7Two scrws (BVTP 3X8)

8Main board

4Three screws (BVTP 3X8)

2-2. TC MECHANISM DECK

6Button (eject-L) 3Three screws (BVTP 2.6X8) 4Four screws (BVTP 2.6X8)

5TC mechanism deck

6Button (eject-R)
2Remove the two cassette lids direction of arrow. 1Push the eject button.

2-3. CD MECHANISM DECK

1Screw (BVTP 3X8)

2Two screws (BVTP 3X8)

3Two screws (BVTP 3X8)

4CD mechanism deck

2-4. BU BRACKET ASSY

2BU bracket assy

1Yoke bracket

2-5. DISC TABLE

5Step screw 1 Screw (BVTP 3X8) 3 Screw (BVTP 3X8)

2Bracket (BU)

4Bracket (BU)

6Disc table

SECTION 3 MECHANICAL ADJUSTMENTS
PRECAUTION 1. Clean the following parts with a denatured alcohol-moistened swab : record/playback heads pinch rollers erase head rubber belts capstan idlers 2. Demagnetize the record/playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. The adjustments should be performed with the rated power supply voltage unless otherwise noted. Torque Measurement
Torque FWD FWD back tension REV REV back tension FF/REW FWD tension REV tension Torque meter CQ-102C CQ-102C CQ-102RC CQ-102RC CQ-201B CQ-403A CQ-403R Meter reading 36 to 61g cm (0.50.84 oz inch) 2 to 6g cm (0.020.08 oz inch) 36 to 61g cm (0.50.84 oz inch) 2 to 6g cm (0.020.08 oz inch) 61 to 143g cm (0.851.99 oz inch) 100g or more (3.53 oz or more) 100g or more (3.53 oz or more)
SECTION 4 ELECTRICAL ADJUSTMENTS

DECK SECTION 0 dB=0.775V

1. Demagnetize the record/playback head with a head damagnetizer. 2. Do not use a magnetized screwdriver for the adjustments. 3. After the adjustments, apply suitable locking compound to the parts adjusted. 4. The adjustmetns should be performed with the rated power supply voltage unless otherwise noted. 5. The adjustments should be performed in the order given in this service manual. (As a general rule, playback circuit adjustment should be completed before performing recording circuit adjustment.) 6. The adjustments should be performed for both L-CH and R-ch. 7. Switches and controls should be set as follows unless otherwise specified. DOLBY NR switch : OFF (US, CND, AEP, UK, G, IT model)
Tape P-4-A100 WS-48B P-4-L300 Signal 10 kHz, 10 dB 3 kHz, 0 dB 315 Hz, 0 dB Used for Azimuth Adjustment Tape Speed Adjustment Level Adjustment

Record/Playback Head Azimuth Adjustment DECK A DECK B
Note : Perform this adjustments for both decks. Procedure : 1. Mode : Playback (FWD)
test tape P-4-A100 (10kHz, 10dB) main board CN403 Pin 3 (L-CH) Pin 1 (R-CH)

level meter

set main board CN403 Pin 2
Abbreviation CND : Canadian model. G : German model. IT : Italian model.
2. Turn the adjustment screw and check output peaks. If the peaks do not match for L-CH and R-CH, turn the adjustment screw so that outputs match within 1 dB of peak.
Tape Speed Adjustment DECK A NOTE : Start the tape speed adjustment as bellow after setting the test mode.The tape speed can be changed with the HIGH SPEED DUBBING button during the test mode. Method : 1. Turn the power switch on. 2. Press the DISPLAY/DEMO button, MENU 1 button and TUNER/ BAND button simulateously. Procedure : Mode : Playback (FWD)
test tape WS-48B (3kHz, 0dB)

L-CH peak

output level

within 1dB

frequency counter
R-CH peak screw position L-CH peak R-CH peak set screw position
main board CN403 (Pin 3 : L-CH) (Pin 1 : R-CH)

3. Mode : Playback (FWD)

test tape P-4-A100 (10kHz, 10dB) main board CN403 Pin 3 Pin 2 L set R

oscilloscope

1. Insert tha WS-48B into the deck A to playback. 2. Press the HIGH SPEED DUBBING button. Then at HIGH SPEED mode. 3. Adjust RV652 on the MD board so that the frequency counter reading becomes 6,Hz. 4. Press the HIGH SPEED DUBBING button again to be set the NORMAL SPEED mode. 5. Set to the playback mode. 6. Adjust RV651 on the MD board so that the frequency counter reading becomes 3,Hz. Frequency difference between deck A and deck B the beginning of the tape should be within 1.5%. Adjustment Location : MD board Playback Level Adjustment DECK A DECK B

Waveform of oscilloscope

in phase

45 good

180 wrong
Procedure : Mode : Playback (FWD)
test tape P-4-L300 (315Hz, 0dB) level meter
4. Repeat steps 1 to 3 in playback (REV) mode. 5. After the adjustments, apply suitable locking compound to the parts adjusted. Adjustment Location : Record/Playback Head (Deck A and B)
Deck A is RV311 (L-CH) and RV411 (R-CH), deck B is RV301 (LCH) and RV401 (R-CH) so that adjustment within the following adjustment level. Adjustment level : CN403 PB level : 301.5 to 338.3 mV (8.2 to 7.2 dB) level difference between the channels : within 0.5 dB Adjustment Location : MD board

