Part No. Mark Symbol and Description PWZ3895
C81, C367, C461, C475, C477 C4276, C4287 C175 C185, C323 C341, C342 C365, C395, C413 C416, C4277 C388, C389 C397 C401 C403 C404 C429, C430, C435 C438 C431, C432 C481, C482 CN401 D391 D394 D1301 D1309, D1312 D1314 IC401 IC406 JA391 JA392 JA394 L151, L152, L307, L351 L309 L391 L395, L396 R310 R312, R411 R413 R341 R342 R375 R391 R392 R401, R472, R473 R405 R410 R427 R430 R435, R436 R437, R438 R439 R442 R470, R471 R481, R482, R485, R486 R487 R490 R1301 R1305, R1307 X341 X401 Not used Not used CEAT101M10 CKCYF103Z50 CCCCH120J50 Not used Not used CCCSL101J50 Not used Not used Not used Not used Not used CCCSL390J50 Not used 1SS254 1SS254 Not used Not used RKN1004 RKN1004 DKN1035 Not used Not used LAU1R0J LAU1R0J Not used RD1/4PU271J RD1/4PU105J RD1/4PU471J RD1/4PU244J RD1/4PU102J Not used Not used Not used Not used RD1/4PU473J RD1/4PU823J Not used RD1/4PU223J RD1/4PU104J RD1/4PU471J PSS1008 Not used

Remarks PWZ3896

CKCYF103Z50 CKCYF103Z50 CEAT471M6R3 Not used Not used CFTLA104J50 CCCSL101J50 CCCSL101J50 CEAT471M6R3 CCCCH120J50 CCCCH220J50 CCCSL390J50 CEAT330M16 Not used 52147-0310 1SS254 1SS254 PD2026B BA15218 RKN1004 Not used DKN1035 RTF1167 RTF1167 LAUR22J LAUR22J RD1/4PU241J Not used Not used RD1/4PU241J RD1/4PU244J RD1/4PU102J RD1/4PU102J RD1/4PU471J RD1/4PU223J RD1/4PU163J RD1/4PU163J RD1/4PU433J RD1/4PU470J Not used Not used RD1/4PU471J Not used PSS1008

PWZ3897

CKCYF103Z50 CKCYF103Z50 CEAT471M6R3 Not used Not used CFTLA104J50 CCCSL101J50 Not used CEAT471M6R3 CCCCH120J50 CCCCH220J50 CCCSL390J50 CEAT330M16 Not used 52147-0310 Not used Not used PD2026B BA15218 Not used Not used Not used RTF1167 Not used Not used LAUR22J RD1/4PU241J Not used Not used RD1/4PU241J Not used Not used RD1/4PU102J RD1/4PU471J RD1/4PU223J RD1/4PU163J RD1/4PU163J RD1/4PU433J RD1/4PU470J Not used Not used Not used Not used PSS1008
Note : Refer to "3.SCHEMATIC DIAGRAM". 5

I POWER BOARD ASSY

PWZ3901 and PWZ3900 are constructed the same except for the following:
Part No. Mark Symbol and Description PWZ3900
C17 Power Transformer(AC120V) Power Transformer(AC220-230V) Not used PTT1342 Not used

Remarks PWZ3901

CKCYF103Z50 Not used PTT1343
Note : Refer to "3.SCHEMATIC DIAGRAM".

M DISPLAY BOARD ASSY

PWZ3905 and PWZ3904 are constructed the same except for the following:

Part No. Mark

C714 J703
Symbol and Description PWZ3904

Not used Not used

Remarks PWZ3905

CKCYF103Z50 DE010WE0

SWITCH BOARD ASSY

Part No.

