SAVA-500/SS-CN16/SR16

SERVICE MANUAL
US Model Canadian Model AEP Model UK Model E Model
(L-ch) Photo: SS-SR16 Photo: SS-CN16

(R-ch)

Photo: Main Unit
The SAVA-500 composed of the following table. Front Speaker Center Speaker Rear Speaker Main Unit SS-CN16 SS-SR16

SPECIFICATIONS

Continued on next page
HOME THEATER ACTIVE SPEAKER SYSTEM

MICROFILM

TABLE OF CONTENTS 1. 2. 3. 4. 5. SERVICING NOTES.. 3 GENERAL.. 4 DISASSEMBLY.. 5 TEST MODE.. 8 DIAGRAMS
5-1. Note for Printed Wiring Boards and Schematic Diagrams.. 5-2. Printed Wiring Board MAIN Board . 5-3. Schematic Diagram MAIN Board (1/3) . 5-4. Schematic Diagram MAIN Board (2/3) . 5-5. Schematic Diagram MAIN Board (3/3) . 5-6. Printed Wiring Boards FILTER/REG/T2/T1/ STANDBY/AC-SW Boards ... 5-7. Schematic Diagram FILTER/REG/T2/T1/ STANDBY/AC-SW Boards ... 5-8. Printed Wiring Board AMP (POW-SR/POW-SW/ POW-CN/POW-LR/CONNECTOR) Board .. 5-9. Schematic Diagram AMP (POW-SR/POW-SW/ POW-CN/POW-LR/CONNECTOR) Board .. 5-10. Printed Wiring Boards DISPLAY/LED/KEY Boards .. 5-11. Schematic Diagram DISPLAY/LED/KEY Boards .. 5-12. IC Pin Function Description..
EXPLODED VIEWS.. 26 ELECTRICAL PARTS LIST. 31
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT LA SCURIT! LES COMPOSANTS IDENTIFIS PAR UNE MARQUE ! SUR LES DIAGRAMMES SCHMATIQUES ET LA LISTE DES PICES SONT CRITIQUES POUR LA SCURIT DE FONCTIONNEMENT. NE REMPLACER CES COMPOSANTS QUE PAR DES PICES SONY DONT LES NUMROS SONT DONNS DANS CE MANUEL OU DANS LES SUPPLMENTS PUBLIS PAR SONY.
SECTION 1 SERVICING NOTES
MODEL IDENTIFICATION Rear view SAFETY CHECK-OUT After correcting the original service problem, perform the following safety check before releasing the set to the customer: Check the antenna terminals, metal trim, metallized knobs, screws, and all other exposed metal parts for AC leakage. Check leakage as described below. LEAKAGE TEST The AC leakage from any exposed metal part to earth ground and from all exposed metal parts to any exposed metal part having a return to chassis, must not exceed 0.5 mA (500 microamperes). Leakage current can be measured by any one of three methods. 1. A commercial leakage tester, such as the Simpson 229 or RCA WT-540A. Follow the manufacturers instructions to use these instruments. 2. A battery-operated AC milliammeter. The Data Precision 245 digital multimeter is suitable for this job. 3. Measuring the voltage drop across a resistor by means of a VOM or battery-operated AC voltmeter. The limit indication is 0.75 V, so analog meters must have an accurate lowvoltage scale. The Simpson 250 and Sanwa SH-63Trd are examples of a passive VOM that is suitable. Nearly all battery operated digital multimeters that have a 2 V AC range are suitable. (See Fig. A)

PART No.

To Exposed Metal Parts on Set

0.15 F

1.5 k

AC voltmeter (0.75 V)

MODEL US model Canadian model EXCEPT US, Canadian models
PART No. 4-217-252-3 4-217-252-4 4-217-252-5

Earth Ground

Fig. A. Using an AC voltmeter to check AC leakage.

SECTION 2 GENERAL

LOCATION OF CONTROLS Main Unit (L-ch) Front View INPUT button 2 SURROUND button 3 CENTER MODE button 4 S. WOOFER button 5 MASTER VOL +/ buttons 6 STANDBY, ON, READY indicators 7 U button

Rear View

1 TV IN jack 2 VIDEO IN jack AUX IN jack 4 5.1CH INPUT (FRONT, REAR, WOOFER, CENTER) jack 5 CONTROL S, TV IN jack (US, Canadian models) 6 WIRELESS REAR SPEAKER jack 7 CENTER SPEAKER terminal 8 REAR SPEAKERS terminal 9 R-ch SPEAKER OUTPUT connector

SECTION 3 DISASSEMBLY

Note: Follow the disassembly procedure in the numerical order given.

AMPLIFIER SECTION

2 grille frame (A) assy 3 screw (BVTT4 25) 4 washer (BF) 5 washer (S)

L-ch speaker section

7 flat wire (CN503)

8 connector (CN907)

6 screw (BVTT4 25) 1 grille frame (B) assy
! Remove the amplifier section in arrow B direction.

