For details on the settings of switches and controls, refer to Location and Function of Controls. Note Make sure that the line output from the car audio unit is connected to the jack marked L (BTL) on the unit.
Pour plus de dtails sur les rglages des commutateurs et commandes, reportez-vous Emplacement et fonction des commandes. Remarque Vrifiez que la sortie de ligne de lautoradio est raccorde la prise portant lindication L (BTL) sur lappareil.
Power Connection Wires Cbles dalimentation
As the Monaural Amplifier for a Subwoofer Comme amplificateur monaural pour un haut-parleur dextrmes graves
to a metal point of the car vers une partie mtallique de la carrosserie
less than 450 mm (18 in) moins de 450 mm (18 po)

OFF LPF

Remote output *1 Sortie de commande *1 (REM OUT)
Fuse (80 A) Fusible (80 A) +12 V car battery Batterie de voiture +12 V Subwoofer (min. 4 ) Haut-parleur dextrmes graves (min. 4 )

Car audio unit Autoradio

*1 If you have the factory original or some other car audio unit without a remote output for the amplifier, connect the remote input terminal (REMOTE) to the accessory power supply. *1 Si vous disposez du modle dorigine ou dun autre autoradio sans aucune sortie de commande distance pour lamplificateur, raccordez la borne dentre de la commande distance (REMOTE) la prise dalimentation accessoires.
For details on the settings of switches and controls, refer to Location and Function of Controls. Note If you wish to use a subwoofer as a monaural speaker, connect the speaker as illustrated above. The output signals to the subwoofer will be the combination of the both right and left output signals.
Pour plus de dtails sur les rglages des commutateurs et commandes, reportez-vous Emplacement et fonction des commandes. Remarque Si vous dsirez utiliser un haut-parleur dextrmes graves comme haut-parleur monaural, raccordez le haut-parleur comme illustr ci-dessus. Les signaux de sortie vers le haut-parleur dextrmes graves seront une combinaison des signaux de sortie droit et gauche.
Notes on the power supply Connect the +12 V power supply wire only after all the other wires have been connected. Be sure to connect the ground wire of the unit securely to a metal point of the car. A loose connection may cause a malfunction of the amplifier. Be sure to connect the remote control wire of the car audio unit to the remote terminal. When using a car audio unit without a remote output on the amplifier, connect the remote input terminal (REMOTE) to the accessorypower supply. Use the power supply wire with a fuse attached (80 A). All power wires connected to the positive battery post should be fused within 450 mm (18 in) of the battery post, and before they pass through any metal. Make sure that the vehicles battery wires connected to the vehicle (ground to chassis) *2 are of a wire gauge at least equal to that of the main power wire connected from the battery to the amplifier. Make sure that the wires to be connected to the +12 V and GND terminals of this unit are at least 4-Gauge (AWG-4) or have a sectional area of more than 22.0 mm 2 ( 7/8 in 2).

Full range speakers (min. 2 ) Haut-parleurs gamme tendue (min. 2 ) Subwoofers (min. 2 ) Haut-parleur dextrmes graves (min. 2 )
High Level Input Connection (As a Monaural Amplifier for a Subwoofer) Connexion dentre haut niveau
(Comme amplificateur monaural pour un haut-parleur dextrmes graves)
Left speaker Haut-parleur gauche
For details on the settings of switches and controls, refer to Location and Function of Controls. Note In this system, the volume of the subwoofers will be controlled by the car audio unit fader control.
Pour plus de dtails sur les rglages des commutateurs et commandes, reportez-vous Emplacement et fonction des commandes. Remarque Dans ce systme, le volume des haut-parleurs dextrmes graves est contrl par la commande de balance avant/arrire de lautoradio.
Car audio unit Autoradio Right speaker Haut-parleur droit
Subwoofer (min. 4 ) Haut-parleur dextrmes graves (min. 4 )
For details on the settings of switches and controls, refer to Location and Function of Controls. Note If you wish to use a subwoofer as a monaural speaker, connect the speaker as illustrated above. The output signals to the subwoofer will be the combination of both right and left output signals.
High Level Input Connection (2-Speaker System) Connexion dentre haut niveau

(Systme 2 haut-parleurs)

White Blanc
Left speaker output Sortie haut-parleur gauche
Black-striped cord Cordon ray noir