FWD side

REV side

Adjustment screw

Record Bias Current Adjustment Procedure : 1. Mode : record
VIDEO IN 1) 315Hz 2) 10kHz AF OSC attenuator 600

DECK B

2. Mode : Playback
recorded position level meter
set 50mV (23.8dB) blank tape CS-123
Confirm playback the signal recorded in step 1 become adjustment level as follows. If these levels do not adjustment level, adjust the RV301 (L-CH) and RV351 (R-CH) on the main board to repeat steps 1 and 2.
Adjustment level: CN 403 PB level: 47.2 to 53.0 mV (24.3 to 23.3 dB) Adjustment Location : main board Adjustment Location
CN 403 (Pin 3 : L-CH) (Pin 1 : R-CH)
[MAIN BOARD] (Component Side)
CN403 RV301 REC LEVEL (L-CH) RV351 REC LEVEL (R-CH)
Confirm playback the signal recorded in step 1 become adjustment level as follows. If these levels do not adjustment level, adjust the RV341 (L-CH) and RV441 (R-CH) on the MD board to repeat step 1 and 2. Adjustment level : The playback output of 10 kHz level difference against 315Hz reference should be 0.5 dB Adjustment Location : MD board
Record Level Adjustment Procedure : 1. Mode : record
VIDEO IN 315Hz, 50mV (23.8dB) AF OSC 600 attenuator set blank tape CS-123
[MD BOARD] (Conductor Side)
RECORD BIAS R L RV301L RV401R RV441 RV341 PB LEVEL DECK B PB LEVEL R DECK A TAPE SPEED (NORMAL) RV651 (HIGH) RV652

TUNER SECTION

0dB=1V
Abbreviation G : German model IT : Italian model
Note : As a front-end (FE1) is difficult to repair if faulty, replace it with new one. AM Tuned Level Adjustment Note : FM Tuned Level adjustment should be performed after this AM Tuned Level adjustment. Setting : Band : AM or MW

AM RF SSG

loop antenna
loop antenna (Supplied accessories)
30% amplitude modulation by 400 Hz signal Carrier frequency : 999kHz (at 9kHz step) 1050kHz (at 10 kHz step)
AM antenna terminal (TM1)
Field strength dB (V/m)=SGG output level dB (V/m)26dB.
Procedure : 1. Set the output of SGG so that the input level of the set becomes 55 dB. 2. Tune the set to 999 kHz or 1050 kHz. 3. Adjust RV41 (AEP, UK, IT, G models), RV42 (other models) to the point (moment) when the TUNED indicator will change from going off to going on. Adjustment Location : TCB board FM Tuned Level Adjustment Note : This adjustment should be performed after the AM Tuned Level Adjustement. Setting : Band : FM
Adjustment Location AEP, UK, G, IT model [TCB BOARD] (Component Side)

Abbreviation FL: Fluorescent Indicator Tube GND: Ground
IC701 MASTER CONTROL (TMP87CS64YF) Pin No. Pin Name VSS XOUT XIN RESET XOUT XIN GND (test) AC CUT SUPER WOOFER ON ST-MUTE ON 180-A-PLAY 180-B-PLAY 180-B-REC V. DET BD-UP (5CD) TRAY CLOSE (1CD) ENCODER-1 ENCODER-2 ENCODER-3 OUT SW OPEN LOAD IN LOAD OUT TBL-L TBL-R SCOR TBL-SENS RDS INT RDS DATA DF LAT SENS XRST MG-RDY ADJ GM-REQ MG-CLK GM-DATA MG-DATA CD-CLK ADJ-2 CD-DATA I/O O I I O I I O O I I I I I I I I I I O O O O I I I I O I O O I I O I O O I O Function GND X tal (10 MHz). Reset signal input. X tal for clock (32.768 kHz) GND Back up signal input. Super woofer ON/OFF control. Mute signal output for tuner. Tape detection sigal input. (Connected to GND) Voltage detection (Not used). Disc table up detect. Connected to GND Input selector control signal output. (Pull up) Out switch signal input. (Pull up) Loading motor control signal output. (Not used) Table motor control signal output. Sub-code sync signal input. CD Table sensor signal input. RDS data start input. RDS data output. Latch signal for digital filter. Table sence signal input. Reset signal output for CD. Ready signal to graphic control. Test mode input. Request signal from graphic control. Clock signal to graphic control. Data input from graphic control. Data output to graphic control. Clock output. Serial bus line. Test mode input. Data output. Serial bus line.
Abbreviation FL : Fluorescent Indicator Tube GND : Ground

