SA-PSD5/WPSD5/ SS-SPSD5

SERVICE MANUAL

Ver 1.0 2001. 05

US Model Canadian Model AEP Model UK Model E Model
The SA-PSD5 system consists of one unit of SA-WPSD5 and five units of SS-SPSD5.

Photo: SA-WPSD5

Photo: SS-SPSD5
This system incorporates Dolby* Digital and Pro Logic Surround and the DTS** Digital Surround System.
Manufactured under license from Dolby Laboratories. Dolby, Pro Logic, and the double-D symbol are trademarks of Dolby Laboratories. **Manufactured under license from Digital Theater Systems, Inc. US Pat. No. 5,451,942 and other worldwide patents issued and pending. DTS and DTS Digital Surround are trademarks of Digital Theater Systems, Inc. 1996 Digital Theater Systems, Inc. All rights reserved.

SPECIFICATIONS

AUDIO POWER SPECIFICATIONS POWER OUTPUT AND TOTAL HARMONIC DISTORTION: With 3 ohm loads, both channels driven, from 120 10,000 Hz; rated 25 watts per channel minimum RMS power, with no more than 10 % total harmonic distortion from 250 milliwatts to rated output. SA-WPSD5 (subwoofer) Max. output Subwoofer: 80 W (4 ohms) Front: 40 W + 40 W (6 ohms) Center*: 40 W Rear*: 40 W + 40 W
* Depending on the sound field settings and the source, there may be no sound output.
Speaker system Bass reflex Speaker unit 200 mm (7 7/8 inches) dia. cone type Rated impedance 4 ohms Dimensions (approx.) 300 mm (11 7/7/7/8 inches) (w/h/d, not including the projecting parts) Mass (approx.) 9.7 kg (21 lb 6 oz ) SS-SPSD5 (satellite speakers) Speaker system Bass reflex Speaker unit 77 mm (3 1/8 inches ) dia. cone type Rated impedance 6 ohms Dimensions (approx.) 110 mm (4 3/5/3/8 inches) (w/h/d) Mass (approx.) 780 g (1 lb 12 oz)
General Power requirements 120V AC, 60Hz (US, Canadian) V AC, 50/60 Hz (AEP, UK, E) Power consumption 90 W (US, Canadian) 95 W (AEP, UK, E) 3.5 W (standby mode) Operating temperature 5C to 35C (41F to 95F) Operating humidity 5 % to 90 % Supplied accessories Subwoofer (1) Satellite speakers (5) Speaker cords (5 m (17 ft) x 3, 15 m (50 ft) x 2) Optical digital cord (1) Remote commander (remote) RM-UP51 (1) R6 (size AA) batteries (2) Foot pads (20) Design and specifications are subject to change without notice.
5.1ch DIGITAL AUDIO SYSTEM

9-873-178-01

2001E1600-1 2001.5

Sony Corporation

Home Audio Company Shinagawa Tec Service Manual Production Group

SA-PSD5/WPSD5/SS-SPSD5

TABLE OF CONTENTS SAFETY CHECK-OUT 2 1. 2. GENERAL 3

SAFETY CHECK-OUT

After correcting the original service problem, perform the following safety checks before releasing the set to the customer: Check the antenna terminals, metal trim, metallized knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below.
DIAGRAMS 4 2-1. Circuit Boards Location 4 2-2. Block Diagrams 5 2-3. Printed Wiring Board Digital Section (Side A) 6 2-4. Printed Wiring Board Digital Section (Side B) 7 2-5. Schematic Diagram Digital Section (1/2) 8 2-6. Schematic Diagram Digital Section (2/2) 9 2-7. Schematic Diagram LCD Section 10 2-8. Printed Wiring Board LCD Section 11 2-9. Schematic Diagram Key Section 12 2-10. Printed Wiring Board Key Section 13 2-11. Schematic Diagram IN/OUT Section 14 2-12. Printed Wiring Board IN/OUT Section 15 2-13. Schematic Diagram Pre Amp Section 16 2-14. Printed Wiring Board Pre Amp Section 17 2-15. Schematic Diagram Power Section (1/2) 18 2-16. Schematic Diagram Power Section (2/2) 19 2-17. Printed Wiring Board Power Section 20 2-18. IC Block Diagrams 21 2-19. IC Pin Function Description 23 EXPRODED VIEWS 25 3-1. SA-WPSD5 (FRONT SECTION) 25 3-2. SA-WPSD5 (AMP SECTION) 26 3-3. SS-SPSDELECTRICAL PARTS LIST 28

LEAKAGE

The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers instructions to use these instruments. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The limit indication is 0.75 V, so analog meters must have an accurate low-voltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2V AC range are suitable. (See Fig. A)
To Exposed Metal Parts on Set

0.15 F

AC Voltmeter (0.75 V)
Earth Ground Fig. A. Using an AC voltmeter to check AC leakage.
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK 0 OR DOTTED LINE WITH MARK 0 ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT LA SCURIT! LES COMPOSANTS IDENTIFS PAR UNE MARQUE 0 SUR LES DIAGRAMMES SCHMATIQUES ET LA LISTE DES PICES SONT CRITIQUES POUR LA SCURIT DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PISES SONY DONT LES NUMROS SONT DONNS DANS CE MANUEL OU DANS LES SUPPMENTS PUBLIS PAR SONY.
Flexible Circuit Board Repairing Keep the temperature of soldering iron around 270C during repairing. Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). Be careful not to apply force on the conductor when soldering or unsoldering.
Notes on chip component replacement Never reuse a disconnected chip component. Notice that the minus side of a tantalum capacitor may be damaged by heat.
Index to Parts and Controls

Remote

Refer to the pages indicated in parentheses for details.