Grey Gris

Right speaker output Sortie haut-parleur droit
For details on the settings of switches and controls, refer to Location and Function of Controls.
Pour plus de dtails sur les rglages des commutateurs et commandes, reportez-vous Emplacement et fonction des commandes.
High Level Input Connection (As a Monaural Amplifier) Connexion dentre haut niveau
(Comme amplificateur monaural)
Left speaker (min. 4 ) Haut-parleur gauche (min. 4 )
Right speaker (min. 4 ) Haut-parleur droit (min. 4 )
* High Level Input Connector * Connecteur dentre haut niveau
Grey/Black striped Gris/Ray noir
White/Black striped Blanc/Ray noir
XM-SD22X SECTION 2 DISASSEMBLY
Note : This set can be disassemble according to the following sequence.
SET 2-1. BOTTOM PLATE (Page 7) MAIN BOARD SECTION (Page 8)

MAIN BOARD (Page 8)

LED BOARD (Page 9)
Note : Follow the disassembly procedure in the numerical order given.

2-1. BOTTOM PLATE

2 two screws (+BTP 3 x 6) 1 two screws (+BTP 3 x 6)

4 bottom plate

5 insulating sheet 3 two screws (+BTP 3 x 6)

2-2. MAIN BOARD SECTION

4 screw (+P 3 x 8) 3 three screws (+P 3 x 8) 2 three screws (+P 3 x 8)

5 MAIN board section

1 four screws (+P 3 x 8)

heat sink (main)

6 CN810

2-3. MAIN BOARD

4 MAIN board
2 three screws (+P 3 x 8)

3 front panel

1 two screws (+P 3 x 8)

2-4. LED BOARD

1 three screws (+P 3 x 8) 2 bracket (LED) 3 LED board
XM-SD22X SECTION 3 ELECTRICAL ADJUSTMENT

Bias Adjustment

Note : In Bias Adjustment, adjust RV103 if any of Q108 through Q113 are replaced. Adjust RV203 if any of Q208 through Q213 are replaced. Condition : This adjustment should be performed about one minute after the remote mode is turned on at a room temperature of about 25C. Setting :

B+, REM terminal

set Stabilized Power supply GND terminal
Procedure : 1. Turn the variable resistors RV103 (L-CH) and RV203 (R-CH) full clockwise as seen from the component side to minimize the bias current. 2. The input signal is to be no signal. 3. Apply the voltage to the B+ and REM terminals from the stabilized power supply and gradually increase it up to 12.0 V while checking for any unusual current. 4. Adjust each of RV103 (L-CH) and RV203 (R-CH) so that the power current of the stabilized power supply is increased in steps of 700 mA (total of 1.4 A). 5. After adjustment, check that the power current is at 1.65 to 2.05 A.
Adjustment Location : Main board (component side)
MAIN BOARD (CONDUCTOR SIDE)
RV103 BIAS ADJUSTMENT (L-CH)
RV203 BIAS ADJUSTMENT (R-CH)
XM-SD22X SECTION 4 DIAGRAMS

4-1. BLOCK DIAGRAM

PRE AMP IC101 (1/2) S801-1 FILTER OFF LPF 6 L.P.F IC301 RV101-1 LEVEL 1 RV301-1 FILTER RV301-2 FILTER INV. AMP IC302 (2/2) CNJ801-2,-4 -2 PRE AMP IC101 (2/2) PRE AMP IC202 (1/2) S801-2 FILTER OFF RV101-2 LEVEL LPF 1 LOW BOOST IC202 (2/2) LINE SWITCH QRV102-1 LOW BOOST (40Hz) 5 L.P.F IC302 (1/2) 7 BOOST EQUALIZER Q101 16.7V (B-) DIFFERENTIAL AMP Q104 DRIVE AMP Q106 BIAS Q107

L (BTL)

CNJ801-1,-3 -1 INPUT

PRE AMP IC102 (1/2) 2

LOW BOOST IC102 (2/2)

LINE SWITCH Q102 7

OUTPUT (THROUGH) -3 CNJ803 L

DIFFERENTIAL AMP Q103

DRIVE AMP Q105 RV103 BIAS

POWER AMP Q108,Q110,Q112

CN804 BTL L

+16.7V (B+)

