STR-DA80ES/TA-V88ES/TA-VA80ES

SERVICE MANUAL

US Model Canadian Model

STR-DA80ES

AEP Model UK Model

TA-VA80ES

E Model

STR-DA80ES/TA-VA80ES

Manufactured under license from Dolby Laboratories Licensing Corporation. Dolby, the double-D symbol a, AC-3 and Pro Logic are trademarks of Dolby Laboratories Licensing Corporation. Photo: STR-DA80ES
Australian Model PX Model

Chinese Model

TA-V88ES

SPECIFICATIONS

AUDIO POWER SPECIFICATIONS POWER OUTPUT AND TOTAL HARMONIC DISTORTION With 8-ohm load, both channels driven, from 20-20,000 Hz, rated 100 watts per channel, minimum RMS power, with no more than 0.09 % total harmonic distorition from 250 milliwatts to rated output (US model).
Depending on the sound Inputs field settings and the source, sound will not be output.
Dynamic power output 155 W + 155 W, 8 ohms 220 W + 220 W, 4 ohms (STR-DA80ES: US, Canadian) PHONO Harmonic distortion at rated output STR-DA80ES: Less than 0.05 % (with DIRECT PASS on) TA-V88ES/TA-VA80ES: Less than 0.7 % (with DIRECT PASS on)
S/N Sensitivity Impedance (weighting network, input level) 2.5 mV 50 kilohms 75 dB (A, 2.5 mV)
Amplifier section POWER OUTPUT Stereo mode STR-DA80ES: (8 ohms 20 Hz-20 kHz, THD 0.05 %) 100 W + 100 W Frequency response TA-V88ES: PHONO: (6 ohms at 1 kHz, THD 0.7%) RIAA equalization curve 100 W + 100 W 0.5 dB TA-VA80ES: CD, TAPE, DAT/MD, (4 ohms at 1 kHz, THD 0.7%) VIDEO 1, 2, 3, LD/DVD, 100 W + 100 W TV (/DBS): 10 Hz-50 kHz +0.5 dB (with 2 Surround mode STR-DA80ES: DIRECT PASS on) (8 ohms at 1 kHz, THD 0.05 %) Front : 100 W + 100 W Center1) : 100 W Rear1) : 100 W + 100 W TA-V88ES: (6 ohms at 1 kHz, THD 0.7%) Front : 100 W + 100 W Center1) : 100 W Rear1) : 100 W + 100 W TA-VA80ES: (4 ohms at 1 kHz, THD 0.7%) Front : 100 W + 100 W Center1) : 100 W Rear1) : 100 W + 100 W
200 mV (STR-DA80ES) 150 mV (TA-V88ES/VA80ES) TAPE, DAT/ 200 mV dB MD, VIDEO (STR-DA80ES) kilohms (A, 150 mV) 1, 2, mV LD, TV/DBS (TA-V88ES/VA80ES) TUNER 150 mV (TA-V88ES/VA80ES) LD DVD 100 dB 75 (A, 20 kHz, LPF) AC-3 RF IN LD DVD 100 dB COAXIAL 0.5 Vp-p 75 (A, 20 kHz, LPF) IN CD LD DVD/TV (DBS)/CD/ DAT MD OPTICAL IN 100 dB (A, 20 kHz, LPF)
STR-DA80ES TA-V88ES/TA-VA80ES
FM STEREO/FM-AM RECEIVER INTEGRATED AV AMPLIFIER

MICROFILM

Outputs
REC OUT: DAT/MD, TAPE Voltage: 200 mV (STR-DA80ES) 150 mV (TA-V88ES/VA80ES) Impedance: 1 kilohm AUDIO OUT: VIDEO 1, 2 Voltage: 200 mV (STR-DA80ES) 150 mV (TA-V88ES/VA80ES) Inpedance: 1 kilohm PRE OUT: Voltage: 2 Vrms Impedance: 1 kilohm PHONES: Accepts low and high impedance headphones +6 dB at 70 Hz (STR-DA80ES) +10 dB at 70 Hz (TA-V88ES/VA80ES)
FM tuner section (STR-DA80ES) Tuning range 87.5-108.0 MHz Antenna terminals 75 ohms, unbalanced Sensitivity Mono: 18.3 dBf, 4.5 V Stereo: 38.3 dBf, 45 V
VIDEO: 1 Vp-p 75 ohms S VIDEO: Y: 1 Vp-p 75 ohms C: 0.286 Vp-p 75 ohms

General System

Usable sensitivity 11.2 dBf, 2 V (IHF) S/N Mono: 76 dB Stereo: 70 dB
Harmonic distortion at 1 kHz Mono: 0.3 % Stereo: 0.5 % Separation 45 dB at 1 kHz
Tuner section: PLL quartz-locked digital synthesizer system (STR-DA80ES) Preamplifier section: Low-noise NF type equalizer Power amplifier section: Pure-complementary parallel P.P.

BASS BOOST

Frequency response 30 Hz-15 kHz Selectivity

+0.5 2

Digital signal processor section Modulation (A/D conversion) High Density Linear Converter Demodulation (D/A conversion) High Density Linear Converter (Advanced pulse D/A converter) Sampling frequency 48 kHz Surround LFE MIX: MUTE, 20 - 0 dB, 0.5 dB step D.RANGE COMP: OFF, 0.1 - 0.9, STD, MAX REAR level: 20 - +10 dB, 0.5 dB step CENTER level: 20 - +10 dB, 0.5 dB step SUB WOOFER level: 20 - +10 dB, 0.5 dB step EFFECT: 21-step adjustable WALL: 17-step adjustable SEAT F/R: 17-step adjustable L/R: 17-step adjustable REBERB time: 17-step adjustable BAND: BASS/TREBLE Turnover frequency: Bass: 99 Hz-992 Hz Treble: 1.0 kHz-8.6 kHz Level: 10 dB, 0.5 dB step

To Exposed Metal Parts on Set
EXPLODED VIEWS.. 69 ELECTRICAL PARTS LIST.. 74

0.15 F

1.5 k

AC voltmeter (0.75 V)

Earth Ground
Fig. A. Using an AC voltmeter to check AC leakage.

