RD1/4PU222J Added Added AWV1815 AWV1791
RS1/16S222J RS1/16S0R0J RS1/16S0R0J AWV1838 AWV1839
R3207 R3481,3482,3483,3500 R3487 Digital video assy Digital video assy
EM, 73 SPC55-008 AA-D1980

Digital video ass'y

( 2/2 )

R3481 R3500

Date: MODEL No. PDP-502MX/LUCBW PDP-502MXE/YVLDK PDP-505HD/KUC PDP-502MX/LUCBW PDP-502MXE/YVLDK PDP-505HD/KUC * A A A B B B June. 1, 2000 SER.No. 036570360101251R/C R/C R/C No.: SI-D01005 S/M No. ARP3044 ARP3044 ARP3044 ARP3044 ARP3044 ARP3044 ( 1/1 ) PG
CHANGE Change of FFC between Analog video assy and Digital video assy Change of resistors in Digital video assy
To improve the reliability of CLK, H.D,V.D signal between Analog video assy and Digital video assy Circuit change of Digital video assy

FFC R3405,3407,3408

ADE1180 RS1/16S100J Added
ADE1181 Deleted RS1/16S100J

FFC R3475,3476,3477

EM, 73 SPC54-391 AA-D1797
Date: MODEL No. * May.18,2000 No.: SI-D01004 ( 1/1 ) PG SER.No. S/M No.

# 1 234

CHANGE Addition of a resistor(R7429) and a transistor(Q7112) Addition of a transistor(Q7326) Change of a resistor(R7429 --> R7153 ---> R7429) Deletion of a transistor(Q7112) To prevent the noise in 3-picture search mode. To prevent the noise in 3-picture search mode. (Production convenience)
As for Circuit diagram, please see page 3/3.

A A A A A A

R7429 R7153 Q7112
Added Added Added RD1/4PU102J RS1/16S102J 2SC2712
RD1/4PU102J 2SC2712 2SC2712 RS1/16S102J RS1/16S102J Deleted
R7429 Q7112 Q7326 R7153 R7429
EM, 9 SPC54-463 SPC54-464

AA-D 1930 AA-D 1938

( 2/3 ) MODEL No. PRO-510HD/KUXC/CA PRO-610HD/KUXC/CA PRO-710HD/KUXC/CA SD-532HD5/KBXC SD-532HD5/KUXC/CA SD-582HD5/KUXC/CA * A A A A A A SER.No. R/C R/C R/C R/C R/C R/C S/M No. ARP3047 ARP3047 ARP3047 ARP3047 ARP3047 PG 45
S/M P45 SIGNAL ASSY Q7112

( 3/3 )

R7153 S/M P47 SIGNAL ASSY
Date: MODEL No. PRO-510HD/KUXC/CA PRO-610HD/KUXC/CA PRO-710HD/KUXC/CA * A A A May.18,2000 No.: SI-D01003 S/M No. ARP3047 ARP3047 ( 1/1 ) PG SER.No. R/C R/C R/C
CHANGE Change of a resistor and addition of a capacitor in SUB VIDEO SERVICE ASSY

To prevent the horizontal noise in single screen mode.
R3270 (0 ohm --> 470 ohm)

C3277 (2200pF Added)

RS1/16S0R0J Added

RS1/16S471J CKSRYB222K50

R3270 C3277

EM, 9 SPC55-005 AA-D1962

Date: MODEL No. PRO-510HD/KUXC/CA PRO-610HD/KUXC/CA PRO-710HD/KUXC/CA SD-532HD5/KBXC SD-532HD5/KUXC/CA SD-582HD5/KUXC/CA * A A A A A A May.15,2000 SER.No. R/C R/C R/C R/C R/C R/C No.: SI-D01002 S/M No. ARP3047 ARP3047 ARP3047 ARP3047 ARP3047 ( 1/1 ) PG 106
CHANGE Change of VR602 in DEFLECTION SERVICE ASSY
To improve the reliability of High voltage adjustment
S/M Location: DEFLECTION SERVICE ASSY P106 C-4

VRTHS6VS223

VRTHS6VS473
EM, 70 SPC55-004 AA-D2008
Date: MODEL No. PRO-510HD/KUXC/CA PRO-610HD/KUXC/CA PRO-710HD/KUXC/CA SD-532HD5/KBXC SD-532HD5/KUXC/CA SD-582HD5/KUXC/CA * A A A A A A Apr. 19, 2000 SER.No. R/C R/C R/C R/C R/C R/C No.: SI-D01001 S/M No. RRV3047 RRV3047 RRV3047 RRV3047 RRV3047 PG 94
CHANGE Change of convergence micro-com in DIGITAL CONV. ASSY Addition of resistor to DIGITAL CONV. ASSY
Production convenience To improve convergence OSD display

DIGITAL CONV. ASSY

IC1652 Location: S/M P94 C-2,3

IC1652

PD5564B9 Added

PD5564C9 RD1/4PU472J

IC1652 R1737
,MANAGER Service Service Engineering Section Division

SPC54-431 AA-D1894

( 1 / 2 )
CORRECTION OF SERVICE MANUAL
No.: SI-A49001 Date:May 30,1994
Please correct your service manua
MODEL [S/M NO.] PAGE INCORRECT The following part is available SD-P404-K -P4043-K [ARP2080] SD-P504-K -P504-Q [ARP2082] SD-P455-K -P4552-K -P4553-K -P4553-W [ARP2284] SD-P505-K -P505-Q -P5053-K -P5053-Q [ARP2285] SD-P4053-K [ARP2273] SD-P5005 [ARP2292] SD-P5553-K -P5553-Q [ARP2353] SD-P5065-K -P5065-Q -P4565-K -P4565-Q etc. [ARP2565] 13 No. 24 Part No. ADE1091 CORRECT as spare parts.

Description RF cable

13 233
PIONEER ELECTRONIC CORPORATION

(QP48-032,QP48-041 SMM-AN 106)
Issued by: Y. IMAMIZU, MANAGER HE Engineering Section Service Dept.
( 2 / 2 ) MODEL [S/M NO.] PAGE INCORRECT The following part is available A-09 [ARP2858] 5 No. 55 Part No. AKE-046 CORRECT as spare parts.
Description Earth terminal
(1/1) No. :SI-A48088-G Date:APRIL 13,1994

MA-99/SD MA-99/SL

A 006601~ A 000701~
MODIFICATION OF GND PATTERN IN MAIN BOARD ASSY

REASON FOR CHANGES X

TO REDUCE HUM NOISE IN SIGNAL LINE COMING FROM POWER SUPPLY LINE
SERVICE MANUAL <PROBLEM> RESIDUAL NOISE LEVEL IS HIGH IN SIGNAL LINE. MODEL :MA-99 <CAUSE> SINCE THE CAPACITOR(C98) OF POWER SUPPLY LINE IS GROUNDED TO THE GND OF SIGNAL LINE, HUM NOISE IS CREATED IN SIGNAL LINE DUE TO THE RIPPLE FROM POWER SUPPLY LINE. S/M NO.:TRT1055 PAGE :7

CUT THE PATTERN

ADD A LEAD WIRE
<COUNTERACTION IN FACTORY>

MAIN BOARD ASSY(MWX3029)

CUT THE GND PATTERN OF C98 - LEAD AS ABOVE. ADD A LEAD WIRE TO CONNECT C98 - LEAD WITH J33(GND) AS ABOVE. <SERVICE REMEDY> SAME AS COUNTERACTION IN FACTORY Ref. CURRENT PARTS PART NUMBER * # SYMBOL/DESCRIPTION CO DE NEW PARTS SYMBOL/DESCRIPTION

PART NUMBER

FA3Y017 TS 120
Date: MODEL No. PDP-502MX/LUCBW/1 PDP-502MXE/YVLDK/1 PDP-505HD/KUC/1 * A A A Jan. 17, 2001 No.: SI-D01029 S/M No. ARP3075 ARP3075 ARP3080 ( 1/1 ) PG SER.No. 001281000741000141-
CHANGE Add the ferrite core (L0006,L0007)
To improve the picture noise

ATX1041

L0006,L0007
AA-D2424 SPC55-188 MTV01-083
Date: MODEL No. PDP-505HD/KUC * A Jan. 17, 2001 No.: SI-D01028 S/M No. ( 1/1 ) PG SER.No. R/C
CHANGE Change the parts in DIGITAL Assy.
To prevent the character from changing.
Please refer to ARP3044 IC2257; page 13 C2281-C2284; page 14 C2259-C2262; page 3
IC2257 C2281,C2282, C2283,C2284 C2259,C2260, C2261,C2262,
TC74VHCT541A FT CCSQCH221J50 CCSRCH220J50
TC74VHC541FT CKSQYB222K50 CKSQYB152K50

AA-D2531 SPC55-332

Date: MODEL No. PDU-50WX1/TUCYV * A Jan. 17, 2001 No.: SI-D01027 S/M No. ARP3072 ( 1/1 ) PG 6,7 SER.No. R/C
CHANGE Change and add the parts.
To change the thickness of PROTECT PANEL Assy. (To improve the performance.)
Protect Panel Assy (AMR3162) Front View

Holder Gasket (ANK1677)

Protect Panel Assy (AMR3162) Side View Front

Protect Panel Assy

AMR3162 Added

AMR3230 ANK1677

Protect Panel Assy Holder Gasket

AA-D2502 SPC55-313

KT, 70
Date: MODEL No. PDP-V400/LU/CA PDP-V401/LU/CA PDP-V402/LUBW/CA PDP-V402/LUBW/CA/1 PDP-V402/LUCBW DETAIL # 1 * A A A A A Mar. 13,2001 No.: SI-D01026 S/M No. ARP2954 ARP2981 ARP3034 ARP3081 ARP3034 ( 1/1 ) PG 100 SER.No. Running Change Running Change Running Change Running Change Running Change
CHANGE Change of resistors in MAIN POWER ASSY

To improve performance

R3107 R3108

RD1/2PM473J RD1/2PM563J

RS1LMF153J RS1LMF153J
M.EGASHIRA BS Service Service

SPC55-299 AA-D2507 NM-70

Date: MODEL No. PDP-V402EA/YVLDK * A Mar.19,2001 No.: SI-D01025 S/M No. ARP3076 ( 1/1 ) PG SER.No. Running Change
CHANGE Addition of Ferrite Core Change from Wire Saddle to Ferrite Core Holder
To improve the performance

Wire Saddle

Added AEC1745

ATX1037 AEC1818

L4 Ferrite Core Holder

SPC55-271 AA-D2501 NM-70

Date: MODEL No. PDP-V402/LUBW/CA/1 * Apr.6, 2001 No.: SI-D01024AG ( 1/2 ) PG

SER.No. ALL

S/M No.

