Adjacent Linearity Entire Linearity Preset mode Pre-load mode (48kHz~) Pre-load mode (under 48kHz)

|C-D| 4.0 mm.

X max-X min
Figure 4-3. Centering 4-2-1 (a) HORIZONTAL SIZE ADJUSTMENT CONDITIONS Scanning frequency: 68 kHz/85 Hz Display image: Crosshatch pattern Brightness: Cut-off Contrast: Maximum Click on the << or >> box next to SIZE B+ to adjust the horizontal size of the display pattern to 312 mm (Tolerance: 3 mm) as the H_SIZE is 60 on the OSD. 4-2-1 (b) VERTICAL SIZE ADJUSTMENT CONDITIONS Scanning frequency: 68 kHz /85 Hz Display image: Crosshatch pattern Brightness: Cut-off Contrast: Maximum Click on the << or >> box next to V_SIZE to adjust the vertical size of the display pattern to 234 mm. (Tolerance: 3 mm.) 4-2-1 (c) HORIZONTAL POSITION ADJUSTMENT CONDITIONS Scanning frequency: 68 kHz/85 Hz Display image: Crosshatch pattern Brightness: Cut-off Contrast: Maximum Click on the << or >> box next to H_POSI to center the horizontal image on the raster. 4-2

4% 5% 5%

8% 10% 14%
Preset Mode : 68KHz / 85Hz Pre-load Mode : Refer to Timing Chart 4-2-2 (a) HORIZONTAL LINEARITY ADJUSTMENT CONDITIONS Scanning frequency: 68 kHz/85 Hz Display image: Crosshatch pattern Brightness: Cut-off Contrast: Maximum To adjust the Horizontal Linearity, refer to Table 4-1 for the tolerance range. Click on the << or >> box next to H_LIN to optimize the image. Table 4-2 (Horizontal x Vertical Size Table) 17

Horizantal Vertical

312 234
AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS
4 Alignment and Adjustments 4-2-2 (b) VERTICAL LINEARITY ADJUSTMENT CONDITIONS Scanning frequency: 68 kHz/85 Hz Display image: Crosshatch pattern Brightness: Cut-off Contrast: Maximum To adjust the Vertical Linearity, refer to Table 4-1 for the tolerance range. Use control bar after selecting V_LINEARITY BAL in left menu to optimize the image.
Figure 4-6. Parallelogram
4-2-6 Side Pincushion Adjustment
CONDITIONS Scanning frequency: 68 kHz/85 Hz Display image: Crosshatch pattern Brightness: Cut-off Contrast: Maximum Use control bar after selecting PINCUSHION in left menu to straighten the sides of the image area.
| C1 |, | C2 | 2.0 mm, | D1 |, | D2 | 2.0 mm. C2
4-2-3 Trapezoid Adjustment
CONDITIONS Scanning frequency: 68 kHz/85 Hz Display image: Crosshatch pattern Brightness: Cut-off Contrast: Maximum Use control bar after selecting TRAPEZOID in left menu to make the image area rectangular.

Yes Replace the CRT and verify focus.

5-2-8 Purity Failure

Degaussing

Purity is right?

No Degaussing circuit is right? No Refer to 5-1-20 Degaussing Failure.
Yes Replace CRT and verify purity.
5-2-9 No Operating High Light Zone
Change the video signal to windows pattern.

21 IC101, #14, 15

Does not the High Light Zone appear? Yes
Are the waveforms right on IC101 Pin 14 and 15 (19:IC105 Pin 14 and 15). Yes
Check connection Assy (CN102). 22 IC105, #14, 15
Is the waveform right on IC101 Pin 18 (19: IC105 Pin 18). Yes Check and replace IC105 (19: IC101) Yes Done.
Check and replace IC103 (19: IC103).

23 IC105, #18

7 Electrical Parts List
7-1-1 AQ17** Main PCB Parts
Loc. No. C416 C602 C607 C701 CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CIS CN201 CN201_ASSY CN202 CN204 CN205 CN205_ASSY CN211 CN211+CN212 CN212 CN401 CORE_FBT D402 D505 D507 D601 D647 EY599 FG601 HS301 HS402_1 HS504 IC201 IC201_SOCKET IC250 IC403 IC620 JW01 L402 L403 L503 L601 L701 Code No. 2306-000147 2305-001049 2401-003391 2301-001314 6501-000004 BH72-60765A BH68-00001A BH46-00003H BH73-60304C BH72-00296A BH72-00351A BH71-00141B 0202-001046 0202-001172 0202-001044 0203-001199 0203-001200 0203-001201 0204-001095 3711-004352 BH39-00060A 3711-004351 3711-004379 3711-004484 BH39-00362A 3711-004484 BH39-00368A 3711-004484 3711-003989 3301-000130 0402-001441 0402-001295 0402-001295 0402-001227 0402-000250 BH39-00232A 3601-000455 6502-000132 6502-000135 6502-000001 0903-001237 3704-001071 1204-001697 BH13-00009A 0604-001018 BH39-40306D BH27-20345J BH26-00001A BH27-00037A BH27-00025A BH27-00053A Description C-FILM,MPPF C-FILM,MPEF C-AL C-FILM,MPPF CABLE TIE GUIDE-POWER LABEL/MARK-CDT MICOM-S/W,AQUILA RUBBER-SUPPORT SHAFT-POWER SHEET-LMF SHIELD-BOTTOM SOLDER-WIRE FLUX SOLDER-WIRE FLUX SOLDER-WIRE. TAPE-KRAFT TAPE-PAPER TAPE-PAPER THINNER CONNECTOR-HEADER CBF-HARNESS CONNECTOR-HEADER CONNECTOR-HEADER CONNECTOR-HEADER WIRE HARNESS CONNECTOR-HEADER CBF HARNESS CONNECTOR-HEADER CONNECTOR-HEADER CORE-FERRITE DIODE-RECTIFIER DIODE-RECTIFIER DIODE-RECTIFIER DIODE-BRIDGE DIODE-RECTIFIER CBF-HARNESS FUSE-CARTRIDGE CABLE CLAMP CABLE CLAMP CABLE CLAMP IC-MICROCONTROLLER SOCKET-IC IC-DEF. PROCESSOR IC-H/V CONVERGENCE PHOTO-COUPLER CBF-HARNESS COIL-HORIZ.CENTER TRANS-H.LINEARITY COIL-CHOKE COIL-LINE FILTER COIL CHOKE Specification 1uF,5%,250V,BK,26x24x15,22.5mm 1000nF,10%,275V,BK,31x23x13mm,27.5 220uF,20%,450V,GP,BK,25x50,10 470NF,10%,275V,BK,25X11.5X21MM,22.5 DA-80,T1,W2.5,L80,NTR,NYLON66 CSM92*,ABS+PC,5V,IV16,T3,ART-PAPER 100G,-,WHT,BLK,-,ALL,CDT AQUILA17,-,-,-,-,-,DP15LT,CR V0,GRAY,-,14*7*10,-,PN19LT,ABS+PC,IV16,-,5V,-,-,AQ19FS,AL+PET,-,-,-,-,-,AQ19FS,SECC ,T1.0,-,DELL,CF-110VH-2A,-,-,-,RS-107,RS60,D1.2,SN60/PB40,S63S-W3.0,S63S,D3,63Sn/37Pb,#53110,T0.1,W6,L2000M,BRN #53128,T0.15,W5.5,L2000M,BEIGE #FB-300,T0.16,W6,L2000M,R/BLU #4520,-,-,BOX,15P,1R,2MM,STRAIGHT,SN 15P/15P,180MM,WHT/BLU/RED/BLK,UL1007,AWG26,SMH200-15 NOWALL,16P,1R,2.54MM,STRAIGHT,SN BOX,4P,1R,2MM,STRAIGHT,SN BOX,5P,1R,2mm,STRAIGHT,SN AQ19FS,UL1007#26,UL/CSA,5P/5P,320MM,WHT,AWG26,SMH200-05,-,-,-,-,-,-,-,BOX,5P,1R,2mm,STRAIGHT,SN AQ17IS,U2464#26-4C,U2464,80`C,300V,5P/5P,240MM,BLK,26AWG*4,SMH200-05,SMH200-05,B BOX,5P,1R,2mm,STRAIGHT,SN NOWALL,4P,1R,8mm,STRAIGHT,SN AC,23.5x9.4x12.6mm,1500,2800G -,40V,3A,DO-201AD,BK GUR460L-5700,600V,4A,DO-201AD,BK GUR460L-5700,600V,4A,DO-201AD,BK D3SBA60,600V,2.3A,SIP-4,BK RG4C,1000V,1A,DP17MO,UL1032,UL/CSA,1P,290MM,RED,AWG22,YHF800-1,-,-,-,-,-,-,-,CBF-CONN ASSY 250V,4A,TIME-LAG,CERAMIC,5.2x20mm DAWS-1NE,ID11,L21.0,NTR,NYLON66 DAWS-2NA,ID10,-,NTR,NYLON66 DAWH-5NB,D15,L35,NTR,NYLON66 ST72774,8BIT,DIP,42P,-,24MHZ,ST,HCMOS,PLASTIC,5.5V,-,0TO+70C,1KB,60KB,8BIT,-,IC42P,DIP,SN,1.778mm TDA9112,DIP,32P,350MIL,PLASTIC,13.2V,-,0to+70C,ST,DEF.PROCESSOR PG17/19,AN5452,SIP,12P,H/V CONVERGENCE,-,1171MW DAR-TR,63-125%,200mW,DIP-4,ST ,80MM,BLK,1015,AWG22,-,-,-,-,-,3.5mH,-,OB6*30-1HHA,-,-,-,-,6.0ohm,-,-,-,BULK -,-,5P,-,-,5.0UH/47.5MH,-, ,-,19.0,-,YL-81,DR1420,C:6.0,-,-,BULK,3.5uH,+/-10%,12*15,BULK,-,-,24.0mH,-,SQE-2828,65.5Ts,PHENOLIC,-,-,0.20 ohm,-,-,-,BK TO-2012,195uH,-,20.20*12.57*6.35,65Ts,PHENOLIC,-,-,0.08ohm,17.0*32.0*10.0,-,-,Remarks

