DVP-NS355/NS501P/NS507P/NS525P/NS575P/NS585P
RMT-D165A/RMT-D165P/RMT-D166P

SERVICE MANUAL

Brazil Model

DVP-NS355

China Model

DVP-NS507P/NS525P/NS585P

Middle East Model

DVP-NS585P

US Model

DVP-NS501P

Photo : DVP-NS575P RMT-D165P
Canada Model PX Model Mexico Model Latin Model Brazil Model Hong Kong Model GA Model Taiwan Model Korea Model Saudi Arabia Model Middle East Model India Model Australia Model China Model Argentina Model US Model Iran Model

DVP-NS575P

Notes: US and Canada model only

SPECIFICATIONS

System Laser: Semiconductor laser Signal format system: NTSC Audio characteristics Frequency response: DVD VIDEO (PCM 96 kHz): 2 Hz to 44 kHz (1.0 dB)/ DVD VIDEO (PCM 48 kHz): 2 Hz to 22 kHz (0.5 dB)/CD: 2 Hz to 20 kHz (0.5 dB) Signal-to-noise ratio (S/N ratio): 115 dB Harmonic distortion: 0.003% Dynamic range: DVD VIDEO: 103 dB/ CD: 99 dB Wow and flutter: Less than detected value (0.001% W PEAK) Outputs (Jack name: Jack type/Output level/ Load impedance) LINE OUT (AUDIO): Phono jack/ 2 Vrms/ 10 kilohms DIGITAL OUT (COAXIAL): Phono jack/ 0.5 Vp-p/75 ohms COMPONENT VIDEO OUT (Y, P B, PR): Phono jack/Y: 1.0 Vp-p/ PB , PR : 0.65 Vp-p/75 ohms LINE OUT (VIDEO): Phono jack/ 1.0 Vp-p 75 ohms S VIDEO OUT: 4-pin mini DIN/Y: 1.0 Vp-p, C: 0.286 Vp-p/75 ohms General Power requirements: 120 V AC, 60 Hz 110-240 V AC, 50/60 Hz See page 5 for further information Power consumption: 11 W Dimensions (approx.): 237.7 mm (11/1/2 in.) (width/height/depth) incl. projecting parts Mass (approx.): 1.95 kg (4 1/3 lb) Operating temperature: 5C to 35C (41F to 95F) Operating humidity: 25% to 80% Supplied accessories See page 17 Specifications and design are subject to change without notice.
ENERGY STAR is a U.S. registered
mark. As an ENERGY STAR Partner, Sony Corporation has determined that this product meets the ENERGY STAR guidelines for energy efficiency.

CD/DVD PLAYER

eclubthai eclubthai eclubthai eclubthai eclubthai

SECTION 3 BLOCK DIAGRAMS

3-1. OVERALL BLOCK DIAGRAM

eclubthai eclubthai

KEY FUNCTION ND401 VFD

eclubthai

IC406 IR RECEIVER

SWITCHING REGULATOR

SW-10V

IF-112

IC404 IF MICON

IC404 RESET IC

BASE UNIT SERVIC ASSY KHM-310AAA

EVER+3.3V

AUDIO/VIDEO OUTPUT J501

INLIMIT SENSOR

MV-044
OPTICAL DEVICE IC204 FLASH MEMORY IC205 EEPROM eclubthai IC502/504 IC201 IC774 REG VIDEO BUFFER SERIAL BUS SYSTEM CONTROL AV DECODER DVD / CD PDIC

PRIMARY

IC601 AUDIO LPF

FOCUS COIL

TRANSFORMER

IC207 DA CONVERTER

IC101 eclubthai

TRACKING COIL

EVER-10V EVER+5V SECONDARY IC206 SW+8V SW+5V SW+3.3V EVER+11V P-CONT eclubthai IC102 SDRAM
FOCUS TRACKING COIL DRIVE SPINDLE/SLED /LOADING MOTOR DRIVE eclubthai

SPINDLE MOTOR

M SLED MOTOR

O/I POWER

SERVO DSP FR AMP

LOADING MOTOR

CHUCK/TRAY DETECT
Notes: MV-44 mounted PWB must be replaced if IC205 (EEPROM IC) is damaged or not functioning. The old MV-44 mounted PWB must be completely eclubthai disposed.