9 eleven screws (4 20)

! five screws (BVTP3 8) B A
! Remove the panel (L/B) in arrow A direction. ! connector

SERVICE POSITION

1 Remove the amplifier section. (Refer to page 5) 2 two screws (transistor)

5 heatsink and AMP board

9 cord bushing 7 bracket 3 two screws (BVTP3 8)

6 two screws (BVTP3 8)

! eleven screws (BVTP3 8)
! back panel (L/A) 8 connector (CN371) ! connector

6 screw (BVTP3 8)

4 two connectors (CN601, 603)
! two screws (BVTP3 8) A ! Erect the MAIN boad in arrow A direction. ! two screws (BVTP3 8)

! four screws (BVTP3 8)

! Attach the bracket to the heatsink with two screws.

bracket

heatsink

MAIN board

! Insert two connectors (CN601, 603) into the connectors (CN301, 911) on the MAIN board.
! Connect the fan motor lead wire to MAIN board connector (CN371).

chassis

! Insert an insulation sheet between chassis and MAIN board.
@ Connect the flat wire to DISPLAY board connector (CN503).
! Connect the power SW lead wire to STANDBY board connector (CN907).

@ Push the power SW.

@ Connect the MAIN board and chassis with two clip wires.

SECTION 4 TEST MODE

This set provides four test modes as follows. 1. INPUT CHECK MODE 2. KEY CHECK MODE 3. AMP CHECK MODE 4. DEMONSTRATION MODE The following describes each test mode in detail.

INPUT CHECK MODE

Procedure: 1. While pressing the both [S.WOOFER] and [MASTERVOL+] buttons, turn the power ON. 2. Fluorescent indicator tube display SAVA-500, after the all lights up, and enter the input check mode. 3. Pressing the [INPUT] button varies the display as follows. SAVA-500 ********* S.WOOFER AUX VIDEO TV AUTO POWER *1 S.WOOFER check mode (5.1CH INPUT check mode) AUX input (SURROUND OFF) check mode VIDEO input (SURROUND OFF) check mode TV input (SURROUND OFF) check mode AUTO POWER ON/OFF check mode

*1 Pressing the [SURROUND] button makes the S.WOOFER level minimum, or the [S.WOOFER] button makes the S.WOOFER level maximum, or [CENTERMODE] button returns default.
Note: In each mode, the volume is muted except for the channels that can be checked.
4. To release the test mode, push back [] button. U

KEY CHECK MODE

Procedure: U 1. Push back [] button to turn the power OFF. 2. Connect the lead wire to TP3 and TP4 on the KEY board. U 3. Push [] button to power ON. 4. Let the lead wire short TP3 and TP4. 5. Fluorescent indicator tube display KEY CHK 500, and enter the key check mode. 6. Pressing any buttons, the number of button will be displayed on the fluorescent indicator tube. 7. Pressing the first button turns on the [READY] LED (red), and the second button turns on the [ON] LED (green). Thus, two LEDs light up alternately each time the buttons are pressed.
Button INPUT SURROUND CENTER MODE WOOFER MASTER VOL MASTER VOL + Button Number 5 6
8. After all buttons are pressed, it will be in the STANDBY mode.
Note: If a check failed, the set does not go in STANDBY state, and you cannot exit from the test mode. In this case, quit the test mode by pushing back [] U button.

AMP CHECK MODE

Procedure: 1. Push back [] button to turn the power OFF. U 2. Connect the lead wire to TP1 and TP2 on the KEY board. U 3. Push [] button to power ON. 4. Let the lead wire connected TP1 and TP2. 5. Fluorescent indicator tube display AMP CHK 500, and enter the amp check mode. 6. The check step advances in order as TP1 and TP2 are shorted.
STEP AMP CHK 500 AMP CHK 1 AMP CHK 2 AMP CHK 3 AMP CHK 4 AMP CHK 5 AMP CHK 6 AMP CHK 7 AMP CHK 8 AMP CHK 9 AMP CHK 10 AMP CHK 11 AMP CHK 12 INPUT VIDEO VIDEO VIDEO VIDEO VIDEO VIDEO AUX AUX 5.1 5.1 5.1 5.1 TV VOL MIN MAX MAX MAX MAX MAX MIN MAX MAX MIN MAX MAX MAX SW MODE 1 OFF OFF OFF 1 SUR MODE PRO LOGIC OFF PRO LOGIC GAME OFF OFF PRO LOGIC PRO LOGIC PRO LOGIC BASS 5 +TREBLE 5 +5 0
*1 The step 12 is the AUTO POWER ON/OFF check. *2 The step 12 is automatically turned the power OFF in one second, ON when a signal is entered to TV input, and OFF when a signal input stops. *3 After the step 12 finished, return the parameters to default values, then turn the power OFF. U 7. To release the test mode, push back [] button. Checking Location KEY Board (Conductor Side)

TP3 TP2

TP1 TP4

DEMONSTRATION MODE

1. Entering the demonstration mode Press the [INPUT] and [MASTERVOL+] buttons simultaneously to start demonstration mode. When the set goes in demonstration mode, the [ON] LED (green) blinks, and the [STANDBY] and [READY] LEDs (red) light up. The sequence during the demonstration mode is following as bellow.
Note: 1. In the demonstration mode, only the [INPUT], [MASTERVOL], and [S.WOOFER] buttons are active. 2. The operation with remote commander is disabled.
Demonstration mode sequence:

@@@@@@@@@ @ HELLO @ *1

WELCOME TO SAVA SOUND SYSTEM I AM SAVA-500 MY FEATURES ARE 4 INPUTS AND 5 SURROUND MODE LISTEN TO MY SOUND 5.1 INPUT 5.1 CH IN PRO LOGIC C.STUDIO HALL STUDIUM GAME THANK YOU
OTHER INPUT *2 *2 *2 *2 *2 *2 *1 First seven characters are displayed, then eighth and subsequent characters are displayed. (Characters run on the display) *2 Displayed for 5 seconds.
Note: 1 The demonstration mode operates with the input, and volume position selected last. 2 The input and volume are variable even during demonstration mode.
2. Releasing the demonstration mode U To release the demonstration mode, push back [] button.