Subwoofer

qs 1 qd qf
TV CH SOUND FUNCTION FIELD SHIFT TV DVD2 DVD1

Top panel/Front panel

8./>PREV/NEXT buttons (13) Press to go to the next chapter or track, or to go back to the previous chapter or track. 9 TITLE button (13) Displays the title menu on the TV screen. 0 </M/m/,/ENTER button Selects and executes the items or settings.

1 SOUND FIELD button (11) Selects the sound field. 4
TV/VIDEO LEVEL SPEAKER SET UP

qg qh qj qk ql w; wa

2 FUNCTION button (9) Selects the input signal. 5
CENTER REAR WOOFER VOLUME
3 ?/1 (POWER) switch and indicator (9) Turns on and off the power of the system. 6

PLAY PAUSE STOP MUTING

TEST TONE
TITLE DVD MENU PREV NEXT SCAN
4 Display window (7, 9, 11, 14) Indicates the speaker setting, input signal, sound field mode, etc.
qa DISPLAY button (14) Displays the setup display of the PlayStation 2 or DVD player. qs DVD 1/DVD 2 button (13) Turns on and off the power of the DVD player. qd ?/1 (POWER) switch (7, 9) Turns on and off the system.

DISPLAY RETURN

5 MASTER VOL (volume) +/ buttons (9) Adjust the volume.

DVD CONTROL

6 MUTING button (9) Mutes the sound. ws
remote sensor (4) Accepts the remote control signals.
qf FUNCTION button (9) Selects the input signal.
Rear panel 1 TV button (15) Turns the TV on and off. 2 SHIFT button (7, 10, 14, 15) Switches the function of the buttons on the remote.
qg SOUND FIELD (SPEAKER SETUP) button (7, 11, 14) Selects the sound field mode. Pressing this button while pressing SHIFT will select the speaker setup parameters. qh WOOFER +/ buttons (10) Adjust the subwoofer volume.
8 SPEAKER jacks (5) Connect to the supplied satellite speakers.

SECTION 1 GENERAL

9 AUDIO IN 1/2 jacks (6) Connect to the audio output of a TV, VCR, PSone, etc.

SPEAKER

FRONT R

CENTER

FRONT L

BASS CONTROL

LEVEL MID

FREQUENCY

ONLY FOR SS-SPSD5

REAR R

REAR L
0 DIGITAL IN OPTICAL 1/2 jacks (5, 6) Connect to the DIGITAL OUT (OPTICAL) jack of the PlayStation 2, DVD player, etc.
3 TV CH +/ (TV/VIDEO) buttons (15) Changes the TV channel. To change the TV input, press while pressing SHIFT. 4 REAR +/ buttons (10) Adjust the rear speakers volume. 5 CENTER +/ buttons (10) Adjust the center speaker volume. 6 XPAUSE button (13) Pauses playing a disc. 7 NPLAY button (13) Plays a disc.
qj VOLUME +/ buttons (7, 9, 14) Make the speaker settings or adjust the volume of the system. Pressing this button while pressing SHIFT will set the speaker setup parameters.

OPTICAL

AUDIO IN

DIGITAL IN

qa BASS CONTROL knobs (10) Make fine adjustment of the bass sound.

qk xSTOP button (13) Stops playing a disc. ql MUTING (TEST TONE) button (9, 10) Mutes the sound. Pressing this button while pressing SHIFT will sound the test tone. w; m/M (SCAN) buttons (13) Locate a point while monitoring the picture. wa DVD MENU button (13) Displays the DVD menu on the TV screen. ws RETURN button (14) Returns to the previously selected screen.
This section is extracted from instruction manual.
SA-PSD5/WPSD5/SS-SPSD5 SECTION 2 DIAGRAMS
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.)
Note on Schematic Diagram: All capacitors are in F unless otherwise noted. p: pF. 50 WV or less are not indicated except for electrolytics and tantalums. All resistors are in and 1/4 W or less unless otherwise specified. f : internal component. C : panel designation. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Note: Les composants identifis par une marque 0 sont critiques pour la scurit. Ne les remplacer que par une pice por tant le numro spcifi. Note on Printed Wiring Board: X : parts extracted from the component side. Y : parts extracted from the conductor side. x : parts mounted on the conductor side. a : Through hole. : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) Indication of transistor
C Q B E These are omitted
A : B+ Line. B : B Line. Voltages and waveforms are dc with respect to ground under no-signal (detuned) conditions. Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. Circled numbers refer to waveforms. Signal path. F : AUDIO (ANALOG) J : AUDIO (DIGITAL) Abbreviation CND : Canadian model. SP : Singapore model.

