AUDIO/VIDEO MULTI-CHANNEL RECEIVER

Nm-.,,

MULTI JOG

INPUT SELECTOR

ENTER STANDBY

STANDBY/ON

MASTER VOLUME
ADVANCED SURROUND STEREO/ DIRECT SIGNAL SELECT

STATION

TUNING

STANDARD

MONITOR

MIDNIGHT

LOUDNESS

QUICK SETUP DOWN

LISTENING MODE TUNER CLASS EDIT BAND MPX INPUT ATT FL DIMMER

PHONES

ORDER NO.

RRV2599

VSX-D511-K

VSX-D511-S

VSX-D511-K VSX-D511-S VSX-D511-K VSX-D511-K MVXJI MYXJIEW MYXJIEW MYXJIGR
THIS MANUAL IS APPLICABLE TO THE FOLLOWING MODEL(S) AND TYPE(S).
AC230V AC220-230V AC220-230V AC220-230V

Power Requirement

Remarks
For details, refer to "Important symbols for good services" on the next page.
PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936

PIONEER CORPORATION 2002

T-ZZR APR.2002.printed in Japan

SAFTY INFORMATION

This service manual is intended for qualified service technicians; it is not meant for the casual do-it-yourselfer. Qualified technicians have the necessary test equipment and tools, and have been trained to properly and safely repair complex products such as those covered by this manual. Improperly performed repairs can adversely affect the safety and reliability of the product and may void the warranty. If you are not qualified to perform the repair of this product properly and safely, you should not risk trying to do so and refer the repair to a qualified service technician.
WARNING This product contains lead in solder and certain electrical parts contain chemicals which are known to the state of California to cause cancer, birth defects or other reproductive harm. Health & Safety Code Section 25249.6 Proposition 65
NOTICE (FOR CANADIAN MODEL ONLY) Fuse symbols (fast operating fuse) and/or (slow operating fuse) on PCB indicate that replacement parts must be of identical designation. REMARQUE (POUR MODLE CANADIEN SEULEMENT)

Les symboles de fusible

(fusible de type rapide) et/ou
(fusible de type lent) sur CCI indiquent que
les pices de remplacement doivent avoir la mme dsignation.
(FOR USA MODEL ONLY) 1. SAFETY PRECAUTIONS
The following check should be perfor med for the continued protection of the customer and ser vice technician.

LEAKAGE CURRENT CHECK

Measure leakage current to a known ear th ground (water pipe, conduit, etc.) by connecting a leakage current tester such as Simpson Model 229-2 or equivalent between the ear th ground and all exposed metal par ts of the appliance (input/output terminals, screwheads, metal overlays, control shaft, etc.). Plug the AC line cord of the appliance directly into a 120V AC 60 Hz outlet and turn the AC power switch on. Any current measured must not exceed 0.5 mA.

To protect the product from damages or failures that may be caused during transit, the shipping mode should be set or the shipping screws should be installed before shipping out in accordance with this manual, if necessary.
5. Lubricants, glues, and replacement parts
Appropriately applying grease or glue can maintain the product performances. But improper lubrication or applying glue may lead to failures or troubles in the product. By following the instructions in this manual, be sure to apply the prescribed grease or glue to proper portions by the appropriate amount.For replacement parts or tools, the prescribed ones should be used.

CONTENTS

SAFTY INFORMATION. 1. SPECIFICATIONS. 2. EXPLODED VIEWS AND PARTS LIST. 2.1 PACKING. 2.2 EXTERIOR SECTION. 2.3 FRONT PANEL SECTION. 3. BLOCK DIAGRAM AND SCHEMATIC DIAGRAM. 3.1 BLOCK DIAGRAM. 3.2 OVERALL WIRING CONNECTION DIAGRAM. 3.3 D.D & INPUT(1/4) ASSY. 3.4 D.D & INPUT(2/4) ASSY. 3.5 D.D & INPUT(3/4) ASSY. 3.6 D.D & INPUT(4/4) ASSY. 3.7 AMP & PRIMARY(1/2), TRANS2 and TRANS3 ASSYS. 3.8 AMP & PRIM.(2/2), REG., HASHIGETA, B TO B and MECH SW ASSYS 3.9 VIDEO, 6CH IN and S.VIDEO ASSYS. 3.10 FRONT, R.ENCODER and POWER SW ASSYS. 3.11 DIGITAL IN, H.P. and KAWA ASSYS. 3.12 FM/AM TUNER MODULE. 4. PCB CONNECTION DIAGRAM. 4.1 TRANS1, TRANS2 and TRANS3 ASSYS. 4.2 D.D & INPUT ASSY. 4.3 AMP INPUT, AMP & PRIMARY and MECHA SW ASSYS. 4.4 FRONT, POWER SW, H.P. and R.ENCODER ASSYS. 4.5 REGULATOR, HASHIGETA and KAWA ASSYS. 4.6 DIGITAL IN, 6CH IN, VIDEO and BOARRO TO BOARD ASSYS. 4.7 FM/AM TUNER MODULE. 5. PCB PARTS LIST. 6. ADJUSTMENT. 7. GENERAL INFORMATION. 7.1 DISASSEMBLY and DIAGNOSI. 7.1.1 DISASSEMBLY and PCB LOCATION. 7.1.2 U-COM BLOCKDIAGRAM. 7.1.3 PROTECTION CIRCUIT. 7.1.4 POWER ON SEQUENCE. 7.1.5 POWER OFF SEQUENCE. 7.2 PARTS. 7.2.1 IC. 7.2.2 DISPLAY. 8. PANEL FACILITIES.