Pin No. 79 80

Pin Name AUB IN AUB OUT FOCUS SW SQ-CLK SQ-DATA X-LAT TEST VAREF AVSS VSS VDD SPEC DESTINATION DISC SENS TC RELAY A-SHUT B-SHUT B-HALF A-HALF 220-A-PLAY 220-B-PLAY 62427 LAT K-CON-LAT VOL LAT (AV) FRONT SP RELAY B REAR SP RELAY C POWER ON CD POWER RPOLOG LAT MUTE COM CLK COM DIN COM DATA K CON ON LIDDED LED MD/VIDEO DBFB-HIGH PWM-OUT PRO-LOGIC TC A
I/O I O O O I O I I I I I O I I I I I I O O O O O O O O O O I O O O O O I O O
Function Audio bus in/output. (Not used) Focus switching signal output. Subcode Q data read clock output. Subcode Q data input. Latch signal digital signal processor. Test land. Analog reference voltage input. GND +5V Destination detection input. Not used. REC/PB select signal output.
Control signal input form deck.
PLL latch output. Not used. Latch signal for electrical volume. (Not used) Not used. Rear speaker relay control output. Power on signal output CD power control signal output. Not used. Mute signal for AMP. PLL clock output. (PLL, Function, Graphic Equalizer) PLL data input. (PLL, Function, Graphic Equalizer) PLL data output. (PLL, Function, Graphic Equalizer) Not used. Disc No. LED drive signal output. MD/VIDEO select output. DBFB switching signal output. Not used. Dolby pro-logic control ourput. Deck A, B select output.

Pin No. 99 100

Pin Name NORM BIAS OFF REC MUTE NR OFF PB PASS. AMP/DOLBY LINE MUTE ON CAP. M-HIGH A-TRG B-TRG TRG LOW CAP M ON STEREO TUNED ST-CE DELAY SEL MIC DELAY ON DELAY LEVEL A DELAY LEVEL B VDD
I/O O O O O O O O O O O O O I I O O O O O
Function NORMAL/HIGH control signal output. Bias oscillation output. Mute output. Dolby ON/OFF signal output. REC/PB control signal output. Dolby switching signal output. Mute signal output for deck. Capstan motor control signal output. Trigger motor control signal output. Trigger motor high/low control signal output. Capstan motor ON/OFF control signal output. Stereo detection signal from tuner. Tuned detection signal from tuner. Latch signal output for tuner. Not used. ECHO delay ON/OFF control signal output (Not used) ECHO delay level control signal output (Not used) +5V

SECTION 6 EXPLODED VIEWS

NOTE: Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. The mechanical parts with no reference number in the exploded views are not supplied. Abbreviation CND : Canadian model G : German model IT : Italian model MX : Mexican model AUS : Australian model AR : Argentine model The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifis par une marque ! sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi.
6-1. CABINET AND BALCK PANEL SECTION

#1 #1 #1 #1 #2 #1

FRONT PANEL
Ref. No. 1 * 2 * 2 * 2 * 2

Part No.

Description

Remark

Ref. No. * * * * * * * * * 8 8
Part No. 4-929-973-01 4-978-177-71 4-978-193-01 4-978-193-11 4-978-193-21 4-978-193-31 4-978-193-41 4-978-193-51 4-978-194-01 4-978-194-11
Description SCREW (CASE, 3 POINT) CASE PANEL, BACK (D670AV:US) PANEL, BACK (D670AV:CND) PANEL, BACK (N555AV:AEP) PANEL, BACK (N555AV:G) PANEL, BACK (N555AV:IT) PANEL, BACK (N555AV:UK) PANEL, BACK (N555AV:E) PANEL, BACK (N555AV:AR)
4-963-404-21 EMBLEM (5-A), SONY A-4303-502-A TCB BOARD, COMPLETE (Except Malaysia product) (N555AV:AEP,UK) A-4303-503-A TCB BOARD, COMPLETE (N555AV:IT,G) A-4303-510-A TCB BOARD, COMPLETE(D670AV) A-4303-513-A TCB BOARD, COMPLETE (N555AV:E,AUS,AR,MX,PX)

TCM-220WR2E

139 140

107 106

supplied with S502

102 101
Remark Ref. No. Part No. 4-978-152-01 4-978-119-01 4-978-683-01 4-978-682-01 4-978-135-01 4-978-121-11 4-978-136-01 4-978-167-01 4-978-123-01 4-978-681-01 Description BUTTON (AUTO) BUTTON (CURSOR) SPRING, COMPRESSION COVER (CURSOR) INDICATOR (BAND) BUTTON (BAND) INDICATOR (ENTER) BUTTON (PRO LOGIC) BUTTON (FU) INDICATOR (SE5) Remark
4-978-131-01 DISPLAY (ST) (D670AV/N555AV:E,AUS,PX,MX,AR) 4-978-131-11 DISPLAY (ST)(N555AV:AEP,UK,G,IT) 4-978-146-01 BUTTON (EJECT-L) 4-978-116-01 PANEL, FRONT (D670AV) 4-978-116-11 PANEL, FRONT (N555AV:AEP,UK,G,IT) 4-978-116-21 4-978-157-01 4-978-145-01 4-978-159-01 4-978-158-01 4-978-127-11 4-978-160-01 4-978-118-01 4-978-151-01 4-978-137-01 PANEL, FRONT (N555AV:E,AUS,PX,MX,AR) INDICATOR (TC) BUTTON (TC) INDICATOR (REV) INDICATOR (FWD) BUTTON (DISC 5) INDICATOR (CLIP) BUTTON (POWER) BUTTON (PON)(N555AV:E,AUS,PX,MX,AR) INDICATOR (PLAY)
4-978-124-11 BUTTON (DOLBY) 4-978-120-01 BUTTON (TUNING) (D670AV/N555AV:E,AUS,PX,MX,AR) 4-978-120-11 BUTTON (TUNING)(N555AV:AEP,UK,G,IT) 4-979-017-01 INDICATOR (SW)(N555AV) 4-978-166-01 BUTTON (SUPER-W)(N555AV) 4-978-161-01 INDICATOR (PAUSE) 4-978-144-01 BUTTON (DUBBING) (D670AV/N555AV:AEP,UK,G,IT) 4-978-144-11 BUTTON (DUBBING)(N555AV:E,AUS,PX,MX,AR) 4-978-147-01 BUTTON (EJECT-R) 4-980-061-01 SPRING (OPEN) 4-978-130-01 BUTTON (OPEN) 4-978-128-01 BUTTON (PLAY)