HIGH LEVEL INPUT R

OVER CURRENT DET Q114

POWER AMP Q109,Q111,Q113

SPEAKER OUT

OUTPUT (THROUGH) R INPUT

DIFFERENTIAL AMP Q203

DRIVE AMP Q205 RV203 BIAS BIAS Q207

POWER AMP Q208,Q210,Q212

CNBTL 2 R
+16.7V (B+) BOOST EQUALIZER Q201 DIFFERENTIAL AMP Q204

OVER CURRENT DET Q214

RV102-2 LOW BOOST (40Hz)
16.7V (B-) LINE SWITCH CONTROL Q701,702

DRIVE AMP Q206

POWER AMP Q209,Q211,Q213
DC OFFSET DET Q802,Q803,Q804
CN801 REM POWER ON/OFF Q903 DC DET IC902 F902 +12V GND F901 B+ SWITCH Q901,QD850,852 (POWER) D851,853 (POWER) PROTECT LATCH Q801,Q805,Q806 D854 PROTECTOR 14 TEMP.DET Q809 TH801,803,808 PTH801 D820,822,827,2 +45V (B+) -45V (B-) DRIVER Q911 SWITCHING DRIVER Q907,Q908,Q909 REF. REG SWITCHING Q913 RECT D910 RECT D912,918 B-REG Q915 RECT D906 D920 54V (B) -45V (B-) 10 DRIVER Q910 SWITCHING Q912 DC-DC CONVERTER ICSWITCHING DRIVER Q904,Q905,Q906 DC-DC CONVERTER TRANSFORMER T901 RECT D911,917 RECT D909 D919 RECT D905 +45V (B+)

B+REG Q914

+16.7V (B+) +54V (B+)

16.7V (B)

HI-VOLTAGE DET IC903,Q920

Signal path : AUDIO

4-2. SCHEMATIC DIAGRAM MAIN SECTION (1/2) Refer to page 15 for Waveform and IC Block Diagram.

CNJ801

IC101(1/2) R101 C130 C109

IC102(1/2)

C111 R120

C231 R254 C221

R154 C102 R102 C107 R107

R104 R301 C110 C104

R303 R304 C301 C303 RV301 RV101 R302 IC301 R307 R305 R306 R308 C304 IC302(1/2) RV301

C106 CN803 C105

C108 R106
C207 R205 C208 C201 CNJ801

C902 R309 R310

R207 IC101(2/2) R202 C230 C209 IC202(1/2) C305 C211 R220
R201 C210 RV101 C204 R204 R208 R210 IC302(2/2) C212

R939 R938

(Page 13)
R941 C914 F902 F901 R834 C915 L901 L903 R942 D915 Q920 IC903 CN801
R853 R815 R809 C805 Q809 R901 Q901

D851 JR800

C202 C101 C222 C102

R154 C131

C224 R235

R204 C204 R206 R201 C230 R202 C203

R203 R207

JW309 JW308 JW307 R104 C104 R106 R101 C130 R102 C103

JW335 R135

JW347 JW346 Q205

JW305 JW304 JW303 R107

RV103 C125 R136

C206 C205 R205

R134 C107 C207 C208 JW296

R132 R155 R156 JW332

C108 C128

C901 C902

JW255 JW260 JW186 R150 JW185 JW258 JW334 JW259 JW256

JW251 JW252

JW248 JW249 R160 R161 JW234 JW235 JW238 Q114

JW245 JW246 R151

JW220 JW221 JW222 JW244 JW230 JW241 JW242 R143 JW239 JW243 R152 JW181 Q112 Q110 Q108 R139 R144 TH803 R146 Q111 R148 Q113 JW240 Q109 JW253 JW254 R149