.2.5.6.6.73 75

1. SPECIFICATIONS

Amplifier Section

Continuous Power Output (STEREO mode) Front. 80 W per channel (DIN 1kHz, THD 1.0 %, 8 ) Continuous Power Output Front... 80 W per channel (1kHz, THD 1.0 %, 8 ) Center... 80 W (1kHz, THD 1.0 %, 8 ) Surround.. 80 W per channel (1kHz, THD 1.0 %, 8 ) Above specifications are applicable when the power supply is 230V. Input (Sensitivity/Impedance) CD, VCR/DVR, CD-R/TAPE/MD, DVD/LD, TV/SAT. 200 mV/47 k Frequency Response CD, VCR/DVR, CD-R/TAPE/MD, DVD/LD,TV/SAT... 5 Hz to 100,000 Hz +03 dB Output (Level/Impedance) VCR/DVR REC, CD-R/TAPE/MD REC.. 200 mV/2.2 k Tone Control BASS... 6 dB (100 Hz) TREBLE... 6 dB (10 kHz) LOUDNESS.. +9 dB/+9 dB (100 Hz/10 kHz) Signal-to-Noise Ratio [DIN (Continuous rated power output/50 mW)] CD, VCR/DVR, CD-R/TAPE/MD,DVD/LD, TV/SAT. 88/64 dB

FM Tuner Section

Frequency Range.. 87.5 MHz to 108 MHz Usable Sensitivity.. Mono:13.2 dBf, IHF (1.3 V/ 75 ) 50 dB Quieting Sensitivity... Mono: 20.2 dB Stereo: 38.6 dBf Signal-to-Noise Ratio.. Mono: 73 dB (at 85 dBf) Stereo: 70 dB (at 85 dBf) Signal-to-Noise Ratio (DIN).. Mono: 62 dB Stereo: 58 dB Distortion... Stereo: 0.5 % (1 kHz) Alternate Channel Selectivity.. 60 dB (400 kHz) Stereo Separation.. 40 dB (1 kHz) Frequency Response.. 30 Hz to 15 kHz (1 dB) Antenna Input (DIN)... 75 unbalanced

AM Tuner Section

Frequency Range.. 531 kHz to 1,602 kHz Sensitivity (IHF, Loop antenna)... 350 V/m Selectivity... 25 dB Signal-to-Noise Ratio.. 50 dB Antenna... Loop antenna

Miscellaneous

Power Requirements AC 230 V, 50/60Hz UK model.. European model... AC 220-230 V, 50/60 Hz Power Consumption... 220W In Standby.... 1 W Dimensions.. 420 (W) x 158 (H) x 393 (D) mm Weight (without package)... 9.0 kg

Video Section

Input (Sensitivity/Impedance) VCR/DVR, DVD/LD, TV/SAT... 1 Vp-p/75 Output (Level/Impedance) VCR/DVR... 1 Vp-p/75 Frequency Response +0 VCR/DVR, DVD/LD,TV/SAT ] MONITOR. 5 Hz to 7 MHz 3 dB Signal-to-Noise Ratio.. 55 dB Cross Talk... 55 dB

Furnished Parts

AM loop antenna... 1 FM wire antenna... 1 Dry cell batteries (AA size IEC R6P)... 2 Remote control... 1 Operating instructions... 1
Manufactured under license from Dolby Laboratories. Dolby, Pro Logic II and the double D symbol 2 are trademarks of Dolby Laboratorories. "DTS" ,ES and "DTS Digital Surround" are trademarks of Digital Theater Systems, Inc.
Specifications and the design are subject to possible modifications without notice, due to improvements.

Accessories

TOP MENU

RECEIVER

ADVANCED MASTER STANDARD SURROUND STEREO VOLUME
CD-R/ VCR/ MIDNIGHT/ LOUDNESS TUNER TAPE/MD DVR

LEVEL EFFECT

DISPLAY

DVD CONTROL

INPUT SELECTOR CD

RECEIVER DVD/LD TV/SAT

CH SELECT

FL DIMMER

TEST TONE

TUNER EDIT

AM loop antenna (ATB7009)
FM wire antenna (ADH7005)
AA size IEC R6P Dry cell batteries (x2)
Remote control unit (XXD3039)

SUB TITLE

INPUT ATT

AV RECEIVER

2. EXPLODED VIEWS AND PARTS LIST

NOTES:

Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. Screws adjacent to mark on product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.)

2.1 PACKING

/MYXJIEW Type 12

PACKING parts List

Mark No. 1 NSP NSP Description FM wire antenna Warranty Card AM loop antenna Dry cell batteries (AA/R6P) Operating instructions (English/German) Operating instructions Remote Control Unit Part No. ADH7005 ARY7022 ATB7009 VEM-013 XRE3057 Mark No. 8 NSP Description Battery Cover Polyethylene Bag Packing Sheet Left Pad R5 Right Pad R5 Packing Case Operating instructions Part No. AZA7378 Z21-038 AHG7069 XHA3032 XHA3033 See Contrast table(2) See Contrast table(2)
See Contrast table(2) XXD3039
(2) CONTRAST TABLE VSX-D511-K/MVXJI, /MYXJIEW, /MYXJIGR and VSX-D511-S/MYXJIEW are constructed the same except for the following :
Mark NO 14 Symbol and Description Operating Instructions (French,Italian) Packing Case Operating Instructions (Spanish,Dutch) VSX-D511-K/ MVXJI Not used XHD3204 Not used VSX-D511-S/ MYXJIEW XRC3056 XHD3205 XRC3070 VSX-D511-K/ MYXJIEW XRC3056 XHD3204 XRC3070 VSX-D511-K/ MYXJIGR Not used XHD3204 Not used

