CDP-XB930/XB930E

SERVICE MANUAL

AEP Model

CDP-XB930

UK Model E Model

CDP-XB930E
PHOTO : CDP-XB930 (BLACK Model)
Manufactured under license from Dolby Laboratories Licensing Corporation. DOLBY and the double-D symbol a are trademarks of Dolby Laboratories Licensing Corporation.
Model Name Using Similar Mechanism CD Mechanism Type Base Unit Type Optical Pick-up Type
CDP-XB920/XB920E CDM36C-14D BU-14D KSS-213B/K-N

SPECIFICATIONS

Compact disc player Laser Semiconductor laser ( = 780 nm) Emission duration: continuous Laser output Max 44.6 W* * This output is the value measured at a distance of 200 mm from the objective lens surface on the Optical Pick-up block with 7 mm aperture. Frequency response Signal-to-noise ratio Dynamic range Harmonic distortion Channel separation Outputs
Jack type Phono jacks DIGITAL Optical OUT output (OPTICAL) connector DIGITAL Coaxial OUT output (COAXIAL) connector Stereo PHONES phone (only for CDP-XB930) jack LINE OUT Maximum output level 2V (at 50 k) 18 dBm 0.5 Vp-p (at 75 ) 10 mW Load impedance Over 50 k Wave length:660nm
General Power requirements Power consumption Dimensions (approx.) (w/h/d) Mass (approx.)
220 V 230 V AC, 50/60 Hz 15W 290 mm (5/1/2 in.) incl. projecting parts 6.0 kg (13 lbs 04 oz)
2 Hz to 20 kHz 0.5 dB More than 113 dB More than 99 dB Less than 0.0025% More than 105 dB
Supplied accessories Audio cord (2 phono plugs2 phono plugs) (1) Remote commander (remote) (1) R6 (size AA) batteries (2) Stabilizer (1) Design and specifications are subject to change without notice.

COMPACT DISC PLAYER

MICROFILM

TABLE OF CONTENTS

CAUTION
1. SERVICING NOTE 5 2. GENERAL 6 3. DISASSEMBLY
Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure.
The laser component in this product is capable of emitting radiation exceeding the limit for Class 1. This appliance is classified as a CLASS 1 LASER product. The CLASS 1 LASER PRODUCT MARKING is located on the rear exterior.
3-1. Slide Rack 8 3-2. Front Panel 8
4. TEST MODE 9 5. ELECTRICAL BLOCK CHECKING 11 6. DIAGRAMS
6-1. 6-2. 6-3. 6-4. 6-5. 6-6. 6-7. 6-8. 6-9. 6-10. 6-11. 6-12. 6-13. 6-14. 6-15. Circuit Boards Location 13 Block Diagram 14 Schematic Diagram Main Section (1/2) 15 Schematic Diagram Main Section (2/2) 16 Printed Wiring Board Main Section 17 Schematic Diagram Display Section 18 Printed Wiring Board Display Section 19 Schematic Diagram Power section 20 Printed Wiring Board Power section 21 Schematic Diagram Servo section 22 Printed Wiring Board Servo section 23 Schematic Diagram Motor section 24 Printed Wiring Board Motor section 24 IC Block Diagrams 25 IC Pin Function Description 27
This caution label is located inside the unit.
7. EXPLODED VIEWS 31 8. ELECTRICAL PARTS LIST 36
Notes on chip component replacement Never reuse a disconnected chip component. Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing Keep the temperature of soldering iron around 270C during repairing. Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). Be careful not to apply force on the conductor when soldering or unsoldering.
MODEL IDENTIFICATION BACK PANEL
4-219-772-0: XB930 (AEP) model 4-219-772-1: XB930E (UK) model 4-219-772-2: XB930E (Singapore) model
SAFETY-RELATED COMPONENT WARNING !! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.

* Other channel is infinity zero.
Table 2: CD-TEXT TEST DISC Recorded Contents and Display (TRACKS NO. 33 to 99) (In this unit, some special characters cannot be displayed. This is no a fault.) TRACK 67 to 99
Recorded contents 100Hz/0dB/R* 1kHz/0dB/R* 10kHz/0dB/R* 20kHz/0dB/R* 100Hz Squer Wave //L&R 1Hz Squer Wave //L&R 1kHz w/emphasis/-0.37dB/L&R 5kHz w/emphasis/-4.53dB/L&R 16kHz w/emphasis/-9.04dB/L&R ! ( # $ %& (21h to 27h)1kHz 0dB L&R ( ) * + 89 =
Display 0 H Z / 0 D B/R are not displayed 1 K H Z / 0 D B /R are not displayed K H Z / 0 D B/R are not displayed K H Z / 0 D B/R are not displayed 0 HZ 1 KHZ S Q uer Wave //L&R are not displayed S Q U er Wave //L&R are not displayed
1 K H Z W / E mphasis/-0.37dB/L&R are not displayed 5 K H Z W / E mphasis/-4.53dB/L&R are not displayed K H Z W / emphasis/-9.04dB/L&R are not displayed ! # $ % & (21h to27h)1kHz 0dB L&R are not displayed / ,. (28h to 2Fh) are not displayed ? : ; < > (38h to 3Fh) are not displayed

) * + , . / (28h to 2Fh)