MODEL IDENTIFICATION

BACK PANEL

4-991-

STR-DA80ES STR-DA80ES STR-DA80ES STR-DA80ES TA-V88ES TA-VA80ES TA-VA80ES
US Model : 373-3 Canadian Model : 373-4 Australian Model : 373-5 E, PX Model : 373-6 Chinese Model : 374-4 AEP, UK, German, EE, CIS Model : 374-0 E, Malaysia, Singapore Model : 374-3
SAFETY-RELATED COMPONENT WARNING!! COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINE WITH MARK ! ON THE SCHEMATIC DIAGRAMS AND IN THE PARTS LIST ARE CRITICAL TO SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
ATTENTION AU COMPOSANT AYANT RAPPORT LA SCURIT! LES COMPOSANTS IDENTIFIS PAR UNE MARQUE ! SUR LES DIAGRAMMES SCHMATIQUES ET LA LISTE DES PICES SONT CRITIQUES POUR LA SCURIT DE FONCTIONNEMENT. NE REMPLACER CES COM- POSANTS QUE PAR DES PICES SONY DONT LES NUMROS SONT DONNS DANS CE MANUEL OU DANS LES SUPPLMENTS PUBLIS PAR SONY.
This section is extracted from instruction manual. STR-DA80ES

SECTION 1 GENERAL

Front Panel Description

TA-V88ES

TA-VA80ES

SECTION 2 DISASSEMBLY

Note: Follow the disassembly procedure in the numerical order given.
1 three screws (M 3 8) 1 two screws (M 3 8)

1 three screws (M 3 8)

3 case

1 two screws (M 3 8)

REAR PANEL SECTION
3 two screws (BVTP 3 6) 1 connector (CNV902) 4 back panel section 2 screw 2 seven screws (BVTP 3 8) (BVTP 3 8) 1 connector (CNE807)

1 connector (CNE910)

1 connector (CNV903)
2 two screws (BVTP 3 8) (STR-DA80ES)
2 eight screws (BVTP 3 8)
2 seven screws (BVTP 3 8)

1 connector (CND3503)

2 four screws (BVTP 3 8)
TUNER/AUDIO/SPTM BOARD, FRONT PANEL SECTION
1 connector (CNE211) 8 front panel section 7 four screws (BVTP 3 8) 2 SPTM board 1 connector (CNS210) 1 five connectors CND621, CNE601, 602, CNV615, 616

1 connector (CNS623)

STR-DA80ES 3 AUDIO board 7 three screws (BVTP 3 8) 4 flat wire (CNS3503) 5 connector (CNS201) 6 TUNER board

INPUT BOARD

2 five screws (BVTP 3 8)

1 connector (CNV613)

3 claw 1 connector (CNE939)

2 two screws (BVTP 3 8)

1 five connectors CNE601, 620, 622, 3501, CNP202

4 INPUT board

SECTION 3 ELECTRICAL ADJUSTMENTS
DC BIAS CURRENT Adjustment (with no signal input)

Receive data input from the on screen display controller Transmit data output to the on screen display controller Busy signal input from the on screen display controller
Display clear signal output to the fluorescent indicator tube driver (IC101, 102) Serial data output to the fluorescent indicator tube driver (IC102) Serial data transfer clock signal output to the fluorescent indicator tube driver (IC101, 102) Serial data latch pulse signal output to the fluorescent indicator tube driver (IC101, 102) Sircs signal input from the remote control receiver (IC104) Power supply terminal (+5V) Reference voltage input terminal (+5V) Reference voltage input terminal (+0V) Ground terminal Key input terminal (A/D input) S132 to 134 (INPUT MODE, DIRECT PASS, BASS BOOST keys) Key input terminal (A/D input) S116 to 119 (FM/AM, SHIFT, PRESET TUNING +/ keys) (STR-DA80ES). Not used (open) (TA-V88ES/VA80ES) Ground terminal Key input terminal (A/D input) S109 to 114 (STR-DA80ES: EQUALIZER BAND, TUNING +/, FM MODE, MEMORY, DISPLAY keys) (TA-V88ES/VA80ES: EQUALIZER BAND, EQUALIZER ON/OFF, SOUND FIELD STANDARD, SLEEP, DIMMER) Key input terminal (A/D input) S101 to 108 (EQUALIZER CH, DPC MODE, cursor ///, SET UP, OPEN/CLOSE keys) Key input terminal (A/D input) S129 to 131 (MODE, SOUND FIELD ON/OFF, GENRE keys) Setting terminal for the destination (A/D input) Motor drive signal input for the master volume Motor drive signal input for the master volume
AD KEY IN 2 DVSS AD KEY IN 3
AD KEY IN 4 AD KEY IN 5 AD VERSION VOL-UP VOL-DOWN