2.2 EXTERIOR SECTION

54 H 4

K L H M G

31 N 10 GL 15

8 M 39(1/2)

5 C 55

53 39(2/2) 18 X

3 E 26
B Accessory of Front Panel

6 F 37

NON-CONTACT SIDE CONTACT SIDE
Refer to "2.3 FRONT PANEL SECTION".
EXTERIOR SECTION parts List
Mark No. 15 NSP 16 NSP 19 > Description D.D & INPUT ASSY AMP ASSY REGULATOR ASSY AMP INPUT ASSY TRANS2 ASSY HASHIGETA ASSY BOARD TO BOARD ASSY 6CH IN ASSY DIGITAL IN ASSY S. VIDEO ASSY KAWA ASSY VIDEO ASSY TRANS1 ASSY TRANS3 ASSY FM/AM TUNER MODULE Power Transformer (T1) Fuse (FU1:T2.5A) Power Cord Cord Stopper 28P FFC/30V (J31) DD CN102 - FRONT CN402 Part No. XWX3044 XWZ3533 XWZ3544 XWZ3547 XWZ3555 XWZ3566 XWZ3527 XWZ3507 XWZ3518 XWZ3521 Mark No. 30 Description Part No.
DD CN106 - AMP INPUT CN254 23P FFC/30V (J36) XDD3102 AMP CN53 - REGULATOR CN801 7P FFC/30V (J37) XDD3103 DD CN9101 - DIGITAL IN CN1901 9P FFC/30V (J48) XDD3106 DD CN104 - 6CH IN CN307 Top Cover See Contrast table(2) Under Base 409 Insulator FFC Cover R5 Rear Panel Bonnet D510 Push Rivet Tuner Shield R5 PCB Angle R5 Reg Support R5 Heat Sink Assy 0.8 Heat Sink Angle F Heat Sink Angle R Heat Sink 0.8 Screw 3x23 PCB Mold Screw Screw Screw Screw Tuner Sheet Screw

NSP 45 NSP 48 NSP 57

XWZ3529 XWZ3490 XWZ3552 XWZ3560 AXQ7232 ATS7259
ANA7094 PNW2766 XMR3047 XNC3143 See Contrast table(2) See Contrast table(2) XNG3072 XNG3073 XNG3074 ANH7118 ANG7251 ANG7252 ANH7110 ABA7043 AMR2533 See Contrast table(2) BBZ30P080FMC BBZ30P200FMC FBT40P080FZK XEC3031 See Contrast table(2)

> >

REK1026 See Contrasttable(2) CM-22B XDD3097

NOTE FOR FUSE REPLACEMENT CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE WITH SAME TYPE AND RATINGS ONLY.

B 1/2 C D

3.8 AMP & PRIM.(2/2), REG., HASHIGETA, B TO B and MECH SW ASSYS

CN5003

A 1/4 CN105

CN5002

REGULATOR ASSY (XWZ3544)

A 1/4 CN101

B 2/2 E F G

A 2/4 CN106

B 1/2 CN601
CAUTION : FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE ONLY WITH SAME TYPE NO. 491.315 FOR IC52 MFD, BY LITTELFUSE INC.

REK1026 (T2.5A)

NEUTRAL AC POWER CORD VDG1076 : /MVXJI VDG1077 : /MYXJI

B 2/2 H I Y

3.9 VIDEO, 6CH IN and S.VIDEO ASSYS

VIDEO ASSY (XWZ3490)

CN5004

G CN390

G CN391
3.10 FRONT, R.ENCODER and POWER SW ASSYS
R.ENCODER ASSY S511 : ENTER S512 : MULTI JOG DIAL S513 : MASTER VOLUME

CN5001

POWER SW ASSY S501 : POWER STANDBY/ON

EON MODE

PTY SEARCH

PDG268B

FRONT ASSY S451 : SIGNAL SELECT S452 : MONITOR S453 : MIDNIGHT S454 : LOUDNESS S455 : TONE S456 : SETUP S457 : ADVANCED SURR S458 : DIRECT S459 : EON MODE S460 : PTY SEARCH S461 : MPX S462 : BAND S463 : STANDARD S464 : TUNING(+) S465 : TUNING() S466 : STATION(+) S467 : STATION() S468 : MULTI JOG S476 : CLASS
3.11 DIGITAL IN, H.P. and KAWA ASSYS

A 2/4 CN9101

B 1/2 CN702

O CN401

CN1001

3.12 FM/AM TUNER MODULE

FM FRONT END L1

(FM) (FM)

(FM) (FM) (AM) (AM) (AM) (AM) MW RF TUNING BLOCK
OSC : 981 - 2052kHz 9k step

(TX) (AM) (FM)

: AUDIO SIGNAL ROUTE (TUNER) : AM SIGNAL ROUTE : FM SIGNAL ROUTE

(TX) (TX)

(TX) (TX) (TX)

CN5005

C D E F

(FM) (AM)

ATE7003
4. PCB CONNECTION DIAGRAM

NOTE FOR PCB DIAGRAMS :

1. Part numbers in PCB diagrams match those in the schematic diagrams. 2. A comparison between the main parts of PCB and schematic diagrams is shown below.
Symbol In PCB Diagrams Symbol In Schematic Diagrams B C E B C E Part Name
3. The parts mounted on this PCB include all necessary parts for several destinations. For further information for respective destinations, be sure to check with the schematic diagram. 4. View point of PCB diagrams.

