HIGH BEAM

PAINLESS HEADLIGHT RELAY KIT 30815
SPAL FAN RELAY KIT 185 FRH -

BATTERY

GROUND BLK 16 GA

RADIO SONY CDX-M7815X

RW RB B

LT GRN TAN BLK RED YEL

1966 Datsun 1600
SPL 311-02305 Custom Wiring Harness
PANEL LIGHTS V CONSTANT V SWITCHED 941

BLK RED BLK YEL BLK

BRN BLU

RIGHT TURN SIGNAL

FUEL PUMP

LOW BEAM

HEADLIGHTS & COOLING FAN RELAYS

RED YEL

BATTERY NEG

BATTERY POS

TURN SIGNAL

RED 14 GA

901 GRY RED

BLK 14 GA

922 LT GRN 14 GA LT GRN 14 GA 918 917

PARKING LIGHT

WIRING MODIFICATIONS FOR GM ALTERNATORS OVER 65 AMPS STARTER SOLENOID RIGHT FOG LIGHT

+ S B RED 8 GA

50A 1 R F 914
NUMBERED WIRES ALSO CAME WITH TEXT FOR CIRCUIT IDENTIFICATION. NOT ALL WIRES WERE USED IN THEIR MARKED CIRCUITS. I.E., BLACK/ WHITE WIRE 902 WAS MARKED: <TO A/C COMPRESSOR <#902> TO AC/HEAT THERMOSTAT SWITCH> THERE IS NO A/C, THEREFORE WIRE 902 WAS USED IN THE HEADLIGHT CIRCUIT FOR USE WITH ORIGINAL NISSAN COMPONENTS. SOME NEW WIRES HAVE COLORED HEAT SHRINK AT THE ENDS TO MATCH THE ORIGINAL WIRING FOR EASE OF MATCHING. I.E., FRONT PARKING/ TURN SIGNAL AND COLUMN SWITCH CONNECTOR
HARNESS FUSE HORN (LOW) 916 RED 10 GA FUSE BLOCK 915 RED 10 GA

960 RED 10 GA

ALTERNATOR OVER 65 AMPS

NOTES:

10 GA TO CHASSIS
1. CONNECTIONS 1 & 2 (R & F) ARE NOT USED FOR A ONE-WIRE ALTERNATOR 2. CONNECTIONS 1 & 2 (R & F) ARE USED FOR ALL ALTERNATORS THAT ARE NOT ONE-WIRE
CIBIE HEADLIGHTS 7" E-CODE HALOGEN 7-HCR BULB 60/ 55 W H4 HELLA HORNS

905 BLK RED LT BLU BLU

10 GA TO CHASSIS DISTRIBUTOR MODIFIED NISSAN (Gary Boone)

1 R F 2

B+ C 63 AMP NAPA 2134011 B 3 4

ALTERNATOR DELCO REMY

TEMPERATURE SENDING UNIT 185 TS
OIL PRESSURE SENDING UNIT SN PSI
IGNITION MODULE REVERSE LIGHT SWITCH
RADIATOR FAN MOTOR 30100847

SPL 311 - 02305

SPEEDOMETER SENDING UNIT SN16-C W
TEMPERATURE SENDING UNIT SN 22

STARTER SOLENOID

INSTRUMENT HARNESS SN 84
BLK 16 GA BLK 16 GA BLK BLU 16 GA 993 BLK PNK BLK GRN-WHT

BLK 935

RED 8 GA

WASHER PUMP

WHT BLK RED

HORN (HIGH)

HEADLIGHT RELAY

D M S B

= LO BEAM = HI BEAM = SWITCH = B+

HARNESS FUSE

909 908

LEFT FOG LIGHT

FOG LIGHTS HEADLIGHT RELAYS PARK-TURN SPEED SENSOR SONY CDX-M7815X WINDSHIELD WIPERS WASHER PUMP ANT-THEFT & FAN SWITCHES INSTRUMENT HARNESS