I I I I I

Pin No. 79 80
Pin Name MODE0 MODE1 MODE2 STANDBY STOP U-RESET U-SREQ U-MREQ U-DATA U-CLOCK HIFI/ES AUBUS-IN AUBUS-OUT FUNCTION-B FUNCTION-A OUT-OPEN OUT-CLOSE SW-OPEN SW-CLOSE SWBAL RESET GND XO XI VCC LED-TUNER LED-PHONO LED MUTE LED-LEARNING LED D.PASS LED-INPUT LED VOL LED BASS.B SP-A SP-B PW-SW LED-TV LED-LD
I/O I I I I I I O I I/O I I I O I I O O I I I I O I O O O O O O O O I I I O O I Mode selection terminal (fixed at H) Mode selection terminal (fixed at H) Mode selection terminal (fixed at L)

DIGITAL BOARD IC3410 DSP56009FJ88F (DIGITAL SIGNAL PROCESSOR)
Pin No. 45 Pin Name AGND MCS0 MCS3 MA14 MA13 AVCC MA12 AGND QVCC QGND MA11 MA10 MA9 MA8 AGND MA7 AVCC MA6 MA5 MA4 AGND MA3 MA2 MA1 MA0 SCK EXTAL QVCC QGND PINIT PGND PCAP PVCC SGND MISO RESET MODA MODB MODC SVCC MOSI SS HREQ SGND SDO2 I/O O O O O O O O O O O O O O O O O O I I I I I I I I I O I I O Serial data reading clock signal input from the master controller (IC3413) Master clock signal input terminal (3MHz) Power supply terminal (+5V) (for internal logic) Ground terminal (for internal logic) Initialize input for the PLL circuit (fixed at L) Ground terminal (for PLL circuit) Connected to the external capacitor for PLL circuit filter Power supply terminal (+5V) (for PLL circuit) Ground terminal (for serial port) Communication data input from the master controller (IC3413) Reset signal input from the master controller (IC3413) Mode selection terminal (fixed at H) Mode selection terminal (fixed at L) Mode selection terminal (fixed at H) Power supply terminal (+5V) (for serial port) Communication data output to the master controller (IC3413) SPI slave select signal input from the master controller (IC3413) Host request signal input from the master controller (IC3413) Ground terminal (for serial port) Audio serial data output terminal Not used (open) L: reset Address signal output to the external RAM device Not used (open) Ground terminal (for address bus buffer) Address signal output to the external RAM device Not used (open) Ground terminal (for address bus buffer) Address signal output to the external RAM device Not used (open) Power supply terminal (+5V) (for address bus buffer) Address signal output to the external RAM device Not used (open) Ground terminal (for address bus buffer) Chip select signal output to the external RAM device Chip select signal output to the external RAM device Address signal output to the external RAM device Address signal output to the external RAM device Address signal output to the external RAM device Ground terminal (for address bus buffer) Power supply terminal (+5V) (for internal logic) Ground terminal (for internal logic) Not used (open) Not used (open) Function
Not used (open) Not used (open) Not used (open)
Power supply terminal (+5V) (for address bus buffer)

Pin No. 80

Pin Name SDO1 SDO0 SVCC SCKT WST SCKR QGND QVCC SGND WSR SDI1 SDI0 DSO DSI DSCK DR MD7 MD6 MD5 MD4 DGND MD3 MD2 MD1 DVCC MD0 DGND GPIO3 GPIO2 GPIO1 GPIO0 MRD MWR MRAS MCAS

I/O O O O O I I I I O I I I I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O I/O O O O O Ground terminal (for data bus buffer)
Function Audio serial data output to the digital signal processor (IC3412) Audio serial data output to the digital signal processor (IC3412) Power supply terminal (+5V) (for serial port) Audio serial data transfer clock signal output to the digital signal processor (IC3412) Word transmission output to the digital signal processor (IC3412) Bit clock signal (2.8224 MHz) input terminal Ground terminal (for internal logic) Power supply terminal (+5V) (for internal logic) Ground terminal (for serial port) L/R sampling clock signal (44.1 kHz) input terminal Audio serial data input terminal Audio serial data input terminal Debug serial data output terminal Not used (open) Debug serial data input terminal Not used (open) Debug serial data reading clock signal input terminal Not used (open) Debug request signal input terminal Not used (fixed at H)
Two-way data bus with the external RAM device Not used (open)
Two-way data bus with the external RAM device Not used (open) Power supply terminal (+5V) (for data bus buffer) Two-way data bus with the external RAM device Not used (open) Ground terminal (for data bus buffer)
General digital signal processor in/out terminal Not used (open)
Write strobe signal output to the external RAM device Not used (open) Read strobe signal output to the external RAM device Not used (open) Row address strobe signal output to the external RAM device Not used (open) Column address strobe signal output to the external RAM device Not used (open)
DIGITAL BOARD IC3412 SSP424023FJ88 (DIGITAL SIGNAL PROCESSOR)
Pin No. 45 Pin Name AGND MCS0 MA15 MA14 MA13 AVCC MA12 AGND QVCC QGND MA11 MA10 MA9 MA8 AGND MA7 AVCC MA6 MA5 MA4 AGND MA3 MA2 MA1 MA0 SCK EXTAL QVCC QGND PINIT PGND PCAP PVCC SGND MISO RESET MODA MODB MODC SVCC MOSI SS HREQ SGND SDO2 I/O O O O O O O O O O O O O O O O O O I I I I I I I I I O I I O Serial data reading clock signal input from the master controller (IC3413) Master clock signal input terminal (3MHz) Power supply terminal (+5V) (for internal logic) Ground terminal (for internal logic) Initialize input for the PLL circuit (fixed at L) Ground terminal (for PLL circuit) Connected to the external capacitor for PLL circuit filter Power supply terminal (+5V) (for PLL circuit) Ground terminal (for serial port) Communication data input from the master controller (IC3413) Reset signal input from the master controller (IC3413) L: reset Mode selection terminal (fixed at H) Mode selection terminal (fixed at L) Mode selection terminal (fixed at H) Power supply terminal (+5V) (for serial port) Communication data output to the master controller (IC3413) SPI slave select signal input from the master controller (IC3413) Host request signal input from the master controller (IC3413) Ground terminal (for serial port) Audio serial data output terminal (for rear side speaker) Address signal output to the S-RAM (IC3411) Ground terminal (for address bus buffer) Address signal output to the S-RAM (IC3411) Ground terminal (for address bus buffer) Address signal output to the S-RAM (IC3411) Power supply terminal (+5V) (for address bus buffer) Address signal output to the S-RAM (IC3411) Power supply terminal (+5V) (for address bus buffer) Address signal output to the S-RAM (IC3411) Ground terminal (for address bus buffer) Power supply terminal (+5V) (for internal logic) Ground terminal (for internal logic) Address signal output to the S-RAM (IC3411) Ground terminal (for address bus buffer) Chip select signal output to the external RAM device Not used (open) Function