# SYMPTOM

DETAIL PDP repeats on and off in the state that a rear fan is not connected.
In Main Power Assy (ARW1077), noises enter into the Power ON/OFF signal coming from Microcomputer, and it causes malfunction.
Remove the cathodic side of D3802, and add another diode (HSS104-02) to D3802 in series in Main Power Assy (AWR1077). *Please refer to Figure 1.

Same as Service Remedy

HSS104-02 (New added diode)
Please discard the previous Service Information, SI-D01024-G, dated on Mar. 9, 2001

SERVICE NETWORK

M.EGASHIRA ,MANAGER BS Service BS Service Administration Group Division

MTV01-

Date: MODEL No. PDP-V402EA/YVLDK * A Jan 26, 2001 No.: SI-D01023-G ( 1/1 ) PG SER.No. 1541S/M No.
DETAIL Only when the incoming signal is PAL, Synchronism sometimes; two or three times during 30 minutes, falls into disorder in a moment.
Noise is easy to obstruct the wave at the beginning due to the heavy load on the communication line in u-com.
Please change R7174 and R7175, from 8.2kohm to 2.7kohm.
Same as the service remedy

R7174, R7175

RS1/16S822J

RS1/16S272J

MTV01-080 SPC55-333 AA-D3013 NM-6
Date: MODEL No. PDP-V402EA/YVLDK * A Aug.7,2001 No.: SI-D01023AG ( 1/1 ) PG

SER.No. 1541-

Date: MODEL No. PDP-502MX/LUCBW S/M No. ARP3037 PG 42 Jun. 7, 2001 No.: SI-D01022 S/M No. ARP3037 ( 1/1 ) PG 42 MODEL No. PDP-502MXE/YVLDK
Please correct your service manual

6. ADJUSTMENT

SERVICE FACTORY MODE <lower figure>

(AXD1445)

Memo: K.NOHARA HE Service Service ,MANAGER Engineering Section Division
Date: MODEL No. PRO-700HD/KUXC/CA SD-641HD5/KUXC/CA 64LHP5000 (for SHARP) 64LHP4000 (for SHARP) # 1 * A B C D Dec.19 ,2000 No.: SI-D01021-G S/M No. ARP3013 ARP3031 ( 1/3 ) PG SER.No. ---------

ADD jumper cable

Sub video Assy ( parts mount side )

CUT R3883 C3828

IC3802

Silicone bond (GYA1011)

Add jumper cable

VR3001

Date: MODEL No. PDP-502MXE/YVLDK/1 * A Dec.25, 2000 No.: SI-D01020-G ( 1/1 ) PG SER.No. ---S/M No.
DETAIL When the picture size is zoom mode, the picture darkens because still picture detection works even if the moving picture is displayed.

Microcomputer bug.

Change the U-COM Assy (AWZ6520) under the below serial numbers.

Service remedy only

Applicable Serial No. PDP-502MXE/YVLDK/1 : Q'ty 26 UJSS001932WQ UJSS002005WQ UJSS002008WQ UJSS002009WQ UJSS002010WQ UJSS002012WQ UJSS002013WQ UJSS002052WQ UJSS002055WQ UJSS002056WQ UJSS002057WQ UJSS002058WQ UJSS002061WQ UJSS002508WQ UJSS002509WQ UJSS002510WQ UJSS002511WQ UJSS002512WQ UJSS002513WQ UJSS002514WQ UJSS002515WQ UJSS002516WQ UJSS002517WQ UJSS002518WQ UJSS002519WQ UJSS002520WQ
NOTE: U-COM Assy's part number does not changed. The stock parts in WPC have modified.
Y.YAMAMOTO ,MANAGER HE Service Engineering Section Service Division

MTV01-067

Date: MODEL No. PDP-V401/LU/CA PDP-V401E/WYVLD * Jan 25, 2001 No.: SI-D01019-G ( 1/1 ) PG SER.No. ALL ALL S/M No.
DETAIL A picture turns yellow / A cell defect appears at a part of a panel after 20,000 hours used.
A radiative characteristic of a cell is reduced by Long Term Panel Drive. This happens only on a panel of the first generation.
Adjust Vofs from 140V to 150V. Adjust the voltage of VR3601 between TP3601 and TP3602 in Main Power Assy; AWR1077. Only Service Remedy

MTV01-062

Date: MODEL No. PDP-V501X/KUC PDP-501MX/KUC PDP-501MX/TYVL PDP-501MX/TB # 1 * A A A A Jan.11, 2001 No.: SI-D01017 S/M No. ARP2997 ARP2997 ARP3011 ARP3012 ( 1/1 ) PG SER.No. ALL ALL ALL ALL
CHANGE When one of the following FET in Y DRIVE A Assy(AWZ6321) or Y DRIVE B Assy (AWZ6322) have to be changed, pair FET should be replaced with new part at the same time.
When one of FET is defective, the other is also damaged.
Q3005(FS14UM) Q3006(2SK2255) Q3011(FS14UM) Q3012(2SK2255)

PAIR PAIR

* Parts Number is not changed.
Please be sure to replace pair parts. Otherwise the product is out of order because the other part is also damaged.

MTV01-060

Do red abnormal cells appear? No Increase Vofs by 4V

No Vsus167V ? Yes

Increase Vofs by 6V Decrease Vsus by 2V Readjust B HIGH and R HIGH to the original value

Increase Vofs by 6V

Rewrite Vh and Vofs voltage value printed on the Drive Voltage Label. (Note 2)
Do red abnormal cells disappear?
No Completed this adjustment The panel is defective

( 5/5 )

Date: MODEL No. PDP-502MX/LUCBW PDP-502MXE/YVLDK PDP-505HD/KUC * A A A Dec.19,2000 No.: SI-D01011BG ( 1/2 ) PG SER.No. 373636011301S/M No. ARP3037 ARP3037 ARP3043
DETAIL Red active cells are appeared
The select erase sequence cannot be performed after a long time use.
1) Adjust Vh and Vofs according to flow Vh: VR751 K752-K751 (Y DRIVE Assy) Vofs : VR701 K702-K701 (Y DRIVE Assy) 2) Adjusted voltage are described to Drive Voltage Label. 3) A green seal (8mm in diameter) is pasted near the serial number. Same as the Service Remedy
Please see the following page.
Please discard the previous Service Information SI-D01011A-G dated Oct.12,2000

MTV01020A

Date: MODEL No. PDP-502MX/LUCBW PDP-502MX/LUCBW /1 PDP-502MXE/YVLDK PDP-502MXE/YVLDK /1 # 1 * A A A A Oct.27,2000 No.: SI-D01010A-G ( 1/1 ) PG SER.No. ALL ALL ALL ALL S/M No. ARP3037 ARP3075,ARP3078 ARP3037 ARP3075,ARP3078
DETAIL Panel is cracked by heat stress when still picture which has high brightness is displayed by observation camera. (As shown below.)
A part of panel emits light.

Refer to the following

< Symptom >

< Service Remedy >

NOTE: These contents change the value in factory mode. If this procedure is failed, PDP panel might be damaged. * Prepare either remote control unit below. CU-PDP001(AXD1432), CU-PDP009(AXD1445)

White Black

1. Setting the BRIGHT ENHANCE 2. Change value of PLS NUM OFS Function is set input 1 Enter Service Factory Mode (Menu -> Set -> Power) | | Either Integrator mode (Menu -> Power) Select PICTURE mode | | Select OPTION 1 Select REFERENCE 1 | | Select BRIGHT ENHANCE Select PLS NUM OFS | | Set to VIDEO OFF Change value from 8 to 1

MTV01-019

Date: MODEL No. PRO-710HD/KUXC/CA S/M No. ARP3065 PG 5 Sept. 7,2000 No.: SI-D01009 S/M No. ( 1/1 ) PG MODEL No.

(Old) Part No. AMM2939 (New) Part No.

Description Grille

AMM2936

MTV01-016

Date: MODEL No BA-6310A/KU BA-6310CA/KU BA-6311A/KU BA-6350A/KU BA-6351A/KU
1/1 * No: SI-D49004 SER.No S/M No PG

Oct.24, 1994 MODEL No

* SER.No A 3645701A 3664401A 3602101A 3648501A 3610901-
S/M No ARP2571 ARP2572 ARP2574 ARP2573 ARP2594

CHANGE

1 DELETION OF NUTS AND WASHERS, AND ADDITION OF NUTS WITH WASHERS

1 COST SAVING

Washer

Ref. * A A # 1 1

CURRENT PARTS SYMBOL/DESCRIPTION PART NUMBER Nut Washer ABN-059 WAX0F160N100
NEW PARTS CO DE PART NUMBER SYMBOL/DESCRIPTION 2 BBN1005 - Deleted Nut
Issued by K. WATANABE, MANAGER Industrial Engineering Section Service Division
NOTE: PARTS CODE 1: Changeable from old to new. 2: Not Interchangeable at all. 3: Interchangeable in both ways. 5: Do not use old parts.

