Pin No. 100

Pin Name TE CE RFDC ADIO AVSSO IGEN AVDDO ASYO ASYI RFAC AVSS3 CLTV FILO FILI PCO AVDD3 BIAS VCTL V16M VPCO DVSS MD2 DOUT ASYE DVDD LRCK LRCKI PCMD PCMD BCK BCKI EMPH EMPHI XVDD XTAI XTAO XVSS AVDD1 AOUT1 AIN1 LOUT1 AVSS1 AVSS2 LOUT2 AIN2 AOUT2 AVDD2 RMUT LMUT
I/O I I I O I O I I I O I O I I O O I O I O I O I O I O I I O O I O O I O O O
Pin Description Tracking error signal input Center servo analog input RF signal input Test pin (Not used.) Analog ground Constant current input from OP amplifier. Analog ground EFM full-swing output (L: VSS, H: VDD) Asymmetry comparate voltage input EFM signal input Analog ground VCO control voltage input from master. Filter output for master PLL (slave=digital PLL) Filter input from master PLL. Charge pump output for master PLL. Analog power supply pin Asymmetry circuit constant current input VCO2 control input from wideband EFM PLL. (Not used.) VCO2 oscillator output for wideband EFM PLL. (Not used.) Charge pump output for wideband EFM PLL. (Not used.) Digital ground Digital out ON/OFF control input (L: OFF, H: ON) Digital out output Asymmetry circuit ON/OFF input (L: OFF, H: ON) Digital power supply pin D/A interface LR clock output (f=Fs) D/A interface LR clock input D/A interface serial data output (2s COMP, MSB fast) D/A interface serial data input (2s COMP, MSB fast) D/A interface bit clock output D/A interface bit clock input Emphasis ON/OFF signal output Emphasis ON/OFF signal input (H: ON, L: OFF) Power supply for master clock. Xtal oscillator input from master clock (16.9344 MHz). Xtal oscillator output for master clock (16.9344 MHz). Ground pin for master clock. Analog power supply pin Lch analog output Lch OPAMP input Lch LINE output Analog ground Analog ground Rch LINE output Rch OPAMP input Rch analog output Analog power supply pin Rch 0 detect Flug (Not used.) Lch 0 detect Flug (Not used.)
IC5 CXP84640-063Q (CD SYSTEM CONTROL) (SERVO BOARD) Pin No. Pin Name I/O 1 ITRPT Not used in this set. 2, 3 4, 11 12, 13 14, NCO OPEN CLOSE LINKOFF NCO D SW SSTP NCO EMPH O CDMON CD ON A MUT LD ON CD RST HOLD AGC CONT PH3 TSTIN0 TSTIN1 TST.CLV NCO RESET X IN X OUT GND XT OUT XT IN AVSS AVREF TEP L TEP H SLED PH2 SEK/SMET GFS/MNT2 SEL SC-JIG ON/OFF SCLK LOCK SCK2 SI2 BUS CLK BUS SI BUS SO F OK GFS TEST MODE I O I I I O O O O O O O O I I I I I I O O I I I I I I I I I O I/O O I I/O I O I I I Not used in this set. Not used in this set. Front panel open detection input Front panel close control output Bus interface link input Not used in this set. Down switch input (SW4) Limit switch input (SW3) Not used in this set. Not used in this set.

Pin No. 67 68, 87 88, 119 120
Pin Name COLSW COLSEL VSS DAVN FILE TEXT NOSESW I2C SIO I2C CKO X1A X0A KEYACK BUIN ILLIN TELATT TEST IN ACC IN LOCKIN RCIN1 HSTX MD2 MD1, 0 RSTX VSS X0 X1 VCC DIM SEL TAP CD VSS PW ON
I/O I I I I I I I/O I/O I I I I I I I I I I I I I I O
Pin Description Illumination color switch input (L: 2 colors, H: 1 color) (Fixed at L in CDX-C4900R/C5000R, H in CDX-C5000RX) Illumination color select input (L: AMBER, H: GREEN) (Fixed at L in this set) Ground Block synchronization detection input of RDS data. Custom file setting input CD text setting input Front panel attachment detection input Not used. (Open) I2C BUS serial data input/output I2C BUS serial clock input/output Not used. (Open) Low speed oscillation connecting pin (32.768 kHz) Low speed oscillation connecting pin (32.768 kHz) Not used. (Open) Key acknowledge input Backup voltage detection input Illumination (ILLIN) detection input (Fixed at L in this set) Telephone (TEL) detection input (Fixed at L in CDX-C4900R) Not used. (Open) Test mode setting input Accessory power supply (ACC) detection input Not used. (Open) MD LOCK detection input Rotary commander SHIFT input Hardware standby setting input Connect to VSS in this set. Connect to VCC in this set. Reset input Ground High speed oscillation connecting pin (3.68 MHz) High speed oscillation connecting pin (3.68 MHz) Power supply pin (+5 V) Not used. (Open) Dimmer select input (L: With dimmer select, H: Without dimmer select) (Fixed at L in this set) TAPE/CD select input (L: CD, H: TAPE) (Fixed at L in this set) Not used. (Open) Ground System power control output
3-2. BLOCK DIAGRAM CD SECTION
OPTICAL PICKUP KSS-720A A
RF AMP, LD APC, ERROR AMP IC1
DIGITAL SERVO, DIGITAL SIGNAL PROCESSOR IC501

C 7 B 6 I-V CONV.

EFM DEM

D/A I/F

D/A CONV.

LOUT1 LOUT2

CD L R-CH

(Page 24) TUNER SECTION

CD SYSTEM CONTROL IC5
SYSTEM CONTROL IC501 (1/3) 58 ATT 12 DOOR SW
54 RFDC D 8 D FOCUS ERROR FE E F E 11 F 10 PD LD AMP LD LD DRIVE QLD 22 HOLD SW 21 AGC CONT 20 LD ON TRACKING ERROR TE FE TE SE SQSO SQCK SCOR MD2 XRST DATA XLAT SCLK CLOK SENS GFS FOK FFDR FRDR XTALO 87 TRACKING COIL M902 SLED MOTOR M901 SPINDLE MOTOR M903 LOADING MOTOR TRACKING COIL DRIVE SLED MOTOR DRIVE SPINDLE MOTOR DRIVE LOADING MOTOR DRIVE TFDR SERVO TRDR CTL SFDR SRDR DIGITAL CLV LOCK 34

46 LOCK

A MUT 19 OPEN 6 (KEY BOARD)

SUB CODE PROCESS

49 SISCKSCOR 54 MD2 CD RST CD DATA CD XLAT SCLK CD CKO SENS GFS FOK
BUS CLK 51 BUS SI 52 BUS ON 61 RESET 30 BU IN 60
UNI CKI UNI CKO UNI SI UNI SO BUS ON SYS RST BU IN
TRACKING/FOCUS COIL DRIVE SLED/SPINDLE/LOADING MOTOR DRIVE IC7 FOCUS COIL DRIVE
90 RSTX 86 HSTX IC652 X IN 31 X OUT 32 X1 10MHz SW503 (RESET) 1 RESET 3 BU 5V

FOCUS COIL

XTALI 86

X2 16MHz

SW4 (LIMIT) SW1 (DISC IN) SW3 (LOAD IN)
11 SSTP 10 D SW 64 IN SW 63 SELF SW 10
BATT (H) CHECK Q701 BUS INTERFACE IC701 BATT (L) CHECK
DISPLAY SECTION (Page 25)

SW2 (SELF)

MUTE MUTE 2 35

23 POWER CONT Q365

LM EJ LM LOD SLED DRIVE ON LD ON HOLD AGC CONT

2 Q705

18 CD ON POWER CONT Q363 11V REG Q361 BATT LNK OFF 17 CDM ON BUS SO 53 Q706

CN701 BUS CONTROL IN

CD 5V CD 6V 04

5V REG Q364

6V REG Q362

Signal path :CD

3-3. BLOCK DIAGRAM TUNER SECTION
CNJ1511, 2 BUS AUDIO IN L R
CNJ1513, 4 AUDIO OUT REAR L R
CNJ1515, 6 AUDIO OUT FRONT L R C5000R/C5000RX
ELECTRONIC VOLUME ICFDIL OUT LF 30

POWER AMP IC3

CNFL+ 9 FL
TUNER UNIT TU1 J1 (ANTENNA)

CD (Page 23) SECTION

1 SEL 13 MPX 11 AM AM IF LEVEL MPIN SDA SCL SM OUT LR 29 Q181 MUTE Q171 MUTE AUX IN 4 STAND BY 22 MUTE 4 FR+ 12 FR R-CH 3 RR+ 11 RR MUTE CONT Q621, 622 ATT 2 RL+ 10 RL

2 ANTFM 1 ANTAM

MPX 10 AM DET 8 IF AM 19 Q111 MUTE BUFFER Q1 Q121 MUTE

CD SECTION (Page 23)

BATT F901

16 BATT

MUTE CONT Q131 ICNOISE 1 DET Q90 NOISE ON
SYSTEM CONTROL IC501 (2/3)

C5000R/C5000RX

57 VOL ATT 56 TUN ATT 50 QUALITY
BEEP AMP ON AMP MUTE TEL ATT
ACC CHECK Q661 POWER SUPPLY IC671 BATT 7 VCC 2 8.7V ON 3 5.6V ON 4 STB AMP +B 6 ANT +B 8 BU+B COM 8V TU 5.6V TU 8.7V