C906 C903 JW225

JW236 JW237

JW231 JW232 JW233

JW227 JW228 JW229

R803 R153

C904 C905 R804 R805 Q804 C803 R806 R807

Q802 Q803

R140 D109

JR204 Q107 D104 R138

JW261 JW262 JW263 PTH801 D832 R833

TP24 FMB1

Semiconductor Location (MAIN BOARD)
Ref. No. D104 D106 D107 D108 D109 D204 D206 D207 D208 D209 D701 D702 D703 D801 D802 D803 D820 D822 D827 D832 D850 D851 D852 D853 D854 D901 D902 D905 D906 D909 D910 D911 D912 D913 D914 D915 D917 D918 D919 D920 IC101 IC102 IC202 IC301 IC302 IC901 IC902 IC903 Q101 Q102 Location F-11 E-12 E-12 E-12 E-12 B-9 C-9 B-9 C-9 B-9 F-8 E-8 F-8 D-9 D-8 E-8 E-5 E-12 B-8 B-12 J-7 J-8 J-7 J-6 J-7 G-6 G-6 B-2 C-2 D-5 D-5 D-5 E-5 D-6 E-6 D-6 D-5 E-5 D-7 D-6 G-9 G-8 H-8 G-7 H-6 F-6 F-8 D-6 G-8 F-9 Ref. No. Q103 Q104 Q105 Q106 Q107 Q108 Q109 Q110 Q111 Q112 Q113 Q114 Q201 Q202 Q203 Q204 Q205 Q206 Q207 Q208 Q209 Q210 Q211 Q212 Q213 Q214 Q701 Q702 Q801 Q802 Q803 Q804 Q805 Q806 Q809 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q908 Q909 Q910 Q911 Q912 Q913 Q914 Q915 Q920 Location F-10 F-10 E-10 E-10 F-11 F-11 E-11 F-11 D-11 G-11 D-11 D-11 H-8 F-9 D-9 D-9 D-10 D-9 B-9 B-8 B-9 B-8 B-10 B-7 B-10 C-9 E-8 F-8 D-8 B-11 B-11 B-11 D-8 D-8 E-8 F-6 F-6 G-5 D-2 D-2 E-2 G-2 F-2 F-2 E-4 E-4 E-2 E-2 E-6 E-6 C-6
THIS NOTE IS COMMON FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS. (In addition to this, the necessary note is printed in each block.) for schematic diagram: Note: All capacitors are in F unless otherwise noted. (p: pF) 50 WV or less are not indicated except for electrolytics and tantalums. All resistors are in and 1/4 W or less unless otherwise specified. % : indicates tolerance. 2 : nonflammable resistor. C : panel designation. Note: The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Note: Les composants identifis par une marque 0 sont critiques pour la scurit. Ne les remplacer que par une pice por tant le numro spcifi.

A : B+ Line. B : B Line. H : adjustment for repair. Power voltage is dc 14.4V and fed with regulated dc power supply from +12V and REM terminals. Voltage and waveform are dc with respect to ground under no-signal condition. Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. Circled numbers refer to waveforms. Signal path. F : AUDIO
for printed wiring boards: Note: X : parts extracted from the component side. : Pattern from the side which enables seeing.
IC Block Diagram IC901 TL5941NSR Waveform

REF. REG. 10 9

IC901 5

3.0Vp-p

0.1V OSC

15 sec 1V/div, 5 sec/div

XM-SD22X SECTION 5 EXPLODED VIEWS
NOTE: The mechanical parts with no reference number in the exploded views are not supplied. Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. Color Indication of Appearance Parts Example : KNOB, BALANCE (WHITE). (RED) R R Parts Color Cabinets Color Accessories are given in the last of this parts list. The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifis par une marque 0 sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi.
5-1. HEAT SINK (MAIN) SECTION

not supplied

#2 #2 #3 #2 #2 #2 F901 F902 #3
not supplied (LED board) not supplied not supplied

#2 #1 not supplied

Ref. No. 0 FF902
Part No. X-2025-547-1 2-589-409-01 1-533-743-11 1-533-743-11

Description

Remark

Ref. No. #1 #2 #3

Part No.
PLATE ASSY, ORNAMENTAL SHEET, DOUBLE-FACE ADHESIVE FUSE (BLADE TYPE) (AUTO FUSE) (40A) FUSE (BLADE TYPE) (AUTO FUSE) (40A)
7-685-545-14 SCREW +BTP 3X6 TYPE2 N-S 7-685-546-19 SCREW +BTP 3X8 TYPE2 N-S 7-685-649-79 SCREW +BVTP 3X14 TYPE2 N-S

5-2. MAIN BOARD SECTION

not supplied Q209, 210, 213 Q108, 111, 112 not supplied
not supplied Q108, 111, 112 not supplied

Q208, 211, 212

Ref. No. Q108 Q109
Part No. 3-262-163-01 A-1083-419-A 3-238-413-01 3-225-183-12 3-249-786-01 3-225-183-32 3-225-184-12 3-253-537-01 3-912-431-01 3-912-432-01
Description PANEL (FRONT) MAIN BOARD, COMPLETE SHEET (TR), INSULATING SCREW (+PSW.TT.3XL) HEAT SINK (SUB.POWER) SCREW (+PSW.TT.3XL) SCREW (+PS.TT.3XL) SCREW (M5X11) SCREW (+-P) SCREW (+-B)
Ref. No. Q110 Q111 Q112 Q113 Q208 Q209 Q210 Q211 Q212 Q213 #4
Part No. X-3383-027-1 X-3383-028-1 X-3383-027-1 X-3383-028-1 X-3383-027-1 X-3383-028-1 X-3383-027-1 X-3383-028-1 X-3383-027-1 X-3383-028-1
FET PAIR ASSY (N) (IRF540) (set of 3) FET PAIR ASSY (P) (IRF9540) (set of 3) FET PAIR ASSY (N) (IRF540) (set of 3) FET PAIR ASSY (P) (IRF9540) (set of 3) FET PAIR ASSY (N) (IRF540) (set of 3) FET PAIR ASSY (P) (IRF9540) (set of 3) FET PAIR ASSY (N) (IRF540) (set of 3) FET PAIR ASSY (P) (IRF9540) (set of 3) FET PAIR ASSY (N) (IRF540) (set of 3) FET PAIR ASSY (P) (IRF9540) (set of 3)
X-3383-027-1 FET PAIR ASSY (N) (IRF540) (set of 3) X-3383-028-1 FET PAIR ASSY (P) (IRF9540) (set of 3)
7-685-646-79 SCREW +P 3X8 TYPE2 NON-SLIT
NOTE: Due to standardization, replacements in the parts list may be different from the parts specified in the diagrams or the components used on the set. RESISTORS All resistors are in ohms. METAL:Metal-film resistor. METAL OXIDE: Metal oxide-film resistor. F:nonflammable
SECTION 6 ELECTRICAL PARTS LIST
Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. SEMICONDUCTORS In each case, u : , for example: uA. : A. uPA. : PA. uPB. : PB. uPC. : PC. uPD. : PD. CAPACITORS uF : F COILS uH : H The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified. Les composants identifis par une marque 0 sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi. When indicating parts by reference number, please include the board.