4-982-090-21 CASE (414538E) (SILVER) (V88ES/VA80ES:AEP, UK, G, EE, CIS) 4-985-642-01 CUSHION 4-970-123-01 FOOT (F50180S) 4-970-124-01 CUSHION (F50180S)

(2) FRONT PANEL SECTION

#1 M101

DA80ES

not supplied

#3 #1 not supplied #1

supplied with RV140

Ref. No. 51

Ref. No. * 76 * 76 * 76 * * 80 * 81 * 83 83
4-991-378-11 PANEL, FRONT (BLACK) (DA80ES: US, Canadian) 4-991-378-41 PANEL, FRONT (BLACK) (VA80ES:AEP, UK, G, EE, CIS, E, SP, MY) 4-991-378-51 PANEL, FRONT (SILVER) (V88ES) 4-991-378-81 PANEL, FRONT (BLACK) (DA80ES: E, AUS, PX) 4-991-378-91 PANEL, FRONT (SILVER) (VA80ES: AEP, UK, G, EE, CIS) 4-942-568-01 EMBLEM (NO.5), SONY (BLACK) (DA80ES/ VA80ES: AEP, UK, EE, CIS, E, SP, MY) 4-942-568-21 EMBLEM (NO.5), SONY (SILVER) (V88ES/VA80ES: AEP, UK, G, EE, CIS) X-4948-619-1 LID (FRONT) ASSY (BLACK) (DA80ES/ VA80ES: AEP, UK, G, EE, CIS, E, SP, MY) X-4948-621-1 LID (FRONT) ASSY (SILVER) (V88ES/VA80ES: AEP, UK, G, EE, CIS) 3-974-992-01 SLIDER (L), DOOR 4-991-596-01 4-991-406-01 X-4948-616-1 4-991-393-01 SPRING, TENSION FRAME (DOOR L) SHAFT (L) ASSY, DOOR DRIVING LID (BASE) (BLACK) (DA80ES/VA80ES: AEP, UK, G, EE, CIS, E, SP, MY) 4-991-393-11 LID (BASE) (SILVER) (V88ES/VA80ES: AEP, UK, G, EE, CIS) 1-666-331-11 CONNECTOR BOARD 4-991-394-01 LID (BACK) (BLACK) (DA80ES/VA80ES: AEP, UK, G, EE, CIS, E, SP, MY) 4-991-394-11 LID (BACK) (SILVER) (V88ES/VA80ES: AEP, UK, G, EE, CIS) 4-957-383-01 KNOB (F14) (BLACK) (DA80ES/VA80ES:AEP, UK, G, EE, CIS, E, SP, MY) 4-957-383-21 KNOB (F14) (SILVER) (V88ES/VA80ES:AEP, UK, G, EE, CIS, E, SP, MY) 4-991-384-01 BUTTON (TUNER) (DA80ES) 4-991-390-01 PANEL (WINDOW) (BLACK) (DA80ES) 4-991-390-31 PANEL (WINDOW) (BLACK) (VA80ES: AEP, UK, G, EE, CIS, E, SP, MY) 4-991-390-41 PANEL (WINDOW) (SILVER) (V88ES/VA80ES: AEP, UK, G, EE, CIS, E, SP, MY) 4-991-389-21 WINDOW (DA80ES: US, Canadian) 4-991-389-31 WINDOW (DA80ES: E, AUS, PX/V88ES/ VA80ES) A-4384-608-A BASE ASSY, GEAR 1-666-314-11 SENSOR BOARD 4-812-134-00 RIVET (DIA. 3.5), NYLON 3-325-697-01 WASHER 3-975-016-01 3-377-720-01 3-975-015-01 3-975-014-01 1-666-313-11 GEAR (D) WASHER, POLYETHYLENE GEAR (C) GEAR (B) MOTOR TM BOARD

* 208 209

A-4403-831-A DIGITAL BOARD, COMPLETE (DA80ES: E, PX) 1-769-946-11 WIRE (FLAT TYPE) (11 CORE) (V88ES/VA80ES)
NOTE: Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX and -X mean standardized parts, so they may have some difference from the original one. RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable
SECTION 6 ELECTRICAL PARTS LIST
The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifis par une marque ! sont critiquens pour la scurit. Ne les remplacer que par une pice portant le nemro spcifi. When indicating parts by reference number, please include the board.
Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. SEMICONDUCTORS In each case, u: , for example: uA. : A. uPA. : PA. uPB. : PB. uPC. : PC. uPD. : PD. CAPACITORS uF: F COILS uH: H Abbreviation DA80ES: STR-DA80ES V88ES: TA-V88ES VA80ES: TA-VA80ES AUS: Australian EE: East European G: German MY: Malaysia SP: Singapore