BC E These are omitted

Caution: Pattern face side: (SIDE A) Parts face side: (SIDE B)
Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.
2-1. Circuit Boards Location
LCD board KEY-R board KEY-L board

WAVEFORMS

1 IC815 wz

POWER board ADJ board

81.4 ns

2 IC815 w; XMCK

6.5 Vp-p 6.1 Vp-p

SIRCS board

3 IC815 qg LRCK

INH CE CL DI
AC OFF DET IC702 SWITCH Q401-403 SWITCH Q431-433 EVER+5.6V
+28V +15V +15V REG IC904 SWITCH Q905
LCD DRIVE IC401 S1-48 1-48 COM0-3 55-52
D906 +10V CONT Q904,906 SWITCH Q396 REG Q901,D911
SWITCHING IC901 D902 D904
RCH is omitted Signal Path : DIGITAL INPUT : ANALOG INPUT
LCD LCD401 BACK LIGHT D401-403 POWER D431

KEY INPUT S431-434

KEY INPUT S451-453
REMOTE CONTROL RECEIVER IC471
-15V -28V A+9V A+5V D+5V D+3.3V

-15V REG IC903

SWITCH Q902

D908 ISOLATION PC901

M M901 FAN MOTOR

+5V REG IC816

SWITCH IC906

OVER CURRENT DET IC902

+3.3V REG IC818
SWITCH IC907 OVER CURRENT DET IC910

ISOLATION PC902

EVER+5.6V

+5.6V REG IC905,D909

2-3. PRINTED WIRING BOARD DIGITAL SECTION (SIDE A)
See page 4 for Circut Borads Lacation.

(Page 17)

(Page 15)

IC 818

IC 701

IC 802

(Page 11)

IC 803

Semiconductor Location
Ref. No. D701 D702 D703 D704 D705 D706 D707 D801 D802 D803 D804 D805 D881 D882 : SIDE B Location B-6 A-6 B-6 B-1 A-6 A-6 B-6 B-5 C-3 C-3 B-3 B-3 B-1 B-1 Ref. No. IC604 IC605 IC606 IC701 IC702 IC801 IC802 IC803 IC812 IC813 IC814 IC815 IC816 IC818 Location B-2 A-1 B-2 C-1 A-6 C-4 C-3 C-5 A-2 B-3 B-3 B-5 B-3 B-3 Ref. No. Q601 Q602 Q603 Q604 Q605 Q606 Q701 Q702 Q801 Q802 Q803 Location B-2 B-2 B-2 B-3 B-1 B-1 A-6 C-5 A-3 A-3 B-4
2-4. PRINTED WIRING BOARD DIGITAL SECTION (SIDE B)

IC 605

IC 812 IC 606

IC 702

IC 816 IC 813 IC 604 IC 814

IC 815

IC 801
2-5. SCHEMATIC DIAGRAM DIGITAL SECTION (1/2)
See page 4 for Waveforms. See page 23 for IC Pin Function.

(Page 16)

(Page 10)

(Page 14)

2-6. SCHEMATIC DIAGRAM DIGITAL SECTION (2/2)

See page 4 for Waveforms. See page 21, 22 for IC Block Diagrams.

IC B/D

2-7. SCHEMATIC DIAGRAM LCD SECTION

(Page 12)

(Page 8)
2-8. PRINTED WIRING BOARD LCD SECTION

(Page 13)

(Page 6)
Ref. No. D401 D402 D403 IC401 Q401 Q402 Q403 Location B-4 B-3 B-2 A-4 B-4 B-3 B-2
2-9. SCHEMATIC DIAGRAM KEY SECTION
2-10. PRINTED WIRING BOARD KEY SECTION
2-11. SCHEMATIC DIAGRAM IN/OUT SECTION

(Page 18)

2-12. PRINTED WIRING BOARD IN/OUT SECTION
2-13. SCHEMATIC DIAGRAM PRE AMP SECTION

(Page 19)

2-14. PRINTED WIRING BOARD PRE AMP SECTION

(Page 20)

Ref. No. D1001 D1002 D1101 D1102 D1201 D1202 D1301 D1302 D1401 D1501 D1502 IC1001 IC1002 IC1201 IC1202 IC1401 Location A-1 A-1 A-1 A-1 A-2 A-2 A-2 A-2 A-3 B-2 B-2 B-1 A-1 B-2 A-2 B-3

IC 1002 IC 1202

IC 1001 IC 1201

IC 1401

2-15. SCHEMATIC DIAGRAM POWER SECTION (1/2)
2-16. SCHEMATIC DIAGRAM POWER SECTION (2/2)
2-17. PRINTED WIRING BOARD POWER SECTION