(30h to 37h) : ; < = > ? (38h to 3Fh) @ A B C D E F G (40h to 47h) H I J K L M N O (48h to 4Fh) P Q R S T U V W (50h to 57h) X Y Z [ ] ^ _ (58h to 5Fh)
(30h to 37h) are not displayed A B C D E F G @ (40h to 47h) are not displayed H I J K L M N O (48h to 4Fh) are not displayed P Q R S T U V W (50h to 57h) are not displayed X Y Z [ \ ] ^ _ (58h to 5Fh) are not displayed
a b c d e f g (60h to 67h)
h i j k l m n o (68h to 6Fh) p q r s t u v w (70h to 77h) x y z { I } ~ i C
A B C D E F G (60h to 67h) are not displayed
H I J K L M N O (68h to 6Fh) are not displayed P Q R S T U V W (70h to 77h) are not displayed XYZ { I } ~ (78h to 7Fh) are not displayed All no displayed C P R (A8h to AFh)are not displayed
(78h to 7Fh) (A0h to A7h) 8859-1

PR (A8h to AFh)

(B0h to B7h)
m (B0h to B7h) are not displayed 1
(B8h to BFh) Y Y NO. 66 NO. 67 to NO. 99

1 Two connectors 6 Five screws (+BV 3 8)
7 Front panel (Disengage claws to remove the rack.)

SECTION 4 TEST MODE

4-1. AF MODE
The following checks can be performed in the AF mode, which is set by connecting the TP51 (AFADJ) terminal on MAIN board to the Ground and turning on the power. FL tube check After all segments light up, when the button is pressed, the following will be displayed. (Partial lighting 1)
Button LANGUAGE MUSIC SCAN AUTO SPACE PEAK SEARCH PLAY MODE Button No. Displayed Button EDIT/ TIME FADE CHECK CLEAR P ENTER OPEN/CLOSE PLAY STOP p ALL lit Partial lighting 1 Partial lighting Button No. Displayed

A B C D E F

REPEAT

(Partial lighting 1)

FADER TIME/TEXT 0 )
When the p button is pressed, the following will be displayed. (partial lighting 2)
(Partial lighting 2) 4 10
When you turn the AMS knob clockwise

JOG RIGHT

When you turn the AMS knob counter-clockwise
When the OPEN/CLOSE button is pressed, all will light up again. Key check All buttons have corresponding button numbers. When a button is pressed, the counter will count up and display the buttons number. However, the counter will only count to 18. It will not count for buttons already pressed once, but will display the buttons number.(Partial lighting 3)

JOG LEFT

Remote commander check When the button of the remote commander is pressed, the following will be displayed. All go off when the other buttons are pressed. (Partial lighting 4)

Display of button number

88 TOTAL 88

(Partial lighting 4)

Display of counting

(Partial lighting 3)

Audio check Initial setting of digital filter and release of mute. When the TP51 (AFADJ) terminal on MAIN board is set to HIGH (VDD), emphasis turns on. When set to LOW (Ground), it turns off.

4-2. ADJ MODE

The following operations are performed in the ADJ mode, which is set by connecting the TP21 (ADJ) terminal to the Ground and turning on the power. During playback, there is no problem even if the GFS is continuously LOW. High speed search is prohibited during access. During playback, the gain of focus servo and spindle servo does not decrease. Servo related manual operations and measurement can be performed. (For details of operations, refer to Table of Key Operations in ADJ Mode.)

PHOTO DETECTOR VCC 7 VC 8 A 4 B 2 C 1 D 5 E 6 F 10 Q101 LD LD DRIVER 3 LD +5V 12 VC 5 A 6 B 7 C 8 D 11 E 10 F FE 14 TE 13 VC RF AMP IC103 RFO 16 RFI 17
DIGITAL SERVO/ DSP ICRF AC D OUT 64 DSP/ D/A CONV. ICRF DC PCMD 66 BCLK 67 LRCK CE 39 FE 41 TE 40 SE XTAI 71 DATA XLT D310 XRST 2 MUTE INIT 9 SYSM R1(+) 37 R1(-) 36 R2(+) 33 R2(-) IN1(+) 17 IN1(-) 20 IN2(+) 21 IN2(-) IOR+ 6 IOR- 5 IC402 I/V CONV. MUTE Q402 HP AMP IC304 L.P.F IC401 16.9M 3 IC203 5.6M 3 DATA 2 BCK 4 LRCK 54 128FS 6 ATT 7 SHIFT L1(+) 21 L1(-) 20 L2(+) 24 L2(-) 25 CURRENT PULSE D/A CONV. ICIN1(+) 26 IN1(-) 23 IN2(+) 22 IN2(-) IOL+ 35 IOL- 36 IC502 I/V CONV. MUTE Q502 L.P.F IC501
IC208 IC251 OPTICAL DIGITAL OUT SIGNAL PATH :CD IC251 J351 COXIAL :DIGITAL OUT

J301 LINE OUT

SENS 7 LD SW Q102 AGC ON 21 LD ON 22 SQCK 77 SCLK 8 SQSO 76 SCOR PD FCS/TRK COIL SL/SP MOTOR DRIVER ICLATCH

RV350 MUTE Q504

J350 PHONES

Q303 D353 MUTE L 51

Q302 D354 MUTE R 9 FFDR FRDR TFDR TRDR 33 FFDR 34 FRDR 31 TFDR 32 TRDR X301 45MHz XO 28 XI 29 D352 D351

MUTE Q404

F+ FOCUS COIL F T+ TRACKING COIL T

FOCUS COIL DRIVE

J352 Q621 D621 S LINK CONTROL A1

TRACKING COIL DRIVE

IC903 +12V 1 REG IC904 -12V 2 REG IC905 DAC +B 3 REG ICDAC -B A UNREG +10V 2 REG D923 D921 D901-904 D924 D925 POWER TRANSFORMER T3