Ref. No.

Ref. No. C208 C209 C210 C211 C212 C216 C217 C218 C221 C222 C223 C224 C225 C226 C227 C228 C230 C231 C232 C301 C302 C303 C304 C305 C701 C801 C802 C803 C804 C805 C806 C860 C901 C902 C903 C904 C905 C906 C907 C908 C909 C911 C912 C913

Part No. 1-107-826-11 1-126-796-11 1-162-927-11 1-126-794-11 1-126-794-11 1-162-927-11 1-126-794-11 1-127-715-11 1-115-339-11 1-162-927-11 1-126-786-11 1-107-826-11 1-107-826-11 1-162-925-11 1-107-826-11 1-137-374-11 1-162-919-11 1-115-339-11 1-162-925-11 1-162-927-11 1-162-927-11 1-127-715-11 1-107-826-11 1-162-927-11 1-126-796-11 1-127-715-11 1-126-786-11 1-162-964-11 1-162-962-11 1-126-794-11 1-162-964-11 1-107-826-11 1-115-339-11 1-115-339-11 1-164-161-11 1-164-161-11 1-164-161-11 1-164-161-11 1-126-786-11 1-162-970-11 1-130-471-00 1-126-960-11 1-128-126-11 1-162-964-11
Description CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP MYLAR CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP MYLAR ELECT ELECT CERAMIC CHIP 0.1uF 22uF 100PF 4.7uF 4.7uF 100PF 4.7uF 0.22uF 0.1uF 100PF 47uF 0.1uF 0.1uF 68PF 0.1uF 0.047uF 22PF 0.1uF 68PF 100PF 100PF 0.22uF 0.1uF 100PF 22uF 0.22uF 47uF 0.001uF 470PF 4.7uF 0.001uF 0.1uF 0.1uF 0.1uF 0.0022uF 0.0022uF 0.0022uF 0.0022uF 47uF 0.01uF 0.001uF 1uF 100uF 0.001uF 10% 20% 5% 20% 20% 5% 20% 10% 10% 5% 20% 10% 10% 5% 10% 5% 5% 10% 5% 5% 5% 10% 10% 5% 20% 10% 20% 10% 10% 20% 10% 10% 10% 10% 10% 10% 10% 10% 20% 10% 5% 20% 20% 10%
Remark 16V 50V 50V 50V 50V 50V 50V 16V 50V 50V 16V 16V 16V 50V 16V 50V 50V 50V 50V 50V 50V 16V 16V 50V 50V 16V 16V 50V 50V 50V 50V 16V 50V 50V 50V 50V 50V 50V 16V 25V 50V 50V 25V 50V
A-1083-419-A MAIN BOARD, COMPLETE ********************* 3-225-183-12 3-225-183-32 3-225-184-12 3-238-413-01 3-249-786-01 3-253-537-01 3-912-431-01 3-912-432-01 7-685-646-79 SCREW (+PSW.TT.3XL) SCREW (+PSW.TT.3XL) SCREW (+PS.TT.3XL) SHEET (TR), INSULATING HEAT SINK (SUB.POWER) SCREW (M5X11) SCREW (+-P) SCREW (+-B) SCREW +P 3X8 TYPE2 NON-SLIT < CAPACITOR > C101 C102 C103 C104 C105 C106 C107 C108 C109 C110 C111 C112 C116 C117 C118 C123 C124 C125 C126 C127 C128 C130 C131 C132 C201 C202 C203 C204 C205 C206 C207 1-126-794-11 1-126-794-11 1-162-919-11 1-162-919-11 1-163-251-11 1-163-251-11 1-107-826-11 1-107-826-11 1-126-796-11 1-162-927-11 1-126-794-11 1-126-794-11 1-162-927-11 1-126-794-11 1-127-715-11 1-126-786-11 1-107-826-11 1-107-826-11 1-162-925-11 1-107-826-11 1-137-374-11 1-162-919-11 1-128-499-11 1-162-925-11 1-126-794-11 1-126-794-11 1-162-919-11 1-162-919-11 1-163-251-11 1-163-251-11 ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP MYLAR CERAMIC CHIP ELECT CERAMIC CHIP ELECT ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP 4.7uF 4.7uF 22PF 22PF 100PF 100PF 0.1uF 0.1uF 22uF 100PF 4.7uF 4.7uF 100PF 4.7uF 0.22uF 47uF 0.1uF 0.1uF 68PF 0.1uF 0.047uF 22PF 220uF 68PF 4.7uF 4.7uF 22PF 22PF 100PF 100PF 0.1uF 20% 20% 5% 5% 5% 5% 10% 10% 20% 5% 20% 20% 5% 20% 10% 20% 10% 10% 5% 10% 5% 5% 20% 5% 20% 20% 5% 5% 5% 5% 10% 50V 50V 50V 50V 50V 50V 16V 16V 50V 50V 50V 50V 50V 50V 16V 16V 16V 16V 50V 16V 50V 50V 16V 50V 50V 50V 50V 50V 50V 50V 16V

