2. DISPLAY OF STANDBY/(1) indicator FLASH COUNT
Diagnosis Item Flash Count* 2 times 4 times 5 times 8 times +B overcurrent I-Prot IK (AKB) HV Protect

Lamp OFF 3 sec

Lamp ON 300ms Lamp OFF 300ms
* One flash count is not used for self-diagnosis. FLASH RED n Please refer diagnosis item. FLASH GREEN n OK
3. STOPPING THE STANDBY/(1) indicator FLASH
Turn off the power switch on the TV main unit or unplug the power cord from the outlet to stop the STANDBY/(1) lamp from flashing.
4. SELF-DIAGNOSTIC SCREEN DISPLAY
/ Power / TV Note that this differs from entering the service mode (volume [+]).

STANDBY indicator

For errors with symptoms such as "power sometimes shuts off" or "screen sometimes goes out" that cannot be confirmed, it is possible to bring up past occurrence of failure on the screen for confirmation. [To Bring Up Screen Test] In standby mode, press buttons on the remote commander sequentially in rapid succession as shown below: [display] / channel [5] / volume [-]
Self-Diagnostic screen display

SELF DIAGNOSTIC

0 N/A 0 N/A

2: 3: 4: 5: 8: 101 :

Numeral "0" means that no fault was detected. Numeral "1" means the number of a fault occurrence (1~255).
5. HANDLING OF SELF-DIAGNOSTIC SCREEN DISPLAY
Since the diagnosis results displayed on the screen are not automatically cleared, always check the self-diagnostic screen during repairs. When you have completed the repairs, clear the result display to "0". Unless the result display is cleared to "0", the self-diagnosis function will not be able to detect subsequent faults after completion of the repairs.
[Clearing the result display] To clear the result display to "0", press buttons on the remote commander sequentially when the self-diagnostic screen is displayed, as shown below: Channel [8] / "0" [Quitting Self-diagnostic screen] To quit the entire self-diagnostic screen, turn off the power switch on the remote commander or the main unit.
A BOARD IC001 Y/CHROMA JUNGLE A BOARD IC503 V.OUT A BOARD IC001 SYSTEM A BOARD IC003 MEMORY FROM C BOARD IC751 PIN 5 SDAIK F.B-PLS V.GUARD SDA A BOARD FROM Q511 COLLECTOR RED LED 97 EHTO 7 DISPLAY

e. OTHER FUNCTION VIA REMOTE COMMANDER 7, 8, [Display], 2, 5

3-2. ADJUSTMENT METHOD

All the data becomes the values in memory. All user control goes to the standard state. Service data initialization (Be sure not to use usually.) Select Device or Category (Up, Down)
Item Number 000 HPOS This explanation uses H POSITION as an example. 1. Select "000 HPOS" with the 1 and 4 buttons, or 2 and 5. 2. Raise/lower the data with the 3 and 6 buttons. 3. Select the optimum state. (The standard is IF for PAL reception.) 4. Write with the [MUTING] button. (The display changes to WRITE.) 5. Execute the writing with the - button. (The WRITE display will be changed to red color while excuting, and back to SERVICE.) Example on screen display :-
GEOM 00 HPOS 1F 59 7F SERVICE 60 0

637S 1.0C

Adjusted with 3 and 6 buttons.

GEOM 00

HPOS 1F 59 7F

WRITE 0

Write with [MUTING]

GEOM 00 637S 1.0C

60 000A

Write executed with

RED The WRITE display then the display returns to green SERVICE.
Use the same method for all Items. Use 1 and 4 to select the adjustment item, use 3 and 6 to adjust, write with [MUTING], then execute the write with -.
Note : 1. In [WRITE], the data for all items are written into memory together. 2. For adjustment items that have different standard data between 50Hz or 60Hz, be sure to use the respective input signal after adjustment.

4-1. BLOCK DIAGRAM

FSS TUNER

AGC IN

5V 30V

VIF SAW SIF SAW

AC in ~

CISPR/ PFC

MAIN Power Supply

Mon out

Stdy 3.3

Stdby Power

AUDIO VCC

RGB Amp Rot Amp

98 AGC OUT

81 MON-OUT 93 OUTL

RGB OUT 42.44

VIF & SIF

LCC Amp

I/O Port

RGB/ DVD in

G/Y B/PB R/PR L R

C592 470p CHIP

+B (A9) To C16 HOUT-DEFL (A10) To C22 AFC-DEFL (A11) To C21 LSR-AUDIO (A12) To B2 LSL-AUDIO (A13) To B1

5V (A4) To C9, D17, E10

SDA-0 (A5) To D15, E23

SCL-0 (A6) To D16,E24

9V (A8) To B11 , C14, C24, D13, E18

MOMUTE-AUDIO (A7) To B7

3.3V (A3) To B10 , C6 , E20
SY (A14) To E4 SU (A15) To E5 SV (A16) To E6 SEL(A17) To E7
B-Y/BIN (A18) To E30 Y/GIN (A19) To E29 R-Y/RIN (A20) To E31 SCARTFBL/A16 (A21) To E36
RRN-CP R019 XX CHIP R020 XX CHIP L011 10uH C012 C021 0.22 100p CH 16V B R012 2.2k RN-CP RRN-CP RRN-CP RRN-CP R018 XX RN-CP
(A68) B_DAT To E43 (A67) B_INT To E44 (A66) DGC-RELAY To C13 C308 0.1 16V B 3.3V GND LED G LED R SIRCS GND KEY CN014 7P WHT TO H3 BOARD CN6 7
JR1080 XX CHIP RRN-CP RRN-CP
RCHIP C020 0.1 16V B RCHIP L009 10uH D072 MMDL914T1 PROTECT R015 1.5k RN-CP C310 XX 16V B:CHIP R320 XX RN-CP C35V R363 3.3k RN-CP C011 0.22 16V B RCHIP