32 NS MASK

TEL ATT Q571

13 ATT 7 ACC 15 TEST

ACC IN 82 TEST IN 81
S-METER 14 I2C SDA 12 I2C SCL SDA 20 LV IN 10 SCA MULTI PATH DET RDS/RDBS DEM/DEC OSCI 5 X51 4.332MHz FM AGC 4 E2PROM SDA 17 E2PROM SCL 2 RDS DECODER IC51

53 VSM 70 I2C SIO 71 I2C CKO
5 AMP R 6 ANT R BU 5V COM 8V TU 5.6V TU 8.7V

TU ON MPTH PW ON 120

RDS DET 9

64 DAVN

OSCO 4

Signal path :FM

51 FM AGC 9 E2P SIO 10 E2P CKO

:MW :CD

3-4. BLOCK DIAGRAM DISPLAY SECTION
3-5. CIRCUIT BOARDS LOCATION
SYSTEM CONTROL IC501 (3/3) KEY MATRIX LSW901-917 S901-904 LSW801

LCD DRIVE IC901

46 KEY INKEY IN1
LCD SO 13 LCD CKO 14 LCD CE 15
64 DATA 63 CL 62 CE GREEN 2 AMBER 1

LCD901

DISC IN SW board

SUB board

SUB (CD) board

LIMIT SW board

KEY ACTIVE Q651

76 KEY ACK

35 AD ON KEY ACTIVE Q652 C4900R/ C5000R DOOR IND 29 J501 (REMOTE IN) 85 RC INRC IN0 IC951 IR RECEIVE 24 SIRCS LED801-803 POWER CONT Q633 +10V REG Q631 LED910-915 LSW901-917 LED901-904 DOOR IND DRIVE Q551 AMBER DRIVE Q901 GREEN DRIVE Q902

KEY ACT

tuner unit (TU1) MAIN board
SIRCS Q704 ROTARY ENCODER RERE INRE IN1 ILL ON 7

LOAD SW board KEY board

ILL +B
SW504 (NOSE DET) X502 32.768kHz 04
67 NOSE SW 73 XOA 74 XIA XO 92 XI 93

SERVO board

X501 3.68MHz
3-6. PRINTED WIRING BOARDS CD MECHANISM SECTION
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) for schematic diagram: All capacitors are in F unless otherwise noted. pF: F 50 WV or less are not indicated except for electrolytics and tantalums. All resistors are in and 1/4 W or less unless otherwise specified. % : indicates tolerance. f : internal component. C : panel designation. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. U : B+ Line. Power voltage is dc 14.4V and fed with regulated dc power supply from ACC and BATT cords. Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. Circled numbers refer to waveforms. Signal path. F : FM f : MW J : CD for printed wiring boards: X : parts extracted from the component side. Y : parts extracted from the conductor side. x : parts mounted on the conductor side. a : Through hole. b : Pattern from the side which enables seeing. (The other layers patterns are not indicated.) Caution: Pattern face side: (Side B) Parts face side: (Side A) Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
Semiconductor Location Ref. No. Location IC1 C-1 IC5 C-6 IC7 F-2 IC501 F-5 Q101 B-2

(Page 31)

3-7. SCHEMATIC DIAGRAM CD MECHANISM SECTION (1/2) Refer to page 39 for IC Block Diagrams.

Waveforms (MODE:PLAY)

0V Approx. 200mVp-p

0V Approx. 620mVp-p

1.2Vp-p

(Page 29)

Note: Voltage and waveforms are dc with respect to ground under no-signal conditions. no mark : CD PLAY

(Page 33)

3-8. SCHEMATIC DIAGRAM CD MECHANISM SECTION (2/2) Refer to page 40 for IC Block Diagrams.

(Page 28)

Note: Voltage is dc with respect to ground under no-signal conditions. no mark : CD PLAY
3-9. PRINTED WIRING BOARD MAIN SECTION
Semiconductor Location (Side A) Ref. No. Location D1 E-9 D301 G-4 D501 I-7 D502 H-7 D551 J-13 D552 K-13 D553 K-13 D554 J-12 D555 K-13 D556 J-12 D557 K-13 D558 J-12 D559 K-13 D560 J-12 D571 B-5 D603 B-4 D605 B-5 D611 B-7 D612 B-7 D613 C-7 D614 B-7 D615 C-7 D616 C-7 D617 C-6 D618 C-6 D622 D-9 D624 C-9 D653 I-7 D661 D-5 D662 D-5 D673 C-5 D674 C-5 D701 E-5 D702 C-4 D703 B-3 D704 B-2 D705 B-2 D706 B-2 D708 D-7 D710 D-4 IC51 IC90 IC151 IC501 IC652 IC701 Q1 Q111 Q131 Q171 Q181 Q271 Q281 Q363 Q365 Q551 Q571 Q621 Q622 Q633 Q651 Q652 Q661 Q701 Q704 Q705 Q706 I-12 H-11 D-11 I-6 J-3 C-3 G-11 E-12 F-12 B-11 B-12 C-11 C-12 I-3 G-2 J-6 D-6 C-10 C-9 J-2 I-8 I-8 D-5 E-5 G-7 C-4 D-4

(Page 27)

Semiconductor Location (Side B) Ref. No. Location D2 E-7 D90 H-12 D91 H-11 D92 D-12 D131 F-12 D302 G-8 D361 I-2 D362 G-2 D363 G-3 D561 K-11 D562 K-11 D601 C-3 D602 B-4 D604 A-5 D621 B-10 D631 J-2 D671 B-5 D672 C-5 D675 I-4 D676 I-4 D677 I-4 D709 G-5 D901 K-12 D902 K-13 IC611 IC671 Q90 Q121 Q361 Q362 Q364 Q631 B-7 E-1 D-11 E-12 H-1 G-1 G-2 J-2

(Page 36)

3-10. SCHEMATIC DIAGRAM MAIN SECTION (1/3) Refer to page 39 for IC Block Diagrams.

(Page 34)

Note: Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM ( ) : MW
3-11. SCHEMATIC DIAGRAM MAIN SECTION (2/3)

(Page 32)

Note: Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM ( ) : MW < > : CD PLAY
3-12. SCHEMATIC DIAGRAM MAIN SECTION (3/3) Refer to page 39 for IC Block Diagrams.

(Page 35)

3-13. SCHEMATIC DIAGRAM SUB (CD) SECTION

(Page 38)

3-14. PRINTED WIRING BOARD SUB (CD) SECTION

LOCK ASSY SCREW +P 2X3 COVER CORD (WITH CONNECTOR) (ISO) (POWER) (C4900R) 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER) (C5000R/C5000RX)
14 * 15 * 16 * * 19 * 20 F901 TU1

* 10 11

3-041-012-01 BRACKET (CD) 3-376-464-11 SCREW (+PTT 2.6X6), GROUND POINT

4-2. FRONT PANEL SECTION

#12 #12

not supplied (KEY board)

Ref. No. * 59
Part No. 3-040-980-01 3-040-981-01 3-040-992-01 X-3378-398-1 X-3378-517-1 X-3378-518-1 X-3378-591-1 3-041-006-01 3-041-005-11 3-040-989-01
Description BUTTON (SOURCE) KNOB (VOL) HOLDER (LCD) PANEL ASSY, FRONT BACK SUB ASSY, PANEL (C4900R) SUB ASSY, PANEL (C5000R) SUB ASSY, PANEL (C5000RX) BUTTON (AF/TA) BUTTON (D) BUTTON (OPEN)

Remark

Ref. No. * * 66 * 67 LCD901
Part No. 3-041-010-01 3-041-003-01 3-040-987-01 3-040-986-01 3-040-997-01 1-694-660-11 3-041-371-02 3-040-993-01 1-803-906-11
Description BUTTON (1-6/M) BUTTON (LIST/ENTER) BUTTON (OFF) BUTTON (MENU/SOUND) PLATE (LCD), GROUND
CONDUCTIVE BOARD, CONNECTION SHEET (REFLECTOR) PLATE (LCD), LIGHT GUIDE DISPLAY PANEL, LIQUID CRYSTAL (C4900R/C5000R) LCD901 1-803-906-31 DISPLAY PANEL, LIQUID CRYSTAL (C5000RX)
3-037-267-01 SPRING (OPEN)
4-3. CD MECHANISM SECTION (1) (MG-383Z-121//Q)

109 101

105 106

111 110

Ref. No. * 101 * * 106 107
Part No. 1-659-836-11 A-3315-034-A 3-931-909-01 X-3371-501-1 3-338-737-01
Description DISC IN SW BOARD CHASSIS (T) ASSY SPRING (LR), TENSION LEVER (L) ASSY SCREW (2X3), +PS

Ref. No. * 110 * M903

Part No. 3-039-629-01 3-013-388-02 A-3315-040-A A-3326-231-A 3-047-477-01
Description BRACKET (MOTOR) GUIDE (DISC) ROLLER ASSY, ARM SERVO BOARD, COMPLETE SPRING (RA2), TENSION
1-659-837-11 LOAD SW BOARD X-3371-502-1 LEVER (R) ASSY
A-3315-039-A MOTOR SUB ASSY, LD (LOADING)
4-4. CD MECHANISM SECTION (2) (MG-383Z-121//Q)

155 153

165 164

Ref. No. 159

Part No. X-3378-956-1 3-931-897-61 3-039-627-01 3-040-165-01 3-018-272-01 3-931-895-01 3-931-898-01 3-032-483-02 A-3307-471-A
Description ARM ASSY, CHUCKING DAMPER (T) LEVER (D) RETAINER (DISC) WASHER SPRING (CH), TENSION SPRING (FL), COMPRESSION SPRING (KF1), TENSION OVERALL ASSY, CHASSIS (M)