BATTERY NEG 10 GA

BLU 16 GA PWR ANT 993

905 906

10A GAUGES 30A HEATER 10A RADIO (SWITCHED) 10A RADIO/ CLOCK (CONSTANT) 30A HEAD LIGHTS 10A RADIATOR FAN 15A WIPERS 20A HORN/ STOP 15A FOG LIGHTS 10A REVERSE LIGHT 15A FUEL PUMP

15A TURN SIGNALS

B RB RW
15A MAP LIGHT 15A ACCESSORY
PWR ANT BLU 16 GA PWR AMP REM 993

610-1052 TAIL LIGHT

MAP LIGHT & SWITCH

ENVIRONMENTAL CONNECTOR

TAN BLK
STOP LIGHT PRESSURE SWITCH
6 I G S GAS GAUGE & LIGHT

HEATER SWITCH

FUEL PUMP RELAY

INERTIA SWITCH NC

STOP LIGHT

WIRE COLOR CODE

NO CR-92
TURN SIGNALS & TAIL LIGHTS FROM 1970 SPL-311
USE BELOW CHART FOR NUMBERED WIRE CIRCUIT IDENTIFICATION. PAINLESS PERFORMANCE PRODUCTS 14 CIRCUIT MICRO BLOCK HARNESS # 10130 HEADLIGHT RELAY HARNESS # 30815 SPAL ADVANCED TECHNOLOGIES 13" PULL HIGH PERFORMANCE FAN FAN RELAY & SENDER WIRING KIT CLASSIC INSTRUMENTS GAUGE SET (CUSTOM) WIRING HARNESS FUEL TANK SENDER 240 OHM TEMPERATURE SENDER 1/8 NPT OIL PRESSURE SENDER 100 PSI SPEED SENSOR RON FRANCIS WIRING ANTI-THEFT RELAY KIT CRASH RELAY KIT IGNITION SWITCH GROUND PLATE
WINDSHIELD WIPER 7 SWITCH WINDSHIELD WASHER PUMP SWITCH
S-BRAKE SWITCH FROM 1970 SPL-311 (MODIFIED)
# 30100847 # 185 FRH HEATER FAN MOTOR & WIREWOUND RESISTOR

ANTENNA

RADIO 87a
WHITE WIRE IS INDICATED BY A LIGHT GRAY WIRE.
ABBREVIATIONS BLACK BLUE BROW N GRAY
W IRE COLOR GRY/ WHT BLK/ W HT BLK/ W HT BLU BLU GRY/ WHT LT GRN LT GRN TAN W HT RED RED ORN W HT VLT VLT LT GRN LT BLU/ BLK VLT/ WHT GRN BLU LT BLU/ BLK BRN RED/ BLK BRN BRN BRN PNK BRN ORN RED RED RED/ W HT LT BLU BLU PNK RED RED/ BLK W HT GRN YEL ORN BRN VLT VLT BLK RED ORN/ BLK RED BLK YEL YEL/ BLK