Loc. No. C622 C624 C625 C627 C628 C629 C641 C642 C643 C644 C645 C646 C649 C650 C651 C652 C653 C654 C655 C656 C702 C703 C705 C706 C708 C710 CIS CIS CIS CN209 CN210 CN409 CN414 CN415 CN420 CN421 CN601 CN602 CN603 CN608 CN609 D201 D202 D250 D251 D254 D282 D301 D302 D303 D401 D405 D406
Code No. 2301-000013 2301-000016 2401-000025 2301-000004 2301-000174 2201-000019 2401-000142 2401-000142 2401-001378 2401-000770 2401-001422 2401-000040 2201-000551 2401-000042 2202-002008 2401-000010 2201-000119 2401-000142 2301-000148 2202-002009 2305-001041 2201-000602 2301-000188 2202-002009 2401-000970 2201-000019 0203-001199 0203-001200 0203-001201 BH71-40300A BH71-40300A 3711-000197 BH71-40300A BH71-40300A BH71-40300A BH71-40300A 3711-000217 BH71-40300A BH71-40300A BH71-40300A BH71-40300A 0401-000005 0401-000005 0401-000005 0401-000005 0401-000005 0402-001039 0402-000272 0401-000005 0401-000005 0402-000274 0402-000012 0402-000012
Description C-FILM,PEF C-FILM,PEF C-AL C-FILM,PEF C-FILM,PEF C-CERAMIC,DISC C-AL C-AL C-AL C-AL C-AL C-AL C-CERAMIC,DISC C-AL C-CERAMIC,MLC-AXIAL C-AL C-CERAMIC,DISC C-AL C-FILM,PEF C-CERAMIC,MLC-AXIAL C-FILM,MPEF C-CERAMIC,DISC C-FILM,PEF C-CERAMIC,MLC-AXIAL C-AL C-CERAMIC,DISC TAPE-KRAFT TAPE-PAPER TAPE-PAPER PIN-HINGE PIN-HINGE CONNECTOR-HEADER PIN-HINGE PIN-HINGE PIN-HINGE PIN-HINGE CONNECTOR-HEADER PIN-HINGE PIN-HINGE PIN-HINGE PIN-HINGE DIODE-SWITCHING DIODE-SWITCHING DIODE-SWITCHING DIODE-SWITCHING DIODE-SWITCHING DIODE-RECTIFIER DIODE-RECTIFIER DIODE-SWITCHING DIODE-SWITCHING DIODE-RECTIFIER DIODE-RECTIFIER DIODE-RECTIFIER
Specification 4.7nF,5%,100V,TP,10.5x12.5x6.5 22nF,5%,100V,TP,7.2x4.5x9.0mm, 100uF,20%,16V,GP,TP,6.3x11,5 2.2nF,5%,100V,TP,5.5X10X2.9,5m 15nF,5%,100V,TP,7.2x4.0x7.5mm, 10nF,+80-20%,500V,Y5V,TP,13.5x4mm,5 1000uF,20%,16V,WT,TP,10x20,5 1000uF,20%,16V,WT,TP,10x20,5 470uF,20%,16V,WT,TP,10x20,5 220uF,20%,100V,WT,TP,13*25,5mm 470uF,20%,35V,WT,TP,12.5x25,5 47uF,20%,250V,WT,TP,16x25mm,7. 0.47nF,10%,1kV,Y5P,TP,6.3x5,5 100uF,20%,16V,GP,TP,6.3x7,5 10nF,+80-20%,50V,Y5V,TP,2.3X3. 220uF,20%,16V,GP,-,6.3x11mm,2. 100nF,+80-20%,50V,Y5V,TP,8x3,5 1000uF,20%,16V,WT,TP,10x20,5 10nF,5%,100V,TP,7x3.2x7mm,5mm 100nF,+80-20%,50V,Y5V,TP,2.3X3 220nF,5%,63V,TP,7.5x4.5x13.5,5 0.56nF,5%,50V,SL,TP,10x3.5,5 1nF,5%,100V,TP,10.5x12.5x6.5,5 100nF,+80-20%,50V,Y5V,TP,2.3X3 22uF,20%,50V,WT,TP,5x11,5 10nF,+80-20%,500V,Y5V,TP,13.5x4mm,5 #53110,T0.1,W6,L2000M,BRN #53128,T0.15,W5.5,L2000M,BEIGE #FB-300,T0.16,W6,L2000M,R/BLU -,BRASS,D2.36,SN,HEAT/SINK -,BRASS,D2.36,SN,HEAT/SINK 1WALL,3P,1R,2.5mm,STRAIGHT,SN -,BRASS,D2.36,SN,HEAT/SINK -,BRASS,D2.36,SN,HEAT/SINK -,BRASS,D2.36,SN,HEAT/SINK -,BRASS,D2.36,SN,HEAT/SINK 1WALL,3P,1R,3.96mm,STRAIGHT,SN -,BRASS,D2.36,SN,HEAT/SINK -,BRASS,D2.36,SN,HEAT/SINK -,BRASS,D2.36,SN,HEAT/SINK -,BRASS,D2.36,SN,HEAT/SINK 1N4148,100V,200mA,DO-35,TP 1N4148,100V,200mA,DO-35,TP 1N4148,100V,200mA,DO-35,TP 1N4148,100V,200mA,DO-35,TP 1N4148,100V,200mA,DO-35,TP SB020,20V,600mA,MPG06,TP UF4001,50V,1A,DO-41,TP 1N4148,100V,200mA,DO-35,TP 1N4148,100V,200mA,DO-35,TP UF4004,400V,1A,DO-41,TP UF4007,1KV,1A,DO-41,TP UF4007,1KV,1A,DO-41,TP

Loc. No. R460 R461 R462 R463 R464 R465 R466 R467 R468 R490 R501 R502 R503 R504 R505 R506 R507 R508 R509 R510 R511 R512 R515 R520 R521 R522 R523 R524 R525 R526 R527 R531 R532 R541 R542 R543 R545 R546 R547 R550 R551 R552 R553 R555 R556 R557 R558 R560 R561 R563 R564 R565 R567
Code No. 2004-000284 2001-000055 2004-000412 2001-000042 2001-000042 2001-000028 2001-000050 2008-000140 2001-000734 2004-000580 2001-000241 2001-000331 2001-000812 2001-000689 2001-000977 2001-000800 2001-000429 2001-000241 2001-000800 2001-000780 2001-000018 2005-000210 2001-000073 2001-000115 2001-000546 2004-000327 2001-000096 2004-001254 2004-000123 2001-000290 2001-000878 2004-000964 2004-000643 2001-000114 2001-000114 2002-001079 2001-000331 2001-000429 2001-000429 2002-001079 2001-000723 2001-000319 2001-000105 2001-001144 2001-001153 2003-000459 2003-000008 2001-000800 2001-000331 2001-000429 2001-000591 2001-000449 2002-001079
Description R-METAL R-CARBON R-METAL R-CARBON R-CARBON R-CARBON(S) R-CARBON R-FUSIBLE R-CARBON R-METAL R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-WIRE WOUND R-CARBON R-CARBON R-CARBON R-METAL R-CARBON(S) R-METAL R-METAL R-CARBON R-CARBON R-METAL R-METAL R-CARBON(S) R-CARBON(S) R-COMPOSITION R-CARBON R-CARBON R-CARBON R-COMPOSITION R-CARBON R-CARBON R-CARBON R-CARBON(S) R-CARBON(S) R-METAL OXIDE(S) R-METAL OXIDE(S) R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-COMPOSITION
Specification 12Kohm,1%,1/4W,AA,TP,2.4x6.4mm 4.7KOHM,5%,1/4W,AA,TP,2.4X6.4MM 18Kohm,1%,1/4W,AA,TP,2.4x6.4mm 1KOHM,5%,1/4W,AA,TP,2.4X6.4MM 1KOHM,5%,1/4W,AA,TP,2.4X6.4MM 100OHM,5%,1/2W,AA,TP,2.4X6.4MM 2.7KOHM,5%,1/4W,AA,TP,2.4X6.4MM 2.2ohm,5%,1/2W,AA,TP,3.5x9.4mm 4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM 22Kohm,1%,1/4W,AA,TP,2.4x6.4mm 1.5KOHM,5%,1/8W,AA,TP,1.8X3.2MM 12KOHM,5%,1/8W,AA,TP,1.8X3.2MM 5.6KOHM,5%,1/8W,AA,TP,1.8X3.2MM 390KOHM,5%,1/8W,AA,TP,1.8X3.2MM 8.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM 5.1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 1.5KOHM,5%,1/8W,AA,TP,1.8X3.2MM 5.1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 470OHM,5%,1/8W,AA,TP,1.8X3.2MM 6.8OHM,5%,1/4W,AA,TP,2.4X6.4MM 0.33ohm,5%,1W,AC,BK,4.5x11mm 33KOHM,5%,1/4W,AA,TP,2.4X6.4MM 82KOHM,5%,1/4W,AA,TP,2.4X6.4MM 270KOHM,5%,1/4W,AA,TP,2.4X6.4MM 150Kohm,1%,1/4W,AA,TP,2.4x6.4m 1MOHM,5%,1/2W,AA,TP,2.4X6.4MM 8.2Kohm,1%,1/4W,AA,TP,2.4x6.4m 1.2Kohm,1%,1/4W,AA,TP,2.4x6.4m 10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 6.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM 470Kohm,1%,1/4W,AA,TP,2.4x6.4m 270Kohm,1%,1/4W,AA,TP,2.4x6.4m 180KOHM,5%,1/2W,AA,TP,2.4X6.4MM 180KOHM,5%,1/2W,AA,TP,2.4X6.4MM 470Kohm,5%,1/2W,AA,TP,4x10mm 12KOHM,5%,1/8W,AA,TP,1.8X3.2MM 1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 470Kohm,5%,1/2W,AA,TP,4x10mm 4.3KOHM,5%,1/8W,AA,TP,1.8X3.2MM 120KOHM,5%,1/8W,AA,TP,1.8X3.2MM 1.5KOHM,5%,1/4W,AA,TP,2.4X6.4MM 4.7KOHM,5%,1/2W,AA,TP,2.4X6.4MM 47OHM,5%,1/2W,AA,TP,2.4X6.4MM 100ohm,5%,3W,AA,TP,6x16mm 100ohm,5%,1W,AA,TP,3.3x9mm 5.1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 12KOHM,5%,1/8W,AA,TP,1.8X3.2MM 1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 3.3KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM 470Kohm,5%,1/2W,AA,TP,4x10mm