1 W611

Q257 Q258

CMKI-P3X

(XNP3052-C)

A CN106

B AMP&PRIMARY ASSY
CMKS-P3X Q704 Q702 IC702 Q703

W595 4

491.125

R706 R705 E

-12V GND +12V

3 D5SBA20

RED BLUE J8

2 D701

D J6 D J7

Q701 IC701

R702 C706 R707 W574
Q703 GRAY R703 W576 W575 J701 H701 H702

W572 W550

R701 E

W578 W558

VLW559

C703 W560

W531 NECK+

W555 W557 W556

W554 W553 C701 W552 W551

C652 R654

Q633 Q656 Q683 IC607 IC606

491010

Q652 Q654

D632 C658

Q602 Q604 Q606 Q605 Q601 Q603 IC605 IC604

C654 Q692

C662 C632 R635
CR645 DC613 Q601 R613 R607 R601 W22

R657 Q653

C664 C637 W504 IC602

R639 R638

R644 D634

Q651 Q653

Q631 Q632

W501 1

IC601 IC603

word surface

OL ATT AMUTE AG C AG SR AG SL AG FR AG FL

R634 C633

R609 C611

C653 C655 R659

R664 C636

W512 C660

W510 W511

C6 W508

Q697 Q696 Q681 Q682

W533 jp075a

C638 NP R641 Q633

UG NECK DC

NECK+ W540 NECK-

C692 D653 W529

C665 R633
RISK OF FIREREPLACE FUSE AS MARKED.
R606 C602 R608 R604 Q602 R602 Q604

J701 GRAY

W573 R708 C705
5 UG NECK DC OL C252 ATT A.MUTE AG SB AG SR AG SL AG FR AG FL AG AG C
FAN+ FAN4 IC251 CN252 STOP
Q252 Q254 Q255 Q256 Q253 IC251 Q251

MECH. SW.

XWZ3514

H AMP INPUT ASSY

MECHA SW MECHA SW MECHA SW
CMKI-P3X CMKI-P3X CMKI-P3X

Q702 R704

SECONDARY

R51 T51

RISK OF FIRE-REPLACE FUSE AS MARKED.

KN51 C57

IC52 FU2
W663 W664 W665 W661 WW666 W667 W668

491.500

W649 R53 D55 C53 L51

J12 GRAY

R52 D56 W636 Q51 4

J11 RED

J13 BLACK

IC481 Q483

8 R519 R516 R517 R520

C418 C417

XWZ3513

R C1551

C1557 C1556 C1558

HP GND

Q1552 C1553 C1554 C1555

9 C481

R483 R484

Q405 C473

Q402 R540

C485 R485

XWZ3492 XWZ3493 XWZ3494 XWZ3495 XWZ3496 XWZ3497 XWZ3498 XWZ3499 XWZ3500 XWZ3501 XWZ3502 XWZ3503 XWZ3504 XWZ3505 XWZ3506

C408 Q403 C471

XWZ3587

R479 R468 R462

IC401 Q402 Q405 Q403 Q481 Q482 IC481 Q483 Q471

POWER SW.

L HP GND R A MUTE HPSW uGND Q1551 C1552 R1555

LED +5V STBY GND

XWZ3510
4.5 REGULATOR, HASHIGETA and KAWA ASSYS

F HASHIGETA ASSY

A MUTE UG U+5V SYS.DT SYS.CK EXP.DT EXP.ST EXP.CE

A CN105

E REGULATOR ASSY
T.L T.G T.R HP SW NC SP-R/C SP-A -VF AC2 AC1 AC RY W.UP T+12V W754 W753 C814 W750 W751 W752 Q803 W671 W745 Q804 WQ801 W672 1

CN8041

XNP3053-C

W747 W746

STBY W748 IC804 C810 C811
AG AG SWOUT +12V ADG -12V T.L T.G T.R RETURN DG D+5V DAG AD+5V UG U+5V

Q802 W673 W675 W674

W655 W645 C812

NJM78M12 IC805 C813

REGULATOR

XWZ3544

DG IC803 W648 W647

W657 W630

W643 W644
REG +B C807 W633 D +5V -12V ADG +12V UG AG SWOUT

NJM78M05

IC803 Q5001

C808 D810 C804 NJM79M12

ADG W622 REG +B C803 NJM78M12
R/CRY H.P SW NC +12V A RY UG UG U+5V ACRY W UP -VF AC2 AC1 REG B REG B REG G REG G REG B REG B DREG DREG DREG DREG

L CN302

B CN53

W625 REG -B

W631 -12V
A MUTE UG U+5V SYS.DT SYS.CK EXP.DT EXP.ST EXP.CE 16 16
Q805 Q803 Q806 Q801 IC804 Q804 Q802

HASHIGETA XWZ3566 D I P

A CN101

K KAWA ASSY

D5002 C5009 R5008 C5004 R5004 C5005 C5006 CUGND A MUTE SR OUT U5V AC RY WUP -VF AC1 AC2
HP SW PLL DO T MUTE PLL CE T GND FM COMP STEREO TUNED

R5005 R5006

IC5001

XWZ3529

W103 W104 W105
R5020 Q5020 R5021 Q5021 R5022 R5023 Q5022
W106 W107 W108 W109 W110 W111
WUP AC RY AC1 AC2 -VF SP A SP R/C SP B HP SW TR TG TL T+12V
A MUTE UGND U5V SYS DT SYS CK EXP DT EXP ST EXP OE