BLK BLU BRN GRY

GREEN GRN ORANGE ORN PINK PNK RED RED

TAN VIOLET W HITE YELLOW

TAN VLT W HT YEL
DARK DK MEDIUM MD LIGHT LT GROUND GRD
SILVER SERIES SN84 SN35 SN22 SN52 SN16-C

12 V G

CLOCK & LIGHT

CIGAR LIGHTER

AT-70 CR-92 IS-02 GW-15

FOG LIGHT SWITCH

SWITCH PLACEMENT IN DASH PIN 2 UP ON FOG, HEATER & LIGHT SWITCHES PIN 7 UP ON WIPER SWITCH

GAUGE 14 18

DESCRIPTION FAN SW ITCH TO SPAL FAN RELAY LIGHT SW ITCH TO DATSUN HEADLIGHT RELAY HEAT/ AC FUSE - HEATER SW ITCH TO FUSE (SW ITCHED) W IPER FUSE - W ASHER PUMP TO FUSE (SW ITCHED) W IPER FUSE - W IPER MOTOR TO FUSE (SW ITCHED) ELEC. FAN FUSE - FAN RELAY TO FUSE (SWITCHED) HIGH BEAM DATSUN RELAY "M" TERMINAL TO PAINLESS PERFORMANCE RELAY HIGH BEAM DATSUN RELAY "M" TERMINAL TO GAUGE HARNESS CONNECTOR PIN 4 LOW BEAM DATSUN RELAY "D" TERMINAL TO PAINLESS PERFORMANCE RELAY ALTERNATOR EXCITOR (PIN 1) TO SW ITCHED BAR (GAUGES FUSE) ALTERNATOR B + TO CONSTANT BAR (HEADLIGHTS FUSE) 50 AMP HARNESS FUSE TO CONSTANT BAR (RADIO/ CLOCK FUSE) HORN/ STOP FUSE - STOP LIGHT SW ITCH TO FUSE (CONSTANT) STOP LIGHT SWITCH TO REAR BRAKE LIGHTS (W AS 918 W HT 16 GA) SOLENOID "S" TERMINAL TO ANTI-THEFT RELAY ANTI-THEFT RELAY TO IGNITION SW ITCH "S" TERMINAL TEMPERATURE GAUGE SENDER SN22 TO GAUGE HARNESS CONNECTOR PIN 7 OIL PRESSURE GAUGE SENDER SN52 TO GAUGE HARNESS CONNECTOR PIN 9 COIL NEGATIVE TO GAUGE HARNESS CONNECTOR PIN 5 HORN/ STOP FUSE - HORN RELAY TO HORNS (CONSTANT) RIGHT FRONT TURN SIGNAL TO COLUMN SW ITCH LEFT FRONT TURN SIGNAL TO COLUMN SW ITCH FRONT PARKING LIGHTS TO LIGHT SW ITCH HEADLIGHTS FUSE - LIGHT SW ITCH TO FUSE (CONSTANT) REAR TAIL LIGHTS TO LIGHT SW ITCH LIGHT SW ITCH TO DIMMER SW ITCH (RHEOSTAT) DIMMER SWITCH (RHEOSTAT) TO GAUGE HARNESS CONNECTOR PIN 6 COIL POSITIVE TO IGNITION SW ITCH "IGN" TERMINAL IGNITION SW ITCH "ACC" TERMINAL TO SW ITCHED BAR (RADIO FUSE) IGNITION SW ITCH "ACC" TERMINAL TO SW ITCHED BAR (HEAT/ AC FUSE) IGNITION SW ITCH "BAT" TERMINAL TO CONSTANT BAR (ACCESSORY FUSE) IGNITION SW ITCH "BAT" TERMINAL TO CONSTANT BAR (HAZ/ DOME FUSE) GAUGES FUSE - GAUGE HARNESS CONNECTOR PIN 3 TO FUSE (SW ITCHED) COLUMN SW ITCH TO GAUGE HARNESS CONNECTOR PIN 8 COLUMN SW ITCH TO GAUGE HARNESS CONNECTOR PIN 10 FUEL GAUGE SENDER SN35 TO GAUGE HARNESS CONNECTOR PIN 2 RADIO/ CLOCK FUSE - CLOCK AND RADIO TO FUSE (CONSTANT) RADIO FUSE - RADIO TO FUSE (SW ITCHED) HAZ/ DOME FUSE - MAPLIGHT TO FUSE (CONSTANT) RIGHT REAR TURN SIGNAL TO COLUMN SW ITCH LEFT REAR TURN SIGNAL TO COLUMN SW ITCH REAR LEFT BRAKE LIGHT TO THIRD BRAKE LIGHT (SPLICED TO 918 W HT) HAZ/ DOME FUSE - EMERGENCY FLASHERS TO FUSE (CONSTANT) (NOT USED) TURN FUSE - TURN SIGNAL FLASHER CAN TO FUSE (SW ITCHED) TURN SIGNAL FLASHER CAN TO COLUMN SW ITCH HORN/ STOP FUSE - HORN RELAY TO COLUMN SW ITCH (CONSTANT) HEAT/ AC FUSE - ELECTRIC CHOKE (SW ITCHED) (NOT USED) ACCESSORY FUSE - CIGAR LIGHTER TO FUSE (CONSTANT) ALTERNATOR OVER 65 AMP - ALTERNATOR B + TO 50 AMP HARNESS FUSE FOG LIGHT FUSE - FOG RELAY TO FOG LIGHT SW ITCH (CONSTANT) FOG LIGHT FUSE - FOG RELAY TO FOG LIGHTS (CONSTANT) AFTERMARKET RADIO TO POW ER AMP (POW ER AMP REMOTE) RAN INSIDE CAR DRIVER SIDE

