XR-CA400/CA410

SERVICE MANUAL

Ver 1.1 2001.04

AEP Model UK Model

Photo: XR-CA400
Model Name Using Similar Mechanism Tape Transport Mechanism Type

NEW MG-25L-136

SPECIFICATIONS

Cassette player section

Tape track Wow and flutter Frequency response Signal-to-noise ratio 4-track 2-channel stereo 0.08 % (WRMS) 30 18,000 Hz Cassette type TYPE II, IV TYPE I 61 dB 58 dB

Power amplifier section

Outputs Speaker outputs (sure seal connectors) Speaker impedance ohms Maximum power output 50 W 4 (at 4 ohms)

General

Outputs Audio output Power aerial relay control lead Power amplifier control lead Telephone ATT control lead Bass 9 dB at 100 Hz Treble 9 dB at 10 kHz 12 V DC car battery (negative earth) Approx. 176 mm (w/h/d) Approx. 161 mm (w/h/d) Approx. 1.2 kg Parts for installation and connections (1 set) Front panel case (1)

Tuner section

Tuning range Aerial terminal Intermediate frequency Usable sensitivity Selectivity Signal-to-noise ratio 87.5 108.0 MHz External aerial connector 10.7 MHz/450 kHz 8 dBf 75 dB at 400 kHz 66 dB (stereo), 72 dB (mono) Harmonic distortion at 1 kHz 0.6 % (stereo), 0.3 % (mono) Separation 35 dB at 1 kHz Frequency response 30 15,000 Hz Input Tone controls Power requirements Dimensions Mounting dimensions Mass Supplied accessories
Tuning range Aerial terminal Intermediate frequency Sensitivity MW: 531 1,602 kHz LW: kHz External aerial connector 10.7 MHz/450 kHz MW: 30 V LW: 40 V
Design and specifications are subject to change without notice.
FM/MW/LW CASSETTE CAR STEREO

9-870-235-12

2001D0500-1 C 2001.4

Sony Corporation

Audio Entertainment Group General Engineering Dept.
TABLE OF CONTENTS 1. GENERAL
Location of Controls.. 3 Setting the Clock... 3
Notes on chip component replacement Never reuse a disconnected chip component. Notice that the minus side of a tantalum capacitor may be damaged by heat. Flexible Circuit Board Repairing Keep the temperature of the soldering iron around 270 C during repairing. Do not touch the soldering iron on the same conductor of the circuit board (within 3 times). Be careful not to apply force on the conductor when soldering or unsoldering.

2. 3. 4. 5.

DISASSEMBLY.. 7 ASSEMBLY OF MECHANISM DECK. 9 MECHANICAL ADJUSTMENTS.. 12 ELECTRICAL ADJUSTMENTS
Tape Deck Section... 12 Tuner Section... 12

DIAGRAMS

6-1. Note for Printed Wiring Boards and Schematic Diagrams.. 6-2. Printed Wiring Board MAIN Board .. 6-3. Schematic Diagram MAIN Board (1/3) . 6-4. Schematic Diagram MAIN Board (2/3) . 6-5. Schematic Diagram MAIN Board (3/3) . 6-6. Printed Wiring Board KEY Board .. 6-7. Schematic Diagram KEY Board .. 6-8. IC Pin Function Description..
EXPLODED VIEWS.. 24 ELECTRICAL PARTS LIST. 27
XR-CA400/CA410 SECTION 1 GENERAL
This section is extracted from instruction manual.

Location of controls

Setting the clock
The clock uses a 24-hour digital indication. Example: To set the clock to 10:08

SRC SOURCE MBP

D-BASS
Press (DSPL) for two seconds.

The hour indication flashes.