PWZ3908 and PWZ3907 are constructed the same except for the following:

D751 R751

Symbol and Description PWZ3907

Remarks PWZ3908

PCX1019 RD1/4PU471J

PCB PARTS LIST

Mark No. Description Part No.
HADPHONE BOARD ASSY (PWZ3910)
L501, L504, L505 (AXIAL INDUCTOR) LAUR22J
COILS AND FILTERS CAPACITORS

C503, C504 CKCYF473Z50

RESISTORS

VR501 (0.5k) PCS1003

OTHERS
JA501 J501 HADPHONE JACK 3P Cable Holder 2mm JUMPER WIRE RKN1002 51048-0300 D20PDY0315E

3. SCHEMATIC DIAGRAM

3.1 MAIN BOARD ASSY and HEADPHONE ASSY

OV 1.6V

(T) (T) (F) (F) (F) (F)
SIGNAL ROUTE : AUDIO SIGNAL : EFM SIGNAL : FOCUS SERVO LOOP : TRACKING SERVO LOOP : CARRIAGE SERVO LOOP (S) : SPINDLE DRIVE : LOADING DRIVE (D) : DOOR DRIVE

(SEL) (SEL)

L F DISPLAY BOARD ASSY M F SWITCH BOARD ASSY

0V 1.6V -9.2

LINE OUT JACK

-9.2 1.6V 0V 0V

PD-F958/MYXQ Only

PD-F958/MVXQ Only

MAIN BOARD ASSY
(PWZ3896:PD-F958/MYXQ) (PWZ3897:PD-F958/MVXQ)

TO POWER BOARD ASSY

The numbers marked with a circle show the number of each measuring point, which correspond to the number in the service manual PD-F958 (ORDER NO. RRV2085) on page12.
3.2 DISPLAY BOARD ASSY, POWER BOARD ASSY and SWITCH BOARD ASSY

DISPLAY BOARD ASSY

PD-F958/MYXQ, MVXQ :(PWZ3905)

PE5032A

PD-F958/MYXQ,MVXQ :(PWZ3908)

TO MAIN BOARD ASSY

PD-F958/MYXQ,MVXQ Types AC220-230V 50Hz AC POWER CORD MYXQ: PDG1003 MVXQ: PDG1055
(TO MAIN BOARD ASSY) CN11

POWER BOARD ASSY

(PWZ3901:PD-F958/MYXQ PD-F958/MVXQ)

P0WER TRANSFORMER

I F MF M F L N

DE010WE0

4. PCB CONNECTION DIAGRAM

NOTE FOR PCB DIAGRAMS:

1. Part numbers in PCB diagrams match those in the schematic diagrams. 2. A comparison between the main parts of PCB and schematic diagrams is shown below.
Symbol in PCB Diagrams Symbol in Schematic Diagrams Part Name

B B C E B B C E D D G S

E Transistor
E Transistor with resistor
G S Field effect transistor

Resistor array

3-terminal regulator 3. The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic diagram.
4. Viewpoint of PCB diagrams

Connector Capacitor

SIDE A

P. C. Board

Chip Part

SIDE B

HEAD PHONE BOARD ASSY

PNP1455-B

A B C D E

ORDER NO.

RRV2112
FILE-TYPE COMPACT DISC PLAYER

PD-F17

Refer to the service manual RRV2085 for PD-F958/KUXQ/CA.
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
Type Model Power Requirement PD-F17 KUXQ/CA O AC120V Remarks

CONTENTS

1. CONTRAST OF MISCELLANEOUS PARTS.. 2 2. SCHEMATIC DIAGRAM. 8 3. PCB CONNECTION DIAGRAM.. 9
PIONEER ELECTRONIC CORPORATION 4-1, Meguro 1-Chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS SERVICE, INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER ELECTRONIC (EUROPE) N.V. Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER ELECTRONIC CORPORATION 1999
TZZR MAR. 1999 Printed in Japan
1. CONTRAST OF MISCELLANEOUS PARTS
NOTES : Parts marked by NSP are generally unavailable because they are not in our Master Spare Parts List. mark found on some component parts indicates the importance of the safety factor of the part. The Therefore, when replacing, be sure to use parts of identical designation. Reference Nos. indicate the pages and Nos. in the service manual for the base model. When ordering resistors, first convert resistance values into code form as shown in the following examples. Ex. 1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J = 5%, and K = 10%). 560 = 1 = 561... RD1/4PU 1 J 47k = 3 = 473.. RD1/4PU 3 J 0.5 = R50... RN2H K 1 = 1R0... RS1P K Ex. 2 When there are 3 effective digits (such as in high precision metal film resistors). 5.62k = 1 = 5621.. RN1/4PC F