M102 SLED MOTOR

SLED MOTOR DRIVE

MUTE 15

SFDR SRDR MDP
29 SFDR 30 SRDR 25 MDP 26 S STOP 5

M101 SPINDOL MOTOR

SPINDLE MOTOR DRIVE

IC920 RESET

S151 LIMIT

A UNREG -10V D101

RECT L901
S152 LOAD IN S153 LOAD OUT
D UNREG +10V M UNREG +10V IC901 M +7V 34 LOAD SW LD ON RF GH SCOR SENSE SUBQ SQCK 24 CLK XLT DATA 16 D MUTE 17 PGML 49 A MUTE BUS OUT BUS IN 38 RESET IC802 RM IN 8 VFDP(-30V) 45 REMOTE SENSOR D +5V LPF901,902 L.P.F LPF903 L.P.F Q951 SENSOR SW 13 LOD IN EXTAL 12 LOD OUT SENSOR 3 REG ICREG 1 1
D911-914 RECT S991 D951-954 RECT AC IN
LOADING MOTOR DRIVE ICL+ LOADING MOTOR L+ L

SYSTEM CONTROL IC801

XTAL 7 L 16

FILTER SW

31 LPF905 G1-14 S1-21 L.P.F FL2 L.P.F LPF904
X501 8MHz FL1 SENSOR SWITCH Q301,302 ROTARY ENCODER S550 FUNCTION KEY S601-608 FUNCTION KEY S511-515 ENTER (AMS) S531 FUNCTION KEY S521-524

SENSOR IC361,D361

FLURESCENT DISPLAY TUBE FL501
6-3. SCHEMATIC DIAGRAM MAIN SECTION (1/2)
Refer to page 13 for Waveforms. Refer to page 25 for IC Block Diagram.
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
6-4. SCHEMATIC DIAGRAM MAIN SECTION (2/2)
Refer to page 25 for IC Block Diagram.

6-5. PRINTED WIRING BOARDS MAIN SECTION
Refer to page 13 for Circuit Boards Location. Semiconductor

Location

Ref. No. D261 D262 D263 D264 D301 D302 D303 D305 D306 D307 D308 D310 D311 D312 D351 D352 D353 D354 D355 D356 D957 IC203 IC208 IC251 IC301 IC302 IC304 IC401 IC402 IC501 IC502 IC902 IC903 IC904 IC905 IC906 IC920 Q302 Q303 Q402 Q403 Q502 Q503 Q951
Location C-3 C-3 B-4 B-4 E-9 F-9 D-9 D-9 D-10 D-11 D-11 E-11 D-3 E-6 F-11 G-11 F-11 F-11 E-2 F-2 B-10 F-11 C-2 B-3 E-10 E-8 B-6 F-4 F-6 D-4 C-6 C-9 D-3 E-6 C-8 F-6 B-8 G-3 G-3 G-2 B-7 D-2 B-7 B-9

HP BOARD

PHONE LEVEL

1-669-372-

XB930 MODEL
6-6. SCHEMATIC DIAGRAM DISPLAY SECTION
Refer to page 13 for Waveforms. Refer to page 27 for IC Pin Function Description.
6-7. PRINTED WIRING BOARDS DISPLAY SECTION
Refer to page 13 for Circuit Boards Location.

Semiconductor

Ref. No. Location D-4 E-3 C-5 C-9 E-4 C-3 C-2 D621 D958

DISP BOARD

FL501 (FLUORESCENT INDICATOR TUBE) 3 1
IC801 IC802 Q621 Q801 Q802

E E EDIT/ TIME FADE

CLEAR E CHECK

1-669-369-

TO MAIN BOARD (Page 17)

KEY BOARD

ROTARY SW BOARD

TIME/ TEXT

PLAY MODE

FILTER

11 (11)

CANGUAGE

MUSIC SCAN

AUTO SPACE

PEAK SEARCH

1-670-212-

1-669-371-
6-8. SCHEMATIC DIAGRAM POWER SECTION
6-9. PRINTED WIRING BOARDS POWER SECTION
Ref. No. D901 D902 D903 D904 D911 D912 D913 D914 D921 D922 D923 D924 D925 D951 D952 D953 D954 IC901 Location F-3 F-3 G-3 E-3 D-2 D-2 D-2 C-2 G-4 G-4 G-3 G-3 H-3 E-3 E-3 D-3 E-3 B-3

POWER BOARD

TRANS BOARD

TO SERVO BOARD (Page 23)

T901 POWER TRANSFORMER
X NOT REPLACEABLE BUILT IN TRANSFORMER

12 1-669-373(12)

POWER SW BOARD

1-669-36816

(POWER)

11 1-669-370(11)

6-10. SCHEMATIC DIAGRAM SERVO SECTION
Refer to page 13 for Waveforms. Refer to page 26 for IC Block Diagram Refer to page 27 for IC Pin Function Description.
6-11. PRINTED WIRING BOARDS SERVO SECTION
Ref. No. D101 D361 IC101 IC102 IC103 IC104 IC361 Q101 Q102 Q301 Q302 Location G-6 G-5 E-4 C-5 E-2 C-2 F-3 D-3 E-3 F-3 G-3
6-12. SCHEMATIC DIAGRAM MOTOR SECTION 6-13. PRINTED WIRING BOARDS MOTOR SECTION

SLED BOARD

SPINDLE BOARD

LIMIT SW

M151 SPINDLE MOTOR

1-658-708-

1-658-70911 (11)