W117 W118 W119 W120

W112 C5002 W113 W114

X CN201

PLL CE SYS DT SYS CK PLL DO TR TG TL T MUTE STEREO TUNED +10V FM COMP TG 1

R5002 13

PLL CE SYS DT SYS CK PLL DO TR TG TL T MUTE STEREO TUNED +10V FM COMP TG
V1 V2 V3 A MUTE SR OUT 4053A 4053INH

L CN303

UGND A MUTE SR OUT U5V AC RY WUP -VF AC1 AC2 HP SW PLL DO T MUTE PLL CE T GND FM COMP STEREO TUNED

CN5003 CN5002

Q5020 Q5021 Q5022
WUP AC RY AC1 AC2 -VF SP A SP R/C SP B HP SW TR TG TL T+12V A MUTE UGND U5V SYS DT SYS CK EXP DT EXP ST EXP OE

C5001 W115 Q5001 C5003

4.6 DIGITAL IN, 6CH IN, VIDEO and BOARRO TO BOARD ASSYS

J DIGITAL IN ASSY

T T R R

M 6CH IN ASSY

JA1906

OPTOUT2

JA1904

OPTOUT1

JA1903

OPTIN2

JA1902

DIGITAL IN

W210 5DV
OPT3 SHIELD DGND D +5V SHIELD

6 CH. IN

A CN9101

CN305 C309 C307

L VIDEO ASSY
-12V ADG +12V uG AG SW.OUT

A CN104

C310 W204 W203 W141 W173 W172 W171 W170 W142
4053INH 4053A SROUT AMUTE V3 V2 V1

W139 W169 C338

E CN803

1 CN301

Q301 C312

R 31 3

G BOARD TO BOARD ASSY
+5V ADG -5V ADG VIDEO1 VIDEO2 VIDEO3 FRONTV ADG UG SR 4053A 4053INH
SR UG +5V ADG -5V ADG VIDEO1 VIDEO2 VIDEO3 FRONTV ADG

N CN351

G J L M
SR AG SL 12V SW -12V SB AG C
GND D D OUT GND D V +5D DISELC DISELB DISELA
W199 W200 W208 C321 C331 C332 C324 W197 W198 W196

OPTIN1

JA1901

JA1907

W211 DG

DG W212

C1912 W238

DG W220

DG W221

W216 DG W217 DG

DG W218

DG W219

W191 +5V W190
W240 5DV W241 DG C1905 W239 W237

CN1902

W234 5DV W235 5DV W236 DG
W242 DG W267 5DV W168 W167 W137 W140 CN303

W177 W176

W268 5DV W269 DG

BOARD TO BOARD

+5V ADG W174-5V C314
13 +5V ADG -5V 10 ADG V1 V2 V3 FRONTV NC
7 UG SROUT 4053A 1 4053INH

W192 W175

XWZ3527
4053A 4053INH -5V ADG +5V
C316 C344 C342 C343 C R340 SW R332 R334 R331 C317 C318 C319 ICC323 C322 C320 R333 CG R338 C348 C345 SR SL R337 R339 C325 C349 R347 R349 C1351 R348 L1905
C1926 R1911 IC7 C1916 R1907 C1910 R8 R1919 1291C 5191C 9091C C1927 C1902 R1902 C1901 R1901 C1903 R1903 L1904 R1915

R346 IC304 C1350

IC304 IC303 IC302

C1906 C1907 F1901 C1919

C1353 CC1354 C1352 R1351

C329 C1361 R1354

C1922 F1903
R1922 R1917 C1925 R1913 C1924 R1916

R1920 R1924

C1914 C1913
SHIELD D +5V DGND SHIELD OPT3
R1909 C1911 R1910 C1917 R1908

IC1903 IC1902 IC1901

XWZ3581 XWZ3517 XWZ3518 XWZ3519 XWZ3520

R1350 033C

GND D D OUT GND D V +5D DISELC DISELB DISELA 7

IC1901

2091CI

R1905 R1906 R1914

C1929 C1928
XWZ3490 XWZ3491 XWZ3583 XWZ3584

SW Pre

G CG C305 R304

IC301 1

C347 D301
D304 R315 R308 R309 R307 R312

SROUT 4053A

FRONT V AGD UG

C311 303D

4053INH 4053A CN390

W749 W756

RS GU V5+ GDA V5GDA 1OEDIV 2OEDIV 3OEDIV VTNORF GDA
CN392 4053A 4053INH -5V ADG

ZSKJ35

4053INH

XWZ3507

XWZ3508

XWZ3509

CMKI-P3X J48

6 CH IN

G G C1360 G MONI. R305 R302 TV

203C G R303

Q303 IC301

VTNORF

1OEDIV

3OEDIV

2OEDIV

4.7 FM/AM TUNER MODULE

X FM/AM TUNER MODULE

K CN5005

CN201 (ANP7338-B)

(ANP7338-B)

Q201 IC201 Q203 IC202 Q205 Q204

5. PCB PARTS LIST

NOTES: Parts marked by "NSP" are generally unavailable because they are not in our Master Spare Parts List. The mark found on some component parts indicates the importance of the safety factor of the part. Therefore, when replacing, be sure to use parts of identical designation. When ordering resistors, first convert resistance values into code form as shown in the following examples. Ex.1 When there are 2 effective digits (any digit apart from 0), such as 560 ohm and 47k ohm (tolerance is shown by J=5%, and K=10%). x RD1/4PU 1 J 561 47k RD1/4PU 3 J 47 x 473 0.5 RN2H R K RRS1P 1 R 0 K 1R0 Ex.2 When there are 3 effective digits (such as in high precision metal film resistors). 5.62k 562 x 5621 RN1/4PC F

Mark No.