L038 10uH C309 10

R340 10k CHIP

C090 100p CH

C091 100p CH

R360 18k RN-CP

L008 10uH
128 VSSPVSSCVDDC4(1.8) 125 VDDA3(3.3V) 124 VREF_POS_LSL 123 VREF_NEG_LSL+LSR 122 VREF_POS_LSR+HPL 121 VREF_NEG_HPL+HPR 120 VREF_POS_HPR 119 XTALIN 118 XTALOUT 117 VSSAVGUARD 115 DECDIG 114 VPPH2LF 112 PH1LF 111 GNDSECPLL 109 DECBG 108 EWD 107 VD106 VD+ 105 VIFINVIFINVSC 102 IREF 101 GNDIF 100 SIFINSIFIN2
R361 5.6k RN-CP Q017 MSD601-RT1 RESET R:CHIP R362 XX 8 Q013 MSD601-RT1 (RESET) C018 0.22 16V B:CHIP C327 0.22 16V B:CHIP TP02
RRN-CP D068 RD5.6SB-T1 PROTECT

Q016 MSD601-RT1 RESET

C083 XX CH
RRN-CP R381 4.7k RN-CP RRRN-CP RN-CP R3824.7k CHIP R023 1.5K D073 MMDL914T1 C321 DXX C975 16V 0.001 R024 CLRN-CP JR1081 16V 10uH 0 CHIP R026 C014 D0.22 XX RN-CP 16V B:CHIP C016 XX RL013 RN:CHIP 10uH

98 AGCOUT 97 EHTO

SIRCSC SCL1 SDA1 VDDC2 VSSC2 B INT D1_JP/MONSW_MONO MOMUTE-AUDIO DGC RELAY AUDIO MUTE HD SW SCL0 SDA0 VDDP(3.3V) RESET ROT CTRL ROT SW STBY_SW AFT D1_JP/MODE1_EU/ATT VDDC(1.8V) DECV1V8 KEY S2/MODE2-EU VSSC1/P RED LED GREEN LED VDDC3(1.8V) VSSC3 AGC-MUTE SECAM L-L M-SYS-IF
CVBS0 SCARTHPR SCARTHPL LSR LSL C1 CVBS1/Y1 INR1 INL1 CVBS3 INR3 INL3 C2
TV-OUT (A22) To E3 JR1089 XX CHIP C3 (A23) To E40 CVBS3/Y3 (A24) To E39 INR3 (A25) To E37 INL3 (A26) To E38 CVBS2 (A27) To E28 INR2 (A28) To E35 INL2 (A29) To E34 C1 (A30) To E14 CVBS1/Y1 (A31) To E13 DVD-R (A32) To E2 DVD-L (A33) To E1 MON-OUT (A34) To E17 D066 MMDL914T1 JRCHIP

JR1088 XX CHIP JR1090 XX CHIP JR1092 XX CHIP

C319 XX

C318 XX
CVBS2/Y2 IC001 * (ADD:8AH) INR2 INL2 MON_OUT VP2 AGC2SIF VCC8V INTC0_IF IFVO/IF_MON_OUT SIFAGC/SCART PLLIF GND MONO_OUTL DECSDEM OUTR OUTL D1 RIN D1 LIN AVL/2SIF

C16V 7

C072 0.01 25V B L004 47uH L003 10uH
JR1093 XX CHIP JR1094 XX JR1095 CHIP XX CHIP

C073 2.2

C064 2.2

C25V C316 0.47 10V B

C069 0.1 16V B
IFVO/IF_MON_OUT (A35) To D4 PLLIF (A36) To D8 MONO_OUTL (A37) To D14 OUTR (A38) To E11,E16 OUTL (A39) To E12,E15

C063 0.1 16V B

R388 68k CHIP
INR1 (A40) To E33 INL1 (A41) To E32

L033 10uH C25V L036 10uH

C041 0.22 16V B

C019 0.22 16V B

L010 10uH

C050 10

C311 0.1 16V B

X001 24.5MHz

R398 1.5M

C022 C024 0.16V 25V B

C032 R011 C300 XX 100 CHIP 0.22 C031 16V CB XX 16V L037 R305 10uH 0 CHIP
C048 C089 0.22 C052 R051 0.001 16V 0.001 39k B B C055 RN-CP B 0.15 W004 C049 C094 0.022 W001 R048 W005XX 25V W002 B RWCHIP W003 CHIP RCHIP C081 0.001 B C080 0.001 B D064 RD5.6SB-T1 PROTECTION

RCHIPR312 18k CHIP

Q012 MSD601-RT1 R384 (FSC BUFFER) 100 CHIP R383 XX CHIP RCHIP
C306 0.1 16V B FSC (A42) To E27
C058 R313 1000p 18k B CHIP

C085 0.1 16V

L032 10uH
R044 12k CHIP C046 0.0068 25V B:CHIP
C044 C042 2.2 0.0047 16V B F R316 6.8k CHIP
R355 22k RN-CP R315 4.7k RN-CP
R061 C0.01 CHIP 25V B:CHIP