TO OPTICAL PICK-UP BLOCK

LD IN SW BOARD

1 (LOADING) 2

1-666-164-

LOADING BOARD

TO SERVO BOARD (Page 23) M

M101 LOADING MOTOR

11 1-658-710(11)
6-14. IC BLOCK DIAGRAMS IC301 CXD8735N (MAIN BOARD)
INVO BCKI DATA1 LRCKI INIT ATT SHIFT LATCH SYSM
ATT S/P 5 OVERFLOW DETECTER MODE ATT 0 DETECT MUTE CIRCUIT ATT X0.75 OVERFLOW DETECTER OR D/F TIMNG CIRCUIT
56 INVI 55 TEST 54 128FsO 53 DINIT 52 OVFLAG 51 MUTEL 50 MUTER 49 NU FIR64FSI 47 MCKIN 46 DVSS1 DITHER 45 DVDD1 3rd order NOISE SHAPER ATT X0.DVDD256FSO CLOCK BUFFER 42 CKVdd 41 LVCKO 40 64FSO 39 DVSSAVDDR1 Buffer() Buffer(+) PLM-L1 PLM-R1 Buffer() Buffer(+) 37 R1() 36 R1(+) 35 AVSSRAVSSR2 Buffer(+) Buffer() PML-L2 PLM-R2 Buffer(+) Buffer() 33 R2(+) 32 R2() 31 AVDDRXVSS 29 XIN

FIR1 IIR

FIR2 FIR4
NU 10 NU 11 DVSSDVDDNU 14 CKCTL 15 MUTE 16 SYNC 17 VSUB 18 AVDDLL1() 20 L1(+) 21 AVSSLAVSSLL2(+) 24 L2() 25 AVDDLXVDD 27 XVDD 28 REGISTER

3rd order NOISE SHAPER

1024Fs-CLOCK BUFFER

CLOCK GENERATOR

IC104 LA6510L (SERVO BOARD)

VIN1 VIN2 +VIN2 6

VCC 10

VSENCE1 1

CURRENT LIMITER

VOUT1 2

9 VSENCE2
IC103 CXA2568M (SERVO BOARD)
IC302 CXA8055M (MAIN BOARD)
APC PD AMP VCC VEE HOLD 1 VEE AGCVTH 2 LD 3 VC PD 4 VREF
24 VCC 23 LC/PD 22 LD_ON CIREF 1 NC 2 AGND 3 NC 4
ANALOG VOLUME CONTROL CIRCUIT REFERENCE VOLTAGE CIRCUIT
42 RIREF 41 VREF 40 VCNT 39 AGND 38 AVCC 37 NC
APC LD AMP VCC 21 HOLD_SW 20 AGCCONT (50%/30% OFF) 19 RF_BOT VC
IOR 5 IOR+ 6 CCC7R 9 CONSTANT CONTROL CIRCUIT CONSTANT CONTROL CIRCUIT
36 IOL 35 IOL+ 34 C7L 33 AVEES

A B C D VEE

9 VEE VC VC VC VEE RF SUMMING AMP VC

AVEES 10 AVEES 11 LOGIC

32 AVEES 31 C4L 30 DVEE 29 DVCC 28 C1L

RF_EQ_AMP VC

18 RFTC 17 RF_RFO 15 RFE
C4R 12 CDVEE 14 C1R 15 DGND 16

ERROR AMP FOCUS 14 FE

1N1R 17 1N1+R 18 NC 19 1N2+R 20 1N2R 21

ECL SWITCHING CIRCUIT

27 DGND 26 1N1L 25 1N1+L 24 NC 23 1N2+L 22 1N2L
F 10 E TE VC VCC VEE VC VC TRACKING ERROR AMP

VC VC BUFFER VC 12

6-15. IC PIN FUNCTION DESCRIPTION

IC 101 DIGITAL SIGNAL PROCESSOR (CXD2585Q) (SERVO board)
Pin No. Pin Name DVDD XRST MUTE DATA XLAT CLOK SENS SCLK ATSK WFCK XUGF XPCK GFS C2PO SCOR CM4 WDCK DVSS COUT MIRR DFCT FOK PWMI LOCK MDP SSTP FSTO DVDD1 SFDR SRDR TFDR TRDR FFDR FRDR DVSS1 TEST TES1 VC FE SE I/O I I I I I O I I O O O O O O O O I/O I/O I/O I/O I I/O O I O O O O O O O I I I I I Digital power supply System reset L : reset Muting input H : mute Serial data input, supplied from CPU Latch input, supplied from CPU Serial data transfer clock input, supplied from CPU SENS signal output to CPU SENS serial data read-out clock input Input pin for anti-shock (Connected to GND) WFCK output (Not used) Not used Not used Not used Not used Sub-code sync output 4.2336 MHz output (Not used) Word clock output (f=2fs) Digital GND Numbers of track counted signal input/output (Not used) Mirror signal input/output Defect signal input/output Focus OK input/output Spindle motor external control input (Connected to GND) GFS is sampled by 460 Hz. H when GFS is H (Not used) Output to control spindle motor servo Input signal to detect disc inner most track 2/3 divider output of pin 71 Digital power supply Sled drive output Sled drive output Tracking drive output Tracking drive output Focus drive output Focus drive output Digital GND TEST pin connected normally to GND TEST pin connected normally to GND Center voltage input pin Focus error signal input Sled error signal input Description
Abbreviation GFS : Guarded Frame Sync