Ref. No. * * * *

Ref. No. D904 D905 D906 D907
A-4398-769-A AC BOARD, COMPLETE (DA80ES: US, Canadian) A-4398-770-A AC BOARD, COMPLETE (DA80ES: AUS) A-4398-771-A AC BOARD, COMPLETE (DA80ES: E, PX) A-4398-816-A AC BOARD, COMPLETE (V88ES/VA80ES) ****************** 1-533-293-11 HOLDER, FUSE 7-685-872-09 SCREW +BVTT 3X8 (S) < CAPACITOR > C901 C902 C903 C904 C905 C906 C907 C908 C910 C911 1-164-097-11 1-164-097-11 1-126-767-11 1-126-960-11 1-126-959-11 1-124-464-11 1-126-964-11 1-164-159-11 1-164-159-11 1-164-159-11 CERAMIC CERAMIC ELECT ELECT ELECT ELECT ELECT CERAMIC CERAMIC CERAMIC 0.022uF 0.022uF 1000uF 1uF 0.47uF 0.22uF 10uF 0.1uF 0.1uF 0.1uF 0.1uF 0.01uF 50V 50V 16V 50V 50V 50V 50V 50V 50V 50V
8-719-024-99 DIODE 11ES2-NTA2B 8-719-987-63 DIODE 1N4148M 8-719-987-63 DIODE 1N4148M 8-719-987-63 DIODE 1N4148M < EARTH TERMINAL >

F F F F

ENCAPSULATED COMPONENT ENCAPSULATED COMPONENT CARBON 6.8K 5% CARBON 1.5K 5% CARBON CARBON CARBON CARBON CARBON 47K 2.2K 47K 5% 5% 5% 5% 5%
C212 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W F 1/4W F C213 C214

C215 C223

1-162-282-31 CERAMIC 1-162-282-31 CERAMIC 1-162-282-31 CERAMIC 1-162-282-31 CERAMIC 1-162-282-31 CERAMIC
CARBON 10 5% CARBON 10 5% CARBON 10 5% ENCAPSULATED COMPONENT ENCAPSULATED COMPONENT CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 6.8K 1.5K 47K 2.2K 47K 5% 5% 5% 5% 5% 5% 5% 5% 5%

C259 C260 C262

1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W F 1/4W F

C263 C264 C265 C273 C291

1-162-282-31 CERAMIC 1-162-282-31 CERAMIC 1-162-282-31 CERAMIC 1-162-282-31 CERAMIC 1-126-048-81 ELECT 1-126-048-81 1-126-048-81 1-126-048-81 1-162-282-31 1-162-294-31 ELECT ELECT ELECT CERAMIC CERAMIC < CONNECTOR >
CARBON 10 5% ENCAPSULATED COMPONENT ENCAPSULATED COMPONENT CARBON 6.8K 5% CARBON 1.5K 5% CARBON CARBON CARBON CARBON CARBON 47K 2.2K 47K 5% 5% 5% 5% 5% 5% 5%
1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W F 1/4W F 1/4W F

C292 C293 C294 C295 C296

CNE211 1-770-963-11 PIN, CONNECTOR (PCB) (V TYPE) 3P CNS210 1-695-093-11 SOCKET, CONNECTOR 9P
1-249-393-11 CARBON 1-249-393-11 CARBON

AUDIO CBV

Ref. No. Part No. Description < IC > IC291 IC292 8-759-805-13 IC LC7821 8-759-634-51 IC M5218AP < JACK > J210 J211 J212 1-778-064-11 JACK, PIN 4P (LD/DVD IN, TV/DBS IN) 1-778-064-11 JACK, PIN 4P (VIDEO 2 IN/OUT) 1-778-064-11 JACK, PIN 4P (VIDEO 1 IN/OUT) < RESISTOR > RV101 Remark Ref. No. Part No.

BAL (A)

BAL (B) DIGITAL

CONNECTOR

Description < VARIABLE RESISTOR >
1-467-808-11 ENCODER, ROTARY (FUNCTION) < SWITCH >
S140 1-572-184-11 SWITCH, KEYBOARD (MODE) ************************************************************ * 1-666-316-11 BAL (B) BOARD ************* < RESISTOR >
R222 R223 R224 R225 R226 R227 R269 R271 R272 R273 R274 R275 R276 R277 R291

220PF 5% 0.1uF 0.1uF 220PF 5% 0.0033uF 5% 0.1uF 680PF 220PF 0.1uF 680PF

5% 5% 5%

0.0033uF 5% 0.1uF 0.1uF 220PF 5% 220PF 5% 0.1uF 220PF 220PF 220PF 0.1uF 220PF 220PF 0.1uF 0.1uF 220PF
0.0033uF 5% 680PF 5% 0.1uF 220PF 5% 0.1uF 0.0033uF 680PF 0.1uF 220PF 220PF 0.1uF 0.1uF 220PF 10uF 10uF 10uF 10uF 10uF 10uF 10uF 10uF 10uF 10uF 10uF 10uF 0.1uF 0.1uF 22uF 22uF 0.1uF 5% 5% 5% 5%