LIGHT SWITCH

I G VOLTMETER & LIGHT

3AG 003 399-801

B E F2
ANTI-THEFT SWITCH FAN SWITCH I
NAPA AUTO PARTS ALTERNATOR DELCO 63 AMP 2134011 UNIVERSAL ELECTRONIC FUEL PUMP 610-1052 NISSAN STARTER GEAR REDUCTION (FORKLIFT H20 BLOCK) COIL DISTRIBUTOR (MODIFIED BY) HEADLIGHT & COOLING FAN RELAYS HELLA BOSCH SIEMENS FOG LIGHTS & HORNS RELAYS GM AC DELCO FUEL PUMP & ANTI-THEFT RELAYS TYCO BOSCH
23300-K9160 22433-P7500 GARY BOONE

SPEEDOMETER & LIGHT

FUEL TANK FROM 1970 SPL-311 FOR USING THIS SENDER & RETURN LINE COLUMN SWITCH FROM 1970 SPL-311 (MODIFIED)

HI / LO

WIPER MOTOR B E F2

RIGHT TURN INDICATOR

4RD-960-388-204-18 VF4-65F11-S01

FUEL TANK GAUGE SN OHM

HORN RIGHT LEFT FLASH

12088567 15-8571

= B+ = EARTH = SWITCH = HIGH = LOW
LOW BEAM GROUND PULL BACK HI-BEAM OPEN PUSH FORWARD

COLUMN SWITCH

THIRD BRAKE LIGHT

ORN BLK

VF4-15F11-S209-151
BLU-WHT LT BLU DK BLU TAN LT GRN
I G S LEFT TURN INDICATOR OIL PRESSURE GAUGE & LIGHT POWER AMP ALPINE MRV-F545

BLK GW

LICENSE LIGHT
HIGH BEAM INDICATOR TACHOMETER & LIGHT

REMOTE

S I G S
INSTRUMENT HARNESS BLK LT GRN DK GRN RED TAN WHT BLU-WHT LT BLU DK BLU GRAY GAUGE GROUND HIGH BEAM SIGNAL TEMPERATURE SIGNAL GAUGE 12 V FUEL SIGNAL TACHOMETER SIGNAL OIL SIGNAL LEFT TURN SIGNAL RIGHT TURN SIGNAL GAUGE LIGHTS

RED GRY BLK DK GRN

TEMPERATURE GAUGE & LIGHT

DIMMER RHEOSTAT

IG ACC B S

IGNITION SWITCH IS-02

REVERSE LIGHT
PNK BLK GRN-WHT BLK GRD PLATE 902 YEL-WHT 14 GA BLK 14 GA BLK GRD PLATE 914 BLK GRD PLATE 901 BLK GRD PLATE 992 BLK GRD PLATE 924
902 YEL-WHT 14 GA 905 BLK 14 GA 926