Pin No. 79 80

Pin Name TE CE RFDC ADIO AVSS0 IGEN AVDD0 ASYO ASYI RFAC AVSS1 CLTV FILO FILI PCO AVDD1 BIAS VCTL V16M VPCO DVDD2 ASYE MD2 DOUT LRCK PCMD BCLK EMPH XTSL DVSS2 XTAI XTAO SOUT SOCK XOLT SQSO SQCK SCSY SBSO EXCK
I/O I I I O I O I I I O I O I I I/O O I I O O O O O I I O O O O O I I O I Tracking error signal input Center servo analog input RF signal input Test pin (Not used) Analog GND

Description

Stabilized current input for operation amplifiers Analog power supply EFM full swing output Asymmetry comparate voltage input EFM signal input Analog GND Control voltage input for master VCO1 Filter output for master PLL Filter input for master PLL Charge-pump output for master PLL Analog power supply Asymmetry circuit constant current input VCO2 control voltage input for wide band EFM PLL (Connected to VDD) VCO2 oscillator input/output for wide band EFM PLL (Not used) Charge -pump output for wide band EFM PLL (Not used) Digital power supply Asymmetry circuit ON/OFF input L : OFF, H : ON (Connected to VDD) Digital-out ON/OFF control input (Connected to VDD) Digital-out output pin D/A interface LR clock output (f=Fs) D/A interface serial data output D/A interface bit clock output Playback disc output in emphasis mode (Not used) Xtal selection input (Connected to ground) Digital GND Xtal oscillator circuit input Xtal oscillator circuit output (Not used) Serial data output in servo block (Not used) Serial data read clock output in servo block (Not used) Serial data latch output in servo block (Not used) Sub-Q 80-bit and PCM peak level data output (CD text data output) Clock input for SQSO read-out Connected to GND Sub-P through Sub-W serial output (Not used) Clock input for SBSO read-out (Connected to GND)

I/O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O O Not used. Open Not used. Open Not used. Open Not used. Open Not used. Open Not used. Open Not used. Open Not used. Open Not used. Open Not used. Open Not used. Open Not used. Open Not used. Open Not used. Open Not used. Open Not used. Open
Fluorescent display tube segment 21 output Fluorescent display tube segment 20 output Fluorescent display tube segment 19 output Fluorescent display tube segment 18 output Fluorescent display tube segment 17 output Fluorescent display tube segment 16 output Fluorescent display tube segment 15 output Fluorescent display tube segment 14 output Fluorescent display tube segment 13 output Fluorescent display tube segment 12 output Fluorescent display tube segment 11 output Fluorescent display tube segment 10 output Fluorescent display tube segment 9 output Fluorescent display tube segment 8 output Fluorescent display tube segment 7 output Fluorescent display tube segment 6 output Fluorescent display tube segment 5 output Fluorescent display tube segment 4 output Fluorescent display tube segment 3 output Fluorescent display tube segment 2 output Fluorescent display tube segment 1 output Fluorescent display tube Grid 1 output 5 V, VDD Fluorescent display tube Grid 2 output Fluorescent display tube Grid 3 output Fluorescent display tube Grid 4 output Fluorescent display tube Grid 5 output Fluorescent display tube Grid 6 output Fluorescent display tube Grid 7 output Fluorescent display tube Grid 8 output Fluorescent display tube Grid 9 output Fluorescent display tube Grid 10 output Fluorescent display tube Grid 11 output Fluorescent display tube Grid 12 output

SECTION 7 EXPLODED VIEWS

NOTE: -XX, -X mean standardized parts, so they may have some differences from the original one. Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. Abbreviation SP : Singapore model The mechanical parts with no reference number in the exploded views are not supplied. Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE). (RED) Parts of Color Cabinets Color

7-1. CASE SECTION

Ref. No. * 2 * 4 5
Part No. X-4949-884-1 X-4950-218-1 4-997-138-02 4-997-138-42 4-210-291-01 4-210-291-11 4-999-877-01 4-219-772-03 4-219-772-13 4-219-772-22

Remarks

Ref. No. !6 !15 15
Part No. 1-575-651-21 1-751-529-11 4-959-077-01 3-704-515-21 3-704-515-41 4-949-302-11 3-704-515-31 3-704-515-41 4-945-438-21 4-222-671-01
Description CORD, POWER (XB930/XB930E:SP) CORD, POWER (XB930E:UK) DAMPER SCREW(BV/RING) (XB930) SCREW(BV/RING) (XB930E) WASHER SCREW (BV/RING) (XB930) SCREW (BV/RING) (XB930E) SPACER (BOSS) SCREW (PWH3), STEP (XB930)
PANELASSY, LOADING (BLACK) PANELASSY, LOADIBG (SILVER) CASE(4095269) (BLACK) CASE(4095269) (SILVER) SCREW(CASE 3 TP2) (BLACK) (XB930) SCREW(CASE 3 TP2) (SILVER) (XB930) SCREW(CASE) (XB930E) PANEL, BACK (XB930) PANEL, BACK (XB930E:UK) PANEL, BACK (XB930E:SP)
4-966-267-11 BUSHING (FBS001), CORD
4-222-671-11 SCREW (PWH3), STEP (XB930E)