20% 0.5PF 5% 5% 5% 5%

5% 20% 20% 20% 20% 20% 20% 20% 20% 20% 20% 20% 20%

5% 5% 5% 5%

20% 0.5PF 20% 20% 5%
1-126-049-11 ELECT 1-165-319-11 CERAMIC CHIP 1-110-339-11 MYLAR

20% 20%

Ref. No. C3590 C3591 C3592 C3600 C3605 C3606 C3607 C3608 C3609 C3621 C3622 C3623 C3625 C3650 C3653 C3656 C3659 C3662 C3665 Part No. 1-126-009-81 1-126-009-81 1-126-009-81 1-126-049-11 1-126-049-11 1-126-049-11 1-126-049-11 1-126-049-11 1-126-049-11 1-165-319-11 1-165-319-11 1-126-009-81 1-165-319-11 1-130-467-00 1-130-467-00 1-130-467-00 1-130-467-00 1-130-467-00 1-130-467-00 Description ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP MYLAR MYLAR MYLAR MYLAR MYLAR MYLAR < CONNECTOR > * CND35021-564-922-11 CND35031-568-946-11 * CND35041-568-949-11 CNE34021-770-963-11 PIN, CONNECTOR (SMALL TYPE) 6P PIN, CONNECTOR 8P PIN, CONNECTOR 11P PIN, CONNECTOR (PCB) (V TYPE) 3P (DA80ES) CNE34021-770-965-11 PIN, CONNECTOR (PCB) (V TYPE) 5P (V88ES/VA80ES) * CNE34031-564-725-11 PIN, CONNECTOR (SMALL TYPE) 9P * CNE35011-564-719-11 PIN, CONNECTOR (SMALL TYPE) 3P CNS35031-569-061-11 SOCKET, CONNECTOR 11P (V88ES/VA80ES) * CNS35031-569-306-11 SOCKET, CONNECTOR (L TYRE) 15P (DA80ES) < DIODE > D3301 D3302 D3303 D3401 D3402 D3403 D3404 D3407 D3408 D3409 D3501 D3502 8-719-016-74 8-719-016-74 8-719-061-62 8-719-951-05 8-719-801-78 8-719-801-78 8-719-016-74 8-719-820-05 8-719-016-74 8-719-801-78 DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE DIODE 1SS352 1SS352 KV1851 KV1560 1SS184 1SS184 1SS352 1SS181 1SS352 1SS184 100uF 100uF 100uF 22uF 22uF 22uF 22uF 22uF 22uF 0.1uF 0.1uF 100uF 0.1uF 470PF 470PF 470PF 470PF 470PF 470PF 20% 20% 20% 20% 20% 20% 20% 20% 20% Remark 16V 16V 16V 50V 50V 50V 50V 50V 50V 50V 50V 16V 50V 50V 50V 50V 50V 50V 50V Ref. No. Part No. Description < IC > IC3101 IC3102 IC3103 IC3104 IC3105 IC3106 IC3107 IC3108 IC3301 IC3302 8-759-636-55 8-759-636-55 8-759-636-55 8-759-463-77 8-759-711-58 8-759-045-17 8-759-242-70 8-759-233-26 8-749-923-05 8-749-923-05 IC IC IC IC IC IC IC IC IC IC M5218AFP M5218AFP M5218AFP CXD8681M-TP NJM78L05UA NJM79L05UA TC7WU04F TC74HC393AF-TP1 TORX178 (DIGITAL LD/DVD OPTICAL IN) TORX178 (DA80ES: DIGITAL TV/DBS OPTICAL IN) (V88ES/VA80ES: DIGITAL TV OPTICAL IN) Remark

S111 S112 S113

1-216-049-11 METAL GLAZE 1-216-081-00 METAL CHIP 1-216-089-00 METAL GLAZE 1-216-081-00 METAL CHIP
1-572-184-11 SWITCH, KEYBOARD (DA80ES: TUNING ) (V88ES/VA80ES: SOUND FIELD STANDARD) 1-572-184-11 SWITCH, KEYBOARD (DA80ES: FM MODE) (V88ES/VA80ES: SLEEP) 1-572-184-11 SWITCH, KEYBOARD (DA80ES: MEMORY) (V88ES/VA80ES: DIMMER)
Ref. No. S114 S136 S137 Part No. Description Remark Ref. No. C203 C204 C205 C206 C207 C208 C211 C217 * 1-666-305-11 F.VIDEO BOARD ************* < CAPACITOR > C299 1-164-159-11 CERAMIC < CONNECTOR > C221 CND299 1-568-940-21 PIN, CONNECTOR 2P CNE290 1-770-968-11 PIN, CONNECTOR (PCB) (V TYPE) 8P < JACK > C224 J298 J299 1-779-689-11 TERMINAL, S (VIDEO 3 INPUT S-VIDEO) 1-779-798-11 JACK, PIN (BLOCK) (L TYPE) 3P (VIDEO 3 INPUT AUDIO/VIDEO) < RESISTOR > C227 R248 1-249-403-11 CARBON 68 5% 1/4W R298 1-249-403-11 CARBON 68 5% 1/4W R299 1-249-403-11 CARBON 68 5% 1/4W ************************************************************ * 1-666-304-11 HP BOARD ********* < CONNECTOR > CNE100 1-764-341-11 PIN, CONNECTOR (PCB) (L TYPE) 4P < JACK > J100 1-568-519-41 JACK, LARGE TYPE (PHONES) < RESISTOR > R178 1-247-749-11 CARBON 560 5% 1/2W R179 1-247-749-11 CARBON 560 5% 1/2W ************************************************************ * * A-4398-782-A INPUT BOARD, COMPLETE (DA80ES) A-4398-823-A INPUT BOARD, COMPLETE (V88ES/VA80ES) ********************** 7-685-646-79 SCREW +BVTP < CAPACITOR > C001 C002 C003 C004 C005 C014 C201 C202 1-126-047-81 1-110-335-11 1-107-608-11 1-107-601-11 1-124-995-11 ELECT MYLAR CERAMIC CERAMIC ELECT 4.7uF 100PF 68PF 33PF 220uF 4PF 4.7uF 100PF 20% 5% 5% 5% 20% 50V 50V 500V 500V 10V 3X8 TYPE2 IT-3 C272 C274 C275 C278 C297 C516 C563 C225 C226 C222 0.1uF 50V C220 C218 C219 Part No. 1-572-184-11 SWITCH, KEYBOARD (DISPLAY) 1-554-118-00 SWITCH, PUSH (1 KEY) (POWER) (V88ES/VA80ES) 1-572-184-11 SWITCH, KEYBOARD (POWER) (DA80ES) < VIBRATOR > X100 1-767-359-11 VIBRATOR, CERAMIC (4MHz) ************************************************************