R314 4.7k RN-CP

D065 RD5.6SB-T1 PROTECTION
R306 1.2k 1/10W RN-CP C599 XX R5030 XX RCHIP D061 MMDL914T1 ABL R309 150k CHIP R303 1M CHIP D062 R311 RD5.6SB-T1 47k SLICER CHIP Q009 XX MSB709-RT1 ABL BUFFER
C079 XX R326 XX RN-CP C084 XX B

To B9 (A65) AUDIO MUTE

To C17, E9 ,(A53) VGUARD-DEFL To C27 (A52) EWD-DEFL
C326 XX C325 XX R301 2.2M CHIP C077 0.01 25V B R327 XX RN-CP R304 470k RN-CP D060 UDZ-TE-17-7.5B GEOMETRIC CORRECTION
B-12091-SA.-A.-PROCESSOR-XR29M80
To E26 (A61) AFT To E25 (A60) RESET To C28 (A59) ROT_SW To C29 (A58) ROT_CTRL
(A45)OCP-PROTECT To C4, C19 (A44) TUAGC-IF To D10
To C25 (A51) VD--DEFL To C26 (A50) VD+-DEFL

To E41 (A62) S2

To D9 (A63) M-SYS-IF

To C20 (A54) ABL

To D2 (A47) SIFIN1-IF

To C15 (A64) 1.8V_AUDIO

To C12 (A55) 1.8V_MAIN

To D11 (A57) AGC-MUTE

To C3 (A56) STBY_SW
To D7 (A49) VIFIN1-IF To D6 (A48) VIFIN2-IF

To D1 (A46) SIFIN2-IF

(A43) 2SIF To D3, D5
4-3-3. A Board Audio (Block B)
LSR-AUDIO (B2) To A12 LSL-AUDIO (B1) To A13
LSL OUT GND LSR OUT MUTE 3 4

RRN-CP C234 470P CHIP

RJR1280 RN-CP XX C235 470P C202 IC200 CHIP 0.047 16V R208 AN5276T C201 D200 6.8K B 0.22 16V R200 AUDIO AMP DA204K RN-CP B:CHIP 3.3K CHIP C205 C208 0.01 25V R202 R201 0.47 C200 3.3K B:CHIP 5.6K CHIP 0.22 16V CHIP B:CHIP C207 C236 R12 0.1 XX 3.3K PT C237 CHIP XX C203 0.047 16V R207 B:CHIP 6.8K R204 R211 CHIP C209 15K 3.3K R205 0.47 RN-CP CHIP 5.6K R210 C206 RN-CP C204 15K 0.01 25V D209 C212 CHIP 0.1 B:CHIP XX XX R233 XX PT:CHIP R232 C211 C213 C215 D210 C230 XX 4.7 0.XX XX B:CHIP R212 CHIP PT 0 CHIP D201 C238 MMDL914T1 R240 R241 D212 2.2 2.2k 2.2k MMDL914T1 SWITCH 16V CHIP CHIP F
OUTC/NC IN R/NC PW_GND IN C/NC S_GND MUTE IN L STBY VCC

C25V R234 47

R217 330

OUTR/NC

C216 22

C25V RC232 0.047 PT

RCCN204 XX 3P:S-MICRO YEL TO B BOARD CNAUDIO VCC 2 AUDIO VCC 1 GND

C210 100

C231 0.047 PT
To E19 (B4) (MON-MUTE-AUDIO

(BLOCK B)

To C5 (B6) AUDIO_VCC To A8,C14,C24,D13,E18 (B11) 9V To A7 (B7) MOMUTE-AUDIO To A65 (B9) AUDIO-MUTE To A2 (B8) PWR-OFF-MUTE To C7 (B5) AUDIO_GND To A3,C6,E20 (B10) 3.3V

A AUDIO

R2644 4.7 FPRD
B-SSS12091-SA-AUDIO-XR29M80

To C8 (B3)7V

R242 R236 22k D213 10K CHIP Q203 MMDL914T1 RN-CP MSD601-RT1 D202 SWITCH MMDL914T1 SWITCH D203 MMDL914T1 SWITCH
CQ202 R221 MSB709-RT1 D205 1k MMDL914T1 RN-CP AC MUTE D206 XX C219 R218 0:CHIP 220 16V R220 C221 XX 0 25V CHIP D204 MMDL914T1 SWITCH D211 XX

1 SPL 2 GND 3 GND

PH_L SP L GND GND SP R PH_R
CN203 XX WHT TO B BOARD CN 205
CN202 6P:S-MICRO WHT TO H3 BOARD CN3903

CN208 XX

4-3-4. A Board Power Supply/Deflection (Block C)

11V (C1) To C10

PFC IN PFC OUT
R6018 XX C1 D647 D1NL20U-TR RECTIFIER C608 470p 250V B C609 470p 250V B D648 XX

CN605 XX WHT CHOKE COIL

IC_GND (C2) To F1
EY692 XX JW1682 7.5MM JW1683 7.5MM C613 0.0047 500V E 1 D607 D4SB60L RECTIFIER 3 C616 0.0047 500V E

C626 0.500V C627 E 0.0047 500V E
C638 0.0047 TH601 500V THERMISTOR, NTC R665 4.7 FPRD

C639 0.0047 500V

R681 10k CHIP

C658 0.01 B:CHIP

2 CN600 2P TO H2 OR H3 BOARD CNAC IN AC IN 1 CN601 * DGC NC DGC TH600 THERMISTOR FB600 1.1UH C697 0.22 275V PT 3

9 CXX 7

VD602 *

JW1608 17.5MM

R6014 * JW1614 XX JW1601 XX JW1600 XX JW1615 XX

JW1697 XX JW1698 XX

RY602 RELAY (AC POWER)
4 T603 XX C685 XX R613 8.2M 1W RN
JW1609 VD601 22.5MM ERZV14D621 R622 6.8 10W RB
C615 0.0047 500V E JW1621 R* XX
D613 PROTECTOR R6020 0.47 5W RB