SPC49-288

DS-23369A

SPC-SS 9

Date: Aug.31, 1994 MODEL No BA-9510CA/KU BA-9510A/KU BA-9510CR/KU BA-9510C/KU BA-9310C/KU
* SER. No A 3617640A 3605901A 3602057A 3603565A 3605068-
S/M No PG ARP2847 ARP2847 ARP2839 ARP2836 ARP14
MODEL No BA-9510/KU BA-9310/KU BA-9710C/KU
( 1/1 ) No: SI-D49003 * SER. No S/M No PG A 3612573- ARPA 3613069- ARP2836 14

A 3600051ARP2837

1 Change of capacitors in Main Ass'y

1 To improve reliability

Ref. # 1
CURRENT PARTS SYMBOL/DESCRIPTION PART NUMBER C430(0.01F) CKSQYF103Z50
NEW PARTS CO DE PART NUMBER SYMBOL/DESCRIPTION 2 CKSQYB223K50 C430(0.022 F)
PIONEER ELECTRONIC CORPORATION NOTE: PARTS

SPC49-179

DS-23420
Issued by: Y.IMAMIZU, MANAGER HE Engineering Section Service Dev.
1:Changeable from old to new. 2:Not Interchangeable at all. 3:Interchangeable in both ways. 5:Do not use old parts.
(1/1) No :SI-D49002 Date:Jul.27,1994
MODEL NO. BA-6311A/KU BA-6351A/KU BA-6310CA/KU BA-6310A/KU BA-6350A/KU
SER. NO. * A Running Change 36089013638871361680136410010-

MODEL NO. *

Change of Manual
To meet the safety regulation
SERVICE MANUAL MODEL:BA-6311A S/M NO.:ARP2574 PAGE :
MODEL:BA-6351A S/M NO.:ARP2594 PAGE :

B5B-PH-SM3-TBB

R6739 R6735

CN6703

D6716 R6737 R6738

VADR V MID ADRGND DGND SW V MID CLAMP Assy

Changed Q6710, Q6711

Date: MODEL No. PDP-433PE/WYVIO6 PDP-433PE/WYVI6XK PDP-433PG/TLDPKBRO PDP-433PU/KUC PDP-433CMX/LUCBW PDP-433MXE/YVLDK PDP-503PC/TAXQ PDP-503PE/WYVIO6 PDP-503PE/WYVI6XK PDP-503PG/TLDPKBRO PDP-503PU/KUC PDP-503CMX/LUCBO PDP-503MXE/YVLDK PDP-503MXE-S/TA # 1 CHANGE Added service parts. * A A A A B B C C C C C D D D Mar.31, 2003 No.: SI-D03050 S/M No. ARP3112 ARP3112 ARP3118 ARP3112 ARP3124 ARP3124 ARP3135 ARP3108 ARP3108 ARP3117 ARP3108 ARP3100 ARP3100 ARP3120 ( 1/2 ) PG SER.No. Please see the following page

Production convenience.

A B C D

Added Added Added Added

AZN2513 AZN2515 AZN2512 AZN2514
rear case 43P rear case 43CMX rear case 50P rear case 50CMX

SPC57-450 AA-D4814

* These new rear case were made for only service use, and it can be used instead of aluminum rear case. In other words, it cannot be used instead of steel rear case. Please see the following list for the details.
New aluminum rear case Parts No. AZN2513 AZN2513 AZN2513 AZN2513 AZN2515 AZN2515 AZN2512 AZN2512 AZN2512 AZN2512 AZN2512 AZN2514 AZN2514 AZN2514
aluminum rear case steel rear case MODEL PDP-433PE/WYVIO6 PDP-433PE/WYVI6XK PDP-433PG/TLDPKBRO PDP-433PU/KUC PDP-433CMX/LUCBW PDP-433MXE/YVLDK PDP-503PC/TAXQ PDP-503PE/WYVIO6 PDP-503PE/WYVI6XK PDP-503PG/TLDPKBRO PDP-503PU/KUC PDP-503CMX/LUCBO PDP-503MXE/YVLDK PDP-503MXE-S/TA Parts No. Serial No. ANE1600 -0001480 ANE1600 -0003880 ANE1600 -0001270 ANE1600 -0002920 ANE1601 -0005130 ANE1601 -0003670 ANE1598 -0000080 ANE1598 -0002800 ANE1598 -0004110 ANE1598 -0001140 ANE1598 -0003370 ANE1597 -0010250 ANE1597 -0005990 ANE1597 -0000600 Parts No. Serial No. ANE1607 0001481ANE1607 0003881ANE1607 0001271ANE1607 0002921ANE1608 0005131ANE1608 0003671ANE1609 0000081ANE1609 0002801ANE1609 0004111ANE1609 0001141ANE1609 0003371ANE1610 0010251ANE1610 0005991ANE1610 0000601-
[EX.] When you replace aluminum rear case of PDP-433PE/WYVIO6, you can use new rear case, AZN2513.
Date: MODEL No. SD-533HD5/KUXC/CA SD-533HD5/KBXC SD-643HD5/KUXC/CA * A A A Mar.31, 2003 No.: SI-D03049 S/M No. ARP3094 ARP3094 ARP3094 ( 1/2 ) PG SER.No. R/C R/C R/C
Prevent out of current specification of the V deflection Service Assy. For increasing margin of RLS adjustment
----- Please see the back of this page -----

R0830 C0821 R1167

RS2MMF1R5J CFTLA224J50 RD1/4PU562J
RS1MMF3R9J CFTLA683J2A RD1/4PU183J

AA-D4800 AA-D4821

Deflection Service Ass'y AWV1909

LA78045

V.DEF AMP

VGRBD VBR

R828 C829

C834 R835

Please dispose of the previous Service Information, SI-D03025 issued on Sep.19, 2002.
Date: MODEL No. PDP-503PE/WYVIO6 PDP-503PG/TLDPKBRO PDP-503PU/KUC PDP-503CMX/LUCBO PDP-503MXE-S/TA PDP-503MXE/YVLDK PDP-433PE/WYVIO6 PDP-433PG/TLDPKBRO PDP-433PU/KUC PDP-433CMX/LUCBW PDP-433MXE/YVLDK * A A A A A A B B B B B Sep.19, 2002 SER.No. 00027510001101000305100099910000601000559100015510001251000318100043110002521No.: SI-D03025 S/M No. ARP3107 ARP3117 ARP3107 ARP3093 ARP3120 ARP3093 ARP3111 ARP3118 ARP3111 ARP3123 ARP3123 ( 1/2 ) PG
---- Please see the following page ---Ref

AA-D4416 D4427 D4495

D4417 D4428 D4497 SY66
Date: MODEL No. PDP-R03E/WYVI6 PDP-R03G/TLDPBR * A A Sep.17, 2002 No.: SI-D03024-G S/M No. ARP3110 ARP3119 ( 1/2 ) PG SER.No. 205*****205*****-
DETAIL Teletext function does not react at all when teletext button is pressed. It takes about 15-30 sec. to output picture when power is turned on.
Due to the soldering cracks at the lands of IC1602 on AV UNIT.
Resolder IC1602 and IC1603 on AV UNIT.
Enlarged lands of IC1602 about 0.1mm
---- Please see the parts location in the schematic back of this page ----

MTV03-003

AV UNIT
TELTEXT & AV LINK CIRCUIT
Resolder IC1602 & IC1603
P1301 IC1603 SRAM IC1301 COMP. AV SWITCH CIRCUIT SC1401 IC1601 TELTEXT P2502 SC1402 IC2501

ANALOG AV SWITCH CIRCUIT

P2503 P2501

U/V TUNER

IC1401

IC1102

IC1602 FLASH MEMORY
Date: MODEL No. PDP-433PE/WYVIO6 PDP-433PE/WYVI6XK PDP-433PG/TLDPKBRO PDP-433PU/KUC PDP-433CMX/LUCBW PDP-433MXE/YVLDK * A A A A B B Sep.4, 2002 SER.No. R/C R/C R/C R/C R/C R/C No.: SI-D03023 S/M No. ARP3111 ARP3111 ARP3118 ARP3111 ARP3123 ARP3123 ( 1/1 ) PG
CHANGE Changed the color of parts

Production Convenience

Terminal Panel (HD) Terminal Panel CMX Expansion Slot Cover

ANG2485 ANG2486 ANG2463

ANG2534 ANG2535 ANG2536
Terminal Panel Terminal Panel Expansion Slot Cover

SPC57-249 AA-D4528

Date: MODEL No. PDP-433PE/WYVI6XK PDP-433PE/WYVIO6 PDP-433PG/TLDPKBRO PDP-433PU/KUC # 1 * A A A A Sep.6, 2002 No.: SI-D03022 S/M No. ARP3111 ARP3111 ARP3118 ARP3111 ( 1/1 ) PG SER.No. R/C R/C R/C R/C

R707 R708

VRD-HT2EY824J VRD-HT2EY754J
RR-RCR16-824J RR-RCR16-754J
Parts location in power supply Ass'y
Date: MODEL No. PDP-502MX/LUCBW PDP-502MX/LUCBW/1 PDP-502MXE/YVLDK PDP-502MXE/YVLDK/1 PDP-505HD/KUC PDP-505HD/KUC/1 * A A A A A A Jun.20, 2002 No.: SI-D03011-G S/M No. ARP3037 ARP3078 ARP3037 ARP3078 ARP3043 ARP3080 ( 1/2 ) PG SER.No. ALL ALL ALL ALL ALL ALL
DETAIL No power with pop sound.
The cause of this symptom is not clear.
Change emitter resistance of output FET to prevent expansion damage of the power supply board.