SECTION 5 DIAGRAMS

5-1. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS

Circuit Boards Location

FILTER board
Note on Printed Wiring Board: X : parts extracted from the component side. Y : parts extracted from the conductor side. p : parts mounted on the conductor side. b : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) Indication of transistor. Note on Schematic Diagram: All capacitors are in F unless otherwise noted. pF: F 50 WV or less are not indicated except for electrolytics and tantalums. All resistors are in and 1/4 W or less unless otherwise specified. : internal component. 2 : nonflammable resistor. 5 : fusible resistor. C : panel designation. Note: The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Note: Les composants identifis par une marque ! sont critiques pour la scurit. Ne les remplacer que par une pice por tant le numro spcifi.
POW-SW board REG board DISPLAY board KEY board POW-CN board POW-LR board

POW-SR board

Q B C E These are omitted.

CONNECTOR board STANDBY board AMP board MAIN board
U : B+ Line. V : B Line. Voltages and waveforms are dc with respect to ground under no-signal conditions. no mark : AUDIO Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. Circled numbers refer to waveforms. Signal path. F : AUDIO Abbreviation CND : Canadian model

LED board

AC-SW board

L-ch speaker section

5-2. PRINTED WIRING BOARD MAIN Board
See page 11 for Circuit Boards Location.
(Page 18) (Page 20) (Page 16)

Semiconductor Location

Ref. No. D101 D102 D353 D401 D701 D703 D704 D705 D706 D707 D708 D751 D801 D802 D803 D804 D805 D901 D902 D903 D904 D905 D906 D907 D908 D909 D910 D911 IC101 IC102 IC103 IC201 IC202 IC203 IC400 IC401 IC701 IC901 IC902 IC903 IC904 Q301 Q302 Q351 Q352 Q353 Q354 Q371 Q372 Q747 Q748 Q801 Q802 Q902 Location D-13 D-13 C-8 E-12 C-2 G-5 G-5 G-5 G-5 H-6 H-6 E-6 H-8 H-8 H-8 G-8 G-8 B-1 C-4 E-4 E-4 E-4 E-4 D-4 D-4 D-5 D-5 D-7 H-12 F-13 H-13 B-12 B-9 D-11 E-11 G-11 C-2 G-7 F-7 E-7 D-7 A-13 B-13 B-8 B-8 C-8 C-8 B-7 C-7 F-7 G-7 H-8 G-8 D-5

(Page 16)

(Page 18)
5-3. SCHEMATIC DIAGRAM MAIN Board (1/3) See page 22 for Waveform. See page 22 for IC Block Diagrams.

(Page 14)

(Page 17)

(Page 15)

The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified.
Les composants identifis par une marque ! sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi.
5-4. SCHEMATIC DIAGRAM MAIN Board (2/3) See page 22 for IC Block Diagrams.

(Page 21)

(Page 13)

(Page 19)

5-5. SCHEMATIC DIAGRAM MAIN Board (3/3) See page 23 for IC Block Diagrams.
5-6. PRINTED WIRING BOARDS FILTER/REG/T2/T1/STANDBY/AC-SW Boards See page 11 for Circuit Boards Location.

(Page 12)

Semiconductor Location FILTER Board
Ref. No. D351 D352 IC301 IC302 IC303 IC304 Q303 Q304 Q305 Q306 Q307 Q308 Location B-1 B-1 B-4 B-3 B-2 B-1 A-4 B-3 A-2 B-1 B-2 A-1
5-7. SCHEMATIC DIAGRAM FILTER/REG/T2/T1/STANDBY/AC-SW Boards
5-8. PRINTED WIRING BOARD AMP (POW-SR/POW-SW/POW-CN/POW-LR/CONNECTOR) Board
Ref. No. D601 D602 D771 IC601 IC602 IC603 IC604 IC605 IC606 Location A-4 A-3 C-1 A-7 A-7 A-6 A-2 A-1 A-4
5-9. SCHEMATIC DIAGRAM AMP (POW-SR/POW-SW/POW-CN/POW-LR/CONNECTOR) Board
PRINTED WIRING BOARDS DISPLAY/LED/KEY Boards
Semiconductor Location DISPLAY Board
Ref. No. D501 D502 D503 D507 IC501 IC502 IC503 Q501 Q502 Q503 Q504 Q505 Location D-1 D-1 C-1 C-1 B-2 C-1 B-5 C-1 C-4 C-4 C-1 C-1
5-11. SCHEMATIC DIAGRAM DISPLAY/LED/KEY Boards See page 22 for Waveform.

Waveforms MAIN Board

1 IC400 # (OSC)

DISPLAY Board

1 IC501 # (X2)
IC Block Diagrams MAIN Board ICLC75373ED
LTOUT LSIN LS1 LVRIN LCOM LS2 LS3 LT1 LT2 LT3 LSOUT

3.6 Vp-p

5.5 Vp-p

+ + +

22 LFIN 21 LFOUT

118 ns

194 ns

RT1 RT2

RTOUT RSIN RS1

RS2 RS3

OSC PDM-COUT
PDM SRA1-8K R+DELAY P B INV-PHASE
B L-R 20KH-L.P.F. 20K DEC 20K 20K 20K R B L+R -6dB R B B-NR R-STEREO P B 5K/7K-L.P.F.