6-4. CHASSIS SECTION 151

not supplied F1604 F1601 #2 (D670AV) #3 (N555AV) T1601 CDM-5BD19 #1 #1 #1 #1 F1603 #2 (D670AV) #1 #3 (N555AV) #1 #1 #1 #1 not supplied N555AV: AEP, G,IT, AR models CNP1601

162 (AR Only)

N555AV: E, PX, MX models CNP1601

162 (PX Only)

N555AV: AUS model CNP1601 N555AV: UK model CNP1601
#4 not supplied #1 not supplied

D670AV model CNP1601

156 157
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifis par une marque ! sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi. Part No. Description Remark

160 161

not supplied #1
Ref. No. * * 152 * 152 * 153 * 153 * 153 * * 155
Part No. 3-701-946-26 3-701-946-27 1-659-218-11 1-660-805-11 A-4389-604-A
Ref. No. * 161 * 161 * 161 * 161 * 162
LABEL, FUSE RATING (D670AV) LABEL, FUSE RATING (D670AV) TRANS BOARD (D670AV) TRANS BOARD (D555AV) POWER AMP BOARD, COMPLETE (D670AV)
A-4389-602-A MAIN BOARD, COMPLETE (D670AV) A-4389-615-A MAIN BOARD, COMPLETE (N555AV:E,MX,AR) A-4389-622-A A-4389-894-A A-4390-010-A 1-569-007-11 1-569-008-11 MAIN BOARD, COMPLETE (N555AV:AEP,UK) MAIN BOARD, COMPLETE (N555AV:AUS,PX) MAIN BOARD, COMPLETE (N555AV:G,IT) ADAPTER, CONVERSION 2P (N555AV:PX) ADAPTER, CONVERSION 2P (N555AV:AR) CORD, POWER (N555AV:E,PX,MX) CORD, POWER (D670AV) CORD, POWER (N555AV:AEP,G,IT,AR) CORD, POWER (N555AV:AUS) CORD, POWER (N555AV:UK)

3-911-113-01 SPRING, TENSION X-3370-643-1 PINCH LEVER (REV) ASSY
272 3-930-972-3-917-142-01 HP101 1-500-093-11 HRPE101 1-500-094-11
6-7. TC MECHANISM SECTION 3 (TCM-220WR2E)
rA: MOTOR board (Suppplied with MD board)

317 302

309 313

314 313

307 306

312 304

#7 #7 M1
Ref. No. Part No. 3-908-597-01 3-908-608-11 X-3367-590-2 X-3370-169-1 3-928-047-01 3-908-599-01 3-908-601-01 3-908-603-01 X-3370-170-1 3-908-605-01 3-908-609-01 3-913-845-11 3-913-846-11 X-3370-171-1 Description CAM (A) SCREW, STEP ARM (A) ASSY, FR FLYWHEEL (AR) ASSY PULLEY, TENSION LEVER (REV-A) SPRING (REV LEVER), TORSION LEVER (TRIGGER A) FLYWHEEL (BF) ASSY SPRING (TRIGGER), TORSION GEAR, TRIGGER BELT (A) BELT (FR) FLYWHEEL (BR) ASSY

301 302

Remark Ref. No. 315 * * M1 M2 Part No. Description Remark
3-908-600-01 LEVER (REV-B) 1-650-669-11 3-908-598-01 X-3369-849-2 3-914-111-01 3-908-604-01 3-911-115-01 3-917-176-11 X-3370-172-1 A-2007-435-A X-3371-441-1 LEAF SWITCH BOARD CAM (B) ARM (B) ASSY, FR SPRING (FR), TORSION LEVER (TRIGGER B) WASHER, STOPPER BELT (B) FLYWHEEL (AF) ASSY MD BOARD, COMPLETE CHASSIS ASSY, MECHANICAL
X-3371-223-1 MOTOR ASSY (CAPSTAN) A-2004-410-A MOTOR ASSY (TRIGGER)
6-8. CD MECHANISM SECTION (CDM37-5BD19)