D632 D1NS6 SNUBBER

C637 0.001 CHIP Q613 MSD601-RT1 SWITCH R698 XX R690 R6013 1k 56k FPRD RN-CP R694 68k RN-CP R6000 2.2k CHIP R699 10k CHIP
IC603 EK1135 D10ERB20-TB5 RECTIFIER 6 C25V C35V 7 T605 HST FB601 0uH Q609 2SC2785-HFE SWITCH EMI FL5A FL603 90V 5A 90V EMI R686 XX :CHIP R684 XX CHIP
C602 XX D644 MMDL914T1 SWITCH R6003 4.7k CHIP R6001 10k CHIP

D617 D2SB60A-F04

C654 0.0047 500V E

Q614 UN2211 SWITCH

VCC GND

R6022 15k RN-CP

R6021 10k RN-CP Q617 MSB709-RT1
IC605 BA033FP-E2 3.3V REGULATOR

5 30V 5

IC610 BA18BCOWFP-E2 C3.3V REGULATOR 35V
CN619 XX TO B BOARD CN1417 30V GND 11V 7V GND

4 C665 XX 500V

D614 C623 * XX PROTECTOR B

R6015 *

D657 MMDL914T1 SWITCH JW1607 VD600 7.5MM *
D658 UDZS-TE17-12B CLAMP JW1695 XX

C614 0.0047 500V E

JW1639 C621 R639 * * XX JW1696 15.0MM

C646 C450V

Q612 UN2211 SWITCH RCHIP

R6002 10k CHIP

Q615 MSD601-RT1 SWITCH 3.3V
1.8V STBY_SW (C3) To A56 OCP-PROTECT (C4) To A45

R6017 XX

D661 MTZJ-T-77-15 RRN-CP D653 ERA22-08 R603 1k FPRD R604 4.7k RN-CP 4 PH602 ON3171-R PHOTO COUPLER 3 R6004
CN603 * DGC 2 DGC DGC CHK 1 DGC CHK CN602 C600 0.22 2P 275V DGC CHECKING PT
JW1694 XX RY603 RELAY (AC POWER) D651 MMDL914T1 D652 UDZS-TE17-12B D654 RD6.8ESB1 PROTECTOR

RY601 *

JW1659 7.5
RY600 RELAY (AC POWER) D600 1SS119-25 SWITCH R659 XX 1W RS C16V R601 4.7k RN-CP R600 XX CHIP

Q600 MSD601-RT1 SWITCH

R6011 10k CHIP

R606 4.7k RN-CP

R605 4.7k RN-CP

2SA1162-G REGULATOR

R6010 68k CHIP

R6006 0.47 FPRD

C691 *
R654 9.1k RN R6029 R642 R6028 220K C629 270K CHIP CHIP 0.1 0.01 Q607 16V R661 R664 1W B IRFIB7N50A-LF31 R669 FB602 220k 270k RF C630 R670 SWITCH 1k 0uH RN RN XX CFPRD C650 EY626 16V 0.001 FPRD D629 680p C653 Vsense VD B 100V MM3Z15VT1 1kV 0.0047 F/B PP :PP 800V Ct VG(H) R672 :MPS R652 R657 S 10k Q608 VS Rt 12k XX RN-CP D622 RN-CP D633 RN-CP IRFIB7N50A-LF31 GND VB R6008 D1NL20U-TR C651 MTZJ-T-77-SWITCH C635 Timer 680p RECTIFIER FPRD RECT 10 1kV C648 SS VG(L) C636 P-GND 0.1 Vc1 4.7 C632 MPS D665 OCP Vc2 D625 R673 C652 4.7 UDZSTE-1736B UF4005PKGS 220 C633 C692 CLAMP FPRD IC602 35V 0.001 0.01 MCZ3001D B:CHIP C647 CH R675 D631 SW REGULATOR 10k 10 MM3Z15VT1 RN-CP D626 R653 CLAMP R662 MTZJ-T-77-RCLAMP RN-CP 0.1 2W RN-CP RN-CP

FL604 FILTER NOISE 17 FL606' FILTER NOISE EMI EMI PS602 5A

CD637 D10SBS4F PROTECT

JW1699 XX
C50V D636 JW1688 D10SC4M 12.5MM R6009 RECTIFIER PS600 4.7 5A RN-CP D638 D10SC4M RECTIFIER L690 10uH
R695 18k R687 RN-CP C668 2.2k CHIP XX 500V E
D640 RD18ESB REGULATOR D655 MMDL914T1 SWITCH
D643 C679 0.47 10V MMDL914T1 B:CHIP SWITCH