Only Service Remedy

----- Please see the parts location in the schematic back of this page ----Note : This service remedy is not countermeasure for the above mentioned symptom of power supply board. The aim of this SI is to prevent expansion damage of the power supply board when the above symptom occurs.

R312,R363 R134

RS1LMFR22J ACN1139

ACN1157 ACN1160

AA-D4471
PDP-502 series Parts replacement location of power supply ASS'Y (AWZ6405, AWZ6506)

R134 R312 R363

FU101 AC IN
Date: MODEL No. * Mar.17, 2003 No.: SI-D03011B-G S/M No. ( 1/5 ) PG SER.No.
DETAIL Power down failure.
Solder cracks occur at several lands of resistors and diodes on POWER SUPPLY ASSY.
Please see the following pages.
A B AB AB A A A A B B B B
Service Power Supply Assy Service Power Supply Assy R312, R363 R134 RCC Control (A) Assy RCC Control (B) Assy RCC Control (C) Assy OTL Control (A) Assy RCC Control (A) Assy RCC Control (B) Assy RCC Control (C) Assy OTL Control (A) Assy
AWV1775 AWV1845 RS1LMFR22J ACN1139 AWZ6406 AWZ6407 AWZ6408 AWZ6409 AWZ6507 AWZ6508 AWZ6509 AWZ6510
AWV2009 AWV2010 ACN1157 ACN1160 AWZ6768 AWZ6769 AWZ6770 AWZ6771 AWZ6773 AWZ6774 AWZ6775 AWZ6776
AA-D5027 AA-D4942 AA-D5001
( 2/5) MODEL No. PDP-502MX/LUCBW PDP-502MX/LUCBW/1 PDP-502MXE/YVLDK PDP-502MXE/YVLDK/1 PDP-505HD/KUC PDP-505HD/KUC/1 * A B A B A B SER.No. ALL ALL ALL ALL ALL ALL S/M No. ARP3037 ARP3078 ARP3037 ARP3078 ARP3043 ARP3080 PG

[Service Remedy]

Case 1) If Power Supply Assy is defective, perform Remedy 1. Case 2) If Power Supply Assy is not defective (This means that PDP returns to normal operation after you fixed defected parts except Power Supply Assy), perform either Remedy 1 or Remedy 2. <Remedy_1> Replace Power Supply Assy with a new Assy. Ref.A: AWV1775 --> AWV2009 Ref.B: AWV1845 --> AWV2010 <Remedy_2> Perform the following jobs. 2-a: Re-solder several resistors and diodes in Main Power Assy. 2-b: Replace RCC Control A Assy, RCC Control B Assy, RCC Control C Assy and OTL Control A Assy with new parts. 2-c: Change emitter resistors of output FET to prevent expansion damage of Power Supply Assy * After you performed above service remedy, please put an orange seal near the serial number as a mark of this service remedy. In that case, please take care not to overlap to other seals.

[The detail of part A]

Part A Pilot hole

[The detail of part B]

Part B Pilot hole

Date: MODEL No. PRO-520HD/KUXC/CA PRO-620HD/KUXC/CA PRO-720HD/KUXC/CA * A A A April 3, 2002 No.: SI-D02023-G S/M No. ARP3095 ARP3095 ARP3095 ( 1/1 ) PG 42 SER.No. R/C R/C R/C
DETAIL Color noise occurs in case of inputting a video signal to any "S-VIDEO" inputs
Chroma signal is jumping onto power suply line (9V)
Add R7080 ( 0 ohm ) resistance between L7021 at 3D Y/C BLOCK in SIGNAL ASSY (Or making a short-circuit)
Add R7080 or making short-circuit

RS1/16S0R0J-T

SPC56-631 AA-D4263
Date: MODEL No. PDP-503PE/WYVI6 S/M No. ARP3107 PG Mar.29,2002 No.: SI-D02022 S/M No. ARP3107 ( 1/2 ) PG MODEL No. PDP-503PU/KUC
6.2 ADJUSTMENT REQUIRED WHEN THE SET IS REPAIRED OR REPLACED [OLD] Y DRIVE Assy * When replaced 1.SUSB ground timing adjustment 2.Panel white balance adjustment X DRIVE Assy * When replaced 1.SUSB ground timing adjustment 2.Panel white balance adjustment [NEW] Y DRIVE Assy * When replaced 1.Panel white balance adjustment

Page 63

X DRIVE Assy * When replaced 1.Panel white balance adjustment

[ADDITION]

SERVICE PANEL Assy * When you replace service Panel Assy Adjustment 1: SUS-B Ground Timing Adjustment Adjustment 2: VSUS Adjustment All of service panels have a panel identification label (Vsus data, Vofs data). Please just input this V-SUS data on the label to "VSUS" on page 12/13 or 16/17 of service factory mode by remote control. (Please refer to the page 61 of S/M) Adjustment 3: VOFS Adjustment Please just input the V-OFS data on the label to "VOFS" on page 12/13 or 16/17 of service factory mode. (Please refer to the page 61 of S/M) Adjustment 4: Panel White Balance Adjustment Page 63
6.3.2 Main Unit Adjustment
VOFS/VH/IC5V Voltage Adjustment Page 64
Adjusting Method VH (voltage for scan IC) Adjustment VR2703(VH) White 100% (Y DRIVE Assy) Adjust so that the voltage between K2716 (VH) and K2720 (PSUS) becomes 103V 0.5V. Input Signal Adjusting Point
Adjusting Method VH (voltage for scan IC) Adjustment VR2703(VH) White 100% (Y DRIVE Assy) Adjust so that the voltage between K2716 (VH) and K2720 (PSUS) becomes 130V 0.5V. Input Signal Adjusting Point
Date: MODEL No. * Apr.4,2002 No.: SI-D02021 ( 1/4 ) PG SER.No. S/M No.
CHANGE See the following details.
[DETAILS] 1. Change the value of the following resistances R2541, R2543 : 1.0Kohm --> 100ohm 2. Delete the following parts IC2512, IC2513 R2512, R2533, R2574, R2575 C2515, C2516 CN2202, CN3102 3. Add resistances R2576, R2577 See the parts location in the schematic back of this page :

Caution in Replacement of Chassis Block
Please order the PDP Service Assy 503 (AWU1040) when replacing the Chassis block. PDP Service Assy 503 is all common use parts of for business, public use and module. Supply it by the state that installed Circuit Board Spacer (AEC1872) and Wire Saddle (AEC1904) as follows. Therefore need to remove it in accordance with model. Confirm character carved a seal near the parts, and remove it. P : Public exclusive use W : Module exclusive use PW : Common use of public use and module * In case of this unit, the parts that "W" is marked removes all.
PDP Service Assy 503 (AWU1040)
Circuit Board Spacer Wire Saddle (AEC1872) (AEC1904) (There is marking of "P" nearby.
Circuit Board Spacer (AEC1872)
Date: MODEL No. PDP-433PE/WYVI6 PDP-433PU/KUC * A A Mar.11,2002 No.: SI-D02019-G S/M No. ARP3111 ARP3111 ( 1/2 ) PG SER.No. 93639363-
DETAIL Vibration noise (buzz noise) occurs from panel (especially from right (Y drive) side).
It is designed to make 0.5mm clearance between SCAN assy base and panel chassis assy base at a circled area on the following figure1. However by touching between these chassis because of uneven manufacturing of chassis, a vibration noise occurs from there.
Insert antivibration spacer (AMR3312) into the hole on panel chassis assy. --- Please see the following page. ---
SCAN assy base chassis The 0.5 mm clearance

Glass panel

panel chassis assy (AWU1038)

* Fig 1

AMR3312

Antivibration spacer

AA-D4254
1. Disassemble rear case. 2. Disassemble Y Drive assy. (Please refer page 87 of S/M ARP3111) 3. Insert antivibration spacer into the following hole on panel chassis assy. (However you can insert the spacers there by only disassembling Y DRIVE assy)
If it is hard to insert a spacer, Please lift up this chassis a little and then insert the spacers.
This is a inserting hole. There are four holes on a panel chassis assy. * Parts number of spacer : AMR3312
This picture is shown only upper area of panel. Please perform this remedy to the lower area of panel, too.
Date: MODEL No. PDP-433PE/WYVI6 PDP-433PU/KUC * A A Aug.5, 2002 No.: SI-D02019A-G S/M No. ARP3111 ARP3111 ( 1/3 ) PG SER.No. 93639363-

The cushion is added Only X Drive side
Please be careful that the VR cushion not protrude beyond the edge. VR cushion < FRONT CHASSIS V >

AEB1374

Front chassis V

SPC56-347 AA-D4002

Date: MODEL No. PDP-503CMX/LUCB PDP-503MXE/YVLDK PDP-503PE/WYVI6 PDP-503PG/TLDPKB6 PRO-1000HD PDP-503PU/KUC PDU-50WX2/TUCYV PDP-433PE/WYVI6 PDP-433PU/KUC # 1 * A A A A A A A A A Jan.31, 2002 SER.No. No.: SI-D02014 S/M No. ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ( 1/1 ) PG
CHANGE Change of resistor in AWV1903 and AWV1929.
Corrective action for PD by insufficiency of reset when the power turns on.
In AWV1903, it applies from serial# 4534. In AWV1929, it applies to all.