Loc. No. ZD286 ZD450 ZD520 ZD601 ZD705 ZD706 HS651 CIS CIS CIS CIS CIS HS504 CIS CIS CIS CIS HS402_1 CIS CIS CIS CIS CIS CIS HS409 CIS CIS CIS CIS CIS HS401 CIS CIS CIS CIS HS301 CIS CIS CIS CIS CIS HS508 CIS CIS CIS CIS
Code No. 0403-000361 0403-000004 0403-001068 0403-000753 0403-000004 0403-000538 BH99-00011B 0205-001027 1203-000001 1203-000165 BH61-00004A BH62-00045A BH99-00013D 0205-001027 0505-001266 BH61-00004A BH62-00042A BH99-00029C 0205-001027 0402-001319 0502-001202 BH61-70003A BH62-00001A BH62-00040A BH99-00030B 0205-001027 0505-001305 6006-001008 6021-000118 BH62-00044A BH99-00041A 0205-001027 0505-001359 BH61-00004A BH62-00039A BH99-00043A 0205-001027 1204-001508 6006-001008 6021-000118 BH62-00049A BH99-00045A 0205-001027 0502-000348 6006-001008 6021-000118
Description DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-ZENER DIODE-ZENER ASSY HEAT/SINK OIL-SILICON IC-POSI.FIXED REG. IC-POSI.ADJUST REG. SPRING-TR HEAT SINK-TR ASSY HEAT/SINK OIL-SILICON FET-SILICON SPRING-TR HEAT SINK-POWER ASSY HEAT/SINK OIL-SILICON DIODE-RECTIFIER TR-POWER SPRING INSULATION-MICA HEAT SINK-HOR. ASSY HEAT/SINK OIL-SILICON FET-SILICON SCREW-ASSY MACH NUT-HEXAGON HEAT SINK-TR ASSY HEAT/SINK OIL-SILICON FET-SILICON SPRING-TR HEAT SINK-TR ASSY HEAT/SINK OIL-SILICON IC-VERTICAL DEF. SCREW-ASSY MACH NUT-HEXAGON HEAT SINK-V/IC ASSY HEAT/SINK OIL-SILICON TR-POWER SCREW-ASSY MACH NUT-HEXAGON
Specification UZ6.2BSB,6.2V,5.99-6.24V,500mW UZ12BM,12V,11.6-12.4V,500mW,DO UZ4.7BSA,4.7V,4.47-4.65V,500mW MTZJ27D,27V,26.29-27.64V,500mW UZ12BM,12V,11.6-12.4V,500mW,DO MTZ16C,16V,15.69-16.51V,500mW, HS,SPRING,78R12,7805,-,OIL SILICON G746,-,7805,TO-220,3P,-,PLASTIC,4.8/5 78R12,TO-220,4P,-,PLASTIC,11.7/12.3V,1.5W,-20TO+80C,1A,-,ST CDA,CDB,SUS304,T0.5,-,-,-,AQ19FS,A1050S,T1.0,25,54,-,-,HS,SPRING,2SK2761,-,-,OIL SILICON G746,-,2SK2761-01MR,N,600V,10A,0.85oh CDA,CDB,SUS304,T0.5,-,-,-,AQ19FS,A1050S,T1.0,80,55,-,-,HS,SPRING,FJL6820,10F150S,-,MICA,OIL SILICON G746,-,SDS10F150S,1.5KV,10A,TO-220F,ST FJL6820,NPN,200000MW,TO-264,ST,8CVT4857,STS304-W1/2H,T0.5,W3.8 CSM920B,MICA,-,-,-,-,-,-,POWER-TR PN19MT,A1050S,T2.0,95,110,-,-,HS TR,SCREW+NUT,SKS10N20(4),-,-,OIL SILICON G746,-,SKS10N20,N,200V,6.9A,0.36OHM,39W,TO-220F WSP,BH,+,M3,L10,ZPC(YEL),SWRCH 1C,M3,ZPC(YEL),SM20C AQ19FS,A1050S,T2.0,20,55,-,-,HS,SPRING,SFP9634,-,-,OIL SILICON G746,-,SFP9634,P,-250V,-5A,1.3OHM,70W,TO-220 CDA,CDB,SUS304,T0.5,-,-,-,PN19MT,A1050S,T1.0,20,20,-,-,HS V.IC,SCREW+NUT,KA2142,-,-,OIL SILICON G746,-,KA2142,SIP,10P,-,PLASTIC,35V,15W,-20TO+70C,ST,VERTICAL DEFLECTION WSP,BH,+,M3,L10,ZPC(YEL),SWRCH 1C,M3,ZPC(YEL),SM20C AQ17,A1050S,T1.0,H60,L77,-,-,HS,SCREW+NUT,TIP29C,-,-,OIL SILICON G746,-,TIP29C,NPN,2W,TO-220,-,15-75 WSP,BH,+,M3,L10,ZPC(YEL),SWRCH 1C,M3,ZPC(YEL),SM20C

Loc. No. R462 R463 R464 R465 R466 R467 R468 R490 R501 R502 R503 R504 R505 R506 R507 R508 R509 R510 R511 R512 R515 R520 R521 R522 R523 R524 R525 R526 R527 R531 R532 R541 R542 R543 R545 R546 R547 R550 R551 R552 R553 R555 R556 R557 R558 R560 R561 R563 R564 R565 R567 R596 R597
Code No. 2004-000412 2001-000042 2001-000042 2001-000028 2001-000050 2008-000140 2001-000734 2004-000580 2001-000241 2001-000331 2001-000812 2001-000689 2001-000977 2001-000800 2001-000429 2001-000241 2001-000800 2001-000780 2001-000018 2005-000210 2001-000073 2001-000084 2001-000546 2004-000515 2001-000096 2004-001254 2004-000123 2001-000290 2001-000878 2004-000964 2004-000643 2001-000114 2001-000114 2002-001079 2001-000331 2001-000429 2001-000429 2002-001079 2001-000723 2001-000319 2001-000105 2001-001144 2001-001153 2003-000459 2003-000008 2001-000800 2001-000331 2001-000429 2001-000591 2001-000449 2002-001079 BH39-40305U 2002-001075
Description R-METAL R-CARBON R-CARBON R-CARBON(S) R-CARBON R-FUSIBLE R-CARBON R-METAL R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-WIRE WOUND R-CARBON R-CARBON R-CARBON R-METAL R-CARBON(S) R-METAL R-METAL R-CARBON R-CARBON R-METAL R-METAL R-CARBON(S) R-CARBON(S) R-COMPOSITION R-CARBON R-CARBON R-CARBON R-COMPOSITION R-CARBON R-CARBON R-CARBON R-CARBON(S) R-CARBON(S) R-METAL OXIDE(S) R-METAL OXIDE(S) R-CARBON R-CARBON R-CARBON R-CARBON R-CARBON R-COMPOSITION CBF HARNESS R-COMPOSITION
Specification 18Kohm,1%,1/4W,AA,TP,2.4x6.4mm 1KOHM,5%,1/4W,AA,TP,2.4X6.4MM 1KOHM,5%,1/4W,AA,TP,2.4X6.4MM 100OHM,5%,1/2W,AA,TP,2.4X6.4MM 2.7KOHM,5%,1/4W,AA,TP,2.4X6.4MM 2.2ohm,5%,1/2W,AA,TP,3.5x9.4mm 4.7KOHM,5%,1/8W,AA,TP,1.8X3.2MM 22Kohm,1%,1/4W,AA,TP,2.4x6.4mm 1.5KOHM,5%,1/8W,AA,TP,1.8X3.2MM 12KOHM,5%,1/8W,AA,TP,1.8X3.2MM 5.6KOHM,5%,1/8W,AA,TP,1.8X3.2MM 390KOHM,5%,1/8W,AA,TP,1.8X3.2MM 8.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM 5.1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 1.5KOHM,5%,1/8W,AA,TP,1.8X3.2MM 5.1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 470OHM,5%,1/8W,AA,TP,1.8X3.2MM 6.8OHM,5%,1/4W,AA,TP,2.4X6.4MM 0.33ohm,5%,1W,AC,BK,4.5x11mm 33KOHM,5%,1/4W,AA,TP,2.4X6.4MM 100KOHM,5%,1/4W,AA,TP,2.4X6.4MM 270KOHM,5%,1/4W,AA,TP,2.4X6.4MM 200Kohm,1%,1/4W,AA,TP,2.4x6.4m 1MOHM,5%,1/2W,AA,TP,2.4X6.4MM 8.2Kohm,1%,1/4W,AA,TP,2.4x6.4m 1.2Kohm,1%,1/4W,AA,TP,2.4x6.4m 10KOHM,5%,1/8W,AA,TP,1.8X3.2MM 6.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM 470Kohm,1%,1/4W,AA,TP,2.4x6.4m 270Kohm,1%,1/4W,AA,TP,2.4x6.4m 180KOHM,5%,1/2W,AA,TP,2.4X6.4MM 180KOHM,5%,1/2W,AA,TP,2.4X6.4MM 470Kohm,5%,1/2W,AA,TP,4x10mm 12KOHM,5%,1/8W,AA,TP,1.8X3.2MM 1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 470Kohm,5%,1/2W,AA,TP,4x10mm 4.3KOHM,5%,1/8W,AA,TP,1.8X3.2MM 120KOHM,5%,1/8W,AA,TP,1.8X3.2MM 1.5KOHM,5%,1/4W,AA,TP,2.4X6.4MM 4.7KOHM,5%,1/2W,AA,TP,2.4X6.4MM 47OHM,5%,1/2W,AA,TP,2.4X6.4MM 100ohm,5%,3W,AA,TP,6x16mm 100ohm,5%,1W,AA,TP,3.3x9mm 5.1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 12KOHM,5%,1/8W,AA,TP,1.8X3.2MM 1KOHM,5%,1/8W,AA,TP,1.8X3.2MM 3.3KOHM,5%,1/8W,AA,TP,1.8X3.2MM 2.2KOHM,5%,1/8W,AA,TP,1.8X3.2MM 470Kohm,5%,1/2W,AA,TP,4x10mm 52MM,AWG22(0.6PI),-,-,AWG22(0. 30Mohm,5%,1/2W,AA,TP,4.0x10mm