JR1681 XX

R607 *
D071 MMDL914T1 PROTECTION
IC607 PQ05RD11 5V REGULATOR C693 XX 16V B 7V D103 UPC574J C603 XX C604 XX R6023 47k RN-CP 33V R121 22k 3W RS C63V C118 C119 0.B:CHIP C605 XX 7V R6025 15k RN-CP I O G C16V I G VC R6024 10k RN-CP C16V L039 2.2uH 1.8V C16V 5V
AUDIO_VCC (C5) To B6 3.3V (C6) To A3,B10,E20 AUDIO_GND (C7) To B5 7V (C8) To B3 5V (C9) To A4, D17, E10

D664 1SS133T-77

FL607 FILTER NOISE

D600 1SS119-25

11 IC608 *

R677 1.2K

FL605 FILTER NOISE
PS603 5A PS601 5A C656 680p 1kV

D663 MMDL914T1 CLAMP

11V (C10) To C1 33V (C11) To D12 1.8V_MAIN (C12) To A55 DGC-RELAY (C13) To A66 9V (C14) To A8 , B11, C24 ,D13 , E18

R678 2.2K RCHIP

FL600 FILTER NOISE
PH601 ON3171-R PHOTO COUPLER

FL601 FILTER NOISE

C657 680p 1kV

C660 680p 1kV

R6027 10k RN-CP Q618 MSB709-RT1
D662 MA2ZD14001S0 CLAMP RJR1682 2W XX RS C16V +B (C16) To A9 R500 1k CHIP 1.8V_AUDIO (C15) To A64
C610 0.47 R6026 10k RN-CP C35V 5V
135V D667 XX D668 XX 5V 5V R3W

L600 22uH

TP603 TP604
T601 CONVERTER TRANSFORMER (PIT)
EMI D635 D4SBL20U SENSING
C659 680p 1kV C661 470p 1kV R
C607 IC604 XX NJM78M09FA C606 9V REGULATOR 22 25V F:CHIP
IC606 PQ018EF01SZH 1.8V REGULATOR
To A58) (C29) ROT_CTRL To A59 (C28) ROT_SW To A52 (C27) EWD-DEFL To A50 (C26) VD+-DEFL To A51 (C25) VD--DEFL To A8 ,B1, C14 (C24) 9V
15V 135V C514 0.047 200V PT R543 5.6k 1W RS RR557 3W RS XX C543 XX D517 2kV B BY228/A52A/ DUMPER TP502 R5021 1.5k RN-CP C16V RCHIP Q514 MSD601-RT1 R5006 4.7k CHIP
Q506 2SC2688-LK H-DRIVER R5019 XX 15

R3W RS 1 5

16 C528 330p 2KV

R596 1k 3W RS

135V R527 XX C552 680p 2kV B
C512 XX SG501 XX 2 R2W RS 5 T504 HLT R1/2W FPRD C250V PP C568 470p 500V B C595 XX L519 XX
L515 COIL WITH CORE R507 4.7 FPRD

135V D548 1SS133T-77 SWITCH
To A1 (C23) HDSW-DEFL To A10 (C22) HOUT-DEFL
CHIP R523 R3.3K C564 XX C551 1

C538 20000P 1.2KV

To A11 (C21) AFC-DEFL To A54 (C20) ABL To A45 ,C4 (C19) OCP-PROTECT (C18) FBP To E8

R599 27k CHIP

C519 C523 C508 D533 470p 470P T501 HDT XX 1SS119-25 500V 500V B PROTECTOR B CH:CHIP C510 R525 330P 470K CHIP B:CHIP C517 0.01 25V B:CHIP Q505 IRF614 FB501 1.1uH FB502 1.1uH R532 XX R552 2.2k CHIP 1 S
JW1557 7.5MM RQ511 2SD2634-CA H OUT
C539 0.056 630V PP D518 XX DUMPER L502 0.45uH D545 MMDL914T1 SWITCH R5027 150K RN
D519 ERC06-15S DUMPER C598 2.2 10V B:CHIP
C553 680p 2kV B C554 0.0047 200V PT
C561 0.0033 630V PP 1 R585 2.2 FPRD

D504 ELIZ PIN OUT

R533 1K C504 XX

R560 10k CHIP

5 R5016 10k CHIP C593 D532 100P MMDL914T1 B:CHIP PROTECTOR JR1583 XX CHIP C584 100p CHIP
IC502 NJM2903M PIN CONTROL 4

JW1521 10.0MM

C160V C582 XX 25V R561 XX R566 XX CHIP

C507 0.0047 500V E

L518 47uH
C530 0.022 C521 PT XX R564 R570 25V 6.8k Q502 150k B R505 RN-CP JW1580 XX RN-CP BUFFER C502 R565 100k XX 0.0015 18k RN-CP RN-CP 5 B R573 C585 27k R567 C534 R575 XX Q501 RN-CP XX 2.7k 220k R551 2SA1162-GRN-CP R592 C503 25V RN-CP BUFFER 12K 100K 10 RN RN-CP B DXX JR1582 DRD5.6SB-T1 CHIP CLAMP

R517 4.7K RN-CP

R548 3.9K RN-CP

R506 22k RN-CP

R5028 3.3k R:CHIP R574 C548 XX RN-CP R5017 RN-CP XX XX R582 R587 R580 680K 330k 3.9K R542 RN-CP RN-CP RN-CP 10k C559 RN-CP 0.0022 D546 B:CHIP R546 XX 0 :CHIP CLAMP D549 R5049 XX 0:CHIP CLAMP
L507 10mH C567 0.68 250V PP :RS 4 135V 5V C566 XX 500V B 200V 135V 1 HV 15V R590 220k RN JW1583 5.0MM T505 PMT 4 FOCUS T508 XX 2 C200V D523 EL1Z R594 0.47 FPRD 1 C160V W13 SCREEN L503 10uH 12 D522 D2L20U C562 XX 500V B 11 L581 XX JW1581 5.0MM C25V 10 C550 0.1 100V MPS R2W RS TH500 THERMISTOR RRN-CP R593 0.47 FPRD JW1582 5.0MM R591 0.47 1/2W FPRD 7 C560 XX 500V B C25V T506 XX 5V D521 ELIZ