IC101 IC102 IC202 IC301 IC302 IC901
8-759-710-97 8-759-710-97 8-759-710-97 8-759-909-71 8-759-909-71

IC IC IC IC IC

NJM4565M-D NJM4565M-D NJM4565M-D BA4558F BA4558F
6-703-643-01 IC TL594INSR < PHOTO TRANSISTOR >

IC902 IC903

6-600-354-01 PHOTO TRANSISTOR PC-17K1 6-600-354-01 PHOTO TRANSISTOR PC-17K1 < JUMPER RESISTOR >
JR100 JR103 JR106 JR107 JR204 JR205 JR206 JR207 JR208 JR215 JR216 JR217
1-216-296-11 1-216-296-11 1-216-296-11 1-216-296-11 1-216-295-11 1-216-295-11 1-216-295-11 1-216-295-11 1-216-295-11 1-216-295-11
SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP SHORT CHIP
1-216-295-11 SHORT CHIP 1-216-295-11 SHORT CHIP < COIL >

L901 L902 L903 L904 L905

1-456-139-12 1-410-396-71 1-456-139-12 1-410-396-71 1-410-396-71
INDUCTOR FERRITE INDUCTOR FERRITE FERRITE
35uH 0.45uH 35uH 0.45uH 0.45uH
The components identified by mark 0 or dotted line with mark 0 are critical for safety. Replace only with part number specified.
Les composants identifis par une marque 0 sont critiques pour la scurit. Ne les remplacer que par une pice portant le numro spcifi.
Ref. No. L906 L907 L908 Part No. Description 0.45uH 0.45uH 0.45uH Remark Ref. No. Q914 Q915 Q920 Part No. Description Remark
1-410-396-71 FERRITE 1-410-396-71 FERRITE 1-410-396-71 FERRITE
6-550-693-01 TRANSISTOR KTC4373 6-550-690-01 TRANSISTOR KTA1661 6-550-693-01 TRANSISTOR KTC4373 < RESISTOR >
< THERMISTOR (POSITIVE) > PTH801 1-805-163-21 THERMISTOR, POSITIVE < TRANSISTOR > Q101 Q102 Q103 Q104 Q105 Q106 Q107 Q108 Q109 Q110 Q111 Q112 Q113 Q114 Q201 Q202 Q203 Q204 Q205 Q206 Q207 Q208 Q209 Q210 Q211 Q212 Q213 Q214 Q701 Q702 Q801 Q802 Q803 Q804 Q805 Q806 Q809 Q901 Q902 Q903 Q904 Q905 Q906 Q907 Q908 Q909 Q910 Q911 Q912 Q913 8-729-034-51 6-550-686-01 6-550-031-01 6-550-032-01 6-550-691-01 6-550-692-01 8-729-041-66 X-3383-027-1 X-3383-028-1 X-3383-027-1 X-3383-028-1 X-3383-027-1 X-3383-028-1 8-729-034-51 8-729-034-51 6-550-686-01 6-550-031-01 6-550-032-01 6-550-691-01 6-550-692-01 8-729-041-66 X-3383-027-1 X-3383-028-1 X-3383-027-1 X-3383-028-1 X-3383-027-1 X-3383-028-1 8-729-034-51 6-550-690-01 8-729-034-51 8-729-034-50 8-729-034-51 8-729-034-50 8-729-034-51 8-729-034-50 8-729-034-51 6-550-693-01 8-729-052-82 8-729-034-50 8-729-034-51 6-550-341-01 6-550-341-01 6-550-341-01 6-550-341-01 6-550-341-01 6-550-341-01 6-550-693-01 6-550-693-01 8-729-034-51 8-729-034-51 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR KTC3875 KTC2875-B-RTK HN4C06J-GRBL(TE85R) HN4A06J-GRBL(TE85R) KTA1045L-Y R101 R102 R103 R104 R105 R106 R107 R108 R109 R110 R111 R120 R121 R122 R123 R124 R125 R126 R129 R130 R131 R132 R133 R134 R135 R136 R138 R139 R140 R141 R142 R143 