SW1 1-572-288-21 SWITCH, PUSH (DISC IN) SW2 1-572-288-21 SWITCH, PUSH (SELF) ************************************************************* KEY BOARD ********** 1-694-660-11 3-040-992-01 3-040-993-01 3-040-997-01 3-041-371-02 CONDUCTIVE BOARD, CONNECTION HOLDER (LCD) PLATE (LCD), LIGHT GUIDE PLATE (LCD), GROUND SHEET (REFLECTOR) < CAPACITOR >
LED LED LED LED LED LED LED LED LED LED LED LED LED LED
CL-190SR-CD-T (C5000RX) CL-165Y/PG-D-T (C4900R/C5000R) CL-190SR-CD-T (C5000RX) CL-165Y/PG-D-T (C4900R/C5000R) CL-190SR-CD-T (C5000RX) CL-165Y/PG-D-T (C4900R/C5000R) CL-190SR-CD-T (C5000RX) CL-165Y/PG-D-T (C4900R/C5000R) LWA673-R1S2 LWA673-R1S2 LWA673-R1S2 LWA673-R1S2 LWA673-R1S2 LWA673-R1S2

* * * *

< SWITCH > C951 C952 C953 C954 C955 C956 1-164-004-11 1-163-037-11 1-163-251-11 1-164-004-11 1-164-004-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.1uF 0.022uF 100PF 0.1uF 0.1uF 0.22uF 10% 10% 5% 10% 10% 10% 25V 25V 50V 25V 25V 16V LSW901 1-771-610-11 SWITCH, TACTILE (WITH LED) (OFF) (C4900R/C5000R) LSW901 1-771-883-21 SWITCH, TACTILE (WITH LED) (OFF) (C5000RX) LSW902 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (SOURCE) (C4900R/C5000R) LSW902 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (SOURCE) (C5000RX) LSW903 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (SOUND) (C4900R/C5000R) LSW903 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (SOUND) (C5000RX) LSW904 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (MENU) (C4900R/C5000R) LSW904 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (MENU) (C5000RX) LSW905 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (DSPL/PTY) (C4900R/C5000R) LSW905 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (DSPL/PTY) (C5000RX) LSW906 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (LIST) (C4900R/C5000R) LSW906 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (LIST) (C5000RX) LSW907 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (ENTER) (C4900R/C5000R) LSW907 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (ENTER) (C5000RX) LSW908 1-771-610-11 SWITCH, TACTILE (WITH LED) (MODE) (C4900R/C5000R)
1-164-489-11 CERAMIC CHIP < CONNECTOR >
1-794-065-21 PLUG, CONNECTOR 14P < DIODE >
D901 D902 D903 D904 D951 D952
8-719-158-49 8-719-056-82 8-719-056-82 8-719-056-82 8-719-976-99
DIODE DIODE DIODE DIODE DIODE
UDZ-TE-17-12B UDZ-TE-17-6.2B UDZ-TE-17-6.2B UDZ-TE-17-6.2B UDZ-TE-17-5.1B
8-719-976-99 DIODE UDZ-TE-17-5.1B < IC >

IC901 IC951

8-759-366-34 IC LC75824E 8-749-012-25 IC RS-170-TU < LIQUID CRYSTAL DISPLAY >
LCD901 1-803-906-11 DISPLAY PANEL, LIQUID CRYSTAL (C4900R/C5000R) LCD901 1-803-906-31 DISPLAY PANEL, LIQUID CRYSTAL (C5000RX)
Ref. No. Part No. Description Remark Ref. No. R919 R920 R921 R921 R922 Part No. Description 3.3K 4.7K 68 0.5% 0.5% 5% Remark 1/10W 1/10W 1/16W (C5000RX) 5% 1/16W (C4900R/C5000R) 5% 1/16W (C4900R/C5000R) 5% 1/16W (C4900R/C5000R) 5% 1/16W (C5000RX) 5% 1/16W (C4900R/C5000R) 5% 1/10W (C4900R/C5000R) 5% 1/10W (C5000RX) 5% 1/16W (C4900R/C5000R) 5% 1/10W (C4900R/C5000R) 5% 1/10W (C5000RX) 5% 1/16W (C4900R/C5000R) 5% 1/16W 5% 1/16W 5% 1/16W (C4900R/C5000R) 5% 1/16W (C5000RX) 5% 1/16W (C4900R/C5000R) 5% 1/16W 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/16W (C5000RX) 1/16W 1/10W 1/16W 1/10W 1/10W 1/16W 1/16W 1/10W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W (C5000RX) LSW908 1-771-883-21 SWITCH, TACTILE (WITH LED) (MODE) (C5000RX) LSW909 1-762-737-11 SWITCH, KEY BOARD (WITH LED) (D-BASS) LSW910 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (TA) (C4900R/C5000R) LSW910 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (TA) (C5000RX) LSW911 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (AF) (C4900R/C5000R) LSW911 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (AF) (C5000RX) LSW912 1-771-610-11 SWITCH, TACTILE (WITH LED) (6) (C4900R/C5000R) LSW912 1-771-883-21 SWITCH, TACTILE (WITH LED) (6) (C5000RX) LSW913 1-771-610-11 SWITCH, TACTILE (WITH LED) (5) (C4900R/C5000R) LSW913 1-771-883-21 SWITCH, TACTILE (WITH LED) (5) (C5000RX) LSW914 1-771-610-11 SWITCH, TACTILE (WITH LED) (4) (C4900R/C5000R) LSW914 1-771-883-21 SWITCH, TACTILE (WITH LED) (4) (C5000RX) LSW915 1-771-610-11 SWITCH, TACTILE (WITH LED) (3) (C4900R/C5000R) LSW915 1-771-883-21 SWITCH, TACTILE (WITH LED) (3) (C5000RX) LSW916 1-771-610-11 SWITCH, TACTILE (WITH LED) (2) (C4900R/C5000R) LSW916 1-771-883-21 SWITCH, TACTILE (WITH LED) (2) (C5000RX) LSW917 1-771-610-11 SWITCH, TACTILE (WITH LED) (1) (C4900R/C5000R) LSW917 1-771-883-21 SWITCH, TACTILE (WITH LED) (1) (C5000RX) < TRANSISTOR > Q901 Q902 8-729-904-75 TRANSISTOR DTD114EK-T-146 (C4900R/C5000R) 8-729-904-75 TRANSISTOR DTD114EK-T-146 (C4900R/C5000R) < RESISTOR > R901 R902 R903 R904 R905 R906 R907 R908 R909 R910 R911 R912 R913 R914 R915 R916 R917 R918 1-216-647-11 1-216-647-11 1-216-647-11 1-216-651-11 1-216-655-11 1-216-655-11 1-216-659-11 1-216-663-11 1-216-667-11 1-216-671-11 1-208-806-11 1-216-647-11 1-216-647-11 1-216-647-11 1-216-651-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 6.8K 10K 680 1K 1.5K 1.5K 2.2K 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 2% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W R951 R952 R953 R954 R955 R956 R957 R958 R970 R971 R972 R973 R975 R976 R977 R980 R999 1-216-819-11 1-216-057-00 1-216-857-11 1-216-049-11 1-216-049-11 1-216-821-11 1-216-851-11 1-216-033-00 1-216-815-11 1-216-815-11 1-216-864-11 1-216-815-11 1-216-815-11 1-216-815-11 METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 680 2.2K 1M 1K 1K 1K 330K 1-216-663-11 METAL CHIP 1-216-667-11 METAL CHIP 1-216-810-11 METAL CHIP 1-216-811-11 METAL CHIP 1-216-807-11 METAL CHIP

R923 R923 R924 R925 R925

1-216-811-11 METAL CHIP 1-216-812-11 METAL CHIP 1-216-807-11 METAL CHIP 1-216-029-00 METAL CHIP 1-216-031-00 METAL CHIP
R926 R927 R927 R928 R931 R932 R933 R933 R934 R938 R939
1-216-807-11 METAL CHIP 1-216-029-00 METAL CHIP 1-216-031-00 METAL CHIP 1-216-807-11 METAL CHIP 1-216-813-11 METAL CHIP 1-216-813-11 METAL CHIP 1-216-812-11 METAL CHIP 1-216-813-11 METAL CHIP 1-216-808-11 METAL CHIP 1-216-809-11 METAL CHIP 1-216-821-11 METAL CHIP
1-216-655-11 METAL CHIP 1-216-655-11 METAL CHIP 1-216-659-11 METAL CHIP
1-216-815-11 METAL CHIP 1-216-864-11 METAL CHIP 1-216-864-11 METAL CHIP
Ref. No. Part No. Description < ROTARY ENCODER > RE901 1-475-014-12 ENCODER, ROTARY < SWITCH > 1-771-884-21 SWITCH, TACTILE (WITH LED) (SEEK/AMS. m ) S902 1-771-884-21 SWITCH, TACTILE (WITH LED) (DISC/PRST +) S903 1-771-884-21 SWITCH, TACTILE (WITH LED) (SEEK/AMS > M +) S904 1-771-884-21 SWITCH, TACTILE (WITH LED) (DISC/PRST ) ************************************************************* * 1-659-835-12 LIMIT SW BOARD *************** < SWITCH > SW3 1-572-688-11 SWITCH, PUSH (1 KEY) (LIMIT) ************************************************************* * 1-659-837-11 LOAD SW BOARD *************** < SWITCH > SW4 1-572-288-21 SWITCH, PUSH (DOWN) ************************************************************* * * * A-3326-196-A MAIN BOARD, COMPLETE (C5000R) A-3326-198-A MAIN BOARD, COMPLETE (C4900R) A-3326-210-A MAIN BOARD, COMPLETE (C5000RX) ********************* 3-040-996-51 3-040-996-61 3-040-998-01 3-041-011-01 7-685-647-11 HEAT SINK (4P) (C4900R) HEAT SINK (6P) (C5000R/C5000RX) BRACKET (IC) HEAT SINK (REG) SCREW BVTP 3X10 TYPE 2 N-S C111 C113 C121 C122 C123 C131 C141 C142 C151 C152 C153 C156 C157 C159 C161 C162 C171 C172 C173 C174 C181 C182 C183 C184 C191 C192 C193 C201 C210 C241 C242 C271 C272 C273 C274 C281 S901 Remark Ref. No. C60 C61 C62 C63 C90 C91 C92 C93 C94 C95 C96 C97 C98 C101 C110