R581 10k RN-CP D550 XX

R3W RS
S501 SWITCH LEVER C572 JL561 0.15 C577 S502 SWITCH LEVEL C574 4.7 160v 0.15 250V R5025 200V :PP L513 4.7k :PT R509 2.2mH CHIP 56 R5026 & L512 3W R519 240k JW1515 RXX RN XX 27 3W 3W R511 R515 D527 DL3W:RS GP08D GP08D 100UH 3W SWITCH SWITCH :RS R510 R5029 JW1511 XX 47 XX 2W

JW1512 XX

R5022 270K RN Q516 2SA1091-O R5023 SWITCH 330K R5024 100k RN-CP
VD+ GND 5V 15V ROT_CTRL ROT_SW CN507 6P YEL TO C BOARD CN1801 GND 7V 11V CN512 XX WHT TO C BOARD CN3800 H+ H+ HHVV+ DY1 6P TO DY

1 3D OUT 2 W GND 3 W GND
CN3901 4P BLK TO SPEAKER CN3902 XX
SP L OUT SP GND SP GND SP R OUT PH L IN SP L IN SP GND SP GND SP R IN PH R IN GND 3D IN 3D IN
STBY 3.3V GND LED G LED R SIRCS GND KEY
CN3903 6P WHT TO A BOARD (AUDIO) CN202
PH L IN SP L IN SP GND SP GND SP R IN PH R IN

CN3904 XX

CN3908 5P WHT TO A BOARD (JACK) CN906
CN3905 7P WHT (PROCCESSOR) CN014

TO A BOARD

CN3602 2P TO A BOARD (POWER SUPPLY /DEFLECTION) CN600

1 AC OUT 2 AC OUT

CN3601 2P TO F BOARD CN4602
D3912 1SS133T-77 D3913 1SS133T-77
C3900 0.01 100V PT L3901 10uH
R IN GND L IN GND CV IN S IN C IN GND Y IN R IN GND L IN GND CV IN 7
JW3602 7.5MM FH001 JW3601 7.5MM F3601 XX FH002 C3916 XX S3601 1
Y C R3918 XX C3904 XX D3901 XX S R3919 XX R3902 XX C3913 XX C3914 XX D3902 JW3914 R3924 XX 5.0MM XX

AUDIO(L)

R3925 XX RR3914 220

1 AC IN 2 AC IN

CN3604 XX

L3902 10uH

C3901 XX C3902 0.01 100V PT C3903 XX
JW3904 R3904 5.0MM XX R3905 XX

D3907 XX

D3900 XX
Q3901 Q3902 DTC143TSA DTC143TSA LED DRIVE LED DRIVE D3906 SPB-25MVWF WAKE UP INDICATOR C3910 R3916 JW47 5.0MM 35V

AUDIO(R)

H3 (FRONT PANEL)
D3908 R3926 RD5.6ESB2 10k RRR3909 R3910 R330 150

R3922 XX

R3917 XX

D3909 1SS133T-77

J3901 XX J3902 XX J3904 JACK 2 1

OUT VCC GND

CR3915 35V 1.5K C3915 470p B

R3907 1k

J3903 PIN 3P JACK
IC3901 D3911 D3910 C3912 RPM7240-H5RD5.6ESB2 RD5.6ESB2 S3908 S3902 S3904 S3905 S3909 SOUND S3907 S3903 470p LED DRIVE MENU VIDEO VOL VOL + CH - CH + MODE PROTECTOR B
B-SSS12091-SA.-H3.-XR29M80

48 49

4-3-10. D3, J1 and F Board Schematic Diagram
C2801 0.1 100V PT D2800 ELIZ BIAS R2802 10k L2803 3.3mH C2806 0.047 100V MPS R2807 1.8k FPRD D2801 1SS119-25 BIAS
1 IC2801 LM358D V.PARA.AMP R2817 270k CHIP 1 R2814 1M CHIP 4 R2816 270k CHIP QPNC QP+ CN2802 3P WHT TO VM BOARD CN2801 D2803 1SS119-25 BIAS CC2810 0.022 200V MPS

L2800 0UH

Q2801 2SC2958-L AMP
R2806 2.2K R2805 100k CHIP R2800 R2804 3.3k 100 FPRD CHIP R2803 10k

Q2800 2SC2785-HFE AMP

C2802 0.015 100V PT

L2804 15mH

CN2800 7P WHT TO A BOARD CN503 (BLOCK C) (POWER SUPPLY /DEFLECTION) VD+ 15V FBP GND GND NC NC
Q2802 2SC4793 DQPV.MOD IC2800 NJM78M09FA 15V REGULATOR 1
I O C2805 G 47 35V CC2804 L2801 XX 35V C2813 XX 0.0033 L2802 4.7MH 630V PP R2801 C2803 XX 0.056 630V PP