7-8 AQ19** Main Different Part List
AQ19MS LOC C305 C207 C272 C273 C408 C409 C411 C413 C415 C416 C417 C451 C457 C701 CISCISCN201_ASSY CN206 CN207 CN409 D402 D456 D601 EY599 HS409 HS504 JP221 JP332 JP538 JP538 JP539 JP540 JP541 JP551 JP552 JP553 JP554 JP557 JP558 JP559 JP560 JP561 JP562 JP575 JP580 JP584 JP594 JP661 JP669 JP670 code 2301-000013 2303-001022 2303-001022 2306-000127 2306-000127 2301-001194 2306-000147 2306-000125 2401-002299 2201-000602 2301-001314 BH39-00060A 3711-000885 0402-001441 0402-000454 0402-001227 BH39-00232A BH99-00030B BH99-00013D spec 4.7nF,5%,100V,TP,10.5x12.5x6.5 2NF 2.5K 2NF 2.5K 120nF,5%,400V,TP,21.5x17mm,5mm 120nF,5%,400V,TP,21.5x17mm,5mm 470nF,5%,250V,BK,26x18.5x10,20 1uF,5%,250V,BK,26x24x15,22.5mm C-FILM,MPPF;120nF,5%,250V 4.7uF,20%,50V C-CERAMIC,DISC;0.56nF 50V 470NF,10%,275V 15P/15P,180MM ,SMH200-15 3WALL,3P,1R,2.5mm,STRAIGHT,SN SB340 RG10 D3SBA60,600V,2.3A,SIP-4,BK ,1P,290MM,RED,AWG22,YHF800-1 HS TR,SCREW+NUT,SKS10N20(4), HS,SPRING,2SK2761 code 2301-000312 2303-001022 2303-001022 2301-001259 2301-001259 2301-001194 2306-000147 2306-000125 2401-002299 2301-001314 BH39-00060A 3711-000885 0402-001441 0402-000454 0402-001227 BH39-00232A BH99-00030B BH99-00013D AQ19IS spec C-FILM,PEF,8.2nF,5%,100V,TP 2NF 2.5K 2NF 2.5K C-FILM,MPPF;100nF,5%,400V C-FILM,MPPF;100nF,5%,400V 470nF,5%,250V,BK,26x18.5x10,20 1uF,5%,250V,BK,26x24x15,22.5mm C-FILM,MPPF;120nF,5%,250V 4.7uF,20%,50V 470NF,10%,275V 15P/15P,180MM ,SMH200-15 3WALL,3P,1R,2.5mm,STRAIGHT,SN SB340 RG10 D3SBA60,600V,2.3A,SIP-4,BK ,1P,290MM,RED,AWG22,YHF800-1 HS TR,SCREW+NUT,SKS10N20(4), HS,SPRING,2SK2761, code 2301-000013 2202-002009 2202-002008 2401-000025 2303-001023 2303-000007 2306-000127 2301-001259 2306-000249 2306-000293 2306-000137 2401-001625 2202-000470 2305-001049 BH39-00335A BH39-00340A BH39-00292A 3711-003895 3711-004349 3711-000795 0402-000016 0402-001294 0402-001160 BH39-00195A BH99-00030D BH99-00013A BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U BH39-40305U AQ19NS spec 4.7nF,5%,100V 100nF,+80-20%,50V,Y5 10nF,+80-20%,50V,Y5V,TP,2.3X3. 100uF,20%,16V 2.2NF 2.5KV 2.7NF 2.5KV 120nF,5%,400V,TP,21.5x17mm,5mm C-FILM,MPPF;100nF,5%,400V 680nF,5%,250V 1.2uF,5%,250V,BK,26.5x19mm,27. 180nF,5%,250V,TP,19x16.5x8,7.5 6.8uF,20%,50V C-CERAMIC,MLC-RADIAL;330pF,100V 1000nF,10%,275V PG17NF,UL1007#26,6P/4P*2P,360MM PG19NF,UL1015#18,10P/4P,400MM 15P/15P,230MM BOX,13P,1R,2mm,STRAIGHT,SN BOX,3P,1R,2mm,STRAIGHT,SN BOX,2P,1R,2.5mm,STRAIGHT,SN SB540,40V,5A,DO-201AD,BK UF5404L-5709,400V,3A,DOD5SB60,600V,6A,SIP-4,1P,360MM,RED,AWG22,YFH800-01 HS TR,SKS10N20(2),19N20(2) HS,SPRING,2SK2761 JUMPER 52MM,AWG22(0.6PI) 52MM,AWG22(0.6PI) JUMPER JUMPER JUMPER JUMPER 52MM,AWG22(0.6PI) 52MM,AWG22(0.6PI) JUMPER JUMPER 52MM,AWG22(0.6PI) 52MM,AWG22(0.6PI) 52MM,AWG22(0.6PI) 52MM,AWG22(0.6PI) JUMPER JUMPER 52MM,AWG22(0.6PI) JUMPER JUMPER JUMPER 52MM,AWG22(0.6PI),-,-,AWG22(0. 52MM,AWG22(0.6PI) 52MM,AWG22(0.6PI)

7-11-2 BNC Different Part List
Apply to PFC LOC R701 D703 C607 code 2005-001170 0402-001111 2401-003391 spec R-WIRE WOUND,NON;0.33ohm 1W DIODE-RECTIFIER;1N5397GP,600V C-AL,220uF,20%,450V,GP,BK AQ19NF code BH39-40305U BH39-40305U 2401-003483 2401-001137 2401-003619 2401-003620 CORE-FERRITE BEAD CORE-FERRITE BEAD DIODE-ZENER;UZ12BM,12V, DIODE-ZENER;MTZ16C,16V CBF HARNESS;52MM CBF HARNESS;52MM CBF HARNESS;52MM EYELET;ID1.5,OD2, Not Apply to PFC spec CBF HARNESS;52MM,AWG22 CBF HARNESS;52MM,AWG22 270uF,20%,400V,GP,BK,25.4x45 330uF,20%,400V,GP,BK,30x45mm 270uF,20%,450V,GP,BK,30x45mm 330uF,20%,450V,GP,BK,25.4x60 - - - - - - - - -
BD652 BD653 C701 C702 C703 C705 C706 C708 C710 D702 D704 HSD701 IC701 L701 R702 R703 R705 R706 R711 R712 R721 R704 HSQ701 T701 ZD705 ZD706 JP295 EY703 EY704 EY705
2301-001314 2305-001049 2305-001041 2201-000602 2301-000188 2202-002009 2401-000970 2201-000019 0402-000546 0401-000005 BH99-10019X 0402-001191 1203-002081 BH27-00053A 2001-001013 2001-000302 2004-001863 2004-001863 2008-000125 2001-000302 2001-000786 2004-001863 BH99-10047E 0505-001266 BH27-00081A
3301-000011 3301-000011 C-FILM,MPPF;470NF,275V,BK 1000nF,10%,275V BK C-FILM,MPEF;220nF,5%,63V C-CERAMIC,DISC;0.56nF,5%,50V C-FILM,PEF;1nF,5%,100V C-CERAMIC,MLC-AXIAL;100nF C-AL;22uF,20%,50V,WT C-CERAMIC,DISC;10nF,500V DIODE-RECTIFIER;TVR10G,400V DIODE-SWITCHING;1N4148,100V ASSYHEAT/SINK;GUR460 DIODE-RECT;MUR460,600V,4A IC-PWMCONTROLLER;33260 COILCHOKE;TO-2012,195uH R-CARBON;9.1KOHM,5%,1/4W R-CARBON;10OHM,5%,1/8W R-METAL;680Kohm,1%,1/4W R-METAL;680Kohm,1%,1/4W R-FUSIBLE;10ohm,5%,1/4W R-CARBON;10OHM,5%,1/8W R-CARBON;47KOHM,5%,1/8W R-METAL;680Kohm,1%,1/4W ASSYHEAT/SINK;2SK2761 FET;2SK2761-01MR,N,600V,10A, COIL-PFC;EER-2828,135u 0403-000004 0403-000538 BH39-40305U BH39-40305U BH39-40305U 6042-000002
7-12 PFC FET Different Part List
FUJI 2SK2761 LOC HSQ701 D704 R703 code BH99-10047E 0505-001266 0401-000005 2001-000302 spec ASSYHEAT/SINK;2SK2761 FET;2SK2761-01MR,N,600V,10A, DIODE-SWITCHING;1N4148,100V R-CARBON;10OHM,5%,1/8W code BH99-10054C 0505-001493 2001-000281 Infineon SSP7N60 spec ASSY HEAT/SINK SPP07N60S5,N,600V,7.3A, R-CARBON;100OHM,5%,1/8W

7-13 FBT Different Part List
SEMCO LOC R524 code 2004-001254 spec R-METAL;8.2Kohm,1%,1/4W code 2004-001329 HITACHI spec R-METAL;9.1KOHM,1% 1/4W

7-14 Destination OSD IC

FUJI 2SK2761 Destination EUROPE KOREA CHINA code 1204-001864 1204-001868 1204-001867 S5D2509X09 S5D2509X08 S5D2509X07 spec

7-15 AQ19NS Only ASSY

PURITY SENSOR BH98-00285A BH98-00286A ASSY PCB/MISC-PURITY ASSY PCB/MISC-SENSOR

7-16 S-Corretion Table

AQ17HS

AQ17IS

AQ17NS

S1 S2 S3 S4 S5

~110 ~99.9 ~94.9 ~91.9 ~84.9 ~80.9 ~77.9 ~75.9 ~69.9 ~67.9 ~64.9 ~60.9 ~58.9 ~52.9 ~48.9 ~45.9 ~39.9 ~36.9 ~34.9 ~33
H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H
H H H H H H H H H H H H H H H H H H H H H H

H H H H

H H H H H
H H H H H H H H H H H H H H H H

H H H H H H H H H H

AQ19MS

AQ19IS

AQ19NS
~110 ~99.9 ~94.9 ~91.9 ~84.9 ~80.9 ~77.9 ~71.9 ~69.9 ~67.9 ~64.9 ~60.9 ~58.9 ~52.9 ~48.9 ~45.9 ~39.9 ~36.9 ~34.9 ~33 7-62
H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H H
~110 ~99.9 ~94.9 ~89.9 ~84.9 ~80.9 ~77.9 ~71.9 ~69.9 ~67.9 ~64.9 ~60.9 ~58.9 ~52.9 ~48.9 ~45.9 ~39.9 ~36.9 ~34.9 ~33

H H H H H H

H H H H H H H H H H H H H H H H H H

9 Wiring Diagram

H_SYNC_OUT +5V +12V +80V +6.3V GND G1 CN102 GND H_FLB V_BLK CLAMP SCL SDA ACL DC_FOCUS H_SYNC_OUT +5V +12V +80V 6.3V GND G1 CN201 GND H_FLB V_SYNC_OUT CLAMP SCL SDA ABL DC_FOCUS

H_CG H_CG V_CG V_CG

Video PCB

CN207 TEMP GND +5V

TEMPERATURE SENSOR PCB 1 TEMP 2 GND +5V 3
GND BLUE GND GREEN GND RED

CN101 CN103

BNC PCB
GND +12V +5V GND NC SOG_SYNC GND GND (NC) GND DDC 5V H_Sync V_Sync DDC_CLK DDC_DATA S_RASTER GND NC USB DM USB DP GND BNC_DSUB

Main PCB

GND BLUE GND GREEN GND RED NC
CN204 KEY 1 GND KEY 2 GND
CONTROL PCB 1 KEY GND KEY GND 4

Purity Coil

TL TL + BL BL + TR TR + BR BR +
ABL GND TEMP CN803 GND +5V RESET2 SDA SCL
1 ABL 2 GND 3 TEMP 4 GND 5 +5V 6 RESET 13 SDA SCL GND -14V +14V GND +12V