IC 904

Ref. No. D101 D102 D103 D104 D105 D106 D111 D112 D201 D202 D203 D204 D205 D206 D211 D212 D301 D302 D303 D304 D305 D306 D311 D312 D392 Location D-8 D-9 D-9 E-9 B-9 B-9 D-9 D-9 D-6 D-7 D-7 E-7 B-8 B-7 D-7 D-7 D-4 D-4 D-5 E-6 B-6 B-5 D-5 D-5 A-9 Ref. No. D393 D394 D395 D901 D902 D903 D904 D906 D907 D908 D909 D910 D911 D913 D916 D917 D923 D925 IC101 IC102 IC201 IC202 IC302 IC901 Location A-9 A-9 F-4 H-2 F-2 F-2 F-2 D-1 C-3 C-2 A-1 F-2 E-2 A-3 B-3 A-3 E-3 F-2 D-8 C-9 C-6 C-7 C-5 F-2 Ref. No. IC902 IC903 IC904 IC905 IC906 IC907 IC910 Q101 Q201 Q301 Q391 Q392 Q393 Q394 Q395 Q396 Q901 Q904 Q905 Q906 Q912 Q913 Location B-1 A-4 A-4 A-2 A-3 A-5 B-1 B-9 B-7 B-5 A-9 B-9 B-9 B-9 A-9 A-9 F-2 A-3 B-4 B-3 B-2 B-2

IC BLOCK DIAGRAMS

IC604 TC9482F (EL) (DIGITAL BOARD)

VSS NC

28 VDD 27 TEST

L-OUTA

dB VR LATCH 8 dB VR LATCH

26 R-OUTA

25 R-INA

L-A-GNDA

24 R-A-GNDA

L-OUTB

23 R-OUTB 1 dB VR LATCH 8 dB VR LATCH 3 TO 7 DECODER SAME AS L-CH CIRCUIT 22 R-INB

L-A-GNDB

4 TO 13 DECODER

21 R-A-GNDB

L-OUTC

20 R-OUTC

L-INC 10

19 R-INC

L-A-GNDC 11
18 R-A-GNDC STROBE GENERATE CIRCUIT 17 CS2
SHIFT REGISTER (32 BIT) CSLEVEL SHIFT CIRCUIT

GND CK

16 STB

15 DATA

IC803 AK4527 (DIGITAL BOARD)
LOOP1 LOOP0/SDA/CDTI DIF1/SCL/CCLK DIF0/CSN P/SN MCLK DZF1 AVSS AVDD VREFH VCOM
DZF2 RIN+ RIN LIN+ LIN ROUT1 LOUT1 ROUT2 LOUT2 ROUT3 LOUT3 SDOS I2C SMUTE BICK LRCK SDTI1 SDTI2 SDTI8 INPUT CIRCUIT AUDIO INTERFACE OUTPUT CIRCUIT SDTO 9 DAUX 10 DFS 11 FORMAT CONVERTER 22
IC815 LC89055W (DIGITAL BOARD)
VF/P3/C3 F2/P2/C2 F1/P1/C1 F0/P0/C0 CSFLAG DI DO ERROR BPSYNC AUTO DGND
DEM1 DEM0 TVDD DVDD DVSS PDN ICKS2 ICKS1 ICKS0 CAD1 CAD0
CE 37 CL 38 XSEL 39 MODEMODEDGND 42 DVDD 43 MICROCOMPUTER INTERFACE SAMPLING FREQUENCY

C BIT DETECT

PA/PB DETECT

24 AUDIO 23 EMPHA

LOCK DETECT
DOSELDOSELCKSELCKSELXMODE 48

DATA DEMODULATOR

TIMING
XIN XOUT XMCK DVDD DGND XSTATE DATAO LRCK BCK CKOUT

INPUT CIRCUIT

DOUT DINO

DGND DVDD

R VIN LPF

AVDD AGND

Pin No. 19, 22 23, 28 29, 46 47-59
IC PIN FUNCTION DESCRIPTION
Pin Name RXD 300kHz YSSCSB YSSCS YSSSI YSSSO YSSSCK GND CNVSS YSSIC AN/DIG RESET XOUT VSS XIN VCC NMI STOP ASEL1,ASEL2 AU-MUTE V-MUTE VSEL1,VSEL2 D1/P1 D2/P2 P3 P4 TXD1 RXD1 CLK1 RTS1 FLDATA FLINH FLCLK FLCS STBY REAR-SW HOLD SIRCS F-RLY POWRY SLEEP WR FAULT PROTECT-SW VOL-CE VOL-DAT VOL-CLK SWMUTE I/O O O O O O I O O O I O I I I O O O O O O O O O I O I I O O O O O O O I O O O I I I I I O (Not used) 300kHz Pulse to POWER OFF Chip select to CXD9511AQ sub DSP Chip select to CXD9511AQ main DSP Data to CXD9511AQ main/sub DSP Data from CXD9511AQ main DSP Clock to CXD9511AQ main/sub DSP GND GND Initial clear to CXD9511AQ ANALOG/DIGITAL Reset input 16MHz Xtal GND 16MHz Xtal +5V Non-maskable interrupt input (pull up) AC cut detect input Analog audio input select signal output Audio mute output (Not used) Video mute output (Not used) Video input selector (Not used) Dimmer output (Not used) (Not used) (Not used) (Not used) Serial data input for internal FLASH ROM (Not used) Serial data output for internal FLASH ROM (Not used) Clock input for internal FLASH ROM (Not used) RTS input for internal FLASH ROM (Not used) Data to LC75824 LCD driver Reset to LC75824 LCD driver Clock to LC75824 LCD driver Chip select to LC75824 LCD driver Standby LED output Rear sw output (Not used) Hold input for internal FLASH ROM (Not used) Remote control signal input Relay drive output Power sw output Sleep signal output Write enable input for internal FLASH ROM (Not used) (Not used) Fault signal input Protect input (Not used) Chip select to TC9482 EVR Data to TC9482 EVR Clock to TC9482 EVR (Not used) Description