L+DELAY VOL/MUTE

RS-TRIM

LS-TRIM

ENABLE

FCL-IN FCR-IN

FCLS-IN FCRS-IN

RS-OUT

LS-OUT

CXA8081S

R1 R2 R3 R4 RSELO

VDD 39

LSELO L4 L3 L2 L1

20 LROUT

19 VREF DECODER LATCH SHIFT REGISTER CONTROL CE DI CL VSS 14 RROUT

13 RFOUT 12 RFIN

CXA8079S
DCUT L-R-RCT L+R-RCT CT-OUT2 CM-CAP MIXOUT FCC-IN2 ENABLE VCS-TH R-BPF1 R-BPF2 R-BPF3 CT-IN2 R-OUT S-OUT C-OUT L-OUT DCUT VCS23 VLR1 VCC VCSP.S P.S 24 VLR2 DATA CLK
DEC B N-GEN N-BPF N-OH DIV BAL-DET BALCONT R COMB-NET B R B VR VREF VR VCRX8 L-B.P.F. L-RECT VLR-LOG CMODE SMUTE R-RECT B P B P B P P L-R-RECT DUAL-TIME C-TRIM

R-B.P.F.

L+R-RECT

VCS-LOG

1 NS-BPF1

2 NS-BPF2

3 VREF

4 S-DCUT

5 C-DCUT

6 L-DCUT

7 R-DCUT

8 VREF-BUF

9 L-IN

10 R-IN

11 GND

12 CT-OUT1

13 CT-IN1

14 FCC-IN1

15 L-BPF1

16 L-BPF2

17 L-BPF3

18 DCUT

21 DCUT R-RCT L-RCT

22 VLR-TH

PC1237HA
OVER LOAD DET F/F OFFSET DET VCC ON MUTE
LATCH/ AUTORESET AC OFF DET

OVER LOAD DET

RELAY DRIVE

VCC ON MUTE

OFFSET DET

AUTO RESET

AC OFF DET
IC PIN FUNCTION DESCRIPTION
Pin Name 7G to 1G VDD POWER RY SUR CE VOL LR CE VOL CSW CE VOL SR CE S CLOCK S DATA RESET SEL A SEL B AVSS LR MUTE C MUTE S MUTE SW MUTE KEY1 KEY0 FAN SIG IN AUTO SW AVDD AVREF XT2 VSS X1 X2 REAR POWER U SET SW FAN DRIVE I/O O O O O O O O O O I O O O O O O I I I I I I I O O O I O O Power supply terminal (+5V) Relay drive signal output for the power on/off control H: relay on (power on) Serial chip enable signal output to the dolby surround pro-logic circuit (IC400, 401) H active Serial chip enable signal output to the LC75373ED (IC201) (for L/R-ch signal) H active Serial chip enable signal output to the LC75373ED (IC203) (for 5.1ch input center/woofer signal) H active Serial chip enable signal output to the LC75373ED (IC202) (for wireless rear speaker signal) H active Serial data transfer clock signal output to the dolby surround pro-logic circuit (IC400, 401) and LC75373ED (IC201 to IC203) Serial data output to the dolby surround pro-logic circuit (IC400, 401) and LC75373ED (IC201 to IC203) Not used (pull down) System reset signal input from the reset signal generator (IC502, Q501) L: reset For several hundreds msec. after the power supply rises, L is input, then it changes to H Input select signal output to the MC14052BCP (IC101) *1 Input select signal output to the MC14052BCP (IC101) *1 Ground terminal (for A/D converter) Line muting on/off control signal output for the front side speaker L: muting on Line muting on/off control signal output for the center side speaker L: muting on Line muting on/off control signal output for the rear side speaker L: muting on Line muting on/off control signal output for the sub woofer speaker L: muting on Key input terminal (A/D input) S501 to S504 (INPUT, S.WOOFER, SURROUND, CENTER MODE keys input) Key input terminal (A/D input) S505, S506 (MASTER VOL +/ keys input) Not used (fixed at L) TV audio detect signal input for the auto power on/off Power supply terminal (+5V) (for A/D converter analog system) Reference voltage (+5V) input terminal (for A/D converter) Not used (fixed at L) Not used (fixed at L) Ground terminal Main system clock input terminal (5 MHz) Main system clock output terminal (5 MHz) Not used (pull down) Power on/off control signal output for the wireless rear speaker H: power on Setting terminal for the model Fixed at L in this set Not used (pull down) Not used (pull down) Description Gird drive signal output to the fluorescent indicator tube (FL501)

DISPLAY BOARD IC501 PD78043FGF-059-3B9 (SYSTEM CONTROLLER) Pin No. 1 to 39, 40 41
*1 Input select control Function Terminal SEL A (pin !) SEL B (pin !) TV L L VIDEO H L AUX L H OFF H H
Pin No. 42, 45, to 72 to to 80
Pin Name SIRCS STOP IC STANDBY LED READY LED OPERATE LED VDD S24 to S7 VLOAD S6 to S1 10G to 8G
I/O O I O I O O O O O O Not used (pull down)