TILT CONNECTOR

Purity PCB CRT

N/S Coil

GND -14V +14V GND +12V

N/S-OUT NC GND

NC VY VX GND 12V CN882 PURITY MAGNETIC SENSOR NC VY VX GND 12V 5

10 Schematic Diagrams

10-1-1 AQ17** & AQ19** Main Part Schematic Diagram
CN201 slcon15p 1 +5V IC202 KIA7042AP +12V C281 10uF 50V C280 100nF 50V MO IC280 KS24C5 R1/6W W_PROTECT SCL R1/6W G1 R282 +12V +5V_1 R1/6W C202 100UF 16V +5V_1 SDA R1/6W H_FLB V_SYNC_OUT CLAMP 12 SCL 13 IC201 KS88P6232N 1 W_PROTECT 2 BNC/DSUB R215 4.7K 1/8W H_LIN TILT C210 47UF 16V C208 100nF 50V MO R216 4.7K 1/8W C209 1uF 50V R218 19NS 2.2K OTHER 1/6W 3.9K R214 10K 1/8W 7 RESET R221 10K 1/8W 8 H/V_ADJ 9 X-RAY C216 10NF 50V C220 4.7uF 50V R231 1K 1/8W KEY1 KEY2 USBDM USBDP 17 R227 R272 1.5K H_SYNC_IN 100 1/6W R226 V_SYNC_IN ABL 100 1/6W C213 100nF 50V MO C214 100nF 50V MO C212 100pF 50V R225 1M 1/6W C211 1nF 50V ZD286 UZ6.2BSB D201 CLAMP 1N4148 D202 1N4148 D281 SB020 D282 SB020 C285 100nF 50V MO R1/6W LED R1/6W H_SYNC_OUT R1/6W R252 H_SIZE D250 1N4148 27K 1/8W C251 10nF 100V P R273 10K 1/8W CC B E C272 10NF 50V R1/8W C256 10nF 100V P H_FOCUS Q252 KSC945-Y C R253 5K 1/4W MF C254 4.7uF 50V R254 1K 1/8W C253 10nF 50V C255 1uF 63V MP C250 100nF 50V MO C252 0.82NF 50V MO D251 1N4148 IC250 TDAH_HV-IN V_Focus 32 R269 1/6W 100 C269 10uF 50V V_FOCUS +12V SDA R266 1/8W 56 AQ19N* ONLY BD201 +12V +5V Q250 KSC945-Y E H_DRIVE E R264 120K 1/6W B C Q251 KSA733-Y TEMP +5V RESET SDA EW_OUT SCL H-pos HVFocus VOUT VCAP 23 V_OUT 22 C266 150nF 100V P C265 470nF 63V MP C264 16V 47uF +12V +14V Q253 KTA1281-Y C E -14V 13 +12V ZD287 ZPD5,6 C B E Q254 KSC945-Y R277 2.2K 1/8W C273 100UF 16V 8 ABL CN207 slcon3p 1 TEMP CN206 slcon13p 7 B OP201 LTL-10233W A +5V KEY1 OP1 LTL-10233W B 2 KEYA CN204 slcon4p 1 B 2 USBDM 3 USBDP 4 BNC_DSUB 5 1/8W 18 +5V D254 R229 1K 1/8W 1N4148 R230 1/6W 100 R219 3.3K 1/8W R233 4.7K 1/8W 12 ABL KEY1 KEY2 S5 S RAST 3 H LIN 4 DETECT_12V 5 TILT 6 H_SUBSIZE S1 GND 42 SR211 10K 1/8W R209 10K 1/8W R200 10K 1/8W R243 15K 1/6W R242 15K 1/6W R240 4.7K 1/8W R238 1/8W 19MS 4.7K OTHER 2.7K SDA ABL DC_FOCUS C284 100pF 50V C283 100pF 50V CN209 slcon1p S37 SR1/6W 35 X201 Q1 LED 34 OSC IN OSC OUT DEGAUSS QS5 S_RASTER 24MHZ R206 4.7M 1/6W C204 22pF 50V C203 22pF 50V DEGAUSS 3 SDA SCL DDC_DATA DDC_CLK BB R222 3.9K 1/6W AA R1/6W CC R1/6W SOG_SYNC ZD280 UZ6.2BSB ZD281 UZ6.2BSB ZD282 UZ6.2BSB ZD284 UZ6.2BSB ZD283 UZ6.2BSB ZD285 UZ6.2BSB CN203 slcon8p OEM S_RASTER 8 DDC_CLK DDC_DATA 7 H_SYNC_IN H_SYNC_OUT R1/8W 100 1/6W LED V_SYNC_IN 1 SOG_SYNC 2 CN211 slcon5p DDC5V +12V +5V CN202 slcon16p SYNCMASTER CN210 slcon1p 1.5K 1/2W 11 +80V +6.3V 8 BD280 B 4 5

RESET C207 100nF 50V MO

R220 12K 1/6W

ZD201 MTZ7.5C

C201 100nF 50V

W_PROTECT BNC_DSUB

RESET 40 S2 S3 S4 39

H_SUBSIZE H/V_ADJ X-RAY

CN212 slcon5p 1
13 VDD 14 USBVCC 15 USBDM 16 USBDP GND HSYNCIN
SDA 30 SCL 29 DDC DATA DDC CLK CLAMP BB AA 24

R1/6W R1/8W R1/8W R1/8W

R228 1/6W 100 R1/6W R1/6W

17R204

19 VSYNCIN 20 VSYNCOUT 21 H SYNC OUT

CC 23 SOG IN 22

V_SYNC_OUT H_SYNC_OUT DDC5V

CN205 slcon5p 1 2

V_SYNC_OUT

VSYNC-IN HlockOut

R1/8W SDA 56 SCL 30

4 FCPLL2C 6 7

VCC 29 Bout 26 C270 100nF 50V C268 10uF 100V C271 100uF 16V C B

AQ19N* ONLY

CO Hgnd

GND Hout Xray

R268 4.7K 1/8W

R265 1.2K 1/8W

8 RO 9 PLL1F

EWout 24

12 Hfly C258 100pF 500V H_FLB C257 1nF 100V P C260 100nF 50V MO R255 2.2K 1/8W C259 10uF 16V R256 90K 1/4W MF 13 Href 14 15

VGND 21 VAGCCAP 18

R261 10K 1/8W

R275 10K 1/8W

R276 47K 1/6W

Comp Reg-In

VRB VEHTcomp

16 Isense

HEHTcomp 17
10 Schematic Diagrams 9 IC250, #IC250, #2.20 V (IC250, #11, 32) 16 3.42 V (IC201, #33) 17 3.16 V (IC201, #32)
10-1-2 AQ17** & AQ19** Main Part Schematic Diagram

+12V +30V +350V +80V

L502 4.7uH
HIGH_VOLTAGE SCREEN FOCUS(RED) FOCUS(WHT) D598 RGP02-12(T) 1 EY503 EYE1.15 T12 EY511 EYE1.5 EY507 EYE1.5 C535 10NF 500V EY550 SNAME 1 R560 5.1K 1/6W 1 EY506 SNAME +350V R596 17/19NS 33K 1/2W OTHER JUMP H/V_ADJ R531 470K 1/4W MF C533 100nF 63V MP R532 270K 1/4W MF R599 1/2W 17/19NS180K 19MS 240K OTHER 220K R598 1/4W 17/19NS 1K OTHER 180K D599 RGP02-12(T) C598 10nF 500V R597 1/2W CC 19MS 30M OTHER15M CNEY599 SNAME SCREEN EYEYE1.5 EY510 EYE1.-210V +350V 1 EY509 EYE1.5 SK530 SSG-102B2 C B E R563 1K 1/8W C536 100nF 50V R564 3.3K 1/8W R567 470K 1/2W CC Q541 KSP44

C503 470uF 16V 105C

L501 33uH
C504 100uF 16V B C505 10nF 50V D505 GUR460L-5700 IC501 TL494CN B E E B R507 1K 1/8W R508 1.5K 1/8W C Q503 2N3906 R1/6W Q502 C 2N9 D504 1N4148 R511 6.8 1/4W C511 1nF 2KV PP BD532 D G S Q504 2SK2761-01MR R512 0.33 1W WW R515 33K 1/4W C512 47uF 50V D507 GUR460L-5700

C513 2.2uF 350V

4. THE SECONDARY VOLTAGE IS READ WITH SSVM FROM INDICATED POINT TO SECONDARY GROUND ( ) THE PRIMARY VOLTAGE IS READ WITH SSVM FROM INDICATED POINT TO PRIMARY GROUND ( ).
5. THIS SCHEMATIC DIAGRAM IS SUBJECT TO CHANGE WITHOUT NOTICE FOR FURTHER IMPROVEMENT. EY6 EYE2.2 EY61 EYE2.2

C653 100nF 50V

Q671 KSC945-Y
D602 1N4148 C B R604 10K 1/8W DEGAUSS Q601 KSC1008-Y R651 4.7K 1/8W BB

+14V_I

TO DEGAUSSING COIL RL601 G5PA-slcon3p CN1
IC650 MC7805CT INOUT GND C650 100UF 16V C651 10NF 50V
POS601 J503P61D4R5Q270S 17NS/19MS 10ohm 19NS 4.5ohm OTHER 9ohm
BD603 1.2UH,3.5*5.7MM 1 B EYEYE2.2 R670 180K 1/2W CC R671 180K 1/2W CC C610 10nF 500V R606 100K 1/2W R607 120K 1/2W 1 EY614 EYE1.5 C611 220pF 1KV D604 UF4007 EYE1.5 EY6 2
T601 19NS EER4042 OTHER ER16 EY615 EYE1.5
D640 UF4004 C654 1000uF 16V 105C D641 UF5404 HS606 heat_sink D642 UF1G C642 1000uF 16V 105C E B C Q672 KTA1281-Y R675 0.56 1/2W +6.3V +14V C641 1000uF 16V R676 2.2K 1/8W R677 1K 1/8W +14V_I
CN602 slcon1p TH601 SKC-084 1

CN603 slcon1p

D601 D5SB4 19NS D5SB60 OTHER D3SBA60
C607 WITH PFC 220uF 450V 220uF 450V EYEYE2.2
IC601 DP308P C605 10nF 500V F_B DRAIN GND 5 Vcc SYNC BD604
7 D606 TVR10G C612 100pF 1KV KPJ-2S1BB CN608 slcon1p 1 1

SNAME EY616

-14V D644 RG10Z-V1 C643 470UF 16V
HS601 heat_sink EYEYE2.2 EYEYE2.2 C608 33uF 50V 105C R601 150K 1/4W R602 150K 1/4W PFC CIRCUIT D703 1N5397GP 1 EY611 EYE2.2 EY612 EYE2.2

D605 UF4007 1

R688 10K 1/8W
R608 6.8K 3W MO CN609 slcon1p

D645 31DF6

HS60 heat_sink

R644 33K 1/2W

C644 100V/220UF NEW CODE 100uF 105C 100V 105C

C609 100nF 50V MO

ZD601 MTZJ27D-T-72
D646 UF4004 C645 470UF 35V 105C +29V

R605 1.2K 1/4W

C613 2.2nF 125V
D647 RG4C C646 47UF 250V 105C
+210V R628 180K 1W CC C629 10nF 500V
EY705 SNAME C706 100nF 50V MO C708 22uF 50V 105C R1/4W FU

D702 TVR10G

C603 2.2nF 125V BD602 C602 1000nF 275V MP

C604 2.2nF 125V

ER-2828 T701 ZD706 UZ16BM ZD705 UZ12BM EY703 SNAME IC701 B C702 220nF 63V MP C703 560PF 50V

C614 2.2nF 125V

C649 470pF 1KV

D650 RGP02-12(T)

R649 R655 1/2W 1/2W 470K 470K CC CC

C627 2.2nF 100V P

R629 6.8K 1/6W

EY704 SNAME

IC620 LTV817M-SM COLANODE HSD701 heat_sink C655 10nF 100V P R704 680K 1/2W R705 680K 1/2W T620 BH26-30302S R706 680K 1/2W C620 1uF 50V 105C C621 100nF 100V P C4 4.7nF 100V P RD621 1N4148 R623 1K 1/8W R622 1.5K 1/8W
BD653 1.2UH,3.5*5.7MM L2 L701 C701 275V MP 17/19NS 1000nF OTHER 470NF FUSEHOLDER FG601 EY601 SNAME EY602 SNAME R701 0.33 3W WW R702 9.1K 1/4W MF C705 1nF 100V P