IC701 M30622MA-858FP (SYSTEM CONTROL) (1/2)
IC701 M30622MA-858FP (SYSTEM CONTROL) (2/2)
Pin No. 76, 79-VREF AVCC TXD Pin Name CS-MUTE LR-MUTE VCC AMP-MUTE VSS HP-MUTE HP-SW SMUTE PD CDT1 SLK CS /DSR RDS2 DVDPOW MODEL4MODEL2 MODEL1 DIRCLK DIRCDE DIRDI DIRDO DIRERR ZERO +3.3V +5V KEY2,KEY1 ENB,ENA AVSS I/O O O O O O O O O O O I O O O O O I I I I I O (Not used) Line mute signal output +5v Power amp mute output GND Head phone mute output (Not used) Head phone sw output (Not used) Soft mute to AK4527 Reset to AK4527 Data to AK4527 Clock to AK4527 Chip select to AK4527 (Not used) (Not used) (Not used) Xstatus from LC89055W (Not used) (Not used) Destination Reset to LC89055W Clock to LC89055W Latch to LC89055W Data to LC89055W Data from LC89055W Error from LC89055W Zero data from LC89055W (Not used) +3.3V +5V Key input Rotary encoder input (Not used) GND (Not used) +5V +5V (Not used) Description
SA-PSD5/WPSD5/SS-SPSD5 SECTION 3 EXPLODED VIEWS
NOTE: -XX, -X mean standardized parts, so they may have some differences from the original one. Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. The mechanical parts with no reference number in the exploded views are not supplied. Hardware (# mark) list and accessories and packing materials are given in the last of this parts list. Abbreviation CND : Canadian model. SP : Singapore model.
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifis par une marque 0 sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi.
3-1. SA-WPSD5 (FRONT SECTION) 8

SP901 #2

#1 not supplied

not supplied

#3 not supplied

Ref. No. 8

Part No. A-2004-970-A A-4412-943-A 4-981-864-01 1-681-618-11 1-681-617-11 4-233-807-01 X-4953-699-1 4-233-808-01 1-681-616-11
Description CABINET ASSY, SPEAKER (AEP,UK,SP) CABINET ASSY, SPEAKER (US,CND) FOOT SIRCS BOARD KEY-R BOARD BUTTON (R) PANEL ASSY, FRONT BUTTON (L) KEY-L BOARD

Remarks 1/10W 1/16W

1-165-319-11 CERAMIC CHIP 1-126-965-11 ELECT < CONNECTOR >
1-779-281-11 CONNECTOR,FFC (LIF (NON-ZIF)) 13P < FERRITE BEAD >
FB601 FB611 FB621 FB631 FB651 FB652
1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00 1-216-295-00
SHORT SHORT SHORT SHORT SHORT
1-216-295-00 SHORT < IC >

IC601 IC602

8-749-923-05 TORX178B (DIGITAL IN) 8-749-923-05 TORX178B (DIGITAL IN) < JACK >
1-784-429-11 JACK, PIN 4P (AUDIO) < COIL >
1-414-754-11 INDUCTOR < RESISTOR >

R601 R602 R611 R612 R621

1-216-069-00 1-216-089-00 1-216-069-00 1-216-089-00 1-216-069-00
METAL CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP

6.8K 47K 6.8K 47K 6.8K

5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W
R622 1-216-089-00 RES-CHIP 47K 5% 1/10W R631 1-216-069-00 METAL CHIP 6.8K 5% 1/10W R632 1-216-089-00 RES-CHIP 47K 5% 1/10W R651 1-216-025-11 RES-CHIP 100 5% 1/10W R652 1-216-025-11 RES-CHIP 100 5% 1/10W ************************************************************
SA-PSD5/WPSD5/SS-SPSD5 KEY-L

Ref. No.

Remarks Ref. No. Part No. Description < IC > IC401 8-759-366-34 IC LC75824E < LIQUID CRYSTAL DISPLAY > Remarks

Part No.