7-2. PANEL SECTION

supplied with RV350

supplied with J350

not supplied

Ref. No. 56 * * 59 * 60

Part No. 4-996-687-51 4-996-687-82 4-950-189-01 4-950-189-61 4-942-568-41 4-942-568-61 4-997-199-62 4-997-199-72 4-997-199-81 4-997-202-01 4-997-202-32 4-998-790-01 4-998-790-21 1-669-370-11 4-951-620-01
Description KNOB(AMS) (BLACK) KNOB(AMS) (SILVER) KNOB(A) (VOL) (BLACK) KNOB(A) (VOL) (SILVER) EMBLEM (NO.5), SONY (BLACK) EMBLEM (NO.5), SONY (SILVER) PANEL, FRONT (BLACK) (XB930) PANEL, FRONT (SILVER) (XB930) PANEL, FRONT (BLACK) (XB930E) BASE(M1), PANEL (BLACK) BASE(M1), PANEL (SILVER) KNOB, POWER (BLACK) KNOB, POWER (SILVER) POWER SW BOARD SCREW (2.6 8), +BVTP
Ref. No. * 63 * 64 * FL501
Part No. 1-669-371-11 4-997-211-01 4-997-211-23 4-997-200-03 4-997-200-24 A-4724-932-A 4-997-495-01 4-997-213-01 4-997-213-22 X-4949-458-1 X-4950-217-1 4-997-210-01 3-354-981-11 4-948-469-01 4-221-138-01
Description KEY BOARD BUTTON (MODE) (BLACK) BUTTON (MODE) (SILVER) BASE(L), PANEL (BLACK) BASE(L), PANEL (SILVER) DISP BOARD, COMPLETE GUIDE (FL) BUTTON (F.R) (BLACK) BUTTON (F.R) (SILVER) BASE(R) ASSY, PANEL (BLACK) BASE(R) ASSY, PANEL (SILVER) PLATE, INDICATION SPRING (SUS), RING SPRING, RING EMBLEM (UK) (XB930E:UK)

Description SPRING(SLIDE BASE),COMPRESSION RACK, SLIDE SHAFT, SLED SPINDLE BOARD WIRE (FLAT TYPE) (5 CORE) SPRING (SPINDLE), LEAF GEAR (B), FLAT OPTICAL PICK-UP KSS-213B/K-N WIRE (FLAT TYPE) (16 CORE)
Ref. No. * * * 268 M102 M151
Part No. 4-993-919-01 4-917-562-01 4-977-918-01 4-977-920-01 1-658-709-11 4-951-620-01 2-279-715-01 X-4947-303-1 X-4950-461-1
Description SPRING (A) (OP), LEAF INSULATOR BASE (OUTSERT) GEAR (C), FLAT SLED BOARD SCREW (2.6 8), +BVTP RIVET, NYLON MOTOR ASSY (WITH PULLEY)(SLED) MOTOR ASSY (SPINDLE)
NOTE: Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX, -X mean standardized parts, so they may have some difference from the original one. Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. Ref. No. * Part No. Description
SECTION 8 ELECTRICAL PARTS LIST
CAPACITORS: uF: F RESISTORS All resistors are in ohms. METAL: metal-film resistor METAL OXIDE: Metal Oxide-film resistor F: nonflammable COILS uH: H Abbreviation SP : Singapore model Remarks Ref. No. R624 R625 R626 R811 R812 R813 R814 R815 R816 R821 R822 R823 R824 R825 R826 R830 R831 R832 R834 R837 R838 R851 R953 ! R961 ! R962 Part No. 1-249-393-11 1-249-429-11 1-249-425-11 1-249-427-11 1-249-415-11 1-249-417-11 1-249-419-11 1-249-421-11 1-247-843-11 1-249-427-11 1-249-415-11 1-249-417-11 1-249-419-11 1-249-421-11 1-247-843-11 1-249-427-11 1-249-441-11 1-249-441-11 1-249-417-11 1-249-429-11 1-249-429-11 1-249-427-11 1-249-437-11 1-212-869-00 1-212-869-00 SEMICONDUCTORS In each case, u: , for example: uA.: A. , uPA. , PA. , uPB. , PB. , uPC. , PC. , uPD., PD.
When indicating parts by reference number, please include the board name. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
Description CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON FUSIBLE FUSIBLE < SWITCH > 10 10K 4.7K 6.8K 680 1K 1.5K 2.2K 3.3K 6.8K 680 1K 1.5K 2.2K 3.3K 6.8K 100K 100K 1K 10K 10K 6.8K 47K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
Remarks 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F F F F F F F F
A-4724-932-A DISP BOARD, COMPLETE ******************** 4-955-901-01 CUSHION (FL) 4-997-495-01 GUIDE (FL) < CAPACITOR > C503 C804 C806 C807 C810 C813 1-164-159-11 1-164-159-11 1-164-159-11 1-124-584-00 1-126-868-11 CERAMIC CERAMIC CERAMIC ELECT ELECT 0.1uF 0.1uF 0.1uF 100uF 47uF 100uF 50V 50V 50V 10V 50V 10V