Vcc-G GIN SOG IN

C186 100nF 50V MO

CR01 100nF 50V

VCC BIN

BOUT VCC

RR31 15

CR14 1uF

100V RG1/10W

R-IN RG1/10W RG1/10W

R-OUT GND RG1/10W CG14 1uF 100V LG03 0.07uH

j_c11p 1011

GND G-OUT

RB1/10W

B-IN RB1/10W

6 CB01 100nF 50V

RIN VSSA VCOIN VREF VICTL VDDA SDA

BRT/L B-OUT

C111 100nF 100V MO

CB14 1uF 100V

RB1/2W
C112 10uF 100V 105C LB03 0.07uH BD181 1.2uH CN12

LR01 0.47uH

LG01 0.47uH

LB01 0.47uH

RG1/10W

DBMMBD4148SE

GOSD 10 CG03 100nF 50V MO BOSD CB03 100nF 50V MO 17

C126 100UF 16V

H_SYNC

BIN Vcc-B BOSD

B-CUT G-CUT R-CUT

CR04 15PF 50V MO RR1/10W

CG04 15PF 50V MO RG1/10W

CB04 15PF 50V MO RB1/10W

DR04 BAV21

DG04 BAV21

DB04 BAV21 DR05

SK101 DG05

SK103 X3 C181 1nF 2KV

R191 1K 1/10W

25 RGRR04

DMS-200D DB05

SK108 SSG-102B2

R1/6W C115 0.68NF 50V MO

R187 30M 1/4W

C122 6.8nF 50V

C180 100UF 16V

NOT USE

R1/10W BD104 1.5uH

GND ABL B/U

BRIGHT GND SDA

IC104 LM2480NA $P C F E

BD102 1.2UH,3.5*5.7MM CR16 100nF 100V P

DMS-200D

MMBD4148SE

C182_1 100nF 50V

R180 8.2K 1/10W R189 12K 1/10W

R190 6.8K 1/10W

BD103 R111 10K 1/10W R1/6W
C109 100nF 50V MO R113 22K 1/10W R196 10K 1/10W

RCUT GCUT

100 1/10W

C182 100nF 50V MO

SCL CLAMP

L104 1.5uH

CR20 10uF 25V CG20 10uF 25V CB20 10uF 25V
CB16 100nF 100V P R1/2W C183 4.70NF 500V

R108 4.7K 1/10W

R112 2.7K 1/10W

C116 4.7uF 50V

C117 220uF 16V

C118 100nF 50V MO

ZD102 BZX79C5V6 CR21 100nF 50V MO C119 47pF 50V MO
C114 10uF 160V CG21 100nF 50V MO CB21 100nF 50V MO

ZD101 BZX79C5V6

+5V +5V

CG16 100nF 100V

BD182 1.2UH,3.5*5.7MM

HS3 heat_sink

C106 R105 1K 1/10W 10nF 50V MO

R125 2.4K 1/10W

H_FLB1

V_BLK AFC G1

Q107 2N3904 R107 2K 1/10W

D104 MMBD4148SE

R178 5.6K 1/10W

6.3V 80V 12V 5V

BD106 1.2UH,3.5*5.7MM

SCL ACL

C153 100UF 16V
C154 100nF 50V MO L107 4.7uH

9 Wiring Diagram

H_SYNC_OUT +5V +12V +80V +6.3V GND G1 CN102 GND H_FLB V_BLK CLAMP SCL SDA ACL DC_FOCUS H_SYNC_OUT +5V +12V +80V 6.3V GND G1 CN201 GND H_FLB V_SYNC_OUT CLAMP SCL SDA ABL DC_FOCUS

H_CG H_CG V_CG V_CG

Video PCB

CN207 TEMP GND +5V

TEMPERATURE SENSOR PCB 1 TEMP 2 GND +5V 3
GND BLUE GND GREEN GND RED

CN101 CN103

BNC PCB
GND +12V +5V GND NC SOG_SYNC GND GND (NC) GND DDC 5V H_Sync V_Sync DDC_CLK DDC_DATA S_RASTER GND NC USB DM USB DP GND BNC_DSUB

Main PCB

GND BLUE GND GREEN GND RED NC
CN204 KEY 1 GND KEY 2 GND
CONTROL PCB 1 KEY GND KEY GND 4

Purity Coil

TL TL + BL BL + TR TR + BR BR +
ABL GND TEMP CN803 GND +5V RESET2 SDA SCL
1 ABL 2 GND 3 TEMP 4 GND 5 +5V 6 RESET 13 SDA SCL GND -14V +14V GND +12V

TILT CONNECTOR

Purity PCB CRT

N/S Coil

GND -14V +14V GND +12V

N/S-OUT NC GND

NC VY VX GND 12V CN882 PURITY MAGNETIC SENSOR NC VY VX GND 12V 5
AQ17HS/AQ17IS/AQ17NS AQ19MS/AQ19IS/AQ19NS/AQ19FS

10 Schematic Diagrams

10-1-1 AQ17** & AQ19** Main Part Schematic Diagram
CN201 slcon15p 1 +5V IC202 KIA7042AP +12V C281 10uF 50V C280 100nF 50V MO IC280 KS24C5 R1/6W W_PROTECT SCL R1/6W G1 R282 +12V +5V_1 R1/6W C202 100UF 16V +5V_1 SDA R1/6W H_FLB V_SYNC_OUT CLAMP 12 SCL 13 IC201 KS88P6232N 1 W_PROTECT 2 BNC/DSUB R215 4.7K 1/8W H_LIN TILT C210 47UF 16V C208 100nF 50V MO R216 4.7K 1/8W C209 1uF 50V R218 19NS 2.2K OTHER 1/6W 3.9K R214 10K 1/8W 7 RESET R221 10K 1/8W 8 H/V_ADJ 9 X-RAY C216 10NF 50V C220 4.7uF 50V R231 1K 1/8W KEY1 KEY2 USBDM USBDP 17 R227 R272 1.5K H_SYNC_IN 100 1/6W R226 V_SYNC_IN ABL 100 1/6W C213 100nF 50V MO C214 100nF 50V MO C212 100pF 50V R225 1M 1/6W C211 1nF 50V ZD286 UZ6.2BSB D201 CLAMP 1N4148 D202 1N4148 D281 SB020 D282 SB020 C285 100nF 50V MO R1/6W LED R1/6W H_SYNC_OUT R1/6W R252 H_SIZE D250 1N4148 27K 1/8W C251 10nF 100V P R273 10K 1/8W CC B E C272 10NF 50V R1/8W C256 10nF 100V P H_FOCUS Q252 KSC945-Y C R253 5K 1/4W MF C254 4.7uF 50V R254 1K 1/8W C253 10nF 50V C255 1uF 63V MP C250 100nF 50V MO C252 0.82NF 50V MO D251 1N4148 IC250 TDAH_HV-IN V_Focus 32 R269 1/6W 100 C269 10uF 50V V_FOCUS +12V SDA R266 1/8W 56 AQ19N* ONLY BD201 +12V +5V Q250 KSC945-Y E H_DRIVE E R264 120K 1/6W B C Q251 KSA733-Y TEMP +5V RESET SDA EW_OUT SCL H-pos HVFocus VOUT VCAP 23 V_OUT 22 C266 150nF 100V P C265 470nF 63V MP C264 16V 47uF +12V +14V Q253 KTA1281-Y C E -14V 13 +12V ZD287 ZPD5,6 C B E Q254 KSC945-Y R277 2.2K 1/8W C273 100UF 16V 8 ABL CN207 slcon3p 1 TEMP CN206 slcon13p 7 B OP201 LTL-10233W A +5V KEY1 OP1 LTL-10233W B 2 KEYA CN204 slcon4p 1 B 2 USBDM 3 USBDP 4 BNC_DSUB 5 1/8W 18 +5V D254 R229 1K 1/8W 1N4148 R230 1/6W 100 R219 3.3K 1/8W R233 4.7K 1/8W 12 ABL KEY1 KEY2 S5 S RAST 3 H LIN 4 DETECT_12V 5 TILT 6 H_SUBSIZE S1 GND 42 SR211 10K 1/8W R209 10K 1/8W R200 10K 1/8W R243 15K 1/6W R242 15K 1/6W R240 4.7K 1/8W R238 1/8W 19MS 4.7K OTHER 2.7K SDA ABL DC_FOCUS C284 100pF 50V C283 100pF 50V CN209 slcon1p S37 SR1/6W 35 X201 Q1 LED 34 OSC IN OSC OUT DEGAUSS QS5 S_RASTER 24MHZ R206 4.7M 1/6W C204 22pF 50V C203 22pF 50V DEGAUSS 3 SDA SCL DDC_DATA DDC_CLK BB R222 3.9K 1/6W AA R1/6W CC R1/6W SOG_SYNC ZD280 UZ6.2BSB ZD281 UZ6.2BSB ZD282 UZ6.2BSB ZD284 UZ6.2BSB ZD283 UZ6.2BSB ZD285 UZ6.2BSB CN203 slcon8p OEM S_RASTER 8 DDC_CLK DDC_DATA 7 H_SYNC_IN H_SYNC_OUT R1/8W 100 1/6W LED V_SYNC_IN 1 SOG_SYNC 2 CN211 slcon5p DDC5V +12V +5V CN202 slcon16p SYNCMASTER CN210 slcon1p 1.5K 1/2W 11 +80V +6.3V 8 BD280 B 4 5

RESET C207 100nF 50V MO

R220 12K 1/6W

ZD201 MTZ7.5C

C201 100nF 50V

W_PROTECT BNC_DSUB

RESET 40 S2 S3 S4 39

H_SUBSIZE H/V_ADJ X-RAY

CN212 slcon5p 1
13 VDD 14 USBVCC 15 USBDM 16 USBDP GND HSYNCIN
SDA 30 SCL 29 DDC DATA DDC CLK CLAMP BB AA 24

R1/6W R1/8W R1/8W R1/8W

R228 1/6W 100 R1/6W R1/6W

17R204

19 VSYNCIN 20 VSYNCOUT 21 H SYNC OUT

CC 23 SOG IN 22

V_SYNC_OUT H_SYNC_OUT DDC5V

CN205 slcon5p 1 2

V_SYNC_OUT

VSYNC-IN HlockOut

R1/8W SDA 56 SCL 30

4 FCPLL2C 6 7

VCC 29 Bout 26 C270 100nF 50V C268 10uF 100V C271 100uF 16V C B

AQ19N* ONLY

CO Hgnd

GND Hout Xray

R268 4.7K 1/8W

R265 1.2K 1/8W

8 RO 9 PLL1F

EWout 24

12 Hfly C258 100pF 500V H_FLB C257 1nF 100V P C260 100nF 50V MO R255 2.2K 1/8W C259 10uF 16V R256 90K 1/4W MF 13 Href 14 15

D450 1N4148
R1W MO T502 EE 1916(5P) C551 150nF 100V P R555 4.7K 1/2W 8 Q551 C TIP29C HS508 heat_sink E D551 1N4148 R1/2W R316 1.2 1/2W FU D552 1N4148 EY301 EYE2.EY302 EYE2.HS301 heat_sink B R551 4.3K 1/6W H_FOCUS R552 120K 1/6W B E R553 1.5K 1/4W Q553 2N5551C-Y V_FOCUS D540 1N4148 C C E D553 1N4148 Q552 TIP30C HS509 heat_sink R545 12K 1/6W 1