3 IC102 wl

C IN 7 MUTE1 C OUT 31

EC1, RUS EXCEPT EC1, RUS

2.0Vp-p
S VIDEO OUT EXCEPT EC1, RUS

2 IC102 ea

16 MUTE2 Y Cb Cr 12 Y IN 15 Cb IN 17 Cr IN Y OUT 24 Cb OUT 22 Cr OUT 20 Cr Cb COMPONENT VIDEO OUT EXCEPT EC1, RUS H 1.8Vp-p

6 IC102 w;

5 IC102 ws

4 IC102 wf

H Q504, 505 WIDE SWITCH

1.4Vp-p

IC901 VIDEO BUFFER SELECT SWITCH V CN 11 G 15 B 9 V Y C R 1 CN V IN V/Y OUT Y IN 6 C IN R/C OUT 12 R IN 15 G IN 17 B IN 7 MUTEMUTEMUTESWSW2 G OUT 17 B OUT 29 G B

Y C R G B

5 eclubthai 3
V/Y OUT BLANKING OUT R/C OUT G OUT FUNC. SW B OUT

D907 VMUTE EUROVY 12 19

BLANKING SIGNAL GENERATOR

eclubthai WIDE

eclubthai FUNCTION SIGNAL GENERATOR

RGBSEL

DISCEXT
3-6. INTERFACE CONTROL BLOCK DIAGRAM

EVER+3.3V SW+3.3V

3 CN 401

IF-112 BOARD

SW+3.3V

PROG LED VCC IR

SYSRST

SYSRST XIFCS SOO

CN 402

eclubthai 2

/CS 14 SI 15 SO 16 SC 17 /AMUTE 23

IC 406

SIO SCO A-MUTE V-MUTE

TO MV 11

IC 408 VOUT 1 EVER+3.3V 8 /RST
/VMUTE 24 BUSY 27 PCONT 26 O/C 35

eclubthai XIFBUSY

OPEN/ CLOSE
VFD DRIVER CIRCUIT 40 VKK
IC 404 IF CON R429 AD1 34

R430 R431

NEXT PREV

PAUSE PLAY

ND401 FLUORESCENT INDICATOR TUBE

DIG 1-7 SEG 1-20

2 X401 8MHz

XOUT 3

3-7. POWER BLOCK DIAGRAM

T101 D411

L421 Q211

P.CONT POWER

Bridge Rectifier Diode FLine Filters L101, L102

Transformer

eclubthai L512

E -10V

Switching eclubthaiIC & Circuit

SW +5V

QSW+3.5V

PC101 Photo Coupler

IC611 eclubthai Shunt Reg

E +11V

1 CN201

SW +8V

SECTION 4 PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
4-1. FRAME SCHEMATIC DIAGRAM

1 eclubthai A

4 eclubthai

7 eclubthai

11 eclubthai

eclubthai 14

SC-IN(N) AC-IN(L)

HARNESS

10P CNXXX SW+8V SYSRTS EVER+11V EVER+5V SW+3.3V 5

(PM-112)

10P CN771 SW+8V SYSRTS EVER+11V EVER+5V SW+3.3V SW+5V GND P-CONT POWER SW EVER-10V
SW+5V eclubthai 67 GND P-CONT POWER SW EVER-10V 10

24P CN103

24P orefe 11 GND(LD) eclubthai 23 LD(650) N.C N.C PD LD(780) VR(650) VR(780) N.C VoE/e+g Vcc Vc
13P CN10 GND MTRST 3.3V_MNT (SW+3.3V) XIFCS IFBUSY 13P CN201 GND MTRST 3.3V_MNT XIFCS IFBUSY SIO SOO GND SCO 9
GND(LD) LD(650) N.C N.C PD LD(780) VR(650) VR(780) N.C VoE/e+g Vcc

BASE UNIT

FFC (FMO-011)
8 eclubthai SIO 7 SOO GND SCO XV_MUTE XA_MUTE P_CONT POWER_SW
Vc 12 GND(PDIC) VoF/f+n 15
12 GND(PDIC) eclubthai 1 VoF/f+n VoB/b VoA/a RF (LO:DVD:HI:CD) MSW VoD/d VoC/c TRKTRK+ FCS+