Description

Sircs remote control signal input from the remote control receiver (IC503) and CONTROL S TV IN (CONTROL S TV IN: used for the US, Canadian models) Not used (pull down) Power down detection signal input terminal L: power down, normally : H L: LED on Internal connection terminal (connected to ground) LED drive signal output of the STANDBY (D510) indicator LED drive signal output of the READY (D509) indicator LED drive signal output of the ON (D508) indicator Power supply terminal (+5V) Segment drive signal output to the fluorescent indicator tube (FL501) Negative power supply terminal for the fluorescent indicator tube drive (24V) Segment drive signal output to the fluorescent indicator tube (FL501) Gird drive signal output to the fluorescent indicator tube (FL501) L: LED on

L: LED on

SECTION 6 EXPLODED VIEWS
NOTE: -XX and -X mean standardized parts, so they may have some difference from the original one. Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE). (RED) Parts Color Cabinet's Color Abbreviation CND : Canadian model Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. The mechanical parts with no reference number in the exploded views are not supplied. Hardware (# mark) list and accessories and packing materials are given in the last of the electrical parts list. The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifis par une marque ! sont critiquens pour la scurit. Ne les remplacer que par une pice portant le numro spcifi.

L-CH SPEAKER SECTION 5

Amplifier section

not supplied

#1 not supplied

SP201 #1

Remark Ref. No. 21 SP101 SP201 Part No. A-4411-490-A 4-217-262-01 4-967-287-01 4-218-228-01 4-218-227-01 1-673-480-11 1-673-481-11 4-222-862-01 4-222-979-01 1-529-221-11 Description CABINET (L) ASSY, SPEAKER BASE CUSHION (A) PACKING (B) PACKING (A) AC-SW BOARD LED BOARD WASHER (BF) WASHER (S) SPEAKER (10cm) Remark

Ref. No. 11 12

Part No. X-4951-257-1 4-217-245-01 X-4951-172-1 X-4951-171-1 4-914-430-11 4-951-733-01 X-4951-169-1 4-217-241-01 1-673-477-11 4-217-606-01
Description PANEL (L) ASSY, DUCT BUTTON (POWER) FRAME (B) ASSY, GRILLE FRAME (A) ASSY, GRILLE SCREW (4X20), TAPPING CATCHER PANEL (L) ASSY, DISPLAY BUTTON (DSP) KEY BOARD FILTER
4-951-620-01 SCREW (2.6X8), +BVTP A-4419-447-A DISPLAY BOARD, COMP;LETE
1-529-223-11 SPEAKER (16cm)
not supplied not supplied
not supplied #2 T900 M371 #2 #2 #2

#2 #2 supplied

US, CND

53 not

AEP, E
#2 not supplied not supplied not supplied
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifis par une marque ! sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi.

Ref. No. 60 ! 61

Part No. 1-673-074-11 1-773-256-11 1-674-143-11 3-905-609-01 A-4419-453-A 1-673-479-11 1-673-478-11 4-217-252-31 4-217-252-41 4-217-252-51 4-217-251-21 4-217-251-31 4-217-251-51 1-575-042-21
Description STANDBY BOARD WIRE (FLAT TYPE) (27 CORE) REG BOARD SCREW (TRANSISTOR) FILTER BOARD, COMPLETE

Remark

Ref. No. ! 61 ! 61 ! 61 * M371 ! T900 ! T900
Part No. 1-575-651-21 1-751-529-11 1-783-531-31 3-703-244-00 4-956-370-12 A-4419-445-A A-4419-455-A 4-812-134-11 A-4419-454-A 4-219-640-01 4-220-465-01 1-698-792-11 1-433-759-11 1-433-760-11
Description CORD, POWER (AEP, E) CORD, POWER (UK) CORD, POWER (US) BUSHING (2104), CORD BAND, PLUG FIXED
T2 BOARD T1 BOARD PANEL (L/B), BACK (US) PANEL (L/B), BACK (CND) PANEL (L/B), BACK (EXCEPT US, CND) PANEL (L/A), BACK (US, CND) PANEL (L/A), BACK (AEP, E) PANEL (L/A), BACK (UK) CORD, POWER (CND)
MAIN BOARD, COMPLETE (US, CND) MAIN BOARD, COMPLETE (EXCEPT US, CND) RIVET (DIA. 3.5), NYLON AMP BOARD, COMPLETE SPACER, INSULATING WASHER, INSULATING FAN, DC TRANSFORMER, POWER (US, CND) TRANSFORMER, POWER (EXCEPT US, CND)