SEEK AMS

DISC REP SHUF BL SKIP ATA
1 Press either side of the volume button to set the hour.

to go forward

RELEASE

to go back

Refer to the pages listed for details. 2 Press (SEL). 1 Volume +/ button 7, 13, MODE (o) button During tape playback: Playback direction change 7, 8 During radio reception: BAND select 9 During CD/MD playback: CD/MD unit select SRC (SOURCE) (TUNER/TAPE/CD/MD) button 7, 9, SEL (select) button 7, 15, 17, 18, 19, Display window 6 MBP (My Best sound Position) button D (D-BASS) button Z (eject) button RELEASE (front panel release) button 6, 22 q; ATT (attenuate) button 17 qa SENS/BTM button 9, 10, 13 qs RESET button (located on the front side of the unit behind the front panel) 6 qd AF button 11, 13 qf Number buttons 8, 9, 12, 15, 18, 20, 21 During radio reception: Preset number select 9, 12 During tape playback: (3) REP 8 (5) BL SKIP 8 (6) ATA 8 During CD/MD playback: (1) DISC 20 (2) DISC + 20 (3) REP 21 (4) SHUF 21 qg TA button 12, 13 qh PTY/MTL (programme type/Metal) button 8, 14 qj DSPL (display mode change) button 7, 10, 19, 20 qk OFF button* 6, 7 ql SEEK/AMS +/ button 8, 9, 10, 11, 14, 20 Seek 9 Automatic Music Sensor 8, 20 Manual search 10, 20 * Warning when installing in a car without ACC (accessory) position on the ignition key switch Be sure to press (OFF) on the unit for two seconds to turn off the clock display after turning off the engine. When you press (OFF) momentarily, the clock display does not turn off and this causes battery wear.

The clock starts.

The minute indication flashes.
3 Press either side of the volume button to set the minute.

Press (DSPL).

After the clock setting is complete, the display returns to normal playback mode.

AUDIO OUT

BUS AUDIO IN

BUS CONTROL IN

Source selector* Signalquellenwhler* Slecteur de source* Selettore di fonte* Geluidsbronkiezer*
* not supplied nicht mitgeliefert non fourni non in dotazione niet meegeleverd
RCA pin cord (not supplied) Cinchkabel (nicht mitgeliefert) Cordon broche RCA (non fourni) Cavo a piedini RCA (non in dotazione) Tulpstekkersnoer (niet meegeleverd) Supplied with XA-C30 Mit dem XA-C30 geliefert Fourni avec le XA-C30 In dotazione con il modello XA-C30 Geleverd met de XA-C30 Source selector (not supplied) Signalquellenwhler (nicht mitgeliefert) Slecteur de source (non fourni) Selettore di fonte (non in dotazione) Geluidsbronkiezer (niet meegeleverd) XA-C30 Supplied with the CD/MD changer Mit dem CD/MD-Wechsler geliefert Fourni avec le changeur de CD/MD In dotazione con il cambia CD/MD Geleverd met de CD/MD-wisselaar

Esempi di collegamento (2) Anschlubeispiel (2)
Hinweise (2-A) Schlieen Sie unbedingt zuerst das Massekabel an, bevor Sie den Verstrker anschlieen. Wenn Sie einen gesondert erhltlichen Endverstrker anschlieen und den integrierten Verstrker nicht benutzen, wird der Signalton deaktiviert. Tip (2-B- ) Zum Anschlieen von zwei oder mehr CD/MD-Wechslern wird der gesondert erhltliche Signalquellenwhler XA-C30 bentigt.
Voorbeeldaansluitingen (2)
Opmerkingen (2-A) Sluit eerst de massakabel aan alvorens de versterker aan te sluiten. Wanneer u een los verkrijgbare vermogensversterker aansluit en de ingebouwde versterker niet gebruikt, wordt de pieptoon uitgeschakeld. Tip (2-B- ) Om twee of meer CD/MD-wisselaars aan te sluiten, hebt u de geluidsbronkiezer XA-C30 (optioneel) nodig.
Exemple de raccordement (2)
Remarques (2-A) Raccordez dabord le fil de masse avant de connecter lamplificateur. Si vous raccordez un amplificateur de puissance indpendant et si vous nutilisez pas lamplificateur intgr, le bip sera dsactiv. Conseil (2-B- ) Dans le cas du raccordement de deux changeurs de CD/MD ou plus, le slecteur de source XA-C30 (optionnel) est indispensable.
Note (2-A) Assicurarsi di collegare il cavo di terra prima di collegare lapparecchio allamplificatore. Se si effettua il collegamento di un amplificatore di potenza opzionale e lamplificatore incorporato non viene utilizzato, il segnale acustico si disattiva. Suggerimento (2-B- ) Per collegare due o pi cambia CD/MD, si deve utilizzare il selettore di fonte XA-C30 (opzionali).