RS1/16S472J

RD1/4PU473J

AA-D3888 SPC56-310 YY-70

Date: MODEL No. PDP-503CMX/LUCB PDP-503MXE/YVLDK PDP-503PE/WYVI6 PDP-503PG/TLDPKB6 PDP-503PU/KUC PDP-433PE/WYVI6 PDP-433PU/KUC PDU-M5001/WX1K PDU-50WX2/TUCYV # 1 * A A B B B C C B D Jan.31, 2002 SER.No. 005536004871002291ALL ALL ALL ALL ALL 000071No.: SI-D02012 S/M No. ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ( 1/2 ) PG
CHANGE Change of parts and deletion of ASSY.
* V MID CLAMP ASSY (AWV1934) is moved on the aluminum base chassis of power supply module. * AXY1055 and AXY1056 can be used instead of AXY1053. (However, this opposite pattern is impossible.) In this case, V MID CLAMP ASSY on AXY1056 is not used.

following

AA-D3798 SPC56-298 YY-70

Ref * #

CURRENT PARTS CO NEW PARTS SYMBOL / DESCRIPTION PART NUMBER DE PART NUMBER SYMBOL / DESCRIPTION AXY1053 AXY1053 AWV1934 ADX2754 ADX2755 ADX2752 ADX2759 ADX2749 ADX2750 added added added ADX2760 AXY1055 AXY1056 deleted deleted deleted deleted deleted deleted deleted ADX2761 ADX2761 ADX2763 ADX2761
AB 1 C 1 ABC 1 V MID CLAMP ASSY A 1 J0118 A 1 J0119 B 1 J0120 B 1 J0121 C 1 J0120 C 1 J0121 A 1 B 1 C 1 D 1 J0120

J0118 J0120 J0120 J0120

Date: MODEL No. PDP-503CMX/LUCB PDP-503MXE/YVLDK PDP-503PE/WYVI6 PDP-503PG/TLDPKB6 PRO-1000HD PDP-503PU/KUC PDU-50WX2/TUCYV * A A A A A A A Feb.1, 2002 SER.No. Running Change Running Change Running Change Running Change Running Change Running Change Running Change No.: SI-D02009 S/M No. ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ARP3093 ( 1/1 ) PG
CHANGE Add the V cushion to the panel side of front chassis V.
To prevent the interaction between panel and front chassis V.

F r o n t c h assis V

V c u s h i o n (A E D ) (P u t th is c u s h io n s im ila r ly o n t h e o t h e r s i d e.) M atc h th e c u sh io n to th e e d g e o f th e c o r n e r an d p u t th e c u sh io n o n fr o n t c h a s s is V.

PTV Quick Reference Parts Chart Table of Contents

SD-Pxx1 Series (1987)

SD-P401, SDP501

SD-Pxx2 Series (1988)

SD-P402, SD-P452, SD-P502 PRO-71, PRO-91

SD-Pxx3 Series (1989)

SD-P403, SD-P453, SD-P503 PRO-72, PRO-92

SD-Pxx4 Series (1990)

SD-P404, SD-P4043, SD-P4044, SD-P454, SD-P4543, SD-P4546, SD-P504, SD-P5043, SD-P5046, SD-P5047 PRO-73, PRO-93

SD-Pxx5 Series (1991)

SD-P4051, SD-P4053, SD-P455, SD-P4552, SD-P4553, SD-P505, SD-P5053, SD-P5057, SD-P5553 PRO-75, PRO-95

SD-Pxx6 Series (1992)

SD-P4061, SD-P4063, SD-P4561, SD-P4562, SD-P4564, SD-P4565, SD-P5062, SD-P5064, SD-P5065, SD-P5067, SD-P5564, SD-P5565, SD-P5567 PRO-76, PRO-96, PRO-106

SD-Pxx7 Series (1993)

SD-P 4571, SD-P4573, SD-P4575, SD-P5071, SD-P5073, SD-P5075, SD-P5575 PRO-77, PRO-97, PRO-107

SD-Pxx8 Series (1995)

SD-P4681, SD-P4683, SD-P5181, SD-P5183, SD-P5185, SD-P6081, SD-P6085 PRO-98, PRO118

SD-Pxx9 Series (1996)

SD-P4691, SD-P5191, SD-P5193, SD-P5795W, SD-P6091, SD-P6093 PRO-99, PRO-119, PRO-1009W

SD-PxxA Series (1997)

SD-P50A3, SD-P50A5, SD-P55A3, SD-P55A5, SD-P62A3, SD-P62A5

PRO-xx0 Series (1998)

PRO-100, PRO-200

SD-xx1HD Series (1999)

SD-641HD5 PRO-700HD
SD-xx2HD Series (1999-2001)
SD-532HD5, SD-582HD5 PRO-610HD, PRO-510HD, PRO-710HD
SD-xx3HD Series (2001-2004) PRO-x20HD (2001-2002)
SD-643HD5, SD-533HD5 PRO-520HD, PRO-620HD, PRO720HD
PRO-x30HD Series (2002-2003)
PRO-530HD, PRO-630HD, PRO730HD
PRO-x30HDI Series (2003-2004)

PRO-530HDI, PRO730HDI

Page 1 of 18

SDPXX1

SD-Pxx1 Series Quick Reference Chart
Power supply Deflection Complex A Convergence Focus VR Ass'y Red CRT Green CRT Blue CRT Red CRT Drv. PCB Green CRT Drv. PCB Blue CRT Drv. PCB Lenticular Sheet Fresnel Lens SD-P401 AWR1008 -> GZW1009 AWJ1004 -> GZW1008 -> GZW1041 AWM1065 -> GZW1014 AWZ1431 ACX1003 AWY1020 AWY1021-> AWY1343 AWY1022-> AWY1344 AWZ1432 AWZ1434 AWZ1433 AMR1156 AMR1155 SD-P501 E E E E E AWY1029-> GXX1118 E AWY1030-> GXX1119 E E E AMR1164 AMR1163

Page 2 of 18

SDPXX2
SD-Pxx2 Series Quick Reference Chart SD-P402 SD-P452
Tuner / Video Power Supp. / Deflection Convergence Surround Amp. Front Control Red CRT Green CRT Blue CRT Red CRT Drv. Green CRT Drv. Blue CRT Drv. AWV1032 -> GZW1013 AWV1034 -> GZW1011 AWZ1944 N/A AWZ1956 AWY1043 AWY1038 AWY1044 AWZ1945 AWZ1946 AWZ1947 AWZ1027 AWV1029 -> GZW1010-> GZW1039 E AWV1030 AWZ1948 AWY1039 E AWY1040 E E E

SD-P502 PRO-71 PRO-91

E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E E

Page 3 of 18

SDPXX3

SD-Pxx3 Series Reference

MODELS 40" a) SD-P403 45" b) SD-P453P c) SD-P453FP d) SD-P453S e) PRO-72 (SUB NO.) GZW1026 GZW1025 GZW1022 50" f) SD-P503P g) SDP503FP h) SD-P503S i) PRO-92
ELITE DESCRIPTION VIDEO/AUDIO PART NO. AWV1078 AWV1076 AWV1077 AWV1088 AWV1087 AWV1080 AWV1079 AWE1136 AWE1135 AWZ2626 AWZ2537 AWV1085 AWV1086 AWY1063 AWY1060 AWY1058 AWY1062 AWY1057 AWY1064 AWY1061 AWY1059 AMR1708 AMR1707 AMR1706 AMR1705 AMR1704 AMR1703
DEFLECTION TUNER CONVERGENCE SURROUND P IN P RED CRT GREEN CRT BLUE CRT LENTICULAR FRESNEL
MODEL USAGE a b,f d,h c,g e,i GZW1016 -> GZW1038 a,d,h GZW1015 -> GZW1042 b,c,e,f,g,i AWE1155 a AWE1154 b,c,d,e,f,g,h,i a b,c,d,e,f,g,h,i d,h b,c,d,e,f,g,h,i a b,c,d,e f,g,h,i a b,c,d,e,f,g,h,i a b,c,d,e f,g,h,i a b,c,d,e f,g,h,i a b,c,d,e f,g,h,i
NOTE: Watch out for HIGH VOLTAGE! Install bleeder resister kit GXX1024.

Page 4 of 18

SDPXX4
SDPxx4 MODEL SERIES SERVICE KIT CONTENTS
MODELS 40" 45" (a) SD-P404-K (d) SD-P454-K (b) SD-P4043-K * (e) SD-P4543-K (c) SD-P4044-K * (f) SD-P4546-K * (g) PRO-73 50" (h) SD-P504-K (i) SD-P504-Q (j) SD-P5043-K (k) SD-P5043-Q (1) SD-P5046-K * (m) SD-P5047-Q (n) PRO-93 MODEL USAGE (All Models) (a,c,d,h,i) (b,e,f,g,j,k,l,m,n) (a,b,c,d,e,f,h,i,j.k,l,m) (g,n) (a,c,d,h,i) (b,e,f,l) (J,k,m) (g,n) (a,d,h,i) (b,e) (g,j,k,m,n) (c) (f,l) (a,b,c) (d,e,f,g,h,i,j,k,l,m,n) (All Models) (a,b,c,d,e,f,h,i,l) (g, j,k,m,n) (J,k,m) (g,n) (b,e,f,g,j,k,l,m,n) (b,e,f,g,j,k,l,m,n) (b,e,f,g,j,k,l,m,n) (b,e,f,g,j,k,l,m,n) (All Models) (All Models) (All Models) GREEN AWY1085 " " AWY1096 " 45" AMR2155 AMR2158 (a,b,c) (d,e,f) (h,i, j,k) (g) (l) 50" AMR2154 AMR2157