7 CONTRAST TABLE

PD-F17/ KUXQ/CA and PD-F958/KUXQ/CA are constructed the same except for the following:
Ref. No. Part No. Mark Symbol and Description PD-F958/ KUXQ/CA
PWM2269 PWZ3895 PWZ3900 PWZ3904 PWZ3907 Not used Not used REC1263 PNA2452 PNW2766 (X2) PAM1776 PNW2869 PNW2865 Not used Not used Not used

PD-F17/ KUXQ/CA

PWM2272 PWZ3898 PWZ3902 PWZ3905 PWZ3908 PWZ3911 PWZ3917 Not used PNA2502 PNW2766 (X4) PAN1376 PNW2918 PNW2919 PAC1707 PNW2019 PNB1192

Remarks

EXTERIOR
NSP P6-1 P6-2 P6-3 P6-4 MOTHER BOARD ASSY MAIN BOARD ASSY POWER BOARD ASSY DISPLAY BOARD ASSY SWITCH BOARD ASSY HEADPHONE BOARD ASSY COAXIAL OUTPUT BOARD ASSY Foot Assy Rear Base Insulator Name Plate Operation Panel Hood Headphone Knob LED Lens SR Angle

NSP NSP NSP

No.1 No.2
P6-14 P6-18 P6-20 P6-46 P6-50 P6-52

No.3 No.4 No.5

PACKING
P3-5 P3-7 P3-11 NSP Warranty Card Operating Instructions (English) Packing Case ARY7023 PRB1278 PHG2337 ARY7007 PRB1289 PHG2374

Note :

The numbers in the remarks column correspond to the numbers on the exploded diagram, Refer to "EXPLODED VIEWS".

EXPLODED VIEWS

EXTERIOR SECTION

Screw (BBZ30P080FZK)

Rear Base

Under Base No.4

Operation Panel Screw (IBZ30P060FMC) Name Plate
lnsulator Screw (IBZ30P080FZK) No.5
CONTRAST OF PCB ASSEMBLIES

H F MAIN BOARD ASSY

PWZ3898 and PWZ3895 are constructed the same except for the following:
Part No. Mark Symbol and Description PWZ3895
C81, C332, C333, C367, C461 C475, C477, C4276, C4287 C185, C323 C321 C322 C331 C341, C342 C365, C395, C413 C416, C4277 C388, C389 C401 C403 C404 C429, C430, C435 C438 C431, C432 C481, C482 CN401, CN951 D451, D452 IC341 IC401 IC406 JA321 L151, L152, L307, L309, L351 Q451, Q452 Q453, Q454 R310 R312, R411 R413 R341 R342 R364, R451, R452 R365 R375 R401, R457, R458, R472, R473 R405 R410 R427 R430 R435, R436 R437, R438 R439 R442 R470, R471 R481, R482, R485, R486 R487 R490 X341 X401 Not used Not used CKCYF103Z50 CFTLA104J50 CEAT101M10 Not used CCCCH120J50 Not used Not used Not used Not used Not used Not used Not used CCCSL390J50 Not used Not used Not used Not used Not used GP1F32T Not used Not used Not used Not used RD1/4PU271J RD1/4PU105J Not used RD1/4PU103J RD1/4PU471J Not used Not used Not used Not used RD1/4PU473J RD1/4PU823J Not used RD1/4PU223J RD1/4PU104J PSS1008 Not used

Remarks PWZ3898

CKCYF103Z50 CKCYF103Z50 Not used Not used Not used CEAT470M16 Not used CFTLA104J50 CCCSL101J50 CEAT471M6R3 CCCCH120J50 CCCCH220J50 CCCSL390J50 CEAT330M16 Not used 52147-0310 1SS254 PD0236AM PD2029A BA15218 Not used RTF1167 DTC124ES 2SJ103 RD1/4PU241J Not used Not used RD1/4PU103J Not used RD1/4PU241J RD1/4PU102J RD1/4PU471J RD1/4PU223J RD1/4PU163J RD1/4PU163J RD1/4PU443J RD1/4PU470J Not used Not used Not used PSS1008
Note : Refer to "2.SCHEMATIC DIAGRAM".

F POWER

BOARD ASSY
Although PWZ3900 and PWZ3902 are different in part number, they consist of the same components.

M F DISPLAY

C714 J703

Part No.