LIMIT SW

Part No. 1-163-135-00 1-164-161-11 1-163-009-11 1-164-315-11 1-162-964-11 1-162-964-11 1-162-964-11 1-163-133-00 1-162-915-11 1-107-823-11 1-163-809-11 1-164-004-11 1-164-004-11 1-126-160-11 1-163-251-11 1-109-982-11 1-109-982-11 1-164-004-11 1-163-037-11 1-163-037-11 1-124-233-11 1-163-251-11 1-126-160-11 1-162-970-11 1-124-584-00 1-163-009-11 1-163-017-00 1-107-823-11 1-162-970-11 1-124-233-11

LOAD SW

560PF 0.0022uF 0.001uF 470PF 0.001uF 0.001uF 0.001uF 470PF 10PF 0.47uF 0.047uF 0.1uF 0.1uF 1uF 100PF 1uF 1uF 0.1uF 0.022uF 0.022uF 10uF 100PF 1uF 0.01uF 100uF 0.001uF 0.0047uF 0.47uF 0.01uF 10uF 0.22uF 4.7uF 100PF 0.22uF 22PF 4.7uF 100PF 0.22uF 22PF 0 1uF 100PF 100PF 1uF 4.7uF 100PF 0.22uF 22PF 4.7uF 5% 10% 10% 5% 10% 10% 10% 5% 0.5PF 10% 10% 10% 10% 20% 5% 10% 10% 10% 10% 10% 20% 5% 20% 10% 20% 10% 5% 10% 10% 20%

1-164-360-11 CERAMIC CHIP 1-164-360-11 CERAMIC CHIP 1-164-360-11 CERAMIC CHIP < CONNECTOR >

CN1 CN2 CN3

1-764-616-12 HOUSING, CONNECTOR (PC BOARD) 30P 1-794-153-21 CONNECTOR, FPC (ZIF) 16P 1-770-347-21 CONNECTOR, FPC 6P < FERRITE BEAD >
FB101 FB102 FB103 FB501 FB503
1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-500-445-21
SHORT 0 SHORT 0 SHORT 0 SHORT 0 FERRITE BEAD INDUCTOR < IC >

IC1 IC5 IC7 IC501

8-752-095-36 8-752-911-88 8-759-653-67 8-752-392-04

IC IC IC IC

CXA2596M-T6 CXP84640-063Q LA6556L-TE-L CXD2598Q
< JUMPER RESISTOR > JR501 JR505 JR506 JR507 1-216-295-00 1-216-864-11 1-216-864-11 1-216-295-00 SHORT METAL CHIP METAL CHIP SHORT < TRANSISTOR > Q101 8-729-904-87 TRANSISTOR 2SB1197K-T-146-R < RESISTOR > R101 R102 R103 R104 R105 R106 R107 R108 R110 R111 R113 R116 R122 R123 R126 R127 1-216-847-11 1-216-847-11 1-216-158-00 1-216-857-11 1-216-833-11 1-216-857-11 1-216-829-11 1-216-829-11 1-216-837-11 1-216-833-11 1-216-839-11 1-216-845-11 1-216-845-11 1-216-839-11 1-216-842-11 METAL CHIP METAL CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 150K 150K 22 1M 10K 1M 4.7K 4.7K 22K 10K 33K 100K 100K 33K 56K 1K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/16W 1/16W 1/8W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 0 0

1-216-821-11 METAL CHIP

1-216-864-11 METAL CHIP 1-216-809-11 METAL CHIP 1-216-809-11 METAL CHIP
Ref. No. R564 R568 R569 R570 R572 R590 R594 R595 R599 Part No. 1-216-845-11 1-216-837-11 1-216-809-11 1-216-821-11 1-216-809-11 1-216-845-11 1-216-845-11 1-216-845-11 1-216-821-11 Description METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP < VIBRATOR > X1 1-781-758-21 VIBRATOR, CERAMIC (CHIP TYPE) (10MHz) X2 1-781-759-21 VIBRATOR, CERAMIC (CHIP TYPE) (16MHz) ************************************************************* * 1-659-834-11 SUB BOARD ********** < CONNECTOR > CN1 1-770-347-21 CONNECTOR, FPC 6P ************************************************************* * 1-677-056-11 SUB (CD) BOARD ************** < CONNECTOR > CNP801 1-794-064-11 SOCKET, CONNECTOR 14P CNP802 1-792-195-11 CABLE, FLEXIBLE FLAT < DIODE > D801 D802 D803 D804 D805 8-719-056-82 8-719-056-82 8-719-056-82 8-719-056-82 8-719-056-82 DIODE DIODE DIODE DIODE DIODE UDZ-TE-17-6.2B UDZ-TE-17-6.2B UDZ-TE-17-6.2B UDZ-TE-17-6.2B UDZ-TE-17-6.2B 100K 22K 100 1K 100 100K 100K 100K 1K 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W Ref. No. Part No. Description

SUB (CD)

MISCELLANEOUS *************** 1-776-527-51 CORD (WITH CONNECTOR) (ISO) (POWER) (C4900R) 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER) (C5000R/C5000RX) X-3378-598-1 CHASSIS (OP) ASSY (INCLUDING M901) 1-659-880-11 MOTOR FLEXIBLE BOARD 8-820-103-03 PICK-UP, OPTICAL KSS-720A/K1RP

212 1-676-707-21 PICK-UP FLEXIBLE BOARD F901 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) 10A M902 A-3291-674-A MOTOR ASSY, SLED (SLED) M903 A-3315-039-A MOTOR SUB ASSY, LD (LOADING) ************************************************************* ACCESSORIES & PACKING MATERIALS ******************************** 3-044-183-11 MANUAL, INSTRUCTION (ENGLISH,SPANISH, SWEDISH,PORTUGUESE,RUSSIAN) (AEP,UK) 3-044-183-21 MANUAL, INSTRUCTION (FRENCH,GERMAN, DUTCH,ITALIAN,GREEK) (AEP) 3-044-183-31 MANUAL, INSTRUCTION (GERMAN) (G) 3-044-188-11 MANUAL, INSTRUCTION INSTALL (ENGLISH, SPANISH,SWEDISH,PORTUGUESE,RUSSIAN) (AEP,UK) 3-044-188-21 MANUAL, INSTRUCTION INSTALL (FRENCH, GERMAN,DUTCH,ITALIAN,GREEK) (AEP,G) X-3378-490-1 CASE (PANEL) ASSY (for FRONT PANEL) ************************************************************* ************** HARDWARE LIST ************** #1 #2 #3 #4 #5 #6 #7 #8 #9 #10 7-685-793-09 7-685-792-09 7-685-795-09 7-685-647-79 7-621-772-20 7-685-791-09 7-628-253-00 7-627-553-37 7-627-553-17 7-627-850-28 SCREW +PTT 2.6X8 (S) SCREW +PTT 2.6X6 (S) SCREW +PTT 2.6X12 (S) SCREW BVTP 3X10 TYPE 2 N-S SCREW +B 2X5 SCREW +PTT 2.6X5 (S) SCREW +PS 2X4 SCREW, PRECISION +P 2X3 TYPE 3 SCREW, PRECISION +P 2X2 TYPE 3 SCREW, PRECISION +P 1.4X3
D806 8-719-109-97 DIODE RD6.8ESB2 LED801 8-719-037-97 LED CL-190R-CD-T (INSERT MARK) (C5000RX) LED801 8-719-038-07 LED CL-190PG-CD-T (INSERT MARK) (C4900R/C5000R) LED802 8-719-037-97 LED CL-190R-CD-T (INSERT MARK) (C5000RX) LED802 8-719-038-07 LED CL-190PG-CD-T (INSERT MARK) (C4900R/C5000R) LED803 8-719-037-97 LED CL-190R-CD-T (INSERT MARK) (C5000RX) LED803 8-719-038-07 LED CL-190PG-CD-T (INSERT MARK) (C4900R/C5000R) < SWITCH > LSW801 1-771-609-11 SWITCH, TACTILE (WITH LED) (Z) (C4900R/C5000R) LSW801 1-771-883-21 SWITCH, TACTILE (WITH LED) (Z) (C5000RX) *************************************************************
#11 7-627-000-00 SCREW, PRECISION +P 1.7X2.2 TYPE 3 #12 7-685-106-19 SCREW +P 2X10 TYPE 2 NON-SLIT *************************************************************
PARTS FOR INSTALLATION AND CONNECTIONS *************************************** X-3373-602-1 3-386-828-01 3-349-410-01 X-3366-405-1 3-040-979-01 3-934-325-01 1-465-459-21 3-233-644-01 1-776-527-51 FRAME ASSY SCREW, FITTING BUSHING SCREW ASSY (EXP), FITTING COLLAR
SCREW, +K (5X8) TAPPING ADAPTOR, ANTENNA SPRING, FITTING CORD (WITH CONNECTOR) (ISO) (POWER) (C4900R) 1-776-527-61 CORD (WITH CONNECTOR) (ISO) (POWER) (C5000R/C5000RX)

251 252

254 253

SUPPLEMENT-1

File this supplement with the service manual.