DESCRIPTION 1. DEFLECTION 2. VIDEO / AUDIO a) V/A assy b) SP Terminal assy 3. TUNER / CONTROL a) Tuner assy
PART NO. AWV1145 AWZ2960 AWZ2961 AWZ2962 AWZ3025 AWZ2971 AWZ2972 AWZ2973 AWZ2974 AWZ2975 AWZ2976 AWZ2977 AWZ3028 AWZ3029 AWZ2963 AWZ2964 AWZ2965 AWZ2966 AWZ2967 AWZ2969 AWZ2970 AWZ2954 AWZ3025 AWZ2956 AWZ2955
(SUB NO.) (GZW1037) (GZW1018) (GZW1019)

b) MICON

4. CONVERGENCE a) Convergence assy b) Sub Deflection c) Front Control d) Front Input assy 5. PICTURE-IN-PICTURE a) P-in-P assy b) P-in-P Sub assy 6. LOGIC a) P-in-P Select b) Logic assy 7. CRT DRIVER
8. CRT ASSY RED AWY1086 AWY1088 AWY1090 AWY1097 AWY1099 9. SCREEN/LENS Fresnel Lens Lenticular Sheet NOTE: * OEM models.
RED AWZ2957 GRN AWZ2958 BLU AWZ2959 BLUE AWY1087 AWY1089 AWY1091 AWY1098 AWY1100 40" AMR2156 AMR2159

Page 5 of 18

SDPXX5
SDPxx5 MODEL SERIES PARTS KIT ASSEMBLY REFERENCE
MODELS 40" (a) SD-P4051 (b) SD-P4053 45" (c) SD-P455 (d) SD-P4552 (e) SD-P4553 (f) PRO-75 PART NO. AWV1202** AWV1203** AWV1172** AWV1175** AWV1194** AWV1195** AWV1196** AWZ3824** AWZ3523* ACX1061 AWZ3655** AWZ3656 AWZ3534 AWZ3536** AWZ3537** AWZ3538** AWZ3539** AWZ3527** AWZ3528** AWZ3529** AWZ3530** AWZ3531 AWZ3532 AWZ3533 AWZ3547 AWZ3548 AWZ3545 AWZ3546 AWZ3524 AWZ3525 AWZ3526 ANZ3540 AWZ3542 AWZ3543 AWZ3544 50" (g) SD-P505 (h) SD-P5053 (i) SD-P5057 (j) PRO-95 (SUB NO.) (GZW1044) (GZW1047) 55" (k) SD-P5553
ELITE DESCRIPTION POWER SUPPLY DEFLECTION AND VIDEO
USAGE (a) (b.c.d,e,f,g,h,i,j,k) (c,g) (b,e,h,i,k) (a) (d) (f,j) (a) (b,c,d,e,f,g,h,i,j,k) (All models) (b,d,e,h,i,k) (b,d,e,h,i,k) (b,d,e,h,i,k) (a) (c,d,e,g) (b,h,i,k) (f,j) (a) (c,g) (b,d,e,h,i,k) (f, j) (a) (b,c,d,e,g,h,i,k) (f, j) (b, i) (f, j) (b,c,d,e,g,h,i,k) (All Models) (All Models) (All Models) (a,b,f,i,j) (c,d,e,g,h,k) (a,b,f,i,j) (c,d,e,g,h,k)
CONVERGENCE FOCUS VR P IN P P IN P SUB P IN P SELECT AUDIO AUDIO DSE A/V IO-2P A/V IO-3P S-2P S-3P FRONT INPUT SPEAKER TERMINAL RED GREEN BLUE FRONT CONTROL WFRONT CONTROL IR RECEIVER CRT DRIVER

Page 6 of 18

SDPXX5 DESCRIPTION CRT RED AWY1141 AWY1128 AWY1131 AWY1133 AWY1143 AWY1136 AWY1138 40" AMR2159 AMR2156 PART NO. GREEN AWY1140 AWY1127 AWY1130 AWY1130 AWY1130 AWY1135 AWY1135 45" AMR2310 AMR2309 USAGE BLUE AWY1142 AWY1129 AWY1132 AWY1134 AWY1144 AWY1137 AWY1139 50" AMR2308 AMR2307 (a) (b) (c,d,e) (g,h,i) (k) (J) (f) 55" AMR2317 AMR2316
LENTICULAR SHEET FRESNEL LENS
Quantity 1 of AWZ3523 is shipped in it's own box. Quantity 1 of these boards is contained in the SDPxx5 Parts Kit.

Page 7 of 18

SDPXX6
SD-Pxx6 Series Quick Reference Chart
MODELS 40" (a) SD-P4061 (b) SD-P4063 45" (c) SD-P4561 (d) SD-P4562 (e) SD-P4564 (f) SD-P4565 (g) PRO-76 PART NO. AWV1281* AWV1289* AWV1290* AWV1287 AWV1246* AWV1252* AWV1255* AWV1265* AWV1261* AWV1269 AWZ4178* AWZ4193* AWZ4182* AWZ4195* AWZ4240* AWZ4243* AWZ4472 AWZ4546 AXQ1009* 50" (h) SD-P5062 (i) SD-P5064 (j) SD-P5065 (k) SD-P5067 (1) PRO-96 MODEL USAGE (f, j ,n ,k, o, i, e, m, g, l, p) (a,b) (h,d,c) (a) (f,j,n,k,o) (i,, e, m) (b) (c) (d,h) (g, l, p) ( All Models) (f, j, n, k, o, i, e, m) (j, f, n, k, o) (i,e,m,b) (h,d) (c) (g, l, p) (a) (f, j, n, k, o, i, e, m) 55" (m) SD-P5564 (n) SD-P5565 (o) SD-P5567 (p) PRO-106

Description POWER SUPPLY DEFLECTION AND VIDEO
CONVERGENCE POWER AMP ASSY. A/V IO-PinP-Y/C SEP

DOLBY PRO LOGIC ASSY.

Refer to enclosed Master Parts list (Page A4) for Boards not listed here. * Quantity 1 of this board is contained in the SDPxx6 Parts Kit.

Page 8 of 18

SDPXX7
SD-Pxx7 Series Quick Reference Chart

SD-P5575

Power Supply / Deflection Tuner / Video Assy Convergence Assy AV I/0 Assy P in P Select Assy Y/C Select Assy P in P Assy W Front Control Assy S Front Control Assy Dolby Pro-Logic Module Audio Assy Red CRT Green CRT Blue CRT AWV1383 AWV1368 *AWV1409 AWZ5142 AWZ5146 AWZ5151 AWZ5147 AWZ5150 AWZ5148 *AWZ5439

SD-P5075

SD-P4575

SD-P5073

SD-P4573

PRO-107

PRO-97

PRO-77

SD-P4571
AWV1360 AWV1355 AWZ5058 AWZ4240 AWZ4188

SD-P5071

E E E E E E E E

AWV1374 *AWV1411

E E E E E E

AWV1376

E E E E E E E

E E E E E

AWZ5227

AWZ5228

AWZ5063

AWZ5162

AWY1225 AWY1226 AWY1227
AXQ1009 AWZ5156 AWY1209 AWY1206 AWY1210

AWY1219

AWY1223 AWY1232 AWY1224

AWY1228 AWY1229 AWY1230

AWY1207

AWY1231 AWY1212

AWY1221 AWY1218 AVVY1222

AVVY1206 AWY1208

AWY1208

AWY1220

* Use in models with Dual RF Inputs. Serial number changeover not known.

Page 9 of 18

SD-Pxx8 Quick Reference Chart
Power supply/Deflect Tuner/Video Convergence Sub Convergence Convergence PD VM Assembly Pro S.G. Assembly Center SP. Switch P in P Assembly P in P Select Y/C Selector AV I/O Assembly System Control Front Control Front Input Focus VR Ext. SP. Assembly V-Amp Assembly Power SW. Assembly RF Amp Assembly* Photo Diode Assembly* Relay Drive Assembly Red CRT Green CRT Blue CRT Red CRT Drive Green CRT Drive Blue CRT Drive IR Receiver Sub Receiver Lenticular Sheet Fresnel Lens Remote Control Acrylic Panel Frame Cover - H Frame Cover - V Screws w/Acrylic Main Repeater Mini Repeater SD-P4681 AWV1496 AWV1478 AWZ5967 N/A N/A N/A N/A N/A N/A N/A N/A AWZ5971 N/A AWZ5972 N/A ACX1096 N/A AWZ5973 AWZ5974 N/A N/A N/A AWY1315 AWY1314 AWY1316 AWZ5968 AWZ5969 AWZ5970 N/A N/A AMR2730 AMR2759 AXD1414 N/A N/A N/A N/A N/A N/A SD-P5181 E E E N/A N/A N/A N/A N/A N/A N/A N/A E N/A E N/A E N/A E E N/A N/A N/A AWY1312 AWY1311 AWY1313 E E E N/A N/A AMR2726 AMR2758 E N/A N/A N/A N/A N/A N/A SD-P6081 E E E N/A N/A N/A N/A N/A N/A N/A N/A E N/A E N/A E N/A E E N/A N/A N/A AWY1318 AWY1317 AWY1319 E E E N/A N/A AMR2740 AMR2741 E N/A N/A N/A N/A N/A N/A SD-P4683 AWV1499 AWV1483 AWZ5981 AWZ6001 AWZ5991 N/A N/A N/A AWZ5992 AWZ5993 AWZ5987 AWZ5985 N/A AWZ5989 N/A ACX1096 N/A N/A AWZ5984 N/A N/A AWZ5999 AWY1315 AWY1314 AWY1316 AWZ5982 AWZ5983 AWZ6009 N/A N/A AMR2730 AMR2759 AXD1416 N/A N/A N/A N/A N/A N/A SD-P5183 E E E E E N/A N/A N/A E E E E N/A E N/A E N/A N/A E N/A N/A E AWY1321 AWY1320 AWY1322 E E E N/A N/A AMR2726 AMR2758 E N/A N/A N/A N/A N/A N/A SD-P5185 SD-P6085 PRO-98 PRO-118 E E AWV1500 E AWV1484 E AWV1485 E E E E E E E AWZ6001 E E E AWZ5991 E N/A AWZ5997 E E N/A N/A AWZ6005 E N/A N/A AWZ6006 E E E AWZ5992 E E E AWZ5993 E E E AWZ5988 E E E AWZ5986 E AWZ5998 E E E AWZ5990 E AWZ6002 E N/A N/A AWZ6003 E E E ACX1096 E N/A N/A AWZ6008 E N/A N/A N/A N/A E E AWZ5984 E AWZ7658 E E E AWZ7657 E E E E E AWZ5999 E E AWY1318 AWY1327 AWY1329 E AWY1317 AWY1326 AWY1328 E AWY1319 AWY1322 AWY1319 E E AWZ5982 E E E AWZ5983 E E E AWZ6009 E N/A N/A AWZ6004 E N/A N/A AWZ6007 E E AMR2740 AMR2751 AMR2752 E AMR2741 AMR2754 AMR2753 AXD1415 E E E AAK2628 AAK2642 AAK2632 AAK2633 AAP1538 AAP1540 AAP1520 AAP1521 AAP1539 AAP1541 AAP1536 AAP1537 N/A N/A ABA1226 E AXF1079 E E E ADF1002 E E E * AWZ7658 + AWZ7657 = AWX7012