R-CH SPEAKER SECTION

103 104

8-759-299-53 IC LM3886T < RESISTOR > C506 C507 C508 C509 C510 C511 C512 C513 C514 C515 C516 C517 C518 C519
R601 R602 R603 R604 R605 R606 R607 R608 R609 R610 R611 R612 R613 R614 R615 ! R616 ! R617 ! R618 ! R619 ! R620 R621 R622 R623 R624 R625 R626 R627 R628 R629 R630 R631 R632 R633 ! R772 R774 R775 R776 R777 R778 R779
1-249-435-11 1-249-414-11 1-249-435-11 1-249-435-11 1-249-414-11 1-249-435-11 1-249-435-11 1-249-414-11 1-249-435-11 1-249-435-11 1-249-412-11 1-249-435-11 1-249-435-11 1-249-412-11 1-249-435-11 1-249-381-11 1-249-381-11 1-249-381-11 1-249-381-11 1-249-381-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-247-863-91 1-249-407-11 1-247-863-91 1-247-863-91 1-249-435-11 1-260-297-11 1-249-401-11 1-249-399-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-441-11 1-249-439-11
CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON < RELAY >
33K 560 33K 33K 560 33K 33K 560 33K 33K 390 33K 33K 390 33K 1 1K 1K 1K 1K 1K 1K 22K 150 22K 22K 33K 2.33 100K 100K 100K 100K 100K 68K
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/2W 1/4W 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F F F F F
30% 20% 20% 10% 10% 10% 10% 10%
< FLUORESCENT INDICATOR TUBE > FL501 1-517-851-11 INDICATOR TUBE, FLUORESCENT < IC > IC501 IC502 IC503 8-759-580-05 IC uPD78043FGF-059-3B9 8-759-165-81 IC PST600D-T 8-759-459-86 IC NJL64H400A (REMOTE CONTROL RECEIVER) < COIL > L501 1-408-080-00 INDUCTOR < TRANSISTOR > Q501 Q502 Q503 Q504 Q505 8-729-119-79 8-729-900-36 8-729-900-36 8-729-900-36 8-729-900-36 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR > R501 R502 R503 R504 R505 R506 R508 R509 R511 R512 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-247-807-31 1-249-417-11 1-249-417-11 1-247-807-31 1-249-417-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 1K 1K 100 1K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 2SC2785TP-FEK BA1F4M-TP BA1F4M-TP BA1F4M-TP BA1F4M-TP 100uH

RY772 1-515-920-11 RELAY (24V) ************************************************************** A-4419-447-A DISPLAY BOARD, COMPLETE ************************ * 4-991-276-01 HOLDER, FL TUBE < CAPACITOR > C501 C502 C503 C504 1-124-261-00 1-124-261-00 1-164-159-21 1-164-159-21 ELECT ELECT CERAMIC CERAMIC 10uF 10uF 0.1uF 0.1uF 20% 20% 50V 50V 50V 50V
Ref. No. R513 R516 R518 R519 R520 R521 R522 R530 R534 R535 R536 R537 R538 R539 R540 R541 R542 R543 R544 R545 R546 R547 R548 R549 R550 R551 R552 R553 R554 R555 R556 R560 R561 R562 R564 R565 R566 R567 R568 R569 R570 Part No. 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-429-11 1-249-429-11 1-249-427-11 1-249-427-11 1-247-815-91 1-249-407-11 1-247-815-91 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-437-11 1-249-417-11 1-249-429-11 1-249-415-11 1-249-415-11 1-249-417-11 1-249-417-11 1-249-437-11 1-249-425-11 1-249-417-11 1-249-437-11 1-249-437-11 Description CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 1K 1K 1K 1K 10K 10K 6.8K 6.8K 220 47K 47K 47K 47K 47K 47K 47K 47K 47K 47K 47K 47K 47K 47K 47K 47K 47K 47K 1K 10K 1K 1K 47K 4.7K 1K 47K 47K 47K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W Ref. No. C313 C314 C315 C316 C317 C318 C319 C320 C321 C322 C323 C324 C325 C326 C327 C328 Part No. Description 1uF 220uF 0.15uF 0.033uF 220uF 0.22uF 0.22uF 1uF 0.1uF 0.1uF 0.33uF 0.33uF 2.2uF 1uF 1uF 1uF 1-126-960-11 ELECT 1-126-934-11 ELECT 1-136-167-00 1-136-159-00 1-126-934-11 1-136-169-00 1-136-169-00 1-126-960-11 1-136-165-00 1-136-165-00 1-136-171-00 1-136-171-00 1-126-961-11 1-126-960-11 1-126-960-11 1-126-960-11 FILM FILM ELECT FILM FILM ELECT FILM FILM FILM FILM ELECT ELECT ELECT ELECT < CONNECTOR > * CN303

1-249-431-11 CARBON 1-247-863-91 CARBON 1-249-422-11 1-249-426-11 1-249-436-11 1-249-417-11 1-249-435-11 1-249-425-11 1-249-425-11 1-249-439-11 1-249-417-11 1-249-435-11 1-249-401-11 1-247-863-91 1-247-863-91 1-249-437-11 1-247-843-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON
R342 1-249-417-11 CARBON 1K 5% 1/4W R343 1-249-429-11 CARBON 10K 5% 1/4W R344 1-249-441-11 CARBON 100K 5% 1/4W R345 1-247-863-91 CARBON 22K 5% 1/4W ************************************************************** 1-673-477-11 KEY BOARD ********** R523 R524 R525 R527 R528 R529 R557 1-249-417-11 1-249-419-11 1-249-421-11 1-249-417-11 1-249-419-11 CARBON CARBON CARBON CARBON CARBON 1K 1.5K 2.2K 1K 1.5K 2.2K 3.3K 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W
1-249-421-11 CARBON 1-247-843-11 CARBON < SWITCH >