Description

Part No.

XWX3044 XWK3053 XWZ3533 XWZ3544 XWZ3547 XWZ3552 XWZ3555 XWZ3560 XWZ3566 XWZ3527 XWK3038 XWZ3493 XWZ3507 XWZ3510 XWZ3513 XWZ3518 XWZ3521 XWZ3529 XWZ3511 XWZ3490 XWZ3514 AXQ7232
IC102 IC9601 IC9504 IC9505 IC9502, IC9503 IC9506 IC9507 IC101
NJU7312AM NJU7313AM PD8097A TC74LVX244FT TC74VHC574F TC74VHCT244AFT TC7WU04FU TC9273F-007 UPC4570G2 2SC3326 DTA124EK DTC124EK 1SS181 1SS355 DAN217 RB501V-40 UDZS5.1B UDZS6.8B

LIST OF ASSEMBLIES

1.D.D & INPUT ASSY NSP 1.AMP & PS ASSY 2.AMP & PRIMARY ASSY 2.REGULATOR ASSY 2.AMP INPUT ASSY 2.TRANS1 ASSY 2.TRANS2 ASSY 2.TRANS3 ASSY 2.HASHIGETA ASSY 2.BOARD TO BOARD ASSY 1.COMPLEX ASSY 2.FRONT ASSY 2.6CH IN ASSY 2.POWER SW ASSY 2.H.P. ASSY 2.DIGITAL IN ASSY 2.S. VIDEO ASSY 2.KAWA ASSY 2.R. ENCODER ASSY 2.VIDEO ASSY 2.MECHA SW ASSY 1.FM/AM TUNER MODULE

NSP NSP

IC104-IC107, IC9701-IC9705, IC9707 Q107-Q112, Q9201, Q9202 Q9101, Q9204, Q9607, Q9609, Q9610 Q9102, Q9203, Q9608 D9601, D9602 D105, D106, D301, D9921 D107, D108 D201, D202 D104 D101, D102

TC74ACT151F TC74HCU04AF
CN51(AC INLET) KN51,KN601 (EARTH METAL FITTING) CN752(4P SPEAKER TERMINAL) CN751(6P SPEAKER TERMINAL) 701 7P CABLE HOLDER J21 20P JUMPER WIRE J6 JUMPER WIRE
F1901-F1903(BK2125HS601) L1904, L1905 DTF1067 QTL1013
C1918 C1907, C1914, C1928 C1925 C1916, C1926 C1904, C1905, C1912 C1915 C1906, C1919, C1920, C1923, C1929 C1910, C1913 C1902, C1908, C1909, C1921, C1922 C1903 CCSRCH221J50 CCSRCH271J50 CCSRCH470J50 CCSRCH471J50 CEAT101M10 CKSRYB102K50 CKSRYB103K50 CKSRYB103K50 CKSRYB104K25 CKSRYB104K25

C TRANS 2 ASSY

> IC851-IC853(1.6/125)

AEK7012

851 XKP3047

D TRANS 3 ASSY

TRANS3 ASSY has no service part.
IC803, IC804 IC801, IC805 IC802 Q801, Q803 Q802, Q804 D809, D810 NJM78M05FA NJM78M12FA NJM79M12FA KRA103M KRC102M MTZJ6.2A S5688G
OtherResistors RS1/16S###J
CN1901(7P FFC CONNECTOR) JA1902 (OPTICAL LINK IN) JA1904 (OPTICAL OUT) JA1901,JA1907(1P PIN JACK) 52045-0745 JFJ4000-010020 JFJ3000-010020 VKB1077

> D801-D804

IC5001 Q5001 Q5020-Q5022 Q5002 D5001, D5002 BU4094BCF 2SC1740S DTC114TK DTC143EK 1SS355
C808, C811 C805, C806, C813 C801, C802 C809 C803, C804, C807, C810, C812 CEAT101M10 CEAT101M16 CEAT222M25 CEAT332M16 CKPUYF103Z25

L5001 QTL1013

CN801(23P CONNECTOR) CN804 (13P PLUG) CN802 (16P PLUG) CN803 (6P PLUG) 52045-2345 KM200TA13 KM200TA16 KM200TA6
C5004-C5007 C5012 C5001, C5002 C5003 C5009 C5011 C5010 CCSRCH101J50 CCSRCH471J50 CEAT100M50 CEAT101M16 CKSRYB103K50 CKSRYB104K16 CKSRYF105Z10

F HASHICETA ASSY

CN1001, CN1002(8P PLUG) KM200TA8
CN391 (11P PLUG) CN390 (13P PLUG) KM200TA11 KM200TA13
All Resistors RS1/16S###J
CN5004 (7P FFC CONNECTOR ) CN5005 (13P FFC CONNECTOR) CN5001 (17P FFC CONNECTOR) CN5002 (13P SOCKET) CN5003 (8P SOCKET) 5001 (SCREW TERMINAL) 52044-0745 52044-1345 52044-1745 KP200TA13L KP200TA8L VNE1948
CN254 (19P FFC SOCKET) CN253 (16P SOCKET) 52044-1945 KP200TA16L
TRANS1 ASSY has no service part.