1-681-616-11 KEY-L BOARD *********** < DIODE > D431 8-719-079-48 DIODE SMLS72423CTP15
LCD401 1-804-472-11 DISPLAY PANEL, LIQUID CRYSTAL < TRANSISTOR > < TRANSISTOR > Q431 Q432 Q433 8-729-421-22 TRANSISTOR 8-729-424-08 TRANSISTOR 8-729-424-18 TRANSISTOR < RESISTOR > < RESISTOR > R431 R432 R433 R434 1-216-029-00 1-216-049-11 1-216-049-11 1-216-053-00 METAL CHIP RES-CHIP RES-CHIP METAL CHIP < SWITCH > S431 1-762-875-21 SWITCH, KEYBOARD (POWER) S432 1-762-875-21 SWITCH, KEYBOARD (FUNCTION) S434 1-762-875-21 SWITCH, KEYBOARD (SOUNDFIELD) ************************************************************ 1-681-617-11 KEY-R BOARD *********** < RESISTOR > R451 R452 1-216-049-11 RES-CHIP 1-216-053-00 METAL CHIP < SWITCH > S451 1-762-875-21 SWITCH, KEYBOARD (-) S452 1-762-875-21 SWITCH, KEYBOARD (+) S453 1-762-875-21 SWITCH, KEYBOARD (MUTING) ************************************************************ A-4725-858-A LCD BOARD, COMPLETE (US,CND) ******************** A-4725-876-A LCD BOARD, COMPLETE (AEP,UK,SP) ******************** 4-226-339-01 HOLDER (LCD) 4-227-174-01 SHEET, DIFFUSION < CAPACITOR > C401 C404 C405 C406 1-165-319-11 1-165-319-11 1-126-157-11 1-163-251-11 CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP < CONNECTOR > CN401 * CN402 * CN403 1-779-549-21 CONNECTOR,FFC (LIF (NON-ZIF)) 12P 1-568-942-11 PIN, CONNECTOR 4P 1-568-942-11 PIN, CONNECTOR 4P < DIODE > D401 D402 D403 8-719-076-07 DIODE SELU2E10CTP6 (LED) 8-719-076-07 DIODE SELU2E10CTP6 (LED) 8-719-076-07 DIODE SELU2E10CTP6 (LED) CN671 CN672 0.1uF 0.1uF 10uF 100PF 50V 50V 16V 50V C471 C472 1K 1.5K 5% 5% 1/10W 1/10W 150 1K 1K 1.5K 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W R401 R402 R403 R404 R405 R406 R407 R408 R409 R410 1-216-073-00 1-216-023-00 1-216-073-00 1-216-073-00 1-216-023-00 1-216-073-00 1-216-073-00 1-216-023-00 1-216-073-00 1-216-049-11 RES-CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP 10K 82 10K 10K 82 10K 10K 82 10K 1K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W UN2211-TX UN2111-TX UN2113-TX Q401 Q402 Q403 8-729-024-91 TRANSISTOR 8-729-024-91 TRANSISTOR 8-729-024-91 TRANSISTOR 2SC2712-GL-TE85L 2SC2712-GL-TE85L 2SC2712-GL-TE85L

R411 1-216-089-00 RES-CHIP 47K 5% 1/10W R412 1-216-107-00 METAL CHIP 270K 5% 1/10W ************************************************************ 1-681-618-11 SIRCS BOARD *********** < CAPACITOR > 1-165-319-11 CERAMIC CHIP 1-126-157-11 ELECT < CONNECTOR > * CN471 1-568-941-11 PIN, CONNECTOR 3P < IC > IC471 8-759-827-69 IC NJL63H400A-1 ************************************************************ 1-681-620-11 SP BOARD ******** < CAPACITOR > C671 C672 C673 C674 C677 C678 C679 C680 C681 C682 1-163-141-00 1-165-319-11 1-163-141-00 1-165-319-11 1-163-141-00 1-165-319-11 1-163-141-00 1-165-319-11 1-163-141-00 1-165-319-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP < CONNECTOR > 1-785-102-11 PIN, CONNECTOR 4P 1-785-104-11 PIN, CONNECTOR 6P 0.001uF 0.1uF 0.001uF 0.1uF 0.001uF 0.1uF 0.001uF 0.1uF 0.001uF 0.1uF 5% 5% 5% 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 0.1uF 10uF 50V 16V