1-249-528-91 CARBON 1-249-528-91 CARBON 1-259-472-11 CARBON 1-259-480-11 CARBON 1-259-484-11 CARBON
R554 R555 R820 R931 R932 R951 R952 R971 R972
1-259-492-11 CARBON 1-259-396-11 CARBON 1-259-456-11 CARBON 1-259-466-11 CARBON 1-259-440-11 CARBON 1-212-869-00 FUSIBLE 1-259-452-11 CARBON 1-259-420-11 CARBON 1-259-420-11 CARBON
470K 47 15K 39K 3.3K 33 10K 470 470
5% 5% 5% 5% 5% 5% 5% 5% 5%
8-719-024-99 DIODE 11ES2-NTA2B 8-719-024-99 DIODE 11ES2-NTA2B < IC >
< TRANSFORMER > T201 1-409-594-11 COIL (WITH CORE) < VIBRATOR > X301 1-767-926-11 VIBRATOR, CRYSTAL (45 MHz) ************************************************************ A-4724-765-A POWER BOARD, COMPLETE (XB930E) ********************** A-4724-847-A POWER BOARD, COMPLETE (XB930) ********************** 7-685-871-01 SCREW +BVTT (S) < CAPACITOR > C901 C902 C910 C911 C915 C916 C917 C921 C922 C924 C925 C926 C927 C928 C931 C932 C951 C952 C954 C955 1-117-912-21 1-117-912-21 1-136-177-00 1-117-810-11 1-126-012-11 1-136-177-00 1-106-359-00 1-126-943-11 1-126-942-61 1-136-850-11 1-128-197-11 1-128-197-11 1-130-489-00 1-128-197-11 1-128-197-11 1-128-197-11 1-110-395-11 1-124-911-11 1-136-850-11 1-136-177-00 ELECT ELECT FILM ELECT ELECT FILM MYLAR ELECT ELECT FILM ELECT ELECT MYLAR ELECT ELECT ELECT ELECT ELECT FILM FILM 3900uF 3900uF 1uF 6800uF 470uF 1uF 4700PF 2200uF 1000uF 0.1uF 10uF 10uF 0.033uF 10uF 10uF 10uF 330uF 220uF 0.1uF 1uF 20% 20% 5% 20% 20% 5% 5% 20% 20% 5% 20% 20% 5% 20% 20% 20% 20% 20% 5% 5% 25V 25V 50V 25V 16V 50V 200V 25V 25V 63V 50V 50V 50V 50V 50V 50V 63V 50V 63V 50V L902 L903 L904 L905 L906 L907 1-424-122-11 1-424-122-11 1-424-122-11 1-424-122-11 1-424-122-11 IC901
8-759-604-86 IC M5F7807L < COIL > FILTER, NOISE FILTER, NOISE FILTER, NOISE FILTER, NOISE FILTER, NOISE
1-424-122-11 FILTER, NOISE < RESISTOR >
R921 1-249-413-11 CARBON 470 5% 1/4W F R922 1-249-417-11 CARBON 1K 5% 1/4W F R925 1-259-416-11 CARBON 330 5% 1/6W ! R954 1-212-869-00 FUSIBLE 33 5% 1/4W F ************************************************************ * 1-669-370-11 POWER SW BOARD **************** < CAPACITOR > ! C991 1-113-916-11 CERAMIC < CONNECTOR > CN994 1-690-123-21 REED (WITH CONNECTOR) (2 CORE) < SWITCH > S991 1-572-267-51 SWITCH, PUSH (AC POWER)(1 KEY) (POWER) ************************************************************ The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. 0.01uF 20% 250V

0.1uF 47uF 0.1uF 100uF 0.1uF 2.2uF 470PF 0.1uF 470PF 470PF

10% 20% 10% 20% 10%

25V 50V 25V 16V 25V 16V 50V 25V 50V 50V 10V 16V 63V 16V 50V 50V 50V 25V 16V 16V 6.3V 6.3V 2.5V 50V 50V 50V 10V 50V 16V 25V 16V 4V 10V 16V 16V 16V 16V 50V 50V 16V 16V 50V 50V 50V 50V

5% 10% 5% 5%

220uF 20% 2.2uF 0.022uF 5% 2.2uF 0.0068uF 10% 0.0047uF 0.01uF 0.1uF 2.2uF 10uF 1000uF 1000uF 220uF 0.001uF 15PF 0.01uF 1uF 0.01uF 0.47uF 0.1uF 10uF 100uF 220uF 2.2uF 2.2uF 2.2uF 2.2uF 470PF 470PF 2.2uF 2.2uF 470PF 470PF 0.015uF 0.015uF 10% 10% 10% 20% 20% 20% 20% 5% 5% 10% 10% 10% 10% 10% 20% 20% 20%
1-506-481-11 PIN, CONNECTOR 2P < DIODE >

D101 D113 D361

8-719-016-74 DIODE 1SS352-TPH3 8-719-016-74 DIODE 1SS352-TPH3 8-719-938-07 DIODE GL480 < IC >
IC101 IC102 IC103 IC104 IC361
8-752-389-34 8-759-071-79 8-752-085-51 8-759-048-30 8-749-010-61

IC IC IC IC IC

CXD2585Q BA6297AFP-T1 CXA2568M-T6 LA6510L IS471F
< COIL > L101 L102 1-414-234-22 INDUCTOR CHIP 0uH 1-414-234-22 INDUCTOR CHIP 0uH < TRANSISTOR > Q101 Q102 Q301 Q302 8-729-010-08 8-729-010-08 8-729-424-08 8-729-421-22 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > R050 R051 R052 R053 R054 R055 R056 R057 R058 R059 1-216-298-00 1-216-298-00 1-216-298-00 1-216-298-00 1-216-097-91 1-216-065-91 1-216-101-00 1-216-049-91 1-216-097-91 1-216-295-91 METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES,CHIP RES,CHIP METAL CHIP RES,CHIP RES,CHIP SHORT 2.2 2.2 2.2 2.2 100K 4.7K 150K 1K 100K 0 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W MSB710-RT1 MSB710-RT1 UN2111-TX UN2211-TX

5% 5% 5% 5%

Ref. No. R060 R061 R062 R063 R064 R065 R066 R067 R068 R069 R071 R092 R101 R102 R103 R104 R105 R106 R107 R108 R109 R110 R112 R113 R114 R117 R118 R121 R122 R123 R124 R125 R126 R127 R131 R133 R134 R135 R136 R137 R138 R143 R144 R145 R146 R147 R148 R149 R150 R151 R152 R153 R154 R155 R156 R157 R158 R159 R160 R162 Part No.