Adjust L201 so that the DC voltage between Pin 21 and Pin 23 of IC201 (Test point Vtm) gets within 0 50mV.

MPX SG

FM SG FM75 antenna terminal

PRODUCT

DC Voltmeter
Fig.1 Adjustment Wiring Diagram

U FM/AM TUNER MODULE

IC201 pin 21 pin 23

Fig.2 Adjustment Point

7. GENERAL INFORMATION
7.1 DISASSEMBLY and DIAGNOSI
7.1.1 DISASSEMBLY and PCB LOCATION Diagnosis 1
Remove the Bonnet (seven screws). Rear Panel Pull up Note : This photograph shows other models. However, the work method is the same.

REGULATOR Assy

Diagnosis AMP&PRIMARY Assy

Heat Sink

Note : If a speaker and the screw of a rear panel are removed, a set will stop moving. Even if it removes TUNER Unit, it is uninfluential in operation of those other than TUNER Unit.

PCB Location

R. ENCODER Assy
NOTE : This photograph is VSX-D711

P H A K L

O Q U D I C B E
FRONT Assy POWER SW Assy H.P. Assy
AMP INPUT Assy D.D & INPUT Assy KAWA Assy VIDEO Assy 6CH IN Assy
TRANS 3 Assy TRANS 1 Assy TRANS 2 Assy AMP&PRIMARY Assy REGULATOR Assy

FM/AM TUNER Unit

M DIGITAL IN Assy J

7.1.2 U-COM BLOCKDIAGRAM

IC 5001: Expand IC BU4094BCF 2: Serial In
3: CLK 1: ST 15: OE SYS CK EXP ST EXP OE
TUNER MODULE SYS CLK SYS DATA TUNED STEREO PLL CE
SYS DT SYS CK EXP ST EXP OE
SYS CLK SYS DATA TUNED STEREO PLL CE PLL DO T MUTE
IC 9504 ROM FOR DD/DTS PD8097A (MR27V802D)
IC9502: FLIP/FLOP IC9503: FLIP/FLOP TC74VHC574F
IC 301: Expand IC BU4094BCF 10: Q
2: Serial In 3: CLK 1: ST 15: OE

PLL DO T MUTE

IC101: Function Selector TC9273F-007
15: DATA 14: CLK 16: ST SYS DT SYS CK 9273STST
IC103: EVOL (6-CH) M62446FP
40: DATA 41: CLK 39: LATCH SYS DT SYS CK EVRST
CE SDI1~4 SDTO IC9101: CODEC AK4586VQ SDI1~3 SDTO BICK LRCK

FS96 PDN DO CK CS ERR DI

BICK LRCK
IC 9501: Main DSP CS493292 SCDOUT INTREQ SCCLK RESET

IC9601: NJU7313AM

17: DATA 16: CLK 14: ST SYS DT SYS CK SYS ST
IC102: Function Selector NJU7312AM
5V/3V Level Shifter IC9505: 5V -->3V TC74LVX244FT IC9506: 3V-->5V TC74VHCT244AFT

PLL DO PLL CS

TUNED STEREO TMUTE

SYS DT

SYS CK

SYS ST

IC401: System Microprocessor

9273STST

EXP OE
96k CDTO CRST CCS CCK CDT CSDO CRES

RDS DATA

RDS CLK

7.1.3 PROTECTION CIRCUIT

1. DC abnormal detection It processes more preferentially than overload detection.
When detected DC abnormal, A.MUTE* is on and speaker relay is off, then flash "AMP_ERR" on display. An unusual state continues for 3 seconds. continuation A power supply is shut off. The power key cannot be effective for 60 seconds

a1 a2 h j k b f m g c e r p n d1 d2 Dp2 Dp1 S1 S4 S2 S3
EON TUNED RDS S1 A B 1a 1b 1f 1g 1c 1e 1d

2a 2b 2f 2g

2c 2e 2d

8. PANEL FACILITIES

Front panel
TUNER EDIT CLASS BAND MPX PTY SEARCH

LISTENING MODE EON MODE

Switches the receiver between on and standby.

13 PTY SEARCH

Use to search for different program types in RDS mode.

2 STANDBY indicator

Lights when the receiver is in standby mode.

14 EON MODE

Use to search for different programs that are transmitting traffic or news information (this search method is called EON).

3 STATION (+/) buttons

Selects station presets when using the tuner.

4 TUNING (+/) buttons

Selects the frequency when using the tuner.
15 LISTENING MODE buttons STANDARD
Press for Standard decoding and to switch between the various Pro Logic II options.

5 Remote sensor

Receives the signals from the remote control.

ADVANCED SURROUND

Use to switch between the various surround modes.
6 ENTER 7 MULTI JOG/INPUT SELECTOR dial The MULTI JOG/INPUT SELECTOR dial performs a number of tasks. Use it to select options after pressing TONE CONTROL, QUICK SETUP or TUNER EDIT. 8 PHONES jack Use to connect headphones. 9 TUNER EDIT Press to memorize and name a station for recall using the station (+/-) buttons. 10 CLASS Switches between the three banks (classes) of station presets. 11 BAND Switches between AM and FM radio bands. 12 MPX Press the MPX button to receive a radio broadcast in mono. When the headphones are connected, there is no sound output from the speakers.

STEREO/DIRECT

Switches direct playback on or off. Direct playback bypasses the tone controls and channel levels for the most accurate reproduction of a source.

16 SIGNAL SELECT

Use to select between an analog or digital signal.