PWZ3905 and PWZ3904 are constructed the same except for the following:

Symbol and Description PWZ3904

Not used Not used

Remarks PWZ3905

CKCYF103Z50 DE010WE0

L F SWITCH BOARD ASSY
PWZ3908 and PWZ3907 are constructed the same except for the following:

Part No. Mark

D751 R751
Symbol and Description PWZ3907

Remarks PWZ3908

PCX1019 RD1/4PU471J

PCB PARTS LIST

Mark No. Description Part No. Mark No. Description Part No.
P HADPHONE BOARD ASSY (PWZ3911)

COILS AND FILTERS

L501, L504, L505 (AXIAL INDUCTOR) LAU1R0J
Q COAXIAL OUTPUT BOARD ASSY

(PWZ3917)

SEMICONDUCTORS

(LOGIC) TA74HCU04AP

CAPACITORS

C503 CKCYF473Z50

L952 (COIL) PTL1003

RESISTORS

VR501 (0.5k) PCS1003
C959 C954 C951 C955, C957, C958, C961 C952 CCCSL101J50 CEAT101M10 CEAT470M16 CFTLA104J50 CKCYF103Z50

OTHERS

JA501 J501 HADPHONE JACK 3P Cable Holder 2mm JUMPER WIRE RKN1002 51048-0300 D20PDY0315E
R951, R953 R952 RD1/4PU471J RD1/4PU750J
JA951 JA952 J951 OPTICAL LINK OUT 1P JACK 3P Cable Holder 2mm JUMPER WIRE GP1F32T RKB1012 51048-0300 D20PDY0350G

2. SCHEMATIC DIAGRAM

2.1 MAIN BOARD ASSY, HEADPHONE ASSY and COAXIAL OUTPUT ASSY

OV 1.6V

(T) (T) (F) (F) (F) (F)
SIGNAL ROUTE : AUDIO SIGNAL : EFM SIGNAL : FOCUS SERVO LOOP : TRACKING SERVO LOOP : CARRIAGE SERVO LOOP (S) : SPINDLE DRIVE : LOADING DRIVE (D) : DOOR DRIVE

(SEL) (SEL)

L F DISPLAY BOARD ASSY M F SWITCH BOARD ASSY

0V 1.6V -9.2

COAXIAL OUTPUT BOARD ASSY (PWZ3917)

LINE OUT JACK

-9.2 1.6V 0V 0V

MAIN BOARD ASSY

(PWZ3898: PD-F17 /KUXQ/CA)

TO POWER BOARD ASSY

The numbers marked with a circle show the number of each measuring point, which correspond to the number in the service manual PD-F958 (ORDER NO. RRV2085) on page12.
PD-F17 2.2 DISPLAY BOARD ASSY, POWER BOARD ASSY and SWITCH BOARD ASSY

DISPLAY BOARD ASSY

PD-F17/KUXQ/CA :(PWZ3905)

PE5032A

PD-F17/KUXQ/CA :(PWZ3908)

TO MAIN BOARD ASSY

PD-F17/KUXQ/CA AC120V 60Hz AC POWER CORD

CABLE HOLDER 51048 1200

POWER BOARD ASSY

(PWZ3902:PD-F17/KUXQ/CA)

KUXQ/CA : PDG1064
(TO MAIN BOARD ASSY) CN11

P0WER TRANSFORMER

I F MF M F L N

DE010WE0

SWITCH BOARD ASSY
3. PCB CONNECTION DIAGRAM
3.1 HEAD PHONE BOARD ASSY and COAXIAL OUTPUT BOARD ASSY

NOTE FOR PCB DIAGRAMS:

1. Part numbers in PCB diagrams match those in the schematic diagrams. 2. A comparison between the main parts of PCB and schematic diagrams is shown below.
Symbol in PCB Diagrams Symbol in Schematic Diagrams Part Name

B B C E B B C E D D G S

E Transistor
E Transistor with resistor
S Field effect transistor

SIDE A

Resistor array 3-terminal regulator

HEAD PHONE BOARD ASSY

3. The parts mounted on this PCB include all necessary parts for several destination. For further information for respective destinations, be sure to check with the schematic diagram.
4. Viewpoint of PCB diagrams

Connector Capacitor

P. C. Board

Chip Part

SIDE B

PNP1455-B

COAXIAL OUTPUT BOARD ASSY

A B C D E P Q