359 360

BU-5BD19
Ref. No. * * 361 Part No. 4-978-423-01 4-944-490-01 A-4660-978-A 4-978-421-01 4-978-425-01 4-978-420-01 1-452-538-11 4-978-417-01 4-934-376-01 X-4924-457-1 Description SCREW, STEP BELT (TIMING) GEAR (PULLEY) ASSY GEAR (MID) ROLLER (CAM) CAM (HOLDER) MAGNET TABLE, DISC SHAFT (ROLLER) ROLLER ASSY
Remark Ref. No. * 362 * 363 * * 366 * 369 * M201 Part No. 4-978-418-01 4-980-385-01 A-4673-765-A 4-978-426-01 1-659-059-13 1-659-058-13 4-933-134-01 4-958-593-01 4-978-419-01 Description
CHASSIS HOLDER (SW) CD MOTOR BOARD, COMPLETE INDICATOR (NO.) LED BOARD TABLE SENSOR BOARD SCREW (+PTPWH M2.6X6) SPRING (BU), COMPRESSION HOLDER (BU-5)
4-978-583-01 BRACKET (BU)
4-917-583-71 BRACKET, YOKE A-4660-977-A MOTOR ASSY (TABLE)
6-9. BASE UNIT SECTION (BU-5BD19) 402 401

M101 (including rA)

The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifis par une marque ! sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi.

408 407

Ref. No. ! 405 406
Part No. 8-848-387-01 1-769-069-11 4-917-567-01 4-951-940-01 4-917-565-01
Description OPTICAL PICK-UP KSS-213BA/S-N WIRE (FLAT TYPE)(16 CORE) GEAR (M) INSULATOR (BU) SHAFT, SLED

CD (L)

CD (R)
1-216-069-00 METAL CHIP 1-216-049-91 METAL GLAZE
1-579-280-11 VIBRATOR, CRYSTAL (16.9344MHz)
************************************************************** * 1-659-404-11 CD (L) BOARD ************ < CONNECTOR > * CN515 1-568-944-11 PIN, CONNECTOR 6P < DIODE > D638 D639 D640 8-719-057-09 DIODE LNJ801LPDJA (CLIP C) 8-719-057-09 DIODE LNJ801LPDJA (CLIP B) 8-719-057-09 DIODE LNJ801LPDJA (CLIP A) < RESISTOR > R568 R569 R570 R571 R572 R573 R574 R575 R576 R577 1-247-815-91 1-249-411-11 1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11 1-249-421-11 1-249-423-11 1-249-427-11 1-249-431-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON < SWITCH > S569 S570 S571 S572 S573 S574 S575 S576 S577 S578 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 SWITCH, TACTILE (CLIP C) SWITCH, TACTILE (CLIP B) SWITCH, TACTILE (CLIP A) SWITCH, TACTILE (ERASE MUSIC CLIP) SWITCH, TACTILE (PLAY MUSIC CLIP) SWITCH, TACTILE (DISC 1 DISC SELECT) SWITCH, TACTILE (DISC 2 DISC SELECT) SWITCH, TACTILE (DISC 3 DISC SELECT) SWITCH, TACTILE (DISC 4 DISC SELECT) SWITCH, TACTILE (DISC 5 DISC SELECT) 1K 1.5K 2.2K 3.3K 6.8K 15K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W

F F F F F F F

************************************************************** * 1-659-409-11 CD (R) BOARD ************ < CONNECTOR > CN514 1-568-936-11 PIN, CONNECTOR 9P < DIODE > D603 D604 D636 8-719-058-03 DIODE SEL5423E-TP15 () 8-719-058-03 DIODE SEL5423E-TP15 () 8-719-058-17 DIODE LNJ401NPYJA ()
< VARIABLE RESISTOR > RV101 RV102 RV103 1-241-396-11 RES, ADJ, METAL GLAZE 22K 1-241-396-11 RES, ADJ, METAL GLAZE 22K 1-241-396-11 RES, ADJ, METAL GLAZE 22K < SWITCH > S101 1-572-085-11 SWITCH, LEAF (LIMIT)

Ref. No. D637

CD JOG

CD LED

CD MOTOR

DOOR SW

Ref. No. D3152 D3153 D3154 Part No. Description Remark
8-719-057-09 DIODE LNJ801LPDJA (AUTO PLAY) < RESISTOR > 1-249-411-11 1-249-413-11 1-249-415-11 1-249-417-11 1-249-419-11 CARBON CARBON CARBON CARBON CARBON 680 1K 1.5K 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W
8-719-058-19 DIODE HLMF-K405-2UL (5CD) 8-719-058-19 DIODE HLMF-K405-2UL (5CD) 8-719-057-40 DIODE HLMF-K305-2UL (5CD) < RESISTOR >
R553 R554 R555 R556 R557 R678 R680