Page 10 of 18

SD-Pxx9 Quick Reference Chart
SD-P4691 SD-P5191 SD-P6091 SD-P5193 SD-P6093
Power supply/Deflect Ass'y * VM&B Conn. or VM Ass'y Tuner/Video Ass'y * CNR Ass'y * Full Cinema Mute Ass'y * TV Front End Unit * Dual Tuner or ISC Ass'y * Digital Video Ass'y * Wide Video Ass'y Convergence * Full Cinema Convergence * G Conver DAC Ass'y * B Conver DAC Ass'y * R Conver DAC Ass'y AV I/O Ass'y * P IN P Selector Ass'y P IN P Ass'y Audio Ass'y RF Switch S Input or Y/C Select Ass'y A Connector Assembly 3D Y/C Ass'y Front Control Indicator Assembly Front Input Ass'y Ext. SP Ass'y Power or Main SW. Ass'y Focus VR VM Coil Deflection Yoke Red CRT Green CRT Blue CRT Red CRT Drive Ass'y Green CRT Drive Ass'y Blue CRT DriveAss'y Lens Assembly Mirror Lenticular Sheet Fresnel Lens Remote Control Screen Cover or Acrylic Panel Frame Cover - H Frame Cover - V Screws w/Acrylic Main Repeater Mini Repeater * Sub board AWV1551 AWZ6066 AWV1539 N/A N/A AXF1084 AWZ6068 N/A N/A AWZ6071 N/A N/A N/A N/A AWZ6070 N/A N/A N/A AXF1086 AWZ6072 AWZ6065 N/A AWZ6061 AWZ6069 N/A N/A AWZ6096 ACX1096 ATL1123 ATL1124 AWY1353 AWY1351 AWY1354 AWZ6062 AWZ6063 AWZ6064 AMR2833 AMR2834 AMR2841 AMR2843 AXD1414 N/A N/A N/A N/A N/A N/A E E E N/A N/A E E N/A N/A E N/A N/A N/A N/A E N/A N/A N/A E E E N/A E E N/A N/A E E E E AWY1350 AWY1351 AWY1352 E E E E E AMR2835 AMR2836 E N/A N/A N/A N/A N/A N/A E E E N/A N/A E E N/A N/A E N/A N/A N/A N/A E N/A N/A N/A E E E N/A AWV1549 N/A N/A N/A AWZ6067 E E E AWY1355 AWY1351 AWY1356 E E E E AMR2738 AMR2842 AMR2846 E N/A N/A N/A N/A N/A N/A AWV1551 E AWV1552 AWZ6095 N/A E E N/A N/A E N/A N/A N/A N/A E N/A N/A N/A E E E N/A AWZ6061 AWZ6069 N/A N/A E E E E AWY1359 AWY1360 AWY1361 E E E AMR2803 AMR2834 AMR2835 AMR2836 AXD1426 AAK2661 N/A N/A N/A N/A N/A

PRO-99

PRO-119 SD-P5795W PRO-1009W
E E E N/A E E E N/A N/A E E N/A N/A N/A E E E E E E E E E N/A E E E E E E AWY1367 E AWY1368 E E E AMR2857 AMR2739 AMR2752 AMR2844 E AAK2633 AAP1521 AAP1557 E E E E AWZ6164 AWV1597 N/A N/A E E AWV1524 AWZ6124 AWV1590 N/A AWZ6162 AWZ6163 AWZ6160 AWZ6156 E E AWZ6161 E AWZ6158 E E E N/A AWZ6165 E E E E E E E E E E E E AMR2852 AMR2847 AMR2849 E AAK2667 AAP1564 E E E E E AWV1598 N/A N/A E E E E E N/A E E E AWZ6099 E E AWZ6109 E AWZ6159 E E E N/A AWZ6118 E E E E E E E E E E E E E AMR2848 E E E E E E E
E AWV1565 E AWZ6105 E AWV1559 E N/A N/A AWZ6107 E E E AWZ6104 N/A N/A N/A N/A E AWZ6098 N/A AWZ6108 N/A N/A N/A N/A N/A N/A E AWZ6099 N/A AWZ6120 N/A AWZ6101 N/A AWZ6109 E E E AWZ6100 E AWZ6106 N/A AWZ6117 AWV1549 AWZ6113 N/A N/A N/A AWZ6118 N/A AWZ6102 AWZ6067 AWZ6114 E E E E E ATL1127 AWY1362 AWY1365 AWY1360 AWY1364 AWY1363 AWY1366 E AWZ6110 E AWZ6111 E AWZ6112 AMR2857 AMR2803 AMR2739 AMR2852 AMR2842 AMR2751 AMR2844 AMR2845 E AXD1425 AAK2671 AAK2632 AAP1540 AAP1520 AAP1541 AAP1560 N/A ABA1226 N/A AXF7001 N/A ADF1002

PRO-200

E E AWZ6303 E E E E E E E E E E E E E E E E E E E E E AWY1406 E AWY1407 E E E E AMR2739 ANG2008 ANG2007 AMR3084 AMR3086 E AAK2633 AAP1521 AAP1557 E E AV I/O Ass'y AWZ6295 AWZ6320 Component Ass'y AWZ6301 AWZ6300 IQ Selector Ass'y AWZ6310 AWZ6329 O X O X O X O O O X O X O O X O X O Tuner/Video Ass'y AWZ6303 AWZ6330
(IC801=PD5473A) (IC801=PD5473B)

Chart 1

O = Compatible, X = Not Compatible ( See SI-A53005 for more details on AV I/O & Component Ass'y )

Page 13 of 18

PRO-700HD / SD-641HD5 Quick Reference Chart
PRO-700HD SD-641HD5 (Sub No.)
Power Supply Assembly AC In Assy

Power Switch Assembly

Deflection Service Assy

Focus VR

Video Assembly
*Tuner/uCom Assy Front Control Assy LED DPO Assy Antenna Switch *Signal Assy *Sub Video Assy *AV I/O Assy Front Input Assy SR BNC Assy SR Assy
*Convergence DAC Assy Connector Assembly Red CRT Green CRT Blue CRT Red CRT Amp Assembly Green CRT Amp Assembly Blue CRT Amp Assembly Deflection Yoke VM Coil Lens Assembly (CRT) Mirror Mirror Frame H Mirror Frame V Lenticular Sheet Fresnel Lens Protective Screen / Acrylic Panel Frame Cover H Frame Cover V Panel Frame H Panel Frame V Screen Frame Screws for Acrylic Panel (Long) Speaker 66 (Tweeter) Cone Speaker Door Assy Remote Control Service Manual Part 1 Service Manual Part 2 Service Manual (SD-641HD5) Owner's Manual *Sub Board
AWV1710 AWZ6353 AWZ6341 AWV1731 ACX1096 AWV1716 AWV1715 AWZ6337 AWZ6338 AXF1098 AWV1717 AWV1718 AWV1714 AWZ6339 AWZ6342 AWZ6340 AWV1712 AWZ6333 AWZ6335 AWY1414 AWY1413 AWY1415 AWZ6344 AWZ6345 AWZ6346 ATL1136 ATL1137 AMR3121 AMR3113 ANG2314 ANG2315 AMR3115 AMR3116 AAK2729 AAP1593 AAP1594 AND1163 AND1164 AAP1592 ABA1226 D66AP45-56L APV1048 AAN1444 AXD1438 ARP3013 ARP3024 Not used ARB1519

AWV1762

AWZ6374

AWV1722

(AWV1745)

AWZ6373

E E E E E E E E E E E E

AMR2948

AMR3161
AAK2743 AAP1599 AAP1604 AND1163 AND1164 AAP1602 ABA1226 D66AP45-56L APV1048 AAN1455 AXD1444 ARP3013 ARP3024 ARP3031 ARB1526

Page 14 of 18

PRO-510/610/710HD, SD-532/582HD5 Quick Reference Chart

Power Supply Assembly

Video Assembly RGB Sw Assy
*Sub Video Assy. *Signal Assy LED DPO Assy Front Control Assy RF Switch *AV I/O Assy Front Input Assy BNC Assy *Audio Assy

Convergence Amp Assy

*Digital Conv. Assy Connector Assembly Red CRT Green CRT Blue CRT Red CRT Drive Assembly Green CRT Drive Assembly Blue CRT Drive Assembly Deflection Yoke VM Coil Lens Assembly (CRT) Mirror Mirror Frame H Mirror Frame V Lenticular Sheet Fresnel Lens Protective Screen / Acrylic Panel Frame Cover H Frame Cover V Assy Panel Frame H Panel Frame V Screen Frame Screws for Acrylic Panel (Long) Cone Speaker Remote Control Service Manual Part 1 (For all models) Service Manual Part 2 (For all models) Service Manual Part 3 (Supplement for PRO710HD only) Service Manual Part 4 (Supplement for all VA models) Owner's Manual Kick Panel *Sub Board **Notes: There is no interchangeablility between Earlier type and the VA type. SERIAL NUMBER: Special serial number is used for VA type as shown below. xxxx002345xx If first number starts with 0 in 6-digit serial, it is for Earlier type. xxxx104567xx If first number starts with 1 in 6-digit serial, it is for VA type. ( "x" means alpha character)