20% 5%

SA-PSD5/WPSD5/SS-SPSD5 SP
Ref. No. Part No. Description < JACK > J671 1-694-656-11 TERMINAL BOARD (6CH SPEAKER))(SPEAKER) ************************************************************ A-4725-856-A POWER BOARD, COMPLETE (US,CND) *********************** A-4725-875-A POWER BOARD, COMPLETE (AEP,UK,SP) *********************** 1-533-293-11 FUSE HOLDER 3-309-144-21 HEAT SINK 7-685-647-79 SCREW +BVTP < CAPACITOR > C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C112 C113 C114 C115 C116 C117 C118 C119 C120 C121 C122 C123 C124 C125 C126 C127 C128 C129 C130 C131 C132 C133 C134 C135 C201 C202 C203 C204 C205 C206 C207 C208 C209 C210 1-165-319-11 1-126-951-11 1-126-951-11 1-165-319-11 1-165-319-11 1-126-967-11 1-165-319-11 1-126-967-11 1-165-319-11 1-126-967-11 1-136-169-00 1-136-169-00 1-136-169-00 1-136-169-00 1-165-319-11 1-165-319-11 1-163-251-11 1-163-251-11 1-107-826-11 1-165-319-11 1-163-251-11 1-163-251-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-163-245-11 1-163-249-11 1-165-554-91 1-165-554-91 1-107-826-11 1-165-319-11 1-126-951-11 1-126-951-11 1-165-319-11 1-165-319-11 1-126-967-11 1-165-319-11 1-126-967-11 1-165-319-11 1-126-967-11 CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT FILM FILM FILM FILM CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT 0.1uF 470uF 470uF 0.1uF 0.1uF 47uF 0.1uF 47uF 0.1uF 47uF 0.22uF 0.22uF 0.22uF 0.22uF 0.1uF 0.1uF 100PF 100PF 0.1uF 0.1uF 100PF 100PF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 56PF 82PF 0.1uF 0.1uF 0.1uF 0.1uF 470uF 470uF 0.1uF 0.1uF 47uF 0.1uF 47uF 0.1uF 47uF 50V 35V 35V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 16V 50V 50V 50V 25V 25V 25V 25V 25V 25V 25V 25V 50V 50V 100V 100V 16V 50V 35V 35V 50V 50V 50V 50V 50V 50V 50V Remarks Ref. No. C211 C212 C213 C214 C215 C216 C217 C218 C219 C220 C221 C222 C223 C224 C225 C226 C227 C228 C229 C230 C231 C232 C233 C234 C235 C301 C302 C303 C304 C305 C306 C307 C308 C309 C310 C311 C312 C313 C314 C315 C316 C317 C318 C319 C320 C321 C322 C323 C324 C325 C326 C327 C328 C329 C330 C331 C332 C333 C334 C335 Part No. 1-136-169-00 1-136-169-00 1-136-169-00 1-136-169-00 1-165-319-11 1-165-319-11 1-163-251-11 1-163-251-11 1-107-826-11 1-165-319-11 1-163-251-11 1-163-251-11 1-115-340-11 1-126-965-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-163-255-11 1-163-257-11 1-165-554-91 1-165-554-91 1-107-826-11 1-165-319-11 1-126-951-11 1-126-951-11 1-165-319-11 1-165-319-11 1-126-967-11 1-165-319-11 1-126-948-11 1-165-319-11 1-126-967-11 1-136-169-00 1-136-169-00 1-136-169-00 1-136-169-00 1-165-319-11 1-165-319-11 1-163-251-11 1-163-251-11 1-107-826-11 1-165-319-11 1-163-251-11 1-163-251-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-115-340-11 1-163-127-00 1-163-263-11 1-165-554-91 1-165-554-91 1-107-826-11 Description FILM FILM FILM FILM CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT FILM FILM FILM FILM CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 0.22uF 0.22uF 0.22uF 0.22uF 0.1uF 0.1uF 100PF 100PF 0.1uF 0.1uF 100PF 100PF 0.22uF 22uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 150PF 180PF 0.1uF 0.1uF 0.1uF 0.1uF 470uF 470uF 0.1uF 0.1uF 47uF 0.1uF 100uF 0.1uF 47uF 0.22uF 0.22uF 0.22uF 0.22uF 0.1uF 0.1uF 100PF 100PF 0.1uF 0.1uF 100PF 100PF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 0.22uF 270PF 330PF 0.1uF 0.1uF 0.1uF 5% 5% 5% 5%

PRE AMP

Remarks 6.3V 16V 25V 1/16W 50V 6.3V 16V 25V 1/16W 50V 6.3V 16V 25V 1/16W 50V 35V 50V 35V 50V
1-216-055-00 METAL CHIP 1-216-296-11 SHORT < RELAY >

RY101 RY201 RY301

1-755-440-11 RELAY 1-755-440-11 RELAY 1-755-440-11 RELAY < TRANSFORMER >

0 TT901

1-437-306-11 TRANSFORMER, HIGH-FREQUENCY (AEP,UK,SP) 1-437-305-11 TRANSFORMER, HIGH-FREQUENCY (US,CND) < THERMISTOR >
8-719-988-61 DIODE 1SS355TE-17 8-719-988-61 DIODE 1SS355TE-17 < IC >
0 TH901 1-803-916-11 THERMISTOR, NTC ************************************************************ A-4726-870-A PRE AMP BOARD, COMPLETE ************************ < CAPACITOR > C1001 C1002 C1003 C1004 C1005 C1101 C1102 C1103 C1104 C1105 1-117-863-11 1-164-677-11 1-115-340-11 1-216-864-11 1-163-243-11 1-117-863-11 1-164-677-11 1-115-340-11 1-216-864-11 1-163-243-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP METAL CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP METAL CHIP CERAMIC CHIP 0.47uF 0.033uF 0.22uF 0 47PF 0.47uF 0.033uF 0.22uF 0 47PF 10% 10% 10% 5% 5% 10% 10% 10% 5% 5% 6.3V 16V 25V 1/16W 50V 6.3V 16V 25V 1/16W 50V
IC1001 IC1002 IC1201 IC1202 IC1401
8-759-106-02 8-759-106-02 8-759-106-02 8-759-106-02 8-759-106-02