F F F F

1-249-412-11 CARBON
************************************************************** 1-247-815-91 CARBON 1-247-815-91 CARBON < SWITCH > * S554 S555 S556 S557 S558 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 SWITCH, TACTILE () SWITCH, TACTILE ( ) SWITCH, TACTILE () SWITCH, TACTILE (DISC SKIP) SWITCH, TACTILE (AUTO PLAY) 4-980-385-01 HOLDER (SW) < CAPACITOR > C201 C202 C203 1-124-907-11 ELECT 1-164-159-21 CERAMIC 1-124-907-11 ELECT < CONNECTOR > * 1-659-405-11 CD JOG BOARD ************ < CAPACITOR > C515 C516 1-162-306-11 CERAMIC 1-162-306-11 CERAMIC < CONNECTOR > L201 * CN518 1-568-942-11 PIN, CONNECTOR 4P < MOTOR > < RESISTOR > M201 R558 R559 R560 R561 1-249-421-11 1-249-423-11 1-249-427-11 1-249-431-11 CARBON CARBON CARBON CARBON < SWITCH > < SWITCH > S502 S559 S560 S561 S562 1-473-534-11 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 ENCODER, ROTARY ( AMS SWITCH, TACTILE (PROGRAM) SWITCH, TACTILE (REPEAT) SWITCH, TACTILE (SHUFFLE) SWITCH, TACTILE (CONTINUE) ) S201 1-762-587-11 SWITCH, PUSH (1 KEY)(UP) 2.2K 3.3K 6.8K 15K 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W F F F R205 R206 A-4660-977-A MOTOR ASSY (TABLE) < RESISTOR > 1-249-427-11 CARBON 1-249-425-11 CARBON 6.8K 4.7K 5% 5% 1/4W 1/4W F F 1-408-117-00 INDUCTOR 10uH 0.01uF 0.01uF 30% 30% 16V 16V IC201 * CN201 1-568-947-11 PIN, CONNECTOR 9P < IC > 8-759-365-94 IC TA8409S < COIL > 10uF 0.1uF 10uF 20% 20% 50V 50V 50V * A-4673-765-A CD MOTOR BOARD, COMPLETE ************************

**************************************************************
************************************************************** * 1-659-408-11 DOOR SW BOARD ************* < CAPACITOR > C591 1-164-159-21 CERAMIC < CONNECTOR > 0.1uF 50V
************************************************************** * 1-659-406-11 CD LED BOARD ************ < CONNECTOR > CN516 1-506-481-11 PIN, CONNECTOR 2P * CN519 < DIODE > D3151 8-719-057-40 DIODE HLMF-K305-2UL (5CD)
1-506-481-11 PIN, CONNECTOR 2P
Ref. No. Part No. Description < SWITCH > S591 1-572-126-11 SWITCH, PUSH (1 KEY)(6 OPEN) Remark

LEAF SWITCH

Ref. No. *
1-659-059-13 LED BOARD ********* < DIODE >
************************************************************** D201 * 1-659-411-11 HP BOARD ******** Q201 < CAPACITOR > < RESISTOR > C621 C622 C623 C624 1-162-294-31 CERAMIC 1-162-294-31 CERAMIC 1-164-159-21 CERAMIC 1-164-159-21 CERAMIC < JACK > J601 1-569-113-11 JACK, LARGE TYPE (PHONES) * ************************************************************** * 1-650-669-11 LEAF SWITCH BOARD ***************** < CONNECTOR > * CN1001 1-568-854-11 SOCKET, CONNECTOR 11P * < TRANSISTOR > Q1001 Q1002 8-749-010-90 TRANSISTOR PHOTO REFLECTOR NJL5165KA-H2 8-749-010-90 TRANSISTOR PHOTO REFLECTOR NJL5165KA-H2 < RESISTOR > R1001 R1002 R1003 R1004 R1005 1-247-818-11 1-247-820-11 1-249-414-11 1-247-834-11 1-247-818-11 CARBON CARBON CARBON CARBON CARBON < SWITCH > C251 S1001 S1002 S1003 S1004 S1005 S1006 S1008 S1009 1-692-832-11 1-692-832-11 1-572-248-11 1-571-281-21 1-571-281-21 SWITCH, PUSH (1 KEY)(A PLAY) SWITCH, PUSH (1 KEY)(B PLAY) SWITCH, LEAF (A HALF) SWITCH, LEAF (A CrO2) SWITCH, LEAF (REC A) C252 C253 C254 1-572-248-11 SWITCH, LEAF (B HALF) 1-571-281-21 SWITCH, LEAF (B CrO2) 1-571-281-21 SWITCH, LEAF (REC B) 1-164-035-11 CERAMIC 1-102-527-11 CERAMIC 1-162-291-31 CERAMIC 1-162-306-11 CERAMIC 560 1.3K 300 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W C201 C202 C203 C211 C212 C250 1-124-925-11 1-130-479-00 1-126-925-11 1-124-925-11 1-130-479-00 ELECT MYLAR ELECT ELECT MYLAR 2.2uF 0.0047uF 470uF 2.2uF 0.0047uF 0.01uF 20% 5% 20% 20% 5% 100V 50V 10V 100V 50V A-4390-010-A MAIN BOARD, COMPLETE (N555AV:G,IT) ********************************** 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S < CAPACITOR > * A-4389-615-A MAIN BOARD, COMPLETE (N555AV:E,MX,AR) ************************************* A-4389-622-A MAIN BOARD, COMPLETE (N555AV:AEP,UK) ************************************ A-4389-894-A MAIN BOARD, COMPLETE (N555AV:AUS,PX) ************************************ 1000PF 50V (N555AV:AEP,UK,G,IT) 1000PF 50V (N555AV:AEP,UK,G,IT) 0.1uF 50V 0.1uF 50V R201 R202 R203 1-247-863-91 CARBON 1-249-411-11 CARBON 1-249-437-11 CARBON 22K 330 47K 5% 5% 5% 1/4W 1/4W 1/4W 8-719-032-98 DIODE SEL5820A (DISC No.) < TRANSISTOR > 8-729-119-78 TRANSISTOR 2SC2785-HFE