Connection diagram (3)

A To AMP REMOTE IN of an optional power amplifier
This connection is only for amplifiers. Connecting any other system may damage the unit.
B To the interface cable of a car telephone

Warning

If you have a power aerial without a relay box, connecting this unit with the power connecting cord (not supplied) may damage the aerial.
Notes on the control leads The power aerial control lead (blue) supplies +12 V DC when you turn on the tuner or when you activate the AF (Alternative Frequency), TA (Traffic Announcement) function. When your car has built-in FM/MW/LW aerial in the rear/side glass, connect the power aerial control lead (blue) or the accessory power input lead (red) to the power terminal of the existing aerial booster. For details, consult your dealer. A power aerial without a relay box cannot be used with this unit. Memory hold connection When the yellow power input lead is connected, power will always be supplied to the memory circuit even when the ignition switch is turned off. Notes on speaker connection Before connecting the speakers, turn the unit off. Use speakers with an impedance of 4 to 8 ohms, and with adequate power handling capacities to avoid its damage. Do not connect the speaker terminals to the car chassis, or connect the terminals of the right speakers with those of the left speaker. Do not attempt to connect the speakers in parallel. Connect only passive speakers. Connecting active speakers (with built-in amplifiers) to the speaker terminals may damage the unit.

2 two ground point screws

1 screw (PTT2.6 10)

4 main board 1 two screws (PTT2.6 10)

HEAT SINK (ISO)

1 three screws (PTT2.6 10) 2 heat sink (ISO)
1 four screws (PTT2.6 10)
XR-CA400/CA410 SECTION 3 ASSEMBLY OF MECHANISM DECK
Note: Follow the assembly procedure in the numerical order given.

HOUSING

7 Hold the hanger by bending the claw. 5 Fit projection on C part. 2 Install the hanger onto two claws of the housing. 4 Fit claw on B part. 1 Install the catch to the hanger. hanger
3 Put the housing under A part.
6 Fit projection on D part.

housing

C part 8 Hold the hanger by bending the claw.

D part

A part

B part

ARM (SUCTION)
2 Move the arm (suction) in the arrow direction and fit on projection.
projection 1 Fit the arm (suction) on the shaft.

LEVER (LDG-A) / (LDG-B)

shaft A

shaft A shaft B shaft C

shaft B
1 Fit the lever (LDG-A) on shafts A C and install it.
3 type-E stop ring 2.Fit the lever (LDG-B) on shafts A and B and install it.

GEAR (LDG-FT)

gear (LDG-D) hole 6 polyethylene washer 5 gear (LDG-FT)
lever (LDG-A) gear (LDG-FB) 4 Align hole in the gear (LDG-D) with hole the lever (LDG-A).

tension spring (LD-2)

2 tension spring (LD-1)
3 Move the lever (LDG-B) in the arrow direction.

GUIDE (C)

2 guide (C)

1 three claws

MOUNTING POSITION OF CAPSTAN/REEL MOTOR (M901)
two precision screws (P2 2)
capstan/reel motor (M901)
Note: Mount the motor so that the angle between of the motor and the hole for the screw becomes 30 as shown in this figure.
XR-CA400/CA410 SECTION 4 MECHANICAL ADJUSTMENTS
1. Clean the following parts with a denatured-alcohol-moistened swab: playback head pinch roller rubber belt capstan idler 2. Demagnetize the playback head with a head demagnetizer. 3. Do not use a magnetized screwdriver for the adjustments. 4. The adjustments should be performed with the power supply voltage (14.4 V) unless otherwise noted. Torque Measurement
Mode Forward Forward Back Tension Reverse Reverse Back Tension FF, REW Torque Meter CQ-102C Meter Reading 2.95 6.37 mNm (gcm) (0.42 0.90 ozinch) 0.05 0.44 mNm (0.5 4.5gcm) (0.01 0.06 ozinch) 2.95 6.37 mNm (gcm) (0.42 0.90 ozinch) 0.05 0.44 mNm (0.5 4.5gcm) (0.01 0.06 ozinch) 5.89 19.61 mNm (gcm) (0.83 2.78 ozinch)
SECTION 5 ELECTRICAL ADJUSTMENTS