Subject : Service Notes

(ENG-00015, 00016)

SERVICE NOTES

This label is located on the drive unit's internal chassis. When replacing the chassis (T) of mechanism deck which have the CAUTION LABEL attached, please be sure to put a new CAUTION LABEL (3-223-913-11) to the chassis (T).

Remark 50V 50V 25V 10V 50V 50V 16V 25V 16V 16V
1-126-163-11 ELECT 1-163-251-11 CERAMIC CHIP 1-164-489-11 CERAMIC CHIP 1-162-919-11 CERAMIC CHIP 1-126-163-11 ELECT 1-163-251-11 1-164-489-11 1-162-919-11 1-216-295-11 1-216-295-11 1-216-295-11 1-126-160-11 1-163-251-11 1-163-251-11 1-126-160-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP SHORT SHORT SHORT ELECT CERAMIC CHIP CERAMIC CHIP ELECT
7-685-793-09 SCREW +PTT 2.6X8 (S) 7-685-795-09 SCREW +PTT 2.6X12 (S) < CAPACITOR > C1 C3 C4 C6 C7 C13 C14 C52 C53 C54 C55 C56 C57 C58 C59 C60 C61 C62 C63 C90 C91 C92 C93 C94 C95 C96 C97 C98 C101 C110 C111 C113 C121 C122 C123 1-163-233-11 1-124-584-00 1-164-004-11 1-164-004-11 1-124-589-11 1-163-017-00 1-163-021-00 1-164-004-11 1-163-229-11 1-163-229-11 1-164-004-11 1-124-589-11 1-164-004-11 1-163-263-11 1-164-505-11 1-163-135-00 1-164-161-11 1-163-009-11 1-164-315-11 1-162-964-11 1-162-964-11 1-162-964-11 1-163-133-00 1-162-915-11 1-107-823-11 1-163-809-11 1-164-004-11 1-164-004-11 1-126-160-11 1-163-251-11 1-109-982-11 1-109-982-11 1-164-004-11 1-163-037-11 1-163-037-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 18PF 100uF 0.1uF 0.1uF 47uF 0.0047uF 0.01uF 0.1uF 12PF 12PF 0.1uF 47uF 0.1uF 330PF 2.2uF 560PF 0.0022uF 0.001uF 470PF 0.001uF 0.001uF 0.001uF 470PF 10PF 0.47uF 0.047uF 0.1uF 0.1uF 1uF 100PF 1uF 1uF 0.1uF 0.022uF 0.022uF 5% 20% 10% 10% 20% 5% 10% 10% 5% 5% 10% 20% 10% 5% 50V 10V 25V 25V 16V 50V 50V 25V 50V 50V 25V 16V 25V 50V 16V 50V 100V 50V 50V 50V 50V 50V 50V 50V 16V 25V 25V 25V 50V 50V 10V 10V 25V 25V 25V
20% 50V 5% 50V (C5000R/C5000RX) 10% 16V 5% 50V 20% 50V 5% 10% 5% 50V 16V 50V

20% 5% 5% 20%

50V 50V 50V 50V
1-126-163-11 ELECT 1-163-251-11 CERAMIC CHIP 1-164-489-11 CERAMIC CHIP 1-162-919-11 CERAMIC CHIP 1-126-163-11 ELECT 1-163-251-11 1-164-489-11 1-162-919-11 1-164-004-11 1-126-157-11 1-164-004-11 1-126-157-11 1-164-004-11 1-124-233-11 1-109-982-11 1-109-982-11 1-163-021-11 1-163-021-11 1-163-021-11 1-163-021-11 1-163-021-11 1-124-584-00 1-124-584-00 1-164-004-11 1-164-004-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP

1-162-927-11 CERAMIC CHIP 1-164-489-11 1-135-473-21 1-163-251-11 1-162-964-11 1-126-160-11 1-126-160-11 1-126-157-11 1-107-823-11 1-136-165-00 1-124-589-11 1-109-982-11 1-164-222-11 1-164-222-11 1-162-964-11 1-163-021-11 1-125-710-11 1-124-584-00 1-109-982-11 1-126-157-11 1-126-157-11 1-126-157-11 1-124-233-11 1-124-233-11 1-126-157-11 1-163-021-11 1-162-970-11 1-164-004-11 1-164-227-11 1-165-319-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP FILM ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP DOUBLE LAYERS ELECT CERAMIC CHIP ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
5% 50V (C5000R/C5000RX) 0.22uF 10% 16V 3300uF 20% 16V 100PF 5% 50V 0.001uF 10% 50V 1uF 1uF 10uF 0.47uF 0.1uF 47uF 1uF 0.22uF 0.22uF 0.001uF 0.01uF 0.1F 100uF 1uF 10uF 10uF 10uF 10uF 10uF 10uF 0.01uF 0.01uF 0.1uF 0.022uF 0.1uF 470uF 20% 20% 20% 10% 5% 20% 10% 50V 50V 16V 16V 50V 16V 10V 25V 25V 50V 50V 5.5V 10V 10V 16V 16V 16V 16V 16V 16V 50V 25V 25V 25V 50V 16V
10% 10% 20% 10% 20% 20% 20% 20% 20% 20% 10% 10% 10% 10%
1-126-935-11 ELECT < CONNECTOR >

CN301 CN500 CN601 CN701

1-764-617-12 1-784-456-11 1-774-701-11 1-580-907-31
PIN, CONNECTOR (PC BOARD) 30P CONNECTOR, FFC/FPC 14P PIN, CONNECTOR 16P PLUG, CONNECTOR (BUS CONTROL IN) < JACK >
CNJ151 1-774-699-12 JACK, PIN 4P (BUS AUDIO IN, AUDIO OUT REAR) (C4900R)
8-719-017-62 DIODE MA8068-L-TX 8-719-056-82 DIODE UDZ-TE-17-6.2B 8-719-056-93 DIODE UDZ-TE-17-18B
Ref. No. D705 D706 D708 D709 D710 Part No. 8-719-056-93 8-719-072-70 8-719-073-01 8-719-073-01 8-719-073-01 Description DIODE DIODE DIODE DIODE DIODE UDZ-TE-17-18B MA2ZD14001S0 MA111-TX MA111-TX MA111-TX Remark Ref. No. Q171 Q181 Q271 Q281 Q361 Q362 Q363 Q364 Q365 Q551 Q571 < IC > IC51 IC90 IC151 IC501 IC611 IC652 IC671 IC701 8-759-492-59 8-759-909-71 8-759-653-27 8-759-663-56 8-759-690-99 IC IC IC IC IC SAA6588T/V2-118 BA4558F-E2 TDA7402TR MB90574BPMT-G-266-BND TA8268HS Q621 Q622 Q631 Q633 Q651 Q652 Q661 Q701 Q704 Q705 Q706 Part No. 8-729-920-21 8-729-920-21 8-729-920-21 8-729-920-21 8-729-019-00 8-729-019-00 8-729-921-25 8-729-015-11 8-729-921-25 8-729-921-25 Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DTC314TK-T-146 DTC314TK-T-146 DTC314TK-T-146 DTC314TK-T-146 2SD2394-G 2SD2394-G FMC2-T148 2SD1802FAST-TL FMC2-T148 FMC2-T148 Remark
< FERRITE BEAD > FB361 FB362 FB363 FB501 1-414-233-22 1-414-233-22 1-414-233-22 1-414-233-22 INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD
8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR (C5000R/C5000RX) 8-729-027-23 TRANSISTOR DTA114EKA-T146 8-729-021-94 FET 2SK1657-T1B 8-729-423-99 TRANSISTOR 2SD2137-OP-TA 8-729-921-25 TRANSISTOR FMC2-T148 8-729-027-23 8-729-027-23 8-729-120-28 8-729-900-53 8-729-027-23 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DTA114EKA-T146 DTA114EKA-T146 2SC2412K-T-146-QR DTC114EKA-T146 DTA114EKA-T146

CDX-C4900R/C5000R/C5000RX

AEP Model UK Model

SERVICE MANUAL

SUPPLEMENT-2

File this supplement with the service manual.
Subject : Change of Main, Sub (CD) and Key Boards

(ECN-CSA01521/CSA02901)

TABLE OF CONTENTS 1. CHANGE OF MAIN, SUB (CD) AND KEY BOARDS 1-1. Discrimination... 2 1-2. Diagrams
Printed Wiring Board Main Section.. 4 Schematic Diagram Main Section (1/3).. 6 Schematic Diagram Main Section (2/3).. 7 Schematic Diagram Main Section (3/3).. 8 Schematic Diagram Sub (CD) Section.. 9 Printed Wiring Board Sub (CD) Section.. 10 Printed Wiring Board Key Section.. 11 Schematic Diagram Key Section... 12
1-3. ELECTRICAL PARTS LIST.. 13
1. Change of Main, Sub (CD) and Key Boards
When performing service and inspection, check the part number of the main, sub (CD) and key boards.