R-Y VR

C2809 0.47 MPS C2807 C2808 0.MPS R2811 Q2803 R2809 6.8k 2SA1162-G 2.7k DQPV.MOD CHIP CHIP T2800 TRANSFOMER,FERRITE(DFT) 7 8

R1W RS

R2815 C2811 33k 10 CHIP D2802 1SS119-25 R2812 DQPV.MOD 22k R2810 CHIP R2813 1k 2.7k CHIP Q2804 CHIP MSD601-RT1

R2410 XX

JW2421 5.0MM

JW2410 5.0MM

D2410 XX PROTECTION
CN2803 1P TO A BOARD CNDF OUT
(DYNAMIC FOCUS & DQP)
B-SSS12091-SA.-D3.-XR29M80
AC IN AC IN CN4601 2P:VH TO POWER CORD

VDR461 XX

FH002 FH001 FUSE FUSE HOLDER HOLDER

SPARK GAP

F4601 5A 250V
JW4603 JW4606 JW4605 XX XX XX JW4604 T4601 C4602 XX LFT 0.68 T4602 250V LFT PT
R4601 820K 1/2W 1 AC OUT 2 AC OUT CN4602 2P:VH WHT TO H3 BOARD CN3601
1 C2410 RXX R2419 XX CXX D2411 XX R2411 VB B-Y 4 XX XX 5 PROTECTION 6 R2420JW2419 JW2411 C2412 VG D2412 Y 5.0MM 7 XX 5.0MM XX XX 8 R2412 JW2412 R2415 PROTECTION XX 5.0MM XX L JWL C2400 D2414 XX XX C2413 R2414 JW2415 JW2400 XX XX PROTECTION 5 B 5.0MM R R2418 R C2414 XX C2401 XX XX B J2410 R2417 5P JW2418 JW2401 5.0MM XX JACK BLOCK, PIN 5.0MM D2415 XX PROTECTION
CN2410 8P WHT TO A BOARD (JACK) CN907/CN010 DVD Y GND DVD BY GND DVD RY GND DVD L DVD R

J1 (DVD TERMINAL)

B-SSS12091-SA-J1.-XR29M80
GND 1 CN4603 1P:TAB TO A BOARD CN100 (BLOCK D) (TUNER)

C654 0.0047 250V B

JW4608 C4601 XX JW4607 0.47 XX 275V

(CISPR)

B-SSS12091-SA-F.-XR29M80

JW4601 XX JW4602 XX

A Board Mark List
C619 C620 C621 C646 C691 CN601 CN603 D613 D614 D659 D660 IC001 IC608
Note: The parts indicated as "XX" in this circuit diagram are not listed here, as they are not used for these models.
JR1681 R607 R638 R639 R6004 R6005 R6014 R6015 RY601 VD600 VD602
KV-XR29M80 (SA) XX 820 250V 820 250V 22 25V 0.47 450V 3P XX U05G U05G U05G MTZJ-T-77-22 TDA12067H1/N1B0B0KO SELECTION UNIT RECTIFIER XX 2.2K :RN-CP 470K 1/2W 470K 1/2W 4.7 1/2W 4.7 1/2W 1 10W 1 10W RELAY (AC POWER) ENE271D-20A ENE271D-20A
KV-XR29M80 (ME) XX 820 250V 820 250V 22 25V 0.47 450V 3P XX U05G U05G U05G MTZJ-T-77-22 TDA12067H1/N1B0B0KO SELECTION UNIT RECTIFIER XX 2.2K :RN-CP 470K 1/2W 470K 1/2W 4.7 1/2W 4.7 1/2W 1 10W 1 10W RELAY (AC POWER) ENE271D-20A ENE271D-20A
KV-XR29M50 (EM) 470 450V XX XX XX XX XX 2P XX XX XX XX TDA12067H1/N1B0B0KN XX 0 :CHIP 0 :CHIP

D2L20U HSS82-TJ MTZJ-T-77-15 MTZJ-T-77-22 RD5.6ESB2 RD6.8ES-B1 RD18ESB RD39ESB UPC574J 1SS119-25 1SS133T-77
D1NL20U-TR D1NS6 EL1Z ERA22-08 GP08D UF4005PKG23 10ERB20-TB5

MMDL914T1 RD5.6SB-T1

MA2ZD14001S0 MA77 UDZSTE-179.1B UDZS-TE17-12B

D10SC4M

IRF614 2SC4793 2SA1091-0 2SC3779C-DAA

D2B60A-F04

DA204K

2SA1175-HFE 2SC2785-HFE

2SA1606-E 2SC4159-E

2SC2458-YGR

2SC2688-LK
MSB709-RT1 MSD601-RT1 UN2211 UN2216 2SA1162-G 2SD601A-Q-TX

2SD2634-CA

IRF1B7N50A-LF31

BA033FP-E2

TOP VIEW

AN5276T

RPM7240-SH5

PQ018EF01SZH PQ05RD11

TDA6108AJF/N1
TDA12067H1/ N1B0B0KN TDA12067H1/ N1B0B0KO
1 TOP VIEW Dual In-line Package Pin 6~98
BA18BCOWFP-E2 LM358D MCZ3001DA NJM78M09FA TDA8177 BR24L16F-WE2

LA6510

NOTE: Items with no part number and no description are not stocked because they are seldom required for routine service. The construction parts of an assembled part are indicated with a collation number in the remark column.

SECTION 5 EXPLODED VIEWS

Items marked " " are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. The components identified by shading and mark ! are critical for safety. Replace only with part number specified.