TAPE DECK SECTION

Tape Speed Adjustment Setting:
test tape WS-48A (3 kHz, 0 dB) 10 k set + AUDIO OUT REAR jack (CNJ151) frequency counter

0 dB=0.775 V

CQ-102C
Procedure: 1. Put the set into the FWD PB mode. 2. Adjust adjustment resistor for inside capstan motor so that the reading on the frequency counter becomes 3,000 Hz. Specification: Constant speed
Frequency counter 2,955 to 3,075 Hz

CQ-102RC

Adjustment Location:
SET UPPER VIEW Tape Speed Adjustment

CQ-201B

Tape Tension Measurement
Mode Forward Reverse Tension Meter CQ-403A CQ-403R Meter Reading more than 60 g (more than 2.12 oz) more than 60 g (more than 2.12 oz)

TUNER SECTION

Tuner section adjustments are done automatically in this set.
XR-CA400/CA410 SECTION 6 DIAGRAMS
6-1. NOTE FOR PRINTED WIRING BOARDS AND SCHEMATIC DIAGRAMS
Note on Schematic Diagram: All capacitors are in F unless otherwise noted. pF: F 50 WV or less are not indicated except for electrolytics and tantalums. All resistors are in and 1/4 W or less unless otherwise specified. C : panel designation. A : B+ Line. Power voltage is dc 14.4V and fed with regulated dc power supply from ACC and BATT cords. Voltages and waveforms are dc with respect to ground under no-signal (detuned) conditions. no mark : FM ( ) : MW/LW : TAPE PLAYBACK : Impossible to measure Voltages are taken with a VOM (Input impedance 10 M). Voltage variations may be noted due to normal production tolerances. Waveforms are taken with a oscilloscope. Voltage variations may be noted due to normal production tolerances. Circled numbers refer to waveforms. Signal path. F : FM f : MW/LW E : TAPE PLAYBACK L : BUS AUDIO IN
Note on Printed Wiring Board: X : parts extracted from the component side. Y : parts extracted from the conductor side. : Pattern from the side which enables seeing. (The other layers' patterns are not indicated.) Caution: Pattern face side: (Conductor Side) Parts face side: (Component Side) Parts on the pattern face side seen from the pattern face are indicated. Parts on the parts face side seen from the parts face are indicated.

BATT 3 CLK 4 OUT VREF 11 10

BASS SUPPLY TREBLE

DIGITAL CONTROL

19 GND 18 SM

HIGH-CUT

DATA 6 IN/OUT GND 7

9 DATA IN 8 DATA OUT

VOLUME

S&H
PULSE FORMER QUAL 17 QUAL
SOFTMUTE COMPANDER LOUDNESS LOUDNESS

25kHz LP

BA4908-V3

MUX 40

IN-GAIN +AUTO ZERO

IN-GAIN BEEP MUTE

DEMODULATOR +STEREO ADJUST +STEREO BLAND

MULTIPATH DETECTOR

16 MPOUT 15 MPIN REGULATOR
PILOT CANCELATION PIL DET

D/A CONVERTER

14 LEVEL
MAIN SOURCE SELECTOR MDMD1G 42 MDMD2G 44 MAIN

MIXING SELECTOR

SECOND SOURCE SELECTOR 80kHz LP + 1 NC 4 TUNER8.7 ANT SW TUNER5.6 SW STB 5 VDD5.6V PLL
OVER VOLTAGE PROTECT + 11 TUNER8.7V 12 GND + 10 TUNER5.6V + 6 AMP 7 VCC 8 ANT 9 COM8.7V
INPUT MULTIPLEXER PHONO MAIN 1 2