IC IC IC IC IC

uPC4570G2-E1 uPC4570G2-E1 uPC4570G2-E1 uPC4570G2-E1 uPC4570G2-E1
< RESISTOR > R1001 R1002 R1003 R1004 R1005 R1101 R1102 R1103 R1104 R1105 1-216-826-11 1-216-842-11 1-216-833-11 1-216-077-00 1-216-003-11 1-216-826-11 1-216-842-11 1-216-833-11 1-216-077-00 1-216-003-11 METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP 2.7K 56K 10K 15K 12 2.7K 56K 10K 15K 12 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/16W 1/16W 1/16W 1/10W 1/10W 1/16W 1/16W 1/16W 1/10W 1/10W
SA-PSD5/WPSD5/SS-SPSD5 PRE AMP
Ref. No. R1201 R1202 R1203 R1204 R1205 R1301 R1302 R1303 R1304 R1305 R1405 R1501 R1502 R1503 R1504 Part No. 1-216-826-11 1-216-842-11 1-216-833-11 1-216-077-00 1-216-003-11 1-216-826-11 1-216-842-11 1-216-833-11 1-216-077-00 1-216-003-11 1-216-801-11 1-216-826-11 1-216-842-11 1-216-833-11 1-216-077-00 Description METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP 2.7K 56K 10K 15K 12 2.7K 56K 10K 15K 2.7K 56K 10K 15K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remarks 1/16W 1/16W 1/16W 1/10W 1/10W 0 1/16W 1/16W 1/16W 1/10W 1/10W 1/16W 1/16W 1/16W 1/16W 1/10W Ref. No. Part No. Description Remarks ACCESSORIES & PACKING MATERIALS ******************************** 1-476-703-11 1-757-988-11 1-770-019-11 1-823-141-11 1-823-141-21 1-823-141-31 1-823-141-41 1-823-141-51 4-235-290-11 REMOTE COMMANDER (RM-UP51) CORD, LIGHT PLUG ADAPTOR, CONVERSION PLUG 3P (UK) CORD (WITH CONNECTOR) CORD (WITH CONNECTOR) (WHITE) CORD (WITH CONNECTOR) (GREEN) CORD (WITH CONNECTOR) (GRAY) CORD (WITH CONNECTOR) (BLUE) MANUAL, INSTRUCTION (ENGLISH,FRENCH) (US,CND)

R1505 1-216-003-11 RES-CHIP 12 5% 1/10W R1804 1-469-525-91 INDUCTOR 10uH R1904 1-469-525-91 INDUCTOR 10uH ************************************************************ MISCELLANEOUS ************** 157 SP901 SP902 * M901 1-575-651-11 1-783-532-11 1-757-125-11 A-4726-870-A 1-783-113-11 1-757-996-11 1-694-836-11 1-544-842-11 1-544-841-11 1-763-728-11 CORD, POWER (AEP,UK,SP) CORD, POWER (US,CND) WIRE (FLAT TYPE) (25 CORE) PRE AMP BOARD, COMPLETE WIRE (FLAT TYPE) (25 CORE) WIRE (FLAT TYPE) (13 CORE) TERMINAL, SPEAKER SPEAKER (20cm) SPEAKER (8cm) FAN, DC (60 SQUARE)
4-235-290-21 MANUAL, INSTRUCTION (ENGLISH,FRENCH, GERMAN,SPANISH,ITALIAN,DUTCH,SWEDISH, POLISH) (AEP,UK) 4-235-290-31 MANUAL, INSTRUCTION (DANISH,FINNISH, PORTUGUESE,RUSSIAN) (SP) 4-972-322-01 FOOT (Y) 4-236-795-01 COVER, BATTERY (FOR RM-UP51)

REVISION HISTORY

Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. 1.0 Date 2001.05 New Description of Revision

SA-W2500

Key Features 100 Watt Amplified Subwoofer (6 ohms, 80 Hz, 10% THD) 10 Mica Reinforced Cellular Woofer Motion Feed Back Technology Speaker and Line Level Inputs Frequency Response 28-200Hz
Performance Line Subwoofer
Key Technologies 100 Watt Amplified Subwoofer (6 ohms, 80 Hz, 10% THD) 10" Mica Reinforced Cellular Woofer Motion Feed Back Technology Speaker and Line Level Inputs Frequency Response 28-200Hz

Features

Bass Driver(s): Yes (Advanced Bass Reflex Design; 8" Long-Throw Driver) Level Control: Yes

Specifications

Inputs and Outputs
Line Level Input(s): 1 (Rear) Speaker Level Input(s): 1 (Rear)
Power Requirements: 120V AC, 60Hz (Subwoofer) Power Consumption (in Operation): 70W (Subwoofer) Power Consumption (in Standby): less then.3W (Subwoofer)

Speaker

Frequency Response: Subwoofer- 28Hz200Hz Quantity (Packaged): 1 Subwoofer Speaker Terminal Type: Line In Woofer Size(s): Subwoofer- 9 13/16" (25cm) Quantity of Woofer(s): Subwoofer-1 Type: Video Shielded Woofer(s): Power Handling: 100W (6 ohms, 80 Hz, 10% THD)
Service and Warranty Information
Limited Warranty Term: 1 Year Parts / 1 Year Labor

Weights and Measurements

Weight (Approx.): 22 lb, 0 oz (10kg) Dimensions (Approx.): 11 7/16 x 13 3/4 x 16 3/8" (290 x 350 x 391mm) UPC Code: 027242706439
2007 Sony Electronics Inc. Reproduction in whole or in part without express written permission is prohibited. All rights reserved. Sony is a trademark of Sony. Features and specifications are subject to change without notice. Nonmetric weights and measures are approximate.
Please visit the Dealer Network for current information at www.sony.com/dn Sony Electronics Inc. 16530 Via Esprillo San Diego, CA 92127 1.800.222.7669 www.sony.com Last Updated: 06/18/2009