S501 S502 S503 S504 S505

1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21 1-762-875-21
SWITCH, KEYBOARD (INPUT) SWITCH, KEYBOARD (S.WOOFER) SWITCH, KEYBOARD (SURROUND) SWITCH, KEYBOARD (CENTER MODE) SWITCH, KEYBOARD (MASTER VOL +)
S506 1-762-875-21 SWITCH, KEYBOARD (MASTER VOL ) ************************************************************** 1-673-481-11 LED BOARD ********** < CONNECTOR > * CN505 1-568-942-11 PIN, CONNECTOR 4P < LED > D508 8-719-046-41 LED SEL5521C-TP15 (ON) D509 8-719-812-44 LED SEL5220S-TP15 (READY) D510 8-719-812-44 LED SEL5220S-TP15 (STANDBY) ************************************************************** A-4419-445-A MAIN BOARD, COMPLETE (US, CND) A-4419-455-A MAIN BOARD, COMPLETE (EXCEPT US, CND) ********************* 7-685-646-79 SCREW +BVTP 3X8 TYPE2 N-S
Ref. No. C271 C272 C273 C274 C275 C276 C277 C278 C280 C281 C282 C283 C301 C302 C303 C304 C371 C400 C401 C402 C403 C404 C405 C406 C407 C408 C409 C410 C411 C412 C413 C414 C415 C416 C418 C419 C420 C421 C422 C423 C424 C425 C426 C427 C428 C429 C434 C435 C438 C440 C441 C442 C444 C445 C446 C447 C448 C449 Part No. 1-137-367-11 1-136-157-00 1-136-161-00 1-136-161-00 1-126-960-11 1-137-367-11 1-136-157-00 1-126-960-11 1-136-168-00 1-136-168-00 1-126-960-11 1-126-965-11 1-126-960-11 1-126-961-11 1-126-961-11 1-126-960-11 1-126-964-11 1-102-951-00 1-136-165-00 1-102-852-91 1-130-469-00 1-136-157-00 1-102-973-00 1-102-953-00 1-136-161-00 1-126-934-11 1-126-964-11 1-126-934-11 1-126-964-11 1-136-164-00 1-126-959-11 1-126-964-11 1-137-367-11 1-136-177-00 1-126-964-11 1-136-164-00 1-126-934-11 1-136-177-00 1-126-959-11 1-126-960-11 1-126-935-11 1-126-960-11 1-124-252-00 1-136-177-00 1-136-177-00 1-126-965-11 1-136-165-00 1-136-165-00 1-126-964-11 1-136-165-00 1-136-165-00 1-126-964-11 1-126-959-11 1-126-959-11 1-126-963-11 Description FILM FILM FILM FILM ELECT FILM FILM ELECT FILM FILM ELECT ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC FILM CERAMIC MYLAR FILM CERAMIC CERAMIC FILM ELECT ELECT ELECT ELECT FILM ELECT ELECT FILM FILM ELECT FILM ELECT FILM ELECT ELECT ELECT ELECT ELECT FILM FILM ELECT FILM FILM ELECT FILM FILM ELECT ELECT ELECT ELECT 0.0033uF 0.022uF 0.047uF 0.047uF 1uF 0.0033uF 0.022uF 1uF 0.18uF 0.18uF 1uF 22uF 1uF 2.2uF 2.2uF 1uF 10uF 15PF 0.1uF 47PF 680PF 0.022uF 100PF 18PF 0.047uF 220uF 10uF 220uF 10uF 0.082uF 0.47uF 10uF 0.0033uF 1uF 10uF 0.082uF 220uF 1uF 0.47uF 1uF 470uF 1uF 0.33uF 1uF 1uF 22uF 0.1uF 0.1uF 10uF 0.1uF 0.1uF 10uF 0.47uF 0.47uF 4.7uF 4.7uF 0.47uF 0.47uF 5% 5% 5% 5% 20% 5% 5% 20% 5% 5% 20% 20% 20% 20% 20% 20% 20% 5% 5% 5% 5% 5% 5% 5% 5% 20% 20% 20% 20% 5% 20% 20% 5% 5% 20% 5% 20% 5% 20% 20% 20% 20% 20% 5% 5% 20% 5% 5% 20% 5% 5% 20% 20% 20% 20% 20% 20% 20% Remark 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 16V 50V 16V 50V 50V 50V 50V 50V 50V 50V 50V 16V 50V 50V 50V 16V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V Ref. No. C450 C451 C452 C453 C454 C455 C456 C457 C458 C460 C461 C462 C463 C464 C465 C466 C467 C468 C469 C470 C471 C474 C476 C495 C703 C704 C705 C751 C752 C753 C801 C802 C901 C902 C903 C904 C905 C906 C907 C908 C909 C910 C911 C912 C913 C914 C915 C916 C917 C918 C919 C920 C921 C922 C923 C924 C925 Part No. Description 4.7uF 4.7uF 0.15uF 0.15uF 3.3uF 3.3uF 0.15uF 0.15uF 10uF 1uF 220PF 220PF 220PF 220PF 220PF 220PF 1uF 1uF 1uF 1uF 220uF 0.1uF 33PF 0.1uF 100uF 4.7uF 100uF 220uF 100uF 100uF 47uF 0.47uF 8200uF 8200uF 0.1uF 0.1uF 10000uF 10000uF 0.1uF 0.1uF 4700uF 1000uF 0.1uF 0.1uF 100uF 100uF 10uF 47uF 10uF 100uF 0.1uF 100uF 0.1uF 100uF 0.1uF 100uF 0.1uF 20% 20% 20% 20% 20% 20% 20% 20% 20% 20% 10% 10% 10% 10% 10% 10% 20% 20% 20% 20% 20% Remark 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 50V 16V 50V 50V 50V 25V 50V 25V 35V 50V 25V 25V 50V 50V 50V 50V 50V 63V 63V 50V 50V 25V 25V 50V 50V 50V 50V 50V 50V 50V 25V 50V 25V 50V 25V 50V 25V 50V 1-126-963-11 ELECT 1-126-963-11 ELECT 1-124-250-11 1-124-250-11 1-126-962-11 1-126-962-11 1-124-250-11 1-124-250-11 1-126-964-11 1-126-960-11 1-162-286-21 1-162-286-21 1-162-286-21 1-162-286-21 1-162-286-21 1-162-286-21 1-126-960-11 1-126-960-11 1-126-960-11 1-126-960-11 1-126-934-11 1-164-159-21 1-102-518-11 1-136-165-00 1-104-665-11 1-126-963-11 1-104-665-11 1-126-949-11 1-126-968-11 1-104-665-11 1-104-664-11 1-126-959-11 1-117-691-11 1-117-691-11 1-136-165-00 1-136-165-00 1-117-203-11 1-117-203-11 1-136-165-00 1-136-165-00 1-128-548-11 1-126-942-61 1-136-165-00 1-136-165-00 1-126-968-11 1-126-968-11 1-126-964-11 1-126-967-11 1-126-964-11 1-104-665-11 1-136-165-00 1-104-665-11 1-136-165-00 1-104-665-11 1-136-165-00 1-104-665-11 1-136-165-00 ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC CERAMIC ELECT ELECT ELECT ELECT ELECT CERAMIC CERAMIC FILM ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT (BLOCK) ELECT (BLOCK) FILM FILM ELECT (BLOCK) ELECT (BLOCK) FILM FILM ELECT ELECT FILM FILM ELECT ELECT ELECT ELECT ELECT ELECT FILM ELECT FILM ELECT FILM ELECT FILM