SPINDLE

Remarks 2.2 2.2 2.2 2.2 100K 4.7K 150K 1K 100K 0 10K 0 15K 100K 15K 33K 100K 510 15K 3.3K 1M 100 1K 10K 10K 10K 10K 10K 10K 6.2K 100K 1K 1K 180K 180K 6.8K 1M 22K 1M 10K 10K 10K 10K 10K 10K 220K 220K 150K 100K 470K 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. R163 R168 R170 R171 R172 R173 R174 R175 R176 R177 R181 R182 R183 R184 R185 R186 R187 R191 R192 R193 R194 R301 R312 R359 R366 Part No. 1-216-105-91 1-216-295-91 1-216-025-91 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-025-91 1-216-065-91 1-216-065-91 1-216-065-91 1-216-065-91 1-216-065-91 1-216-065-91 1-216-065-91 1-216-009-91 1-216-009-91 1-216-009-91 1-216-009-91 1-216-021-00 1-216-073-00 1-216-089-91 1-216-295-91 Description RES,CHIP SHORT RES,CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP RES,CHIP METAL CHIP METAL CHIP RES,CHIP SHORT < SWITCH > S153 1-762-930-11 SWITCH, LEVER (LOAD OUT) ************************************************************ * 1-658-709-11 SLED BOARD ********** < CONNECTOR > CN104 CN105 * CN106 1-774-380-11 CONNECTOR, FFC/FPC 16P 1-568-838-11 SOCKET, CONNECTOR 21P 1-750-737-11 CONNECTOR, FFC/FPC 5P < MOTOR > M102 X-4947-303-1 MOTOR ASSY (WITH PULLEY)(SLED) ************************************************************ 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W * 1-658-708-11 SPINDLE BOARD ************* < CONNECTOR > * CN107 1-568-848-11 SOCKET, CONNECTOR 5P < MOTOR > M151 X-4950-461-1 MOTOR ASSY (SPINDLE) < SWITCH > S151 1-571-958-11 SWITCH, PUSH (1 KEY) (LIMIT) ************************************************************ 220K 10K 10K 10K 10K 10K 10K 100 4.7K 4.7K 4.7K 4.7K 4.7K 4.7K 4.7K 68 10K 47K 0 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W

Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES,CHIP RES,CHIP METAL CHIP RES,CHIP RES,CHIP SHORT METAL CHIP SHORT METAL CHIP RES,CHIP METAL CHIP METAL CHIP RES,CHIP METAL CHIP METAL CHIP METAL CHIP RES,CHIP RES,CHIP RES,CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES,CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES,CHIP RES,CHIP SHORT SHORT SHORT SHORT METAL CHIP METAL CHIP METAL CHIP RES,CHIP METAL CHIP METAL CHIP RES,CHIP RES,CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES,CHIP RES,CHIP METAL CHIP RES,CHIP METAL CHIP
1-216-298-00 1-216-298-00 1-216-298-00 1-216-298-00 1-216-097-91 1-216-065-91 1-216-101-00 1-216-049-91 1-216-097-91 1-216-295-91 1-216-073-00 1-216-296-91 1-216-077-00 1-216-097-91 1-216-077-00 1-216-085-00 1-216-097-91 1-216-042-00 1-216-077-00 1-216-061-00 1-216-121-91 1-216-025-91 1-216-049-91 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-068-00 1-216-097-91 1-216-037-00 1-216-037-00 1-216-037-00 1-216-037-00 1-216-049-91 1-216-049-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-295-91 1-216-103-00 1-216-103-00 1-216-069-00 1-216-121-91 1-216-081-00 1-216-001-00 1-216-003-11 1-216-121-91 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-073-00 1-216-105-91 1-216-105-91 1-216-101-00 1-216-097-91 1-216-113-00
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
Ref. No. * Part No. Description Remarks Ref. No. Part No. Description Remarks 1-669-373-12 TRANS BOARD ************ < CAPACITOR > ! C992 ! C993 ! C994 1-113-916-11 CERAMIC 1-102-106-00 CERAMIC 1-113-916-11 CERAMIC < CONNECTOR > * CN991 CN992 1-580-230-11 PIN, CONNECTOR (PC BOARD) 2P 1-564-321-00 PIN, CONNECTOR 2P < COIL > ! L901 1-424-485-11 FILTER, LINE < RESISTOR > ! R991 1-249-413-11 CARBON 470 5% 1/4W F ************************************************************ MISCELLANEOUS *************** CORD, POWER (XB930/XB930E:SP) CORD, POWER (XB930E:UK) WIRE (FLAT TYPE) (21 CORE) WIRE (FLAT TYPE) (5 CORE) OPTICAL PICK-UP KSS-213B/K-N WIRE (FLAT TYPE) (16 CORE) INDICATOR TUBE, FLUORESCENT MOTOR ASSY (WITH PULLEY)(LOADING) MOTOR ASSY (WITH PULLEY)(SLED) MOTOR ASSY (SPINDLE) 0.01uF 100PF 0.01uF 20% 10% 20% 250V 50V 250V 1-473-720-11 1-590-925-31 3-866-364-11 3-866-364-21 ACCESSORIES & PACKING MATERIALS ******************************** REMOTE COMMANDER (RM-DX50) CORD, CONNECTION MANUAL, INSTRUCTION (ENGLISH,FRENCH,SPANISH) MANUAL, INSTRUCTION (GERMAN,DUCH,SWEDISH,ITALIAN, PORTUGUESE)(XB930) MANUAL, INSTRUCTION (CHINESE) (XB930E:SP)