BLK 10 GA

SIDE RAIL GROUND
REAR HARNESS CONNECTORS LOCATED IN ENGINE BAY STOP LIGHT

10A RL 15A FP

LT GRN 14 GA YEL-WHT 14 GA
WHT 10A G 30A H 10A 86 FOG RELAY 87a 30 992

YEL-WHT 14 GA LT GRN 14 GA WHT 14 GA 950

TAIL LIGHT

GROUND PLATE GW-15
FOG LIGHT & HORN RELAYS

ANTI-THEFT RELAY

TURN SIGNAL FLASHER

15A TS R

991 924

15A ML RC

10A HS
20A 86 15A FL HORN RELAY 87a 30

ANTI-THEFT RELAY AT-70

14 CIRCUIT MICRO FUSE BLOCK

GRY 919 993

LEFT TURN SIGNAL

15A A HL

953 DK GRN

Discountcarstereo.com

Sony AUX-LITE Application guide for Peripheral PXA07 and PIE SON-AUX.
Looking for a way to play the audio from a portable device, video system, or anything else through your Sony Car stereo system?
Note: When connecting a portable device, be sure BUS CONTROL IN is not connected. If a device is connected to BUS CONTROL IN, AUX cannot be selected with the SOURCE button.
Tip When connecting both a portable device an a cd changer, use the optional AUX-IN selector (i.e. Sony XA300 or PIE SON-AUX)
We make it extremely simple. You can connect optional portable devices to the BUS AUDIO IN (see Fig.1) terminal on the Sony AUXLITE Ready unit. If the changer or other device is NOT connected to the terminal, the unit allows you to listen to the portable device on your car speakers.
Purchase our PXA07 iPod adapter with charging feature to play your iPod on the Sony AUX-LITE Ready Stereo. Installation instructions for Peripheral PXA07 1. Connect the RCA outputs of the PXA07 to the BUS AUDIO IN AUX IN connectors on the back of the Sony radio 2. Connect iPod to the dock connector 3. Connect the red wire to +12V ignition wire and gray to ground. 3. Look up the user manual for the corresponding Sony radio to enable to AUX-Lite function Here is how to enable the AUX-LITE function on Sony CDX-630 CD Receiver Selecting Auxiliary on Sony AUX-LITE Ready Radios It is possible to use auxiliary equipment with this unit. Activate the auxiliary setting when using auxiliary equipment connected to this unit. 1. Press SOURCE repeatedly until AUX Aux appears in the display. 2. Adjusting the volume level. Press MENU appears in the display. Press the repeatedly to select the AUX Level Press Enter Press the repeatedly to select the desired level the volume level is adjusted in 1dB steps from -6dB to + 6dB Press Enter

Fig. 1

SONY AUX-LITE Ready Radios
If you're looking for a way to play a portable audio device, video system, or anything else through your Sony system, we make it extremely simple. In models with Aux Lite, the BUS audio inputs can be used as an auxiliary input instead of a CD changer input, allowing any audio signal to play through the head unit, and the entire audio system. Warning: The Sony Radio must be AUX-LITE ready.
The following Sony radios are AUX-LITE ready: CDX-GT805DX MEX-BT5000 CDX-RA700 CDX-M7815X CDX-F7710 CDX-M8810 CDX-F7705X CDX-F7700 CDX-F5700 CDX-M800 CDX-CA900X CDX-GT705DX CDX-R505X CDX-GT500 CDX-M7810 CDX-M8815X CDX-F5710 CDX-M8805X CDX-F5705X CDX-M850MP CDX-M630 CDX-GT805DX CDX-F605X CDX-F50M MEX-1GP CDX-F7715X CDX-R5715X CDX-F7005X CDX-M8800 CDX-F7000 CDX-M3DI MEX-5DI
Use the SON-AUX audio switcher to connect two audio devices to any AUX LITE Ready Radio (no CD Changer required). Use the SON-AUX audio switcher to connect a single audio device to Sony radios without AUX-LITE (CD Changer required)
Revised July 17, 2008 1995-08 Discount Car Stereo, Inc. All rights reserved. Information in this document is subject to change without notice. Other products and companies referred to herein are trademarks or registered trademarks of their respective companies or mark holders.