F. VIDEO

100PF 47uF 0.0056uF 0.0015uF 1uF 47uF 33uF
Remark 10% 20% 5% 5% 20% 20% 20% 50V 16V 50V 50V 50V 16V 25V

20% 10V 0.25PF 50V 20% 50V 5% 50V 5% 500V 5% 500V 20% 10V 0.25PF 50V 20% 50V 10% 50V (DA80ES) 20% 10V 10% 500V 20% 63V (V88ES/VA80ES) 20% 100V (DA80ES) 20% 63V (V88ES/VA80ES) 20% 100V (DA80ES) 10% 50V 20% 10% 20% 10% 10% 5% 5% 5% 20% 20% 20% 20% 20% 20% 20% 20% 20% 50V 50V (DA80ES) 10V 500V 50V 50V 50V 50V 35V 35V 35V 35V 16V 25V 25V 25V 25V
8-719-024-99 DIODE 11ES2-NTA2B 8-719-024-99 DIODE 11ES2-NTA2B < EARTH TERMINAL >

* EB201

1-537-738-21 TERMINAL, EARTH < IC >

C703 C704 C705 C705

1-126-923-11 ELECT 1-102-233-00 CERAMIC 1-126-063-11 ELECT 1-128-563-11 ELECT

220uF 33PF 100uF 100uF

IC001 IC201 IC202 IC203 IC253 IC601 IC651 IC701 IC971 IC972 IC973 IC974
8-749-011-16 8-759-636-74 8-759-805-13 8-759-636-74 8-759-636-74 8-749-011-16 8-749-011-16 8-759-326-52 8-759-982-15 8-759-701-89
IC IC IC IC IC IC IC IC IC IC
STK350-230 M5218AP-22 LC7821 M5218AP-22 M5218AP-22 STK350-230 STK350-230 uPC2581V RC7815FA NJM7915FA
C706 C706 C714 C751 C752 C753 C754 C764 C920 C921 C922 C971 C972 C975 C976 C977 C978 C979 C980 C983
1-126-063-11 ELECT 1-128-563-11 ELECT 1-162-193-31 CERAMIC 1-126-963-11 ELECT 1-162-282-31 CERAMIC 1-126-923-11 ELECT 1-102-233-00 CERAMIC 1-162-193-31 1-136-153-00 1-136-153-00 1-136-153-00 1-126-947-11 1-126-947-11 1-126-041-11 1-126-041-11 1-128-547-11 1-126-023-11 CERAMIC FILM FILM FILM ELECT ELECT ELECT ELECT ELECT ELECT
100uF 100uF 3.3PF 4.7uF 100PF 220uF 33PF 3.3PF 0.01uF 0.01uF 0.01uF 47uF 47uF 2200uF 2200uF 6800uF 100uF 100uF 100uF 100uF
8-759-231-53 IC TA7805S 8-759-231-53 IC TA7805S < JACK >

J201 J201 J202 J203

1-774-727-11 1-778-064-11 1-778-064-11 1-779-493-11
JACK, PIN 2P (PHONO IN) JACK, PIN 4P (TUNER IN) (V88ES/VA80ES) JACK, PIN 4P (DAT/MD IN/REC OUT) JACK, PIN 6P (PRE OUT CENTER/WOOFER/REAR/FRONT)

J204 J205 J207

1-778-064-11 JACK, PIN 4P (TAPE IN/REC OUT) 1-784-035-11 JACK, PIN 1P (PRE OUT WOOFER) 1-774-727-11 JACK, PIN 2P (CD IN) < TRANSISTOR >

Q201 Q202 Q203 Q204 Q251

8-729-141-30 8-729-900-63 8-729-119-79 8-729-900-36 8-729-141-30
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR < RESISTOR >
2SC3623A-LK DTA124ES 2SC2785-FEK DTC124ES 2SC3623A-LK
1-126-023-11 ELECT 1-126-023-11 ELECT 1-126-023-11 ELECT < CONNECTOR >
CNE620 CNE621 CNE622 CNE939 CNP201 CNP202 CNP203 CNP204 CNS202