R144 R145 R146 R147 R148 R149 R150 R151 R152 R153 R154 R155 R156 R160 R161 R201 R202 R203 R204 R205 R206 1-216-837-11 1-216-837-11 1-216-837-11 1-216-837-11 1-216-206-00 1-216-845-11 1-216-845-11 1-216-833-11 1-216-033-00 1-216-845-11 1-216-845-11 1-216-077-11 1-216-843-11 1-216-295-11 1-216-827-11 1-216-045-00 1-216-837-11 1-216-829-11 1-216-841-11 1-216-829-11 1-216-829-11 1-216-829-11 1-216-077-11 1-216-077-11 1-216-033-00 1-216-033-00 1-216-821-11 1-216-845-11 1-216-845-11 1-249-421-11 1-249-428-11 1-216-017-11 1-216-017-11 1-216-017-11 1-216-017-11 1-216-017-11 1-216-017-11 1-234-499-11 1-234-499-11 1-234-499-11 1-215-880-31 1-216-853-11 1-216-065-11 1-216-829-11 1-216-829-11 1-216-827-11 1-216-821-11 1-216-837-11 1-216-837-11 1-216-837-11

METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP METAL CHIP SHORT CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP CARBON CARBON RES-CHIP RES-CHIP RES-CHIP RES-CHIP
22K 22K 22K 22K 2.2K 100K 100K 10K 220 100K 100K 15K 68K 0 3.3K 680 22K 4.7K 47K 4.7K 4.7K 4.7K 15K 15K 1K 100K 100K 2.2K 8.2K 47 47
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W 1/10W 1/10W 1/10W 1/10W
TRANSISTOR KTC2025L-Y TRANSISTOR 2SC4015TV2 FET PAIR ASSY (N) (IRF540) (set of 3) FET PAIR ASSY (P) (IRF9540) (set of 3) FET PAIR ASSY (N) (IRF540) (set of 3) FET PAIR ASSY (P) (IRF9540) (set of 3) FET PAIR ASSY (N) (IRF540) (set of 3) FET PAIR ASSY (P) (IRF9540) (set of 3) TRANSISTOR KTC3875 TRANSISTOR KTC3875 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR KTC2875-B-RTK HN4C06J-GRBL(TE85R) HN4A06J-GRBL(TE85R) KTA1045L-Y KTC2025L-Y
TRANSISTOR 2SC4015TV2 FET PAIR ASSY (N) (IRF540) (set of 3) FET PAIR ASSY (P) (IRF9540) (set of 3) FET PAIR ASSY (N) (IRF540) (set of 3) FET PAIR ASSY (P) (IRF9540) (set of 3) FET PAIR ASSY (N) (IRF540) (set of 3) FET PAIR ASSY (P) (IRF9540) (set of 3) TRANSISTOR KTC3875 TRANSISTOR KTA1661 TRANSISTOR KTC3875 TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR FET FET FET FET FET FKV550N FKV550N FKV550N FKV550N FKV550N KTA1504 KTC3875 KTA1504 KTC3875 KTA1504 KTC3875 KTC4373 KTA1281Y-AT KTA1504 KTC3875
RES-CHIP 47 5% 1/10W RES-CHIP 47 5% 1/10W ENCAPSULATED COMPONENT 0.22X2 5W ENCAPSULATED COMPONENT 0.22X2 5W ENCAPSULATED COMPONENT 0.22X2 5W METAL OXIDE METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 10 470K 4.7K 4.7K 4.7K 3.3K 1K 22K 22K 22K 22K 2.2K 100K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 2W F 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W
FET FKV550N TRANSISTOR KTC4373 TRANSISTOR KTC4373 TRANSISTOR KTC3875 TRANSISTOR KTC3875
1-216-837-11 METAL CHIP 1-216-206-00 RES-CHIP 1-216-845-11 METAL CHIP