5-1. PICTURE TUBE

r : 7-685-648-79 SCREW +BVTP TYPE 2 IT-3 p : 7-685-663-71 SCREW +BVTP TYPE 2 IT-3

REF. NO. PART NO. 5

DESCRIPTION REMARK REF. NO. PART NO. DESCRIPTION REMARK X-4042-217-1 4-036-405-11 4-075-747-61 * 4-075-749-01 ! 8-735-056-05 ! 8-735-057-05 BEZNET ASSY 2-4,21,22 SPRING COMPRESSION BUTTON POWER GUIDE LIGHT PICTURE TUBE (M68LNH070X) (SDS) (KV-XR29M50) PICTURE TUBE (M68LNH070X) (except KV-XR29M50) SPACER DY CLIP (29 RSN) DGC DEFLECTION YOKE (Y29RSA-S) MOUNTED PWB (VAR), C COIL DEGAUSSING (KV-XR29M50) COIL DEGAUSSING (except KV-XR29M50) CUSHION (50x550) DGC HOLDER DGC COIL NA ROTATION (RT200) MOUNTED PWB, VM SPRING TENSION 1-452-032-00 1-452-094-00 4-077-228-02 4-079-376-01 8-453-021-11 4-098-501-01 4-047-464-01 4-046-765-12 X-4387-214-3 4-084-918-01 ! 4-075-454-11 4-302-404-03 1-825-691-11 * 4-046-981-03 MAGNET DISC CIRCULAR DISC MAGNET PIECE TLH CONVERGENCE BAND DGC NA2919-M DOOR CONTROL(XR) CATCHER PUSH SCREW TAPPING 7+CROWN WASHER PERMALOY ASSY CORRECTION HOLDER HV CABLE COVER REAR (12 SCREWS p) SCREW (WASHER HEAD) (+P 4x16) SPEAKER (15x6.5cm) BRACKET SPEAKER
4-063-935-21 4-064-883-03 1-452-896-11 * A-1410-218-A 4-369-318-61

L003 L004 L005 L006 L007 L008 L009 L010 L011 L012 L013 L031 L032 L033 L035 L036 L037 L038 L039 L100 L101 L103 L104 L106 L502 L503 L507 L511 L513 L514 L515 L518 L600 L690 L902
1-414-856-11 1-414-187-11 1-469-525-91 1-414-856-11 1-414-856-11 1-414-856-11 1-414-856-11 1-469-525-91 1-412-058-11 1-469-525-91 1-469-525-91 1-469-525-91 1-469-525-91 1-469-525-91 1-469-525-91 1-469-525-91 1-469-525-91 1-414-856-11 1-414-158-11 1-414-857-11 1-408-959-21 1-410-987-42 1-414-187-11 1-414-189-31 1-410-396-41 1-412-525-31 1-419-633-21 1-406-977-21 1-412-552-11 1-408-947-00 INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR FERRITE INDUCTOR INDUCTOR INDUCTOR INDUCTOR INDUCTOR 10UH 47UH 10UH 10UH 10UH 10UH 10UH 10UH 10UH 10UH 10UH 10UH 10UH 10UH 10UH 10UH 10UH 10UH 2.2UH 100UH Q515 Q516 Q600 Q607 Q608 8-729-010-05 8-729-200-17 8-729-010-05 8-729-052-32 8-729-052-32 TRANSISTOR MSB709-RT1 TRANSISTOR 2SA1091-O TRANSISTOR MSB709-RT1 TRANSISTOR IRFIB7N50A-LF31 TRANSISTOR IRFIB7N50A-LF31 TRANSISTOR KTC3199GR-TP TRANSISTOR UN2211 TRANSISTOR MSB709-RT1 TRANSISTOR UN2211 TRANSISTOR MSB709-RT1 TRANSISTOR 2SA1162-G TRANSISTOR MSB709-RT1 TRANSISTOR MSB709-RT1 TRANSISTOR MSB709-RT1 TRANSISTOR MUN2216T1 TRANSISTOR MUN2216T1 Q609 Q612 Q613 Q614 Q615 Q616 Q617 Q618 Q900 Q901 Q902 8-729-016-42 8-729-421-22 8-729-010-05 8-729-421-22 8-729-010-05 8-729-216-22 8-729-010-05 8-729-010-05 8-729-010-05 6-550-600-01 6-550-600-01
1.2UH 0.33UH 47UH 100UH 0.45UH 10UH 10MH 100UH 2.2MH 2.2MH <RESISTOR> R001 R002 R003 R004 R010 R011 R012 R014 R015 R023 R024 R025 R026 R029 R030 R038 R039 R041 R042 R044 1-216-829-11 1-216-809-11 1-216-829-11 1-216-809-11 1-216-833-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 4.7K 100 4.7K 100 10K 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1-459-104-00 1-414-187-11 1-412-529-11 1-412-525-31 1-414-187-11 COIL, WITH CORE INDUCTOR 47UH INDUCTOR 22UH INDUCTOR 10UH INDUCTOR 47UH 1-216-809-11 1-216-825-11 1-216-809-11 1-218-851-11 1-216-823-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-809-11 1-216-825-11 1-216-834-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 100 2.2K 100 1.5K 1.5K 100 5% 5% 5% 0.50% 5% 5% 5% 5% 5% 5% <PHOTO COUPLER>
PH601 ! 8-749-924-35 PH602 ! 8-749-924-35