PRO-710HD PRO-610HD Earlier type VA type **AWV1795 **AWV1872 E AWZ6467 E AWV1809 E ACX1096 E AWV1799 E AWZ6468 E **AWV1819 **AWV1868 E **AWV1800 **AWV1866 E AWZ6463 E AWZ6462 E AXF1088 E AWV1802 E AWZ6466 E AWZ6464 E AWZ6472 E AWZ6456 E AWZ6460 E AWZ6461 E AWY1414 AWY1421 AWY1413 AWY1413 AWY1415 AWY1422 AWZ6457 E AWZ6458 E AWZ6459 E ATL1136 E ATL1137 E AMR3121 AMR3183 AMR3113 AMR3188 ANG2391 ANG2371 ANG2392 ANG2373 AMR3115 AMR3184 AMR3116 AMR3186 AAK2763 AAK2749 AAP1593 AAP1613 AAP1594 AAP1617 AND1163 AAP1629 AND1164 AND1169 AAP1592 AAP1611 ABA1226 ABA1280 APV1021 E AXD1448 E ARP3047 E ARP3051 E ARP3065 Not used Not used Not used ARP3086 E ARB1527 E 261696 270071

PRO-510HD

E E E E E E E E E E E E E E E E E E

AWY1416 AWY1417 AWY1418

SD-582HD5 SD-532HD5 Earlier type VA type **AWV1808 **AWV1869 E

AWV1804

**AWV1806 **AWV1871 **AWV1805 **AWV1870 AWZ6470
AWV1807 AWZ6471 Not used AWZ6469

Not used

AWY1419

E E E E

AWY1416

AWY1420

AWY1418
AMR2833 AMR3189 ANG2372 ANG2374 AMR3185 AMR3187 AAK2750 AAP1614 AAP1619 AAP1630 AND1167 AAP1612
AMR3188 ANG2371 ANG2373 AMR3178 AMR3180 AAK2747 Not used Not used Not used Not used AAP1607 Not used
AMR3189 ANG2372 ANG2374 AMR3179 AMR3181 AAK2748 Not used Not used Not used Not used AAP1608 Not used

AXD1449

270066

ARB1528

271618

Page 15 of 18

SD-533/643HD5 Quick Reference Chart
SD-643HD5 Power Supply Assembly
Power Switch Assembly Earlier type New type **AWV1887 **AWV2011 AWZ6611 AWV1909 AWV1892 ACX1097 AXW1050 ADY1064 AWV1910 AWV1891 AWZ6608 AWZ6610 AXF1109 AWZ6609 **AWY1427 **AWY1446 **AWY1426 **AWY1444 **AWY1428 **AWY1454 AWZ6605 AWZ6606 AWZ6607 ATL1144 ATL1137 AMR3235 AMR3245 ANG2441 ANG2442 **AMR3239 **AMR3378 **AMR3279 **AMR3379 AAK2773 AAP1642 AMB2686 AAP1640 APV1021 AXD1457 AXD1483 ARP3094 ARP3163 ARB1535 ARB1555

SD-533HD5

Earlier type **AWV1887 New type **AWV2011
*Digital Conv. Assy Focus VR HV Distributor HV Cable
Video IP Assy. Signal Assy
Front LED Assy Remote Sensor Assy RF Switch Front Input Assy Red CRT **AWY1424 **AWY1449 Green CRT **AWY1423 **AWY1450 Blue CRT **AWY1425 **AWY1451 Red CRT Drive Assy E Green CRT Drive Assy E Blue CRT Drive Assy E Deflection Yoke E VM Coil E Lens Assembly (CRT) AMR2833 Mirror AMR3244 Mirror Frame H Not used Mirror Frame V Not used Lenticular Sheet **AMR3179 **AMR3376 Fresnel Lens **AMR3181 **AMR3377 Contrast Screen AAK2785 Screen Frame H Assy AAP1641 Decoration Panel Assy (Speaker Grille) AMB2685 Screen Frame V AAP1639 Cone Speaker E Remote Control AXD1457 AXD1483 Service Manual ARP3094 ARP3163 Owner's Manual ARB1535 ARB1555 *Sub Board **Notes: There is no interchangeablility between Earlier type and the New type. SERIAL NUMBER: Special serial number is used for the New type as shown below. xxxx002345xx If first number starts with 0 in 6-digit serial, it is the Earlier type. xxxx104567xx If first number starts with 1 in 6-digit serial, it is the New type. ( "x" means alpha character)

Page 16 of 18

PRO-520/620/720HD Quick Reference Chart
PRO-720HD PRO-620HD Power Supply Assembly
Power Switch Assembly AWV1912 AWZ6467 AWV1921 ACX1096 AWV1916 AWZ6468 AWV1922 AWV1917 AWZ6470 AWZ6462 AXF1088 AWV1919 AWZ6466 AWV1920 AWZ6472 AWZ6649 AWZ6460 AWZ6461 AWY1437 AWY1431 AWY1438 AWZ6601 AWZ6602 AWZ6603 ATL1145 ATL1137 AMR3235 AMR3113 ANG2391 ANG2392 AMR3277 AMR3116 AAK2777 AAP1593 AAP1594 AND1163 AND1164 AAP1636 ABA1226 APV1021 AXD1458 ARP3095 ARP3099 ARB1543 261696
PRO-520HD E E E E E E E E E E E E E E E E E E

AWY1432

*Sub Video Assy *Signal Assy LED DPO Assy Front Control Assy RF Switch *AV I/O Assy Front Input Assy BNC Assy *Audio Assy
*Digital Conv. Assy Connector Assembly Red CRT Green CRT Blue CRT Red CRT Drive Assembly Green CRT Drive Assembly Blue CRT Drive Assembly Deflection Yoke VM Coil Lens Assembly (CRT) Mirror Mirror Frame H Mirror Frame V Lenticular Sheet Fresnel Lens Contrast Screen Frame Cover H Frame Cover V Assy Panel Frame H Panel Frame V Screen Frame Screws for Acrylic Panel (Long) Cone Speaker Remote Control Service Manual Part 1 (For all models) Service Manual Part 2 (For all models) Owner's Manual Kick Panel *Sub Board Bold Type: Change from PRO-510/610/710HD

AWY1434

AWY1435

AWY1433

AMR3248 AMR3188 ANG2371 ANG2373 AMR3250 AMR3186 AAK2776 AAP1613 AAP1617 AAP1629 AND1169 AAP1635 ABA1280
AMR3189 ANG2372 ANG2374 AMR3249 AMR3187 AAK2775 AAP1614 AAP1619 AAP1630 AND1167 AAP1634

270071

Page 17 of 18
PRO-530/630/730HD and PRO-530/730HDI Quick Reference Chart
PRO-730HD Power Supply Assembly
*Digital Conv. Assy Power Switch Assembly AWV1960 AWV1966 AWZ6713 AWV1967 ACX1097 AWV1992 AXY1061 AWZ6718 AWZ6719 AWV1983 ASG1090 N/A AWZ6716 AWZ6712 AXF1109 AWZ6715 AWZ6720 AWZ6714 AWZ6717 AWY1448 AWY1444 AWY1447 AWZ6709 AWZ6710 AWZ6711 ATL1144 ATL1146 AMR3235 AMR3321 AMR3333 ANG2391 ANG2392 AMR3327 AMR3330 AAK2791 AAP1593 AAP1664 AAP1665 AND1174 AND1177 AAP1655 ABA1226 APV1021 AXD1468 ARP3138E ARP3139E ARB1546 AMM2945

PRO-730HDI

AWV2057

PRO-630HD

AWV1960

PRO-530HD

PRO530HDI

AWV2058 AXY1076

AWV1992 AXY1061
Video Ucom Service Assembly
*Progressive Unit Front Control Assy LED RLS Assy

AWZ6822 N/A N/A AWV2061

AWZ6719 AWV1983 ASG1090 N/A

DVI Service Assy

Power Switch (S2) (Trap Switch)
HDMI Service Assy Signal Assy
*Tuner Assy RF Switch Front Input Assy BNC Assy D-Sub Assy Remote Sensor Assy Red CRT Green CRT Blue CRT Red CRT Drive Assembly Green CRT Drive Assembly Blue CRT Drive Assembly Deflection Yoke VM Coil Lens Assembly (Red & Green CRT) Lens Assembly (Blue CRT) Mirror Mirror Frame H Mirror Frame V Lenticular Sheet Fresnel Lens AR Panel (Anti Reflective Screen) Frame Cover H Frame Cover V Assy (Left) Frame Cover V Assy (Right) Panel Frame H Panel Frame V Screen Frame Assy Screws for AR Panel Cone Speaker Remote Control Service Manual Part 1 Service Manual Part 2 Owner's Manual Bottom Rail (Kick Panel) * Sub Ass'y
E E E E E E E E E E E E E E E E E E E E

AMR3390

AWY1446

AWY1443

E E E E E E E E E
AMR3332 ANG2371 ANG2526 AMR3326 AMR3329 AAK2790 AAP1613 AAP1662 AAP1663 AND1173 AND1176 AAP1654

AWY1445

AMR3248
AMR3331 ANG2372 ANG2524 AMR3325 AMR3328 AAK2789 AAP1614 AAP1660 AAP1661 AND1172 AND1175 AAP1653

AMR3388

E E E E E E E E E E
AXD1485 ARP3183 N/A ARB1557
AXD1468 ARP3138E ARP3139E ARB1546 AMM3011

AMM3012

Page 18 of 18