************************************************************** * A-4389-610-A PANEL BOARD, COMPLETE (D670AV) ****************************** A-4389-629-A PANEL BOARD, COMPLETE ********************* (N555AV:AEP,UK,G,IT) * A-4389-619-A PANEL BOARD, COMPLETE ********************* (N555AV:E,AUS,PX,MX,AR) 4-971-014-11 HOLDER, FL TUBE
* 1-238-551-11 RES, ADJ, CARBON 220K 1-238-599-11 RES, ADJ, CARBON 4.7K 1-238-599-11 RES, ADJ, CARBON 4.7K < TRANSFORMER > T621 1-423-980-11 TRANSFORMER, BIAS OSCILLATION
************************************************************** < CAPACITOR > * 1-659-414-11 MIC BOARD (N555AV:E,AUS,PX,MX,AR) ********************************* < CAPACITOR > C901 C903 C904 C905 C906 C907 C908 C909 C910 1-162-306-11 1-162-294-31 1-124-257-00 1-162-215-31 1-162-290-31 1-136-160-00 1-124-257-00 1-162-215-31 1-162-286-21 CERAMIC CERAMIC ELECT CERAMIC CERAMIC FILM ELECT CERAMIC CERAMIC 0.01uF 0.001uF 2.2uF 47PF 470PF 0.039uF 2.2uF 47PF 220PF 30% 10% 20% 5% 10% 5% 20% 5% 10% 16V 50V 50V 50V 50V 50V 50V 50V 50V C501 C502 C503 C504 C505 C506 C511 C512 C513 C514 C515 C518 1-126-160-11 1-164-159-21 1-126-160-11 1-164-159-21 1-162-294-31 1-124-584-00 1-164-159-21 1-164-159-21 1-164-159-21 1-164-159-21 ELECT CERAMIC ELECT CERAMIC CERAMIC ELECT CERAMIC CERAMIC CERAMIC CERAMIC 1uF 0.1uF 1uF 0.1uF 0.001uF 100uF 0.1uF 0.1uF 0.1uF 0.1uF 33uF 10uF 20% 20% 10% 20% 50V 50V 50V 50V 50V 10V 50V 50V 50V 50V 35V 16V
1-126-793-11 ELECT 1-126-157-11 ELECT
Ref. No. C519 C520 C521 C522 C523 C524 C545 C546 C547 C549 C601 C3002 C3010 C3034 C3047 C3048 C3049 C3201 C3202 C3203 C3211 C3212 C3213 C3221 C3222 C3223 C3232 C3233 Part No. Description 0.1uF 0.1uF 0.1uF 0.1uF 100uF 100uF 0.01uF 0.01uF 10uF 100uF 10uF 0.1uF 0.001uF 100uF 0.1uF 100uF 0.1uF 4.7uF 0.22uF 0.22uF 1uF 0.015uF 0.22uF 0.15uF 0.0022uF 0.22uF 820PF 0.22uF Remark 50V 50V 50V 50V 10V 10V 16V 16V Ref. No. D624 D625 D626 D627 D3026 D3027 D3028 D3029 D3201 D3211 D3221 D3231 D3241 D3242 Part No. 8-719-058-04 8-719-058-04 8-719-058-04 8-719-058-04 Description DIODE DIODE DIODE DIODE Remark
1-164-159-21 CERAMIC 1-164-159-21 CERAMIC 1-164-159-21 CERAMIC 1-164-159-21 1-126-177-11 1-126-177-11 1-162-306-11 1-162-306-11 CERAMIC ELECT ELECT CERAMIC CERAMIC

20% 20% 30% 30%

SEL5223S-TP15 (HALL) SEL5223S-TP15 (THEATER) SEL5223S-TP15 (LIVE) SEL5223S-TP15 (SUPER WOOFER) (N555AV) 8-719-987-63 DIODE 1N4148M 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 8-719-987-63 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE 1N4148M 1N4148M 1N4148M 1N4148M 1N4148M 1N4148M 1N4148M 1N4148M 1N4148M
1-126-157-11 ELECT 1-126-177-11 ELECT 1-126-157-11 ELECT 1-164-159-21 CERAMIC 1-162-294-31 CERAMIC 1-124-584-00 1-164-159-21 1-126-177-11 1-164-159-21 1-126-163-11 1-136-169-00 1-124-464-11 1-126-160-11 1-136-155-00 1-124-464-11 1-136-167-00 1-162-302-11 1-124-464-11 1-162-293-31 1-124-464-11 ELECT CERAMIC ELECT CERAMIC ELECT FILM ELECT ELECT FILM ELECT FILM CERAMIC ELECT CERAMIC ELECT < CONNECTOR >