D452 1N4148

R451 4.7 1/4W

C450 100uF 16V

+14V_V
R311 1K 1/6W R310 C Q301 KSC945-Y C305 4.70NF 100V P 3.3K 1/6W R309 8.2K 1/6W D302 1N4148 V_FLB

C540 1nF 1KV

R541 180K 1/2W C552 220nF 100V MP R100 3W MO 5 R543 470K 1/2W CC R550 470K 1/2W CC
(2.43V) (2.49V) (0.23V) (1.3V) C457 100V MO 17/19NS 330pF 19MS 560pF OTHER OPEN R456 75K 1/6W R457 10K 1/8W C458 10NF 50V C459 100nF 50V MO
CMP VF SENSE RC GND OUT VCC REF +210V C301 1000uF 16V 105C C302 100nF 50V MO D303 1N4148 +5V Vcc_L R312 1.2 1/2W FU E
B V_SYNC_OUT R308 10K 1/6W
VOUTPUT VCC_H IC301 GND VinF.G KA2142 Vin+ C304 1uF 50V

R542 180K 1/2W

H_SUBSIZE

R490 22K 1/4W MF

C456 1nF 100V PP
(11.68V) (4.99V) R468 4.7K 1/8W

(7.54V)

C559 100pF 1KV
ONLY 10K OTHER OPEN +12V R460 12K 1/4W MF R462 18K 1/4W MF D478 1N4148 C462 27nF 100V P R463 1K 1/4W R464 1K 1/4W B E Q451 KSC945-Y B C Q453 KSA733-Y Q452 C KSC945-Y B C E E +12V

D301 UF4001(T)

C303 220UF 35V 105C
C B E R546 1K 1/8W R547 1K 1/8W Q540 KSP44
EW_OUT R459 1/4W MF 19MS 24K OTHER 27K H_SIZE R461 4.7K 1/4W R402 2.2K 1/4W

R1/2W C306 1uF 63V MP

C307 100nF 100V P

C308 1000uF 16V 105C

C463 47uF 25V R466 2.7K 1/4W
HS401 SUPLVAL ZD450 UZ12BM S G C465 10NF 500V C466 10uF 250V 105C R313 1/4W 8.2K MF
R314 1/4W MF 17/19NS 2.4K 17IS 2K OTHER 2.2K R315 1/4W 68 17IS 150 OTHER 120
R301 1/4W 15K MF R302 17/19NS 7.5K 1/4W 17IS 6.2K MF OTHER 6.8K C310 5.60NF 100V P R303 0.9 2W WW R1/2W R305 1.5K 1/4W

C312 1uF 63V MP

C550 100pF 50V
V_OUT R1/2W Vcc1 Vcc2 Vcc3 IC403 AN5452 H_LIN C440 3.3uF 50V 3 (TILT) CN409 slcon3p +12V R2W MO

C464 33nF 250V P

Q454 SFP9634 R467 2.2 1/2W FU D 100V 1.2nF C467

C460 27NF 100V P

D454 1SS244

5 GND1

CN401 slcon4p 1 EY409 EYE1.2 T402 EI-2820 C468 100pF 2KV EY408 SNAME 1 BD401 1.2UH,3.5_5.7MM L402 17/19/NS 2.7mH OTHER 3.5mH C B E C406 330nF 100V MP CN420 R406 slcon1p 1/2W 8 R407 1.2 3W MO D19NS SB540L-5705 OTHER SB340 HS402_1 heat_sink R444 3.3 1/2W C433 100nF 50V MO EY411 EYE1.slcon1p CN421 Q402 2SC5583 FJL6820 EYEYE1.5 HS402 SUPLVAL 1 EY401 SNAME 1 EY402 SNAME 1 EY403 SNAME 1 EY404 SNAME EY410 SNAME 1 MO2W 150 D404 UF4007 D403 SDS10U150S 10F150S C408 2.5KV PP 2.2nF C409 30.000 P 2.700000 R411 AQ19FS: DELETE 75ohm CE 5W 1 500V 1NF 1 CN411 HORZ-DY 4 EY440 SNAME 1 L403 BH26-00048A 19NS 3.9uH OTHER 5uH 1 SNAME EYC461 220pF 1KV 9

D456 19NS UF5404L-5709 OTHER RG10

100V 56nF C309 P

4 0-5v_1 AN5451 0-5v_2
R428 18K 1/8W R434 1K 1/8W 17HS 300NF 19NS 300NF OTHER 180NF C414 1uF 250V MPS 17HS 560NF 19NS 680NF OTHER 470NF 19NS 180NF 19MS/IS 120NF OTHER 100NF C417 100nF 250V MPS Q406 SKS10N20 D G S S G S D Q407 SKS10N20 G C418 400V 68nF P R420 1K 1/8W R421 1K 1/8W R422 1K 1/8W R423 1K 1/8W C B E C412 220nF 63V MP EY413 SNAME EY412 SNAME HS409 SUPLVAL Q408 KSC945-Y 1.2K 1/6W C R424 18K 1/6W B E Q409 KSC945-Y 1.2K 1/6W R431 S3 C B E Q410 KSC945-Y 1.2K 1/6W R430 S2 R427 18K 1/6W Q411 KSC945-Y C B E Q412 C KSC945-Y R433 B E 1.2K 1/8W
+29V CN407 slcon1p 1 R401 3WMO 19NS 82 CN408 slcon1p 1 CN414 slcon1p 1
R435 TCO 330 slcon1p 1/2W 1

19NS 1.2uF OTHER 1uF

T401 2.7mH R400 3W MO 19NS EI-2519 19NS 82 OTHER EI-2218 2.5MH 17NS 10 OTHER OPEN OTHER 5.R3W MO CN415 slcon1p 6 7

C405 330nF 100V MP

EYE1.5 EY420

C415 560nF 250V MPS

C416 300nF 250V MPS Q405 SKS10N20

R3W MO

D405 UF4007 D406 UF4007

VR401 vr3 100ohm

R1/2W R1/2W
C413 400V 100nF P 17HS 120NF 19MS 120NF OTHER 100NF
R432 1.2K 1/8W R429 S1 S4
D D G S Q403 SKS10N20 G S Q404 SKS10N20 D407 UF4004

R426 18K 1/6W

1 C401 47uF 100V 105C +80V D401 UF4004 Q401 H_DRIVE R404 SKS4N20 G 220 1/6W S C402 100pF 500V
R1/2W OTHER 560 C403 1nF 500V

C404 27nF 100V P

EY405 EYE1.5 1

19NS 2.2NF OTHER 2NF

19NS 2.7NF OTHER 2NF

R414 100K 3W MO

R425 18K 1/6W
C411 MPS 400V 120nF 17/NS 100NF 17/19/IS 100NF OTHER 120NF

C407 330nF 100V MP

D408 UF4001(T)
R409 3W MO 17/19NS 1.2 OTHER 1ohm
10-1-3 AQ17** & AQ19** Main Part Schematic Diagram
AQUILA PROJECT POWER CIRCUIT WARING: BEFORE SERVICING THIS CHASSIS, CAUTION 1. THE AREAS MARKED WITH A IN THE SCHEMATIC DIAGRAM AND THE PARTS LIST DESIGNATE COMPONENT WHICH HAVE SPECIAL CHARACTERISTICS IMPORTANT FOR SAFETY AND SHOULD BE REPLACED ONLY WITH TYPES IDENTICAL TO THOSE IN THE ORIGINAL CIRCUIT OR SPECIFIED IN THE PARTS LIST. BEFORE REPLACING ANY OF THE COMPONENTS, READ CAREFULLY THE "PRODUCT SAFETY NOTICE". 2. DRAWING A NUMEROUS MEASUREMENT OF THIS MONITOR MATTERS THAT DEMAND SPECIAL ATTENTION IS FOLLOWING 1)DO NOT USE YOUR INSTRUMENT BETWEEN PRIMARY GROUND (SYMBOL ) AND SECONDARY CIRCUIT. 2)DO NOT USE YOUR INSTRUMENT BETWEEN SECONDARY GROUND (SYMBOL ) AND PRIMARY CIRCUIT. READ "X-RAY RADIATION PRECAUTION,SAFETY PRECAUTION, PRODUCT SAFETY NOTICE". WARNING: "THIS EQUIPMENT CONTAINS SAFETY CRITICAL COMPONTS ALL PARTS SHOWN IN THE SHADED AREAS OF THE SCHEMATICARE SAFETY REPLACE SAFETY CRITICAL COMPONENTS ONLY WITH MANUFACTURERS RECOMENDED PARTS LIST FOR EXACT REPLACEMENTS".

NOTE 1. RESISTANCE IS SHOWN IN OHM K=1000, M-1000000. RATED POWER OF RESISTOR NOT NOTED IN SCHEMATIC DIAGRAM IS 1/6W. 2. CAPACITANCE IS SHOWN UF AND NOT NOTED CAPACITANCE IS SHOWN PF. 1UF=1000000PF. RATED VOLTAGE OF CONDENSER NOT NOTED IN SCHEMATIC DIAGRAM IS 50V. 3. ABBREVIATION AND SYMBOL MO:R-METAL-OXIDE MO:C-MONOLYTIC WW:R-WIRE WOUND NPO:C-NPO FU:R-FUSIBLE PP:C-POLYPROPYLENE MF: R-METAL FILM MP:C-M.POLYESTER CC:R-COMPOSITION MPP : C-METAL POLYPROPYLENE P:C-POLYESTER T:C-TANTALIUM PRIMARY GROUND SECONDARY GROUND C652 220UF 16V
+12V 19"FST DEL R1/4W IC651 KA78R3 Vout GND Vin 1 R672 47K 1/6W R673 2.7K 1/6W D670 BZX79C5V6 B E HS651 heat_sink R674 10K 1/8W +12V +14V Q670 KTA1281-Y C E +14V_V

BD651 B

AVERTTISSMENT: " CE RECEPTEUREST EQUIPE DE COMPOSANTS CRITIQUES POUR LA SECURITE TOUTESLES PIECES INDIQUEES DANS LES ZONES OMBREES DU SCHEMA SONT CRITQUEPOUR LA SECURITE DE LAPPAREIL NE REMP LACER LE FABRICANT DONT LE FONCTIONNEMENT EST CRITITE QUE PAR DES PIECES RECOMMANDEES PAR LE FABRICANT CONSULTER LA NOMENCLAYURE DES PIECES POUR TROUVER."
4. THE SECONDARY VOLTAGE IS READ WITH SSVM FROM INDICATED POINT TO SECONDARY GROUND ( ) THE PRIMARY VOLTAGE IS READ WITH SSVM FROM INDICATED POINT TO PRIMARY GROUND ( ).
5. THIS SCHEMATIC DIAGRAM IS SUBJECT TO CHANGE WITHOUT NOTICE FOR FURTHER IMPROVEMENT. EY6 EYE2.2 EY61 EYE2.2