Remark 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/2W 1/4W 1/4W 1/4W 1/2W F 1/4W F 1/4W F 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 3W F
1-247-807-31 CARBON 1-215-910-00 METAL OXIDE < RELAY >

RY771 RY773

1-515-920-11 RELAY (24V) 1-515-920-11 RELAY (24V) < TERMINAL >
1-537-923-11 TERMINAL BOARD (SPEAKER) (6P) (CENTER SPEAKER, REAR SPEAKERS) ************************************************************** 1-674-143-11 REG BOARD ********** < CAPACITOR > C754 C755 1-126-968-11 ELECT 1-104-665-11 ELECT < IC > IC751 8-759-605-01 IC M5F78M18L ************************************************************** 100uF 100uF 20% 20% 50V 25V

1-247-895-91 CARBON

STANDBY

Ref. No. Part No.

Remark Ref. No. ! F902 ! F903 ! F903 ! F904 ! F904 ! F905 ! F905 Part No. Description Remark 1-533-420-11 FUSE GLASS CYLINDRICAL (DIA.5) 5A/125V (US, CND) 1-532-504-31 FUSE T4AL/250V (EXCEPT US, CND) 1-533-420-11 FUSE GLASS CYLINDRICAL (DIA.5) 5A/125V (US, CND) 1-532-504-31 FUSE T4AL/250V (EXCEPT US, CND) 1-533-310-11 FUSE GLASS CYLINDRICAL (DIA.5) 6.3A/125V (US, CND) 1-532-504-31 FUSE T4AL/250V (EXCEPT US, CND) 1-533-310-11 FUSE GLASS CYLINDRICAL (DIA.5) 6.3A/125V (US, CND) < RESISTOR > ! R901 1-212-934-00 FUSIBLE 1 5% 1/2W F ! R902 1-212-934-00 FUSIBLE 1 5% 1/2W F *********************************************************** MISCELLANEOUS *************** 53 ! 61 ! 61 ! 61 ! 61 M371 SP101 SP201 SP301 SP401 1-773-256-11 1-575-042-21 1-575-651-21 1-751-529-11 1-783-531-31 1-698-792-11 1-529-221-11 1-529-223-11 1-529-221-11 1-529-223-11 WIRE (FLAT TYPE) (27 CORE) CORD, POWER (CND) CORD, POWER (AEP, E) CORD, POWER (UK) CORD, POWER (US) FAN, DC SPEAKER (10cm) SPEAKER (16cm) SPEAKER (10cm) SPEAKER (16cm)
1-673-074-11 STANDBY BOARD ************** 1-533-217-31 HOLDER, FUSE < CONNECTOR > CN906 * CN907 * CN908 CNP910 CNP990 1-565-792-11 1-695-044-11 1-580-230-11 1-793-419-11 1-793-419-11 PIN, CONNECTOR 2P PIN, CONNECTOR 2P PIN, CONNECTOR (PC BOARD) 2P CONNECTOR, BOARD TO BOARD 4P CONNECTOR, BOARD TO BOARD 4P < DIODE > D950 D951 D952 D953 D954 D955 8-719-991-33 8-719-200-82 8-719-200-82 8-719-200-82 8-719-200-82 DIODE DIODE DIODE DIODE DIODE 1SS133T-77 11ES2-NTA1B 11ES2-NTA1B 11ES2-NTA1B 11ES2-NTA1B
8-719-991-33 DIODE 1SS133T-77 < FUSE >

! F901 ! F901

1-532-503-31 FUSE T1.6AL/250V (EXCEPT US, CND) 1-533-420-11 FUSE GLASS CYLINDRICAL (DIA.5) 5A/125V (US, CND) < TRANSISTOR >
8-729-119-79 TRANSISTOR 2SC2785TP-FEK < RESISTOR >

R950 R951 R952 R953

1-249-437-11 1-249-425-11 1-249-441-11 1-247-863-91
CARBON CARBON CARBON CARBON < RELAY >

47K 4.7K 100K 22K

5% 5% 5% 5%

1/4W 1/4W 1/4W 1/4W