1-1. Discrimination

-MAIN BOARD (COMPONENT SIDE)-
Main board part No. Former:1-677-055-11 New :1-677-055-12
-SUB(CD) BOARD (COMPONENT SIDE)-
Sub(CD) board part No. Former:1-677-056-11 New :1-677-056-12
-KEY BOARD (COMPONENT SIDE)-
Key board part No. Former:1-676-602-12 New :1-676-602-13

1-2. Diagrams

THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) Refer to page. ( ) : Refer to page of supplement-2. < > : Refer to page of service manual. for schematic diagram: All capacitors are in F unless otherwise noted. pF: F 50 WV or less are not indicated except for electrolytics and tantalums. All resistors are in and 1/4 W or less unless otherwise specified. % : indicates tolerance. f : internal component. C : panel designation. U : B+ Line. Power voltage is dc 14.4V and fed with regulated dc power supply from ACC and BATT cords. Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. Circled numbers refer to waveforms. Signal path. F : FM f : MW J : CD for printed wiring boards: X : parts extracted from the component side. Y : parts extracted from the conductor side. a : Through hole. b : Pattern from the side which enables seeing. (The other layers patterns are not indicated.) Caution: Pattern face side: (Side B) Parts face side: (Side A) Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
PRINTED WIRING BOARD MAIN SECTION
Semiconductor Location (Side A) Ref. No. Location D1 E-9 D301 G-4 D501 I-7 D502 H-7 D551 J-13 D552 K-13 D553 K-13 D554 J-12 D555 K-13 D556 J-12 D557 K-13 D558 J-12 D559 K-13 D560 J-12 (D571) B-5 D603 B-4 (D605) B-5 D622 D-9 D624 C-9 D653 I-7 D661 D-5 D662 D-5 D673 C-5 D674 C-5 D701 E-5 D702 C-4 D703 B-3 D704 B-2 D705 B-2 D706 B-2 D708 G-7 D710 D-4 IC51 IC90 IC151 IC501 IC652 IC701 Q1 Q171 Q181 Q271 Q281 Q363 Q365 Q551 (Q571) Q621 Q622 Q633 Q651 Q652 Q661 Q701 Q704 Q705 Q706 ( I-12 H-11 D-10 I-5 J-3 C-3 G-11 B-11 B-11 C-11 C-11 I-3 G-2 J-6 D-6 C-10 C-9 J-2 I-8 I-8 D-5 D-5 G-7 C-4 D-4
): CDX-C5000R/C5000RX only

<Page 27>

Semiconductor Location (Side B) Ref. No. Location D2 E-8 D90 H-12 D91 H-11 D92 G-12 D302 G-8 D361 I-2 D362 G-2 D363 G-3 D561 K-11 D562 K-11 D601 C-3 D602 B-4 D604 A-5 D621 C-10 D631 J-2 D671 C-5 D672 C-5 D675 I-4 D676 I-4 D677 I-4 D709 G-5 IC611 IC671 Q90 Q361 Q362 Q364 Q631 B-7 E-1 G-11 H-1 G-1 G-2 J-2

(Page 10)

SCHEMATIC DIAGRAM MAIN SECTION (1/3) Refer to page 39 of Service manual for IC Block Diagrams.

(Page 7)

(Page 8)
Note: Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM ( ) : MW
SCHEMATIC DIAGRAM MAIN SECTION (2/3)

(Page 6)

<Page 28>
Note: Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM ( ) : MW < > : CD PLAY : Impossible to measure
SCHEMATIC DIAGRAM MAIN SECTION (3/3) Refer to page 39 of Service manual for IC Block Diagrams.

(Page 9)

SCHEMATIC DIAGRAM SUB (CD) SECTION

(Page 12)

PRINTED WIRING BOARD SUB (CD) SECTION

(Page 5)

(Page 11)
PRINTED WIRING BOARD KEY SECTION

Semiconductor Location Ref. No. (D901) (D902) (D903) (D904) (D951) (D952) (IC901) IC951 LED901 ( < Location A-11 B-10 B-10 B-10 C-4 B-6 B-8 C-5 A-2 Ref. No. LED902 LED903 LED904 LED910 LED911 LED912 LED913 <Q901> <Q902> Location C-2 C-4 A-4 B-12 B-12 A-5 B-5 A-3 A-3 (Page 10)
) : SIDE B > : SIDE B, CDX-C4900R/C5000R only
SCHEMATIC DIAGRAM KEY SECTION
Note: Voltage is dc with respect to ground under no-signal (detuned) condition. no mark : FM : Impossible to measure
1-3. Electrical Parts List
NOTE: Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX and -X mean standardized parts, so they may have some difference from the original one. RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. SEMICONDUCTORS In each case, u : , for example: uA. : A. uPA. : PA. uPB. : PB. uPC. : PC. uPD. : PD. CAPACITORS uF : F COILS uH : H
When indicating parts by reference number, please include the board.

Ref. No.

Part No.
Description KEY BOARD **********

Remark

Ref. No. LED904 LED904 LED910 LED911
Part No. 8-719-061-16 8-719-078-15 8-719-078-19 8-719-078-19
Description LED LED LED LED
1-694-660-11 3-040-992-02 3-040-993-01 3-040-997-02 3-041-371-11
CONDUCTIVE BOARD, CONNECTION HOLDER (LCD) PLATE (LCD), LIGHT GUIDE PLATE (LCD), GROUND SHEET (REFLECTOR) < CAPACITOR >
CL-190SR-CD-T (C5000RX) CL-165Y/PG-D-T (C4900R/C5000R) LWA673-R1S2 LWA673-R1S2
LED912 8-719-078-19 LED LWA673-R1S2 LED913 8-719-078-19 LED LWA673-R1S2 < SWITCH > LSW901 1-771-610-11 SWITCH, TACTILE (WITH LED) (OFF) (C4900R/C5000R) LSW901 1-771-883-11 SWITCH, TACTILE (WITH LED) (OFF) (C5000RX) LSW902 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (SOURCE) (C4900R/C5000R) LSW902 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (SOURCE) (C5000RX) LSW903 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (SOUND) (C4900R/C5000R) LSW903 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (SOUND) (C5000RX) LSW904 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (MENU) (C4900R/C5000R) LSW904 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (MENU) (C5000RX) LSW905 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (DSPL/PTY) (C4900R/C5000R) LSW905 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (DSPL/PTY) (C5000RX) LSW906 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (LIST) (C4900R/C5000R) LSW906 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (LIST) (C5000RX) LSW907 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (ENTER) (C4900R/C5000R) LSW907 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (ENTER) (C5000RX) LSW908 1-771-610-11 SWITCH, TACTILE (WITH LED) (MODE) (C4900R/C5000R) LSW908 1-771-883-11 SWITCH, TACTILE (WITH LED) (MODE) (C5000RX) LSW909 1-762-737-11 SWITCH, KEY BOARD (WITH LED) (D-BASS) LSW910 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (TA) (C4900R/C5000R) LSW910 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (TA) (C5000RX) LSW911 1-762-620-21 SWITCH, KEY BOARD (WITH LED) (AF) (C4900R/C5000R)

C951 C952 C953 C954 C955 C956
1-164-004-11 1-163-037-11 1-163-251-11 1-164-004-11 1-164-004-11
CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
0.1uF 0.022uF 100PF 0.1uF 0.1uF 0.22uF

10% 10% 5% 10% 10% 10%

25V 25V 50V 25V 25V 16V
1-164-489-11 CERAMIC CHIP < CONNECTOR >
1-794-065-21 PLUG, CONNECTOR 14P < DIODE >
D901 D902 D903 D904 D951 D952
8-719-158-49 8-719-056-82 8-719-056-82 8-719-056-82 8-719-976-99
DIODE DIODE DIODE DIODE DIODE
UDZ-TE-17-12B UDZ-TE-17-6.2B UDZ-TE-17-6.2B UDZ-TE-17-6.2B UDZ-TE-17-5.1B
8-719-976-99 DIODE UDZ-TE-17-5.1B < IC >