C653 100nF 50V

Q671 KSC945-Y
D602 1N4148 C B R604 10K 1/8W DEGAUSS Q601 KSC1008-Y R651 4.7K 1/8W BB

+14V_I

TO DEGAUSSING COIL RL601 G5PA-slcon3p CN1
IC650 MC7805CT INOUT GND C650 100UF 16V C651 10NF 50V
POS601 J503P61D4R5Q270S 17NS/19MS 10ohm 19NS 4.5ohm OTHER 9ohm
BD603 1.2UH,3.5*5.7MM 1 B EYEYE2.2 R670 180K 1/2W CC R671 180K 1/2W CC C610 10nF 500V R606 100K 1/2W R607 120K 1/2W 1 EY614 EYE1.5 C611 220pF 1KV D604 UF4007 EYE1.5 EY6 2
T601 19NS EER4042 OTHER ER16 EY615 EYE1.5
D640 UF4004 C654 1000uF 16V 105C D641 UF5404 HS606 heat_sink D642 UF1G C642 1000uF 16V 105C E B C Q672 KTA1281-Y R675 0.56 1/2W +6.3V +14V C641 1000uF 16V R676 2.2K 1/8W R677 1K 1/8W +14V_I
CN602 slcon1p TH601 SKC-084 1

CN603 slcon1p

D601 D5SB4 19NS D5SB60 OTHER D3SBA60
C607 WITH PFC 220uF 450V 220uF 450V EYEYE2.2
IC601 DP308P C605 10nF 500V F_B DRAIN GND 5 Vcc SYNC BD604
7 D606 TVR10G C612 100pF 1KV KPJ-2S1BB CN608 slcon1p 1 1

SNAME EY616

-14V D644 RG10Z-V1 C643 470UF 16V
HS601 heat_sink EYEYE2.2 EYEYE2.2 C608 33uF 50V 105C R601 150K 1/4W R602 150K 1/4W PFC CIRCUIT D703 1N5397GP 1 EY611 EYE2.2 EY612 EYE2.2

D605 UF4007 1

R688 10K 1/8W
R608 6.8K 3W MO CN609 slcon1p

D645 31DF6

HS60 heat_sink

R644 33K 1/2W

BD109 1.2uH

INT ROSD
R139 R140 R141 1/10W R1/10W 330 1/10W

R123 30M 1/4W CC

3 R128 5.6K 1/10W R129 12K 1/10W 4 R130 6.8K 1/10W 7 1G 10

R120 10K 1/10W

R122 1.5K 1/10W

C138 47uF 16V

Q106 KSC945-Y

ZD103 BZX79C5V6

C122 220UF 16V

C123 100nF 25V MO

IC106 AN5451

0-5v_1

56 2WMO

H_FLB2

R132 1K 1/10W

OSDSW H_CG

SDA SCL
R133 1K 1/10W C129 100PF 50V MO C130 100PF 50V MO

R144 3.9K 1/10W

ACL_ADJ

C137 4.7uF 50V

C100 100PF 50V MO
R1/10W R125 2.7K 1/10W C124 10nF 100V P

0-5v_2

R2W MO

V_CG H_FLB1

slcon4p CN103

1L R137

R131 1K 1/10W

H_FLB V_CG

D101 E 1N4148

Q104 2N3904

F_CONT
C131 100nF 25V MO R136 4.7K 1/10W C132 1uF 50V C133 1uF 50V

L101 0.47uH

H H2 IC1 IC2 G1 G2 G3 G4

+5V +5V +5V +5V

DR01 1N4148 DG01 1N4148 DB01 1N4148 RR1/10W CR01 100nF 25V R1/6W

L100 27uH

j_c11p

AQ17NS

L102 1.5uH
C114 100pF 50V C115 100UF 16V

C142 100UF 16V

C104 470uF 16V C113 220uF 16V

C108 15PF 50V MO

HS102 SUPLVAL

C110 100nF 25V MO

C111 100nF 25V MO

C112 470uF 16V

L107 1.5uH

KA2503

1 ROSD 2 GOSD 3 BOSD 4 OSDSW 5

R1/10W

CN101 slcon6p 1
18 C16V 100UF RB1/10W RG1/10W RR1/10W
CB02 100nF 25V MO CG02 100nF 25V MO CR02 100nF 25V MO
ROSD GOSD BOSD OSD-SW RIN Vcc1 gnd1 GIN
B/U RCLP-C R-OUT GCLP-C G-OUT Vcc3 GND3 B-OUT
C109 100nF 25V MO CR03 100nF 25V MO RG1/10W 7

LM2413T 2412T 1

GND VOUT1
DR03 DG03 DB03 BAV21 BAV21 BAV21

C117 10uF 100V 105C

RR09 270K 1/4W

RG09 270K 1/4W

RB09 270K 1/4W LR01 N 80NH RR1/10W
3 BK 2 GK 1RK 1RK 2 GK 3 BK
RB1/10W RR1/10W CR04 1uF 160V

RR1/2W

j_c11p LG01 N 80NH RG1/10W RG1/2W 10 11

30 CG03 100nF 25V MO

RR1/10W

G-IN R-IN

VIN3 GND1

VIN2 VOUT2

RG1/10W RB1/10W
CG01 100nF 25V CB01 100nF 25V

AQ17IS/HS

4 RGG-OUT 1/10W CG04 1uF 160V

1D 1E 1F

RR1/10W B-IN RG1/10W RB1/10W

VBB VOUT3

GND RIN

VIN1 VCC

RB1/10W RB1/2W BD105 1.2uH CN12

OSD-SW RIN Vcc-R

Vcc R-OUT NC

C124 100UF IC105 16V B/MASTER 5

IC101 M52748ASP

M52748SP
C120 33PF 50V MO RR1/10W RR1/10W

C107 100nF 50V MO

IC102 LM2412AT RB31 7

1/10W LR03 0.07uH RG1/2W

C188 100nF 50V MO R1/10W L105 RR1/10W 100nF 50V MO RG1/10W RB1/10W CR02 47uF 16V

1 OSDSW 2

26 RB04 6.8K 6.8K 6.8K 1/10W C110 3.3uF 50V

GND G-IN 9

B-OUT GND 3

CN101 slcon6p

DG01 MMBD4148SE

GIN GND

GND ROUT TEST FBLK VSS VDD HFLB VFLB SCL SDA

CG01 100nF 50V RG1/10W

4 ROSD ROSD CR03 MO 100nF 50V 5 GND CG02 47uF 16V 8

Vcc-G GIN SOG IN

C186 100nF 50V MO

CR01 100nF 50V

VCC BIN

BOUT VCC

RR31 15

CR14 1uF

100V RG1/10W

R-IN RG1/10W RG1/10W

R-OUT GND RG1/10W CG14 1uF 100V LG03 0.07uH

j_c11p 1011

GND G-OUT

RB1/10W

B-IN RB1/10W

6 CB01 100nF 50V

RIN VSSA VCOIN VREF VICTL VDDA SDA

BRT/L B-OUT

C111 100nF 100V MO

CB14 1uF 100V

RB1/2W
C112 10uF 100V 105C LB03 0.07uH BD181 1.2uH CN12

LR01 0.47uH

LG01 0.47uH

LB01 0.47uH

RG1/10W

DBMMBD4148SE

GOSD 10 CG03 100nF 50V MO BOSD CB03 100nF 50V MO 17

C126 100UF 16V

H_SYNC

BIN Vcc-B BOSD

B-CUT G-CUT R-CUT

CR04 15PF 50V MO RR1/10W

CG04 15PF 50V MO RG1/10W

CB04 15PF 50V MO RB1/10W

DR04 BAV21

DG04 BAV21

DB04 BAV21 DR05

SK101 DG05

SK103 X3 C181 1nF 2KV

R191 1K 1/10W

25 RGRR04

DMS-200D DB05

SK108 SSG-102B2

R1/6W C115 0.68NF 50V MO

R187 30M 1/4W

C122 6.8nF 50V

C180 100UF 16V

NOT USE

R1/10W BD104 1.5uH

GND ABL B/U

BRIGHT GND SDA

IC104 LM2480NA $P C F E

BD102 1.2UH,3.5*5.7MM CR16 100nF 100V P

DMS-200D

MMBD4148SE

C182_1 100nF 50V

R180 8.2K 1/10W R189 12K 1/10W

R190 6.8K 1/10W

BD103 R111 10K 1/10W R1/6W
C109 100nF 50V MO R113 22K 1/10W R196 10K 1/10W

RCUT GCUT

100 1/10W

C182 100nF 50V MO

SCL CLAMP

L104 1.5uH

CR20 10uF 25V CG20 10uF 25V CB20 10uF 25V
CB16 100nF 100V P R1/2W C183 4.70NF 500V

R108 4.7K 1/10W

R112 2.7K 1/10W

C116 4.7uF 50V

DIRECTION SENSOR PCB

MANUAL PR : RCA JACK IN, NO, MAX, 2-8KG
10-6 BNC Part Schematic Diagram

+5V +5V +5V +3.3V

+5V_DDC

DB51 1N4148

DG51 1N4148

DR51 1N4148

C151 100nF 50V MO

UPSTREAM slcon6p

C159 10uF 25V

C160 100nF 50V MO

ZD159 UZ-6.2BM CN104 slcon5p SELECTOR

USB_DM D_SUB tpcon15p 15

USB_DP
V C97 100nF 50V DDC_CLK RB1/6W RG1/6W RR1/6W MO RR1/6W IC1

BA7657S

G1 GND B1 H1

VCC G_O S_IN COM

RG1/6W RB1/6W
CG51 10uF 25V CB51 10uF 25V

ZD156 UZ-6.2BM R1/6W

UZ-6.2BM

C95 47PF 50V

RR1/6W RG1/6W
CR52 10uF 25V CG52 10uF 25V CB52 10uF 25V 9

B_O H_O V_O V2 H2

EY101 SNAME EY102 SNAME EY103 SNAME EY104 SNAME EY105 SNAME

DB53 1N4148

DG53 1N4148

DR53 1N4148

RB1/6W

D_SUB JACK BNC JACK

ZD160 UZ-6.2BM

USB_DM

B H DB52 1N4148 DG52 1N4148 DR52 1N4148 BD151 1.2UH,3.5*5.7MM

ZD161 UZ-6.2BM

C98 10uF 25V

+12V +5V

R155 15K 1/6W R1/6W SELECTOR CN105 slcon9p

DDC_DATA R1/6W

CR51 10uF 25V

KA2507 R1 GND CTL R_O

QR52 2N5770

CR53 100nF 50V MO

S_RASTER

RR1/6W

RG1/6W
C96 100nF 63V MP R137 1K 1/8W QG52 2N5770

C152 47PF 50V

CG53 100nF 50V MO
ZD152 UZ-6.2BM ZD151 ZD153

ZD154 UZ-6.2BM ZD155

RB1/6W R159

(17" SHORT)

GND G2 GND
33 1/6W R98 10K 1/8W R1/6W

CB53 100nF 50V MO

QB52 2N5770

SOG-OUT

IC3-1 MC74HCT14AN

14 VCC 2 14

IC3-2 MC74HCT14AN
G-BNC B -BNC H-BNC V -BNC

IC3-5 MC74HCT14AN

14 VCC 10

IC3-6 MC74HCT14AN

14 VCC 12

V_SYNC

DB54 1N4148

DG54 1N4148