F F F F F F F F F F F

F F F F F F F F F F F F F F F F F
1-249-393-11 CARBON 1-247-815-91 CARBON 1-247-903-00 CARBON 1-249-429-11 CARBON 1-249-429-11 CARBON
10 5% 1/4W F 220 5% 1/4W (N555AV:E,AUS,PX,MX,AR) 1M 5% 1/4W 10K 5% 1/4W 10K 5% 1/4W
Ref. No. R3087 R3110 R3115 R3122 R3123 R3124 R3138 R3201 R3202 R3203 R3204 R3211 R3212 R3213 R3214 R3221 R3222 R3223 R3224 R3231 R3232 R3233 R3234 R3241 R3242 Part No.

POWER AMP

Description CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON < SWITCH > * A-4389-625-A 100K 330 47K 470K 680K 330 47K 470K 680K 330 47K 470K 680K 100 47K 470K 680K 2.2K 10 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W Ref. No. S528 S529 S530 S531 S532 S549 S551 S552 S553 S565 S566 S567 S568 S579 Part No. Description Remark
1-249-441-11 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-249-411-11 1-249-437-11 1-247-895-91 1-247-899-11 1-249-411-11 1-249-437-11 1-247-895-91 1-247-899-11 1-249-411-11 1-249-437-11 1-247-895-91 1-247-899-11 1-247-807-31 1-249-437-11 1-247-895-91 1-247-899-11 1-249-421-11 1-249-393-11
1-554-303-21 SWITCH, TACTILE (FILE 2) 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 1-554-303-21 SWITCH, TACTILE (FILE 3) SWITCH, TACTILE (FILE 4) SWITCH, TACTILE (FILE SELECT) SWITCH, TACTILE (FILE 5) SWITCH, TACTILE (SUPER WOOFER)(N555AV) SWITCH, TACTILE (DBFB) SWITCH, TACTILE (TUNER/BAND) SWITCH, TACTILE (PTY)(N555AV:AEP,UK,G,IT) SWITCH, TACTILE (STEREO/MONO) SWITCH, TACTILE (TUNER MEMORY)
1-554-303-21 SWITCH, TACTILE (+ TUNING) 1-554-303-21 SWITCH, TACTILE (- TUNING) 1-467-869-11 ENCODER, ROTARY (VOLUME) < VIBRATOR >
1-579-233-11 VIBRATOR, CERAMIC (4MHz)
************************************************************** * A-4389-604-A POWER AMP BOARD, COMPLETE (D670AV) *********************************** POWER AMP BOARD, COMPLETE **************************** (N555AV:E,AUS,PX,MX,AR) POWER AMP BOARD, COMPLETE ************************************* (N555AV:AEP,UK,G,IT)

Ref. No. M2 M101 M102 M201 S101 ! T1601 ! T1601 ! T1601
Part No. A-2004-410-A X-4917-523-4 X-4917-504-1 A-4660-977-A 1-572-085-11
Description MOTOR ASSY (TRIGGER) MOTOR ASSY (SPINDLE) MOTOR ASSY (SLED) MOTOR ASSY (TABLE) SWITCH, LEAF (LIMIT)
1-429-338-11 TRANSFORMER, POWER (N555AV:AEP,UK,G,IT) 1-429-339-11 TRANSFORMER, POWER (D670AV) 1-429-340-11 TRANSFORMER, POWER (N555AV:E,AUS,PX,MX,AR)
************************************************************** ACCESSORIES & PACKING MATERIALS ******************************* 1-473-608-11 4-979-431-01 4-980-140-01 4-981-643-01 REMOTE COMMANDER (RM-SE1AV) CUSHION (BOTTOM) CUSHION (UPPER) COVER, BATTERY (for RM-SE1AV)
************************************************************** ************* HARDWARE LIST ************* #1 #2 #3 #4 #5 #6 #7 #8 #9 #10 #11 #12 7-685-646-79 7-685-871-01 7-682-560-04 7-685-650-79 7-621-770-67 7-685-131-19 7-685-534-19 7-621-775-10 7-685-533-19 7-623-921-01 SCREW +BVTP 3X8 TYPE2 N-S SCREW +BVTT 3X6 (S) (D670AV) SCREW +BVTT 4X6 (S)(N555AV) SCREW +BVTP 3X16 TYPE2 IT-3 SCREW +BVTT 2.6X6 (S) SCREW +BTP 2.6X4 TYPE2 N-S SCREW +BTP 2.6X8 TYPE2 N-S SCREW +B 2.6X4 SCREW +BTP 2.6X6 TYPE2 N-S RING, RETAINING, CAPSTAN
7-621-775-00 SCREW +B 2.6X3 7-621-255-15 SCREW +P 2X3

Sony Corporation

9-960-525-11
Consumer A&V Products Company Home A&V Products Div.
English 96C0996-1 Printed in Japan 1996. 3 Published by Home A&V Products Div. Quality Engineering Dept.