5% 5% 5% 5% 5% 5% 5% 5%

1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/8W 1/8W 1/10W 1/10W 1/10W 1/10W 1/8W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
RES-CHIP 47 5% 1/10W ENCAPSULATED COMPONENT 0.22X2 5W ENCAPSULATED COMPONENT 0.22X2 5W ENCAPSULATED COMPONENT 0.22X2 5W METAL OXIDE 10 5% 2W F METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 470K 1K 4.7K 4.7K 3.3K 1K 10K 10K 10K 10K 10K 10K 3.3K 3.3K 22K 22K 33K 100K 10K 47K 47K 47K 47K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
1-216-841-11 METAL CHIP 1-216-841-11 METAL CHIP 1-216-841-11 METAL CHIP
1-216-089-11 RES-CHIP 1-216-843-11 METAL CHIP 1-216-837-11 METAL CHIP

Ref. No. R943 R944

Part No. Description 5% 5% Remark 1/10W 1/10W Ref. No. Part No. Description ACCESSORIES ************ 2-514-765-11 MANUAL, INSTRUCTION (ENGLISH,FRENCH) 2-514-765-21 MANUAL, INSTRUCTION (GERMAN,ITALIAN) (AEP,UK,E) 2-514-765-31 MANUAL, INSTRUCTION (SPANISH, TRADITIONAL CHINESE) (AEP,UK,E) 2-514-765-41 MANUAL, INSTRUCTION (DUTCH,PORTUGUESE) (AEP,UK,E) 2-514-765-51 MANUAL, INSTRUCTION (SWEDISH,POLISH) (AEP,UK,E) 2-514-765-61 MANUAL, INSTRUCTION (GREEK,RUSSIAN) (AEP,UK,E) ************************************************************* PARTS FOR INSTALLATION AND CONNECTIONS *************************************** 103 3-367-410-11 SCREW (DIA. 5X15), TAPPING (MOUNTING SCREW) 1-690-779-31 CORD (WITH CONNECTOR) (0.2m) 3-249-791-01 COVER (POWER) Remark
1-216-009-11 RES-CHIP 1-216-009-11 RES-CHIP
< VARIABLE RESISTOR > RV101 RV102 RV301 1-227-558-11 RES, VAR, CARBON 5KX2 (LEVEL) 1-227-558-11 RES, VAR, CARBON 5KX2 (LOW BOOST (40Hz)) 1-227-557-11 RES, VAR, CARBON 20KX2 (FILTER) < CERMET RESISTOR > RV103 RV203 1-241-764-11 RES, ADJ, CERMET 10K 1-241-764-11 RES, ADJ, CERMET 10K < SWITCH > S801 1-692-990-21 SWITCH, SLIDE (FILTER) < TRANSFORMER > T901 1-439-635-21 TRANSFORMER, DC-DC CONVERTER < THERMISTOR (NEGATIVE) > TH801 1-804-301-11 THERMISTOR, CHIP (NEGATIVE) TH803 1-804-301-11 THERMISTOR, CHIP (NEGATIVE) TH808 1-804-301-11 THERMISTOR, CHIP (NEGATIVE) ************************************************************* LED BOARD ********** < DIODE > D850 D851 D852 D853 D854 6-501-118-01 6-501-118-01 6-501-118-01 6-501-118-01 6-501-117-01 LED LED LED LED LED SEL6E10C-STP5 (POWER) SEL6E10C-STP5 (POWER) SEL6E10C-STP5 (POWER) SEL6E10C-STP5 (POWER) SEL2110W-TP3 (PROTECTOR)

< JUMPER RESISTOR > JR800 1-216-296-11 SHORT CHIP < RESISTOR > R850 R851 R853 R854 R856 1-216-815-11 1-216-815-11 1-216-815-11 1-216-815-11 1-216-815-11 METAL CHIP METAL CHIP METAL CHIP METAL CHIP METAL CHIP 330 5% 5% 5% 5% 5% 1/10W 1/10W 1/10W 1/10W 1/10W 0
R857 1-216-815-11 METAL CHIP 330 5% 1/10W *************************************************************

REVISION HISTORY

Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper on the revised page allows you to jump to the next revised page. Ver. 1.0 Date 2004.12 Description of Revision New