17 MONITOR

Press to switch tape monitoring on/off.

18 MIDNIGHT

Use when listening to movie soundtracks at low volumes.

19 LOUDNESS

Use to boost the bass and treble at low volumes.

20 TONE

Press this button to access the bass and treble controls, which you can then adjust with the
MULTI JOG/INPUT SELECTOR dial. 21 QUICK SETUP 22 MASTER VOLUME

Display

SIGNAL AUTO DIGITAL DIGITAL ANALOG DTS
RFATT EON TUNED RDS SP A B
DIGITAL PROLOGIC ADV.SURR.
ATT DIRECT MONITOR Re-EQ MIDNIGHT STEREO LOUDNESS MONO
1 SIGNAL SELECT indicators Lights to indicate the type of input signal assigned for the current component: AUTO Lights when AUTO signal select is on SB Depending on the source, this lights when a signal with surround back channel encoding is detected. DIGITAL Lights when a digital audio signal is detected. DIGITAL Lights when a Dolby Digital encoded signal is detected. ANALOG Lights when an analog signal is detected. DTS Lights when a source with DTS encoded audio signals is detected. 2 DTS When the Standard mode of the receiver is on, this lights to indicate decoding of a DTS signal. 3 DIGITAL When the Standard mode of the receiver is on, this lights to indicate decoding of a Dolby Digital signal. 4 PRO LOGIC II When the Standard mode of the receiver is on, this lights to indicate Pro Logic II decoding. 5 ATT Lights when INPUT ATT is used to attenuate (reduce) the level of the analog input signal.

Televizory penosn

SACD pehrvae
Sony SCD-XA777ES Pioneer DV-747A

Satelitn pijmae

Nokia Mediamaster 9902S Kathrein UFD 554 Panasonic NV-HDB1
Snma pamovch karet Tunery
PQI Travel Flash 7IN1 10/93 Pioneer PDP-R03E

Stihov systm

Apple Final Cut Pro 3.0 Pinnacle Studio V.7

9/17 3/78

10/54 1/39 4/54

Videokamery analogov

Subwoofery

Televizory

Focal BombA 300 a 500
Canon V65Hi JVC GR-SX24EG Sony TRV208E Sony TRV408E

Systmy

9/72 5/56

4/72 7-8/89 7-8/89

Aiwa HT-DV90 4/34 Aiwa NSX-R31 7-8/32 Aiwa NSX-R51 4/53 Aiwa NSX-R81 7-8/32 Aiwa XR-X7 2/51 Bose Lifestyle 50 Systm 1/31 Denon 201 SA Series 9/10 Denon Srie 101 12/13DRA-F 101 a DCD-F101 12/13, 55 Grundig Apollo 2000 1/33 Grundig MS 4101 7-8/34 JVC MX-K10R 12/54 JVC NX-MD1R 2/52 JVC TH-A5R 5/80 JVC TH-A9R 4/34 JVC TH-V70R 9/14, 9/35 Kenwood DVT 6100 11/47 Kenwood DVT 7000 4/35 Kenwood VH-650 1/33 Lenco DVD 511H 11/47 LG DA-3520 3/51 LG DA3530 11/49 LG F-576 7-8/34 LG F-876 7-8/35 Nakamichi Sound Space 1 7-8/46 Nakamichi Sound Space 9 1/34 Onkyo HS-N1 1/36 Onkyo Separate Collection 155 3/50, 10/46 Panasonic DT300 11/49 Panasonic SC-DM3 6/20 Panasonic SC-HT 70 4/35 Philips FW-M355 7-8/36 Philips LX8000SA 11/51 Philips MX3800D 11/51 Philips MZ-9 7-8/36 Pioneer DCS-100 4/36 Pioneer DCS-303 11/53, 12/12 Pioneer IS22CD 2/50 Pioneer NS-11Q 1/36 Pioneer NS-DV1000 12/48 Pioneer NS-DV77 11/53 Pioneer XR-A4900 7-8/37 Roksan Caspian 11/72 Samsung HT-DL100 4/36 Samsung HT-DM150 11/54 Sanyo DC-AVD 8501 4/37 Sharp CD-XP300H 7-8/37 Philips 32PW8807 Philips 32PW9527 Philips 32PW9617/58 Samsung CW-29M64N Sony KF-50SX200K Sony KP-44PS2 Sony KV-29FX30K Sony KV-32LS60K
Finlux 82X110MC 3/66 Grundig MF 72-9101/8 Dolby 12/84 Grundig MFW 82-430/8 Dolby 3/66 Grundig MFW 92-6110/9 DVD 5/73 JVC AV29BF10EES 12/84 JVC AV-32Z10 SL 3/67 LG RE29FA33PX 7-8/101 Loewe Xelos 5381ZW 3/67, 12/8 Mascom MC7153 Multi 12/86 Mascom MC7160S/100 10/84, 12/8 Mascom MC7163/100Hz 1/87 Mascom MC72W28 M2/DVD 2/21 Mascom MC72W29 DVD 5/74 Mascom MC7460STF/100 12/100 Mascom MC8263/100 3/68 Panasonic TX-22LT2F 9/11 Panasonic TX-29PS1P 12/86 Panasonic TX-32PB50F 3/69 Panasonic TX-36PR50F/P 2/79 Panasonic TX-42PT12F/P 9/82 Philips 14PV220/58 5/67 Philips 14PV505/58 5/67 Philips 21PV548/58 5/68 Philips 21PV908 5/70 Philips 28PW6006 4/83 Philips 29PT5507/58 12/87