R234 R235 R236 R237 R238 R239 R240 R241 R242 R243 R244 R245 R246 R247 R249
1-249-421-11 CARBON 1-249-417-11 1-249-417-11 1-249-417-11 1-249-433-11 1-249-417-11 1-249-441-11 1-249-429-11 1-249-429-11 1-247-807-31 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON
1-247-807-31 CARBON 1-249-421-11 CARBON
100 5% 1/4W 2.2K 5% 1/4W (DA80ES/V88ES/VA80ES: E, MY, SP) 1-249-421-11 CARBON 2.2K 5% 1/4W (DA80ES/V88ES/VA80ES: E, MY, SP) 1-249-417-11 CARBON 1K 5% 1/4W 1-249-421-11 CARBON 2.2K 5% 1/4W (DA80ES/V88ES/VA80ES: E, MY, SP) 1-249-409-11 1-249-441-11 1-249-441-11 1-249-416-11 1-247-897-11 1-249-437-11 1-249-441-11 1-247-807-31 1-249-417-11 CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON 220 100K 100K 820 560K 47K 100K 100 1K 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W
CARBON CARBON METAL OXIDE METAL OXIDE METAL OXIDE < RELAY >
RY201 1-515-614-11 RELAY RY202 1-515-614-11 RELAY ************************************************************ * 1-666-313-11 MOTOR TM BOARD **************** < CAPACITOR > C113 1-164-159-11 CERAMIC < CONNECTOR > * CND104 1-568-951-11 PIN, CONNECTOR 2P ************************************************************ * 1-666-302-11 PTA BOARD ********* 1-533-293-11 HOLDER, FUSE < CAPACITOR > C981 C982 C989 1-126-964-11 ELECT 1-126-964-11 ELECT 1-128-564-11 ELECT < CONNECTOR > CNE934 1-770-964-11 PIN, CONNECTOR (PCB) (V TYPE) 4P CNV953 1-766-897-11 PIN, CONNECTOR (PC BOARD) 4P < DIODE > D916 D918 D919 D921 8-719-987-63 8-719-024-99 8-719-024-99 8-719-002-76 DIODE DIODE DIODE DIODE 1N4148M (DA80ES) 11ES2-NTA2B 11ES2-NTA2B UZL-36H 10uF 10uF 220uF 20% 20% 20% 50V 50V 100V 0.1uF 50V
R251 R252 R253 R254 R255 R256 R257 R258 R259
5% 1/4W 5% 1/4W 5% 1/4W 5% 1/4W (V88ES/VA80ES) 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W 1/4W
R260 R261 R262 R263 R264 R266 R270 R278 R279 R282 R283 R284 R285 R286 R287 R288 R289 R293 R294
1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-441-11 1-249-429-11 1-249-437-11 1-249-441-11 1-249-409-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-417-11 1-249-418-11 1-249-418-11
CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON CARBON

#6 7-685-645-79 SCREW +BVTP 3X6 TYPE2 IT-3 #7 7-685-647-79 SCREW +BVTP 3X10 TYPE2 IT-3 (DA80ES) ************************************************************ ACCESSORIES & PACKING MATERIALS ******************************** 1-475-134-11 1-501-374-11 1-501-594-11 3-810-765-11 REMOTE COMMANDER (RM-P501) ANTENNA, LOOP (DA80ES) ANTENNA (FM) (DA80ES: AUS) MANUAL,COMMONNESS INSTRUCTION (DA80ES: US, Canadian)
3-860-902-11 MANUAL, INSTRUCTION (ENGLISH) (DA80ES: US, Canadian, E, PX, AUS) 3-860-902-21 MANUAL, INSTRUCTION (FRENCH) (DA80ES: Canadian, E, PX) 3-860-902-31 MANUAL, INSTRUCTION (SPANISH) (DA80ES: E, PX) 3-860-972-11 MANUAL, INSTRUCTION (ENGLISH, FRENCH, DUTCH, SWEDISH) (VA80ES: AEP, UK, G, EE, CIS) 3-860-972-21 MANUAL, INSTRUCTION (GERMAN, SPANISH, ITALIAN, PORTUGUESE) (VA80ES:AEP, UK, G, EE, CIS) 3-860-972-41 MANUAL, INSTRUCTION (ENGLISH, CHINESE) (VA80ES: E, MY, SP) 3-860-972-51 MANUAL, INSTRUCTION (ENGLISH, CHINESE) (V88ES) 4-983-536-01 COVER, BATTERY (for RM-P501)

Sony Corporation

9-920-929-11
Home A&V Products Company
97G0595-1 Printed in Japan 1997. 7 Published by General Engineering Dept. (Shibaura)

SUPPLEMENT-1

File this supplement with the service manual.
Subject: Change of AMP Board

(SPM-98017)

1. PRINTED WIRING BOARD
Semiconductor Location Ref. No. Location
D001 D002 D003 D011 D603 D653 D703 D753 D971 D972 D973 D991 D992 Q001 Q002 Q005 Q006 Q007 Q010 Q011 Q012 Q601 Q602 Q605 Q606 Q607 Q651 Q652 Q655 Q656 Q657 Q701 Q702 Q705 Q706 Q707 Q751 Q752 Q755 Q756 Q757 A-4 A-3 H-2 A-3 F-1 E-4 G-1 G-3 C-3 C-3 B-3 C-2 C-2 H-3 H-3 H-1 H-4 H-2 A-3 A-3 A-3 C-1 C-1 C-1 A-1 E-1 B-4 C-4 A-4 D-4 E-4 G-1 G-1 H-1 F-1 G-1 G-4 G-4 F-4 H-4 G-4

2. SCHEMATIC DIAGRAM

3. ELECTRICAL PARTS LIST
NOTE: Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. -XX and -X mean standardized parts, so they may have some difference from the original one. RESISTORS All resistors are in ohms. METAL: Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F: nonflammable Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. SEMICONDUCTORS In each case, u: , for example: uA. : A. uPA. : PA. uPB. : PB. uPC. : PC. uPD. : PD. CAPACITORS uF: F COILS uH: H Abbreviation DA80ES: STR-DA80ES V88ES: TA-V88ES VA80ES: TA-VA80ES The components identified by mark ! or dotted line with mark ! are critical for safety. Replace only with part number specified. Les composants identifis par une marque ! sont critiquens pour la scurit. Ne les remplacer que par une pice portant le nemro spcifi. When indicating parts by reference number, please include the board.