OPTICAL DEVICE

XV_MUTE 10 XA_MUTE 11 P_CONT 12 POWER_SW 13

VoA/a 16 RF 17

(LO:DVD:HI:CD) MSW 18 VoD/d 19 VoC/c 20 TRK- 21 TRK+ 22

eclubthai eclubthai1 GND

SW +3.4V SW -10V EVER+3.3V/EVER+5V 4 4P CN401

HARNESS IM-065

4P CN205 GND SW +3.3V SW -10V EVER+3.5V

FCS+ 23

FCS- 24

FCSeclubthai

6P CN104 SPSP+ LIMIT 5 6

HARNESS MD-102

6P CNXXX SPSP+ LIMIT (GND) LIMIT SLSL+

LIMIT SWITCH

SLIDER MOTOR
6P CN4 TXD RXD GND +3.3V V2REFO RF MON

(GND) LIMIT SLSL+

5P CN106 TO SERVO JIG CKSW1 / FWD OCSW1 / REV GND / CTL

5P CN101

5 OCSW1 / REV

FFC (FMO-024)

CN101 5P LDM+ LDM-

4 CKSW1 / FWD

GND / CTL

MS-203 BOARD

FRAME SCHEMATIC DIAGRAM

4-1 4-2

For Schematic Diagram
Refer to page 4-5 for printed wiring board of MV-044 board. Refer to page 4-4 for waveform
MV-044 BOARD (1/5) eclubthai DRIVE -REF.NO.:1000 SERIESXX MARK:NO MOUNT

NO MARK:REC/PB MODE

SIGNAL PATH VIDEO SIGNAL

CHROMA Y

Y/CHROMA

AUDIO SIGNAL

eclubthai eclubthai eclubthai eclubthai

MV-044 (1/5)

MV-044 BOARD (2/5) eclubthai
CPU, SERVO-DSP, AVDEC -REF.NO.:1000 SERIESXX MARK:NO MOUNT NO MARK:REC/PB MODE

SIGNAL PATH

VIDEO SIGNAL

CHROMA Y Y/CHROMA

CPU, SERVO-DSP, AVDEC

4-9 4-10

MV-044 (2/5)
MV-044 BOARD (3/5) eclubthai VIDEO -REF.NO.:1000 SERIESXX MARK:NO MOUNT
eclubthai eclubthai eclubthai
NC NC VIDEO_IN DCCNT1 GND NC NC +5V VIDEO_OUT GND C_OUT NC Y_OUT -5V -5V NC +5V(NC) Y_OUT 35 36

C_IN MUTE1 Y_IN NC(DCCNT2) NC(GND) NC Y_IN(NC)

MV-044 (3/5)

MV-044 BOARD (4/5) eclubthai
AUDIO -REF.NO.:1000 SERIESXX MARK:NO MOUNT NO MARK:REC/PB MODE
The components identified by mark or dotted line with mark are critical for safety. Replace only with part number specified.
Les composants identifis par une marque sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi. eclubthai

4-13 4-14

MV-044 (4/5)
MV-044 BOARD (5/5) eclubthai PS THROUGH -REF.NO.:1000 SERIESXX MARK:NO MOUNT

PS THROUGH

MV-044 (5/5)
Refer to page 4-17 for printed wiring board of IF-112 board.
IF-112 BOARD eclubthai INTERFACE -REF.NO.:1000 SERIESXX MARK:NO MOUNT NO MARK:PB MODE MARKED:MOUNT TABLE

INTERFACE

Refer to page 4-21 for printed wiring board of Power Board.
POWER BOARD eclubthai POWER BLOCK (SRV1487UC) (US, CND, MX) -REF.NO.:1000 SERIESXX MARK:NO MOUNT NO MARK:PB MODE MARKED:MOUNT TABLE

POWER BOARD

POWER BLOCK (SRV1487UC)
Refer to page 4-25 for printed wiring board of Power Board.
POWER BOARD eclubthai POWER BLOCK (SRV1501WW) (E, SP, AUS) -REF.NO.:1000 SERIESXX MARK:NO MOUNT NO MARK:PB MODE MARKED:MOUNT TABLE

POWER BLOCK (SRV1501WW)

ANEXO CONTROLES REMOTO | OCTUBRE 2010

AUDINAC

BLUE SKY - WESTINGHOUSE

RD-3410

RH-3411E

RC-BSW

RC-CAN

CONVERSOR

DURABRAND

GOLDSTAR

CT-1405

CROWN MUSTANG

RS17-8873M

FS-095B

FS-185E

SAMSUNG

LCA-AOC

LCD-SAM

RM-YA006

RC-2185

www.mitsuko.com.ar

PANASONIC

ANTINA NEGRO

10110G

CT-9782

RC-7AS08

RM-SC3

RM-X115

DVD-ADMG1

ADMIRAL - MAGNAVOX

DVD-478A

TELEFUNKEN

DVP-418

DVD-00011K

RMT-D165A

DVD-TFK

URC-11A

UNIVERSAL

PHILCO

TOSHIBA