IC901 IC951

8-759-366-34 IC LC75824E 8-749-012-25 IC RS-170-TU < LIQUID CRYSTAL DISPLAY >
LCD901 1-803-906-11 DISPLAY PANEL, LIQUID CRYSTAL (C4900R/C5000R) LCD901 1-803-906-31 DISPLAY PANEL, LIQUID CRYSTAL (C5000RX) < DIODE > LED901 LED901 LED902 LED902 LED903 8-719-061-16 8-719-078-15 8-719-061-16 8-719-078-15 8-719-061-16 LED LED LED LED LED CL-190SR-CD-T (C5000RX) CL-165Y/PG-D-T (C4900R/C5000R) CL-190SR-CD-T (C5000RX) CL-165Y/PG-D-T (C4900R/C5000R) CL-190SR-CD-T (C5000RX)
LED903 8-719-078-15 LED CL-165Y/PG-D-T (C4900R/C5000R)
Ref. No. Part No. Description Remark Ref. No. R922 R923 R923 R924 R925 LSW914 1-771-610-11 SWITCH, TACTILE (WITH LED) (4) (C4900R/C5000R) LSW914 1-771-883-11 SWITCH, TACTILE (WITH LED) (4) (C5000RX) LSW915 1-771-610-11 SWITCH, TACTILE (WITH LED) (3) (C4900R/C5000R) LSW915 1-771-883-11 SWITCH, TACTILE (WITH LED) (3) (C5000RX) LSW916 1-771-610-11 SWITCH, TACTILE (WITH LED) (2/SHUF) (C4900R/C5000R) LSW916 1-771-883-11 SWITCH, TACTILE (WITH LED) (2/SHUF) (5000RX) LSW917 1-771-610-11 SWITCH, TACTILE (WITH LED) (1/REP) (C4900R/C5000R) LSW917 1-771-883-11 SWITCH, TACTILE (WITH LED) (1/REP) (C5000RX) < TRANSISTOR > R933 Q901 Q902 8-729-904-75 TRANSISTOR DTD114EK-T-146 (C4900R/C5000R) 8-729-904-75 TRANSISTOR DTD114EK-T-146 (C4900R/C5000R) < RESISTOR > R901 R902 R903 R904 R905 R906 R907 R908 R909 R910 R911 R912 R913 R914 R915 R916 R917 R918 R919 R920 R921 R921 1-216-647-11 1-216-647-11 1-216-647-11 1-216-651-11 1-216-655-11 1-216-655-11 1-216-659-11 1-216-663-11 1-216-667-11 1-216-671-11 1-208-806-11 1-216-647-11 1-216-647-11 1-216-647-11 1-216-651-11 1-216-655-11 1-216-655-11 1-216-659-11 1-216-663-11 1-216-667-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 6.8K 10K 680 1K 1.5K 1.5K 2.2K 3.3K 4.7K 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 2% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W R934 1-216-813-11 METAL CHIP 1-216-808-11 METAL CHIP Part No. Description 150 Remark 5% 1/16W (C4900R/C5000R) 5% 1/16W (C4900R/C5000R) 5% 1/16W (C5000RX) 5% 1/16W (C4900R/C5000R) 5% 1/10W (C4900R/C5000R) 1/10W (C5000RX) 5% 1/16W (C4900R/C5000R) 5% 1/10W (C4900R/C5000R) 5% 1/10W (C5000RX) 5% 1/16W (C4900R/C5000R) 5% 1/16W 5% 1/16W 5% 1/16W (C4900R/C5000R) 5% 1/16W (C5000RX) 5% 1/16W (C4900R/C5000R) 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/16W 1/16W (C5000RX) 1/16W 1/10W 1/16W 1/10W 1/10W 1/16W 1/16W 1/10W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W (C5000RX) 5% LSW911 1-771-476-11 SWITCH, KEY BOARD (WITH LED) (AF) (C5000RX) LSW912 1-771-610-11 SWITCH, TACTILE (WITH LED) (6) (C4900R/C5000R) LSW912 1-771-883-11 SWITCH, TACTILE (WITH LED) (6) (C5000RX) LSW913 1-771-610-11 SWITCH, TACTILE (WITH LED) (5) (C4900R/C5000R) LSW913 1-771-883-11 SWITCH, TACTILE (WITH LED) (5) (C5000RX) 1-216-807-11 METAL CHIP 1-216-811-11 METAL CHIP 1-216-812-11 METAL CHIP 1-216-807-11 METAL CHIP 1-216-029-00 METAL CHIP

R925 R926 R927 R927 R928

1-216-031-00 METAL CHIP 1-216-807-11 METAL CHIP 1-216-029-00 METAL CHIP 1-216-031-00 METAL CHIP 1-216-807-11 METAL CHIP

R931 R932 R933

1-216-813-11 METAL CHIP 1-216-813-11 METAL CHIP 1-216-812-11 METAL CHIP
R938 R939 R951 R952 R953 R954 R955 R956 R957 R958 R970 R971 R972 R975 R976 R980 R999
1-216-809-11 METAL CHIP 1-216-821-11 METAL CHIP 1-216-819-11 METAL CHIP 1-216-057-00 METAL CHIP 1-216-857-11 METAL CHIP 1-216-049-11 1-216-049-11 1-216-821-11 1-216-851-11 1-216-033-00 1-216-815-11 1-216-815-11 1-216-864-11 1-216-815-11 1-216-815-11 RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP
100 1K 680 2.2K 1M 1K 1K 1K 330K 0 0
1-216-864-11 METAL CHIP 1-216-864-11 METAL CHIP
< ROTARY ENCODER > RE901 1-475-014-12 ENCODER, ROTARY < SWITCH > S901 S902 1-771-884-11 SWITCH, TACTILE (WITH LED) (SEEK/AMS. m ) 1-771-884-11 SWITCH, TACTILE (WITH LED) (DISC+/PRST+)
1-216-810-11 METAL CHIP 1-216-811-11 METAL CHIP
1/16W (C5000RX) 5% 1/16W (C4900R/C5000R)
Ref. No. S903 Part No. Description Remark Ref. No. C141 C142 C151 C152 C153 C156 C157 C159 C161 C162 C171 C172 C173 C174 C181 C182 C183 C184 C191 C192 C193 C201 C210 C241 C242 C271 C272 C273 C274 C281 C282 C283 C284 C361 C362 C363 C364 C365 C366 C367 C368 C369 C370 C371 C372 C373 C374 C375 C502 C503 C504 Part No. 1-163-251-11 1-126-160-11 1-162-970-11 1-124-584-00 1-163-009-11 1-163-017-00 1-107-823-11 1-162-970-11 1-124-233-11 1-164-489-11 Description CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP 100PF 1uF 0.01uF 100uF 0.001uF 0.0047uF 0.47uF 0.01uF 10uF 0.22uF 4.7uF 100PF 0.22uF 22PF 4.7uF 100PF 0.22uF 22PF 0 1uF 100PF 100PF 1uF 4.7uF 100PF 0.22uF 22PF 4.7uF 100PF 0.22uF 22PF 0.1uF 10uF 0.1uF 10uF 0.1uF 10uF 1uF 1uF 0.01uF 0.01uF 0.01uF 0.01uF 0.01uF 100uF 100uF 0.1uF 0.1uF 0.1uF 5% 20% 10% 20% 10% 5% 10% 10% 20% 10% 1-771-884-11 SWITCH, TACTILE (WITH LED) (SEEK/AMS > M +) S904 1-771-884-11 SWITCH, TACTILE (WITH LED) (DISC-/PRST-) ************************************************************* * * * A-3326-196-A MAIN BOARD, COMPLETE (C5000R) A-3326-198-A MAIN BOARD, COMPLETE (C4900R) A-3326-210-A MAIN BOARD, COMPLETE (C5000RX) ********************* 3-040-996-52 3-040-996-62 3-040-998-01 3-041-011-01 7-685-647-79 HEAT SINK (2P) (C4900R) HEAT SINK (2P) (C5000R/C5000RX) BRACKET (IC) HEAT SINK (REG) SCREW +BVTP 3X10 TYPE2 N-S

Remark 50V 50V 25V 10V 50V 50V 16V 25V 16V 16V

* * * *

1-126-163-11 ELECT 1-163-251-11 CERAMIC CHIP 1-164-489-11 CERAMIC CHIP 1-162-919-11 CERAMIC CHIP 1-126-163-11 ELECT 1-163-251-11 1-164-489-11 1-162-919-11 1-216-295-11 1-216-295-11 1-216-295-11 1-126-160-11 1-163-251-11 1-163-251-11 1-126-160-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP SHORT SHORT SHORT ELECT CERAMIC CHIP CERAMIC CHIP ELECT
7-685-793-09 SCREW +PTT 2.6X8 (S) 7-685-795-09 SCREW +PTT 2.6X12 (S) < CAPACITOR > C1 C3 C4 C6 C7 C13 C14 C52 C53 C54 C55 C56 C57 C58 C59 C60 C61 C62 C63 C90 C91 C92 C93 C94 C95 C96 C97 C98 C101 C110 C111 C113 C121 C122 C123 1-163-233-11 1-124-584-00 1-164-004-11 1-164-004-11 1-124-589-11 1-163-017-00 1-163-021-00 1-164-004-11 1-163-229-11 1-163-229-11 1-164-004-11 1-124-589-11 1-164-004-11 1-163-263-11 1-164-505-11 1-163-135-00 1-164-161-11 1-163-009-11 1-164-315-11 1-162-964-11 1-162-964-11 1-162-964-11 1-163-133-00 1-162-915-11 1-107-823-11 1-163-809-11 1-164-004-11 1-164-004-11 1-126-160-11 1-163-251-11 1-109-982-11 1-109-982-11 1-164-004-11 1-163-037-11 1-163-037-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 18PF 100uF 0.1uF 0.1uF 47uF 0.0047uF 0.01uF 0.1uF 12PF 12PF 0.1uF 47uF 0.1uF 330PF 2.2uF 560PF 0.0022uF 0.001uF 470PF 0.001uF 0.001uF 0.001uF 470PF 10PF 0.47uF 0.047uF 0.1uF 0.1uF 1uF 100PF 1uF 1uF 0.1uF 0.022uF 0.022uF 5% 20% 10% 10% 20% 5% 10% 10% 5% 5% 10% 20% 10% 5% 50V 10V 25V 25V 16V 50V 50V 25V 50V 50V 25V 16V 25V 50V 16V 50V 100V 50V 50V 50V 50V 50V 50V 50V 16V 25V 25V 25V 50V 50V 10V 10V 25V 25V 25V
20% 50V 5% 50V (C5000R/C5000RX) 10% 16V 5% 50V 20% 50V 5% 10% 5% 50V 16V 50V

20% 5% 5% 20%

50V 50V 50V 50V
1-126-163-11 ELECT 1-163-251-11 CERAMIC CHIP 1-164-489-11 CERAMIC CHIP 1-162-919-11 CERAMIC CHIP 1-126-163-11 ELECT 1-163-251-11 1-164-489-11 1-162-919-11 1-164-004-11 1-126-157-11 1-164-004-11 1-126-157-11 1-164-004-11 1-124-233-11 1-109-982-11 1-109-982-11 1-163-021-11 1-163-021-11 1-163-021-11 1-163-021-11 1-163-021-11 1-124-584-00 1-124-584-00 1-164-004-11 1-164-004-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP

1-162-927-11 CERAMIC CHIP 1-164-489-11 1-135-473-21 1-163-251-11 1-162-964-11 1-126-160-11 1-126-160-11 1-126-157-11 1-107-823-11 1-136-165-00 1-124-589-11 1-109-982-11 1-164-222-11 1-164-222-11 1-162-964-11 1-163-021-11 1-125-710-11 1-124-584-00 1-109-982-11 1-126-157-11 1-126-157-11 1-126-157-11 1-124-233-11 1-124-233-11 1-126-157-11 1-163-021-11 1-162-970-11 1-164-004-11 1-164-227-11 1-165-319-11 CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP FILM ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP DOUBLE LAYERS ELECT CERAMIC CHIP ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP
5% 50V (C5000R/C5000RX) 0.22uF 10% 16V 3300uF 20% 16V 100PF 5% 50V 0.001uF 10% 50V 1uF 1uF 10uF 0.47uF 0.1uF 47uF 1uF 0.22uF 0.22uF 0.001uF 0.01uF 0.1F 100uF 1uF 10uF 10uF 10uF 10uF 10uF 10uF 0.01uF 0.01uF 0.1uF 0.022uF 0.1uF 470uF 20% 20% 20% 10% 5% 20% 10% 50V 50V 16V 16V 50V 16V 10V 25V 25V 50V 50V 5.5V 10V 10V 16V 16V 16V 16V 16V 16V 50V 25V 25V 25V 50V 16V
10% 10% 20% 10% 20% 20% 20% 20% 20% 20% 10% 10% 10% 10%
1-126-935-11 ELECT < CONNECTOR >

CN301 CN500 CN601 CN701

1-764-617-12 1-784-456-11 1-774-701-11 1-580-907-31
PIN, CONNECTOR (PC BOARD) 30P CONNECTOR, FFC/FPC 14P PIN, CONNECTOR 16P PLUG, CONNECTOR (BUS CONTROL IN) < JACK >
CNJ151 1-774-699-12 JACK, PIN 4P (BUS AUDIO IN, AUDIO OUT REAR) (C4900R)
8-719-017-62 DIODE MA8068-L-TX 8-719-056-82 DIODE UDZ-TE-17-6.2B 8-719-056-93 DIODE UDZ-TE-17-18B
Ref. No. D705 D706 D708 D709 D710 Part No. 8-719-056-93 8-719-072-70 8-719-073-01 8-719-073-01 8-719-073-01 Description DIODE DIODE DIODE DIODE DIODE UDZ-TE-17-18B MA2ZD14001S0 MA111-TX MA111-TX MA111-TX Remark Ref. No. Q171 Q181 Q271 Q281 Q361 Q362 Q363 Q364 Q365 Q551 Q571 < IC > IC51 IC90 IC151 IC501 IC611 IC652 IC671 IC701 8-759-492-59 8-759-909-71 8-759-653-27 8-759-663-56 8-759-690-99 IC IC IC IC IC SAA6588T/V2-118 BA4558F-E2 TDA7402TR MB90574BPMT-G-266-BND TA8268HS Q621 Q622 Q631 Q633 Q651 Q652 Q661 Q701 Q704 Q705 Q706 Part No. 8-729-920-21 8-729-920-21 8-729-920-21 8-729-920-21 8-729-019-00 8-729-019-00 8-729-921-25 8-729-015-11 8-729-921-25 8-729-921-25 Description TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DTC314TK-T-146 DTC314TK-T-146 DTC314TK-T-146 DTC314TK-T-146 2SD2394-G 2SD2394-G FMC2-T148 2SD1802FAST-TL FMC2-T148 FMC2-T148 Remark
< FERRITE BEAD > FB361 FB362 FB363 FB501 1-414-233-22 1-414-233-22 1-414-233-22 1-414-233-22 INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD INDUCTOR, FERRITE BEAD
8-729-120-28 TRANSISTOR 2SC2412K-T-146-QR (C5000R/C5000RX) 8-729-027-23 TRANSISTOR DTA114EKA-T146 8-729-021-94 FET 2SK1657-T1B 8-729-423-99 TRANSISTOR 2SD2137-OP-TA 8-729-921-25 TRANSISTOR FMC2-T148 8-729-027-23 8-729-027-23 8-729-120-28 8-729-900-53 8-729-027-23 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR DTA114EKA-T146 DTA114EKA-T146 2SC2412K-T-146-QR DTC114EKA-T146 DTA114EKA-T146

1-216-025-11 RES-CHIP 1-216-025-11 1-216-025-11 1-216-025-11 1-216-025-11 1-216-025-11 1-216-025-11 1-216-025-11 1-216-025-11 1-208-806-11 1-208-806-11 1-216-845-11 1-216-845-11 1-216-025-11 1-249-411-11 1-216-845-11 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP CARBON METAL CHIP
R572 R573 R601 R603 R611 R612 R621 R622 R624 R626 R631 R632 R636 R641 R642 R651 R652 R653 R654 R655 R656 R661 R662 R663 R664 R682
1-216-809-11 1-216-809-11 1-216-073-00 1-216-073-11 1-216-833-11 1-216-073-00 1-216-805-11 1-216-864-11 1-216-295-11 1-216-861-11 1-249-385-11 1-249-385-11 1-216-037-00 1-216-849-11 1-216-853-11 1-216-113-00 1-216-845-11 1-208-806-11 1-216-833-11 1-216-809-11 1-216-809-11 1-249-421-11 1-216-081-00 1-216-841-11 1-216-841-11
METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP SHORT METAL CHIP CARBON CARBON METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP CARBON METAL CHIP METAL CHIP METAL CHIP
10K 10K 10K 10K 0 2.2M 2.2 2.220K 470K 470K 100K 10K 10K 2.2K 22K 47K 47K 47K
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 0.5% 5% 5% 5% 5% 5% 5% 5% 5%
R510 R520 R522 R523 R524 R525 R527 R529 R531 R532
1-216-097-11 RES-CHIP 1-216-097-11 1-216-097-11 1-216-845-11 1-216-073-00 1-216-073-00 1-216-845-11 1-216-049-11 1-216-839-11 RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP
100K 100K 100K 100K 10K 10K 100K 1K 33K 10K
5% 1/10W (C4900R/C5000R) 5% 1/10W 5% 1/10W 5% 1/16W 5% 1/10W 5% 1/10W 5% 1/16W 5% 1/10W 5% 1/16W (C5000R/C5000RX) 5% 1/16W (C5000R/C5000RX) 5% 1/16W (C5000R/C5000RX) 5% 1/10W (C5000R/C5000RX) 5% 1/16W

1-216-833-11 METAL CHIP

R533 R534 R535
1-216-833-11 METAL CHIP 1-216-097-11 RES-CHIP 1-216-845-11 METAL CHIP

10K 100K 100K

1-216-089-11 RES-CHIP
Ref. No. R701 R702 R703 R704 R707 R713 R714 R715 R716 Part No. 1-216-805-11 1-216-073-00 1-216-025-11 1-216-809-11 1-216-065-00 1-216-841-11 1-216-841-11 1-216-845-11 1-216-809-11 Description METAL CHIP METAL CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP < SWITCH > SW503 SW504 1-692-431-21 SWITCH, TACTILE (RESET) 1-771-540-11 SWITCH, PUSH (1 KEY) (NOSE DET) < THERMISTOR (POSITIVE) > TH701 1-803-350-21 THERMISTOR, POSITIVE < TUNER > TU1 A-3220-738-A TUNER UNIT (TUX-020//Q) < VIBRATOR > X51 1-579-242-41 VIBRATOR, CRYSTAL (4.332MHz) X501 1-767-833-21 VIBRATOR, CERAMIC (3.68MHz) X502 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz) ************************************************************* * 1-677-056-12 SUB (CD) BOARD ************** 3-039-443-11 SHEET (CONNECTOR) < CONNECTOR > CNP801 1-794-064-11 SOCKET, CONNECTOR 14P CNP802 1-792-195-11 CABLE, FLEXIBLE FLAT (14 CORE) < DIODE > D801 D802 D803 D804 D805 D806 D807 D808 LED801 8-719-056-82 8-719-056-82 8-719-056-82 8-719-056-82 8-719-056-82 8-719-056-82 8-719-056-82 8-719-056-82 8-719-037-97 DIODE DIODE DIODE DIODE DIODE UDZ-TE-17-6.2B UDZ-TE-17-6.2B UDZ-TE-17-6.2B UDZ-TE-17-6.2B UDZ-TE-17-6.2B 47 10K 4.7K 47K 47K 100K 100 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/16W 1/10W 1/10W 1/16W 1/10W 1/16W 1/16W 1/16W 1/16W Ref. No. Part No. Description

SUB (CD)

LED803 8-719-038-07 LED CL-190PG-CD-T (INSERT MARK) (C4900R/C5000R) < SWITCH > LSW801 1-771-609-11 SWITCH, TACTILE (WITH LED) (Z) (C4900R/C5000R) LSW801 1-771-883-11 SWITCH, TACTILE (WITH LED) (Z) (C5000RX)
DIODE UDZ-TE-17-6.2B DIODE UDZ-TE-17-6.2B DIODE UDZ-TE-17-6.2B LED CL-190R-CD-T (INSERT MARK) (C5000RX) LED801 8-719-038-07 LED CL-190PG-CD-T (INSERT MARK) (C4900R/C5000R) LED802 8-719-037-97 LED CL-190R-CD-T (INSERT MARK) (C5000RX) LED802 8-719-038-07 LED CL-190PG-CD-T (INSERT MARK) (C4900R/C5000R) LED803 8-719-037-97 LED CL-190R-CD-T (INSERT MARK) (C5000RX)

9-870-070-82

Sony Corporation
Audio Entertainment Group
2000I0441-1 Printed in Japan 2000. 9 Published by General Engineering Dept.