SEL SER

13 MPX

FM AUX AM 11

FD1L+ FD1L FD1R+ FD1R

AM/FM NOISE BLANKER

12 AMIF

FD2L+ FD2L FD2R+ FD2R

6-2. PRINTED WIRING BOARD MAIN Board
BUS AUDIO IN AUDIO OUT REAR REMOTE IN BUS CONTROL IN
CN781 (FRONT VIEW) 8 F781
VIO GRY WHT GRN GRN/BLK WHT/BLK GRY/BLK VIO/BLK BLU BLU/WHT BLU RED 8 BLK YEL
REAR RCH+ FRONT RCH+ FRONT LCH+ REAR LCH+
REAR LCH FRONT LCH FRONT RCH REAR RCH TEL ATT AMP REM ANT REM ACC

GND BATT

(SUPPLIED WITH ONLY SOUTH EUROPEAN MODEL)

Semiconductor Location

Ref. No.
Location F-5 H-5 J-7 F-2 F-3 I-5 H-12 G-13 F-9 F-12 H-5 E-12 D-13 D-12 B-13 E-12 E-12 D-10 D-8 K-3 K-3 K-4 K-4 K-3 K-3 K-3 K-2 D-9 D-9 D-9 C-8 D-8 C-8
Ref. No. D733 D734 D781 IC51 IC90 IC301 IC331 IC351 IC501 IC551 IC581 IC611 IC751 Q90 Q91 Q171 Q181 Q271 Q281 Q351 Q352 Q353 Q354 Q551 Q571 Q581 Q583 Q601 Q602 Q621 Q622
Location C-10 D-9 D-11 J-2 E-2 G-4 D-4 I-13 I-7 K-10 D-11 F-14 A-7 I-5 F-2 B-5 B-4 B-5 B-4 H-12 I-12 H-12 G-12 I-10 H-10 E-12 G-9 J-13 J-13 D-7 D-7
D1 D51 D55 D90 D91 D92 D351 D352 D502 D552 D553 D581 D582 D585 D586 D610 D611 D613 D622 D703 D704 D705 D706 D707 D708 D709 D710 D721 D722 D723 D724 D731 D732

(Page 20)

SCHEMATIC DIAGRAM MAIN Board (1/3)
See page 13 for Waveform.
See page 14 for IC Block Diagrams.

(Page 18)

(Page 19)
SCHEMATIC DIAGRAM MAIN Board (2/3)
See page 13 for Waveforms.

(Page 17)

6-5. SCHEMATIC DIAGRAM MAIN Board (3/3) See page 14 for IC Block Diagrams.

(Page 17) (Page 21)

6-6. PRINTED WIRING BOARD KEY Board

+ (VOLUME)

21 to 29 30, 43

KEYIN0 RCIN0 QUALITY MPTH NIL VREF+ VDD OSCOUT OSCIN VSS XI XO MMOD LCDSO LCDCE LCDCKO NCO SYSRST BUSON KEYACK DAVN BUIN SIRCS NIL NIH RESET TUNON BEEP PW_ON NCO ACCIN NCO TELATT NIH BUSSO BUSSI
I I I I I I O I I O I O O O O O O I I I I I I I O O O I I O I I O I
ILLON REL POS3 POS2 POS0 POS1 LMLOD LMEJ

O I I I I I O O

Pin No. to 99 100
Pin Name TAPEON CMON NOSESW NS_MASK DAVSS NCO DAVCC

I/O O O I O O

Description Power on/off control signal output of the loading motor drive (IC351) and capstan/reel motor (M901) H: motor on Capstan/reel motor (M901) drive signal output terminal H: motor on Front panel block remove/attach detection signal input L: front panel is attached, H: front panel is removed Discharge control signal output for the noise detection circuit H: discharge Ground terminal (for D/A converter) Not used (open) Power supply terminal (+5V) (for D/A converter)
*1 Loading motor control Mode Terminal LMLOD (pin il ) LMEJ (pin o; ) STOP L L LOADING/ FORWARD H L EJECT/ REVERSE L H BRAKE H H
XR-CA400/CA410 SECTION 7 EXPLODED VIEWS
NOTE: -XX and -X mean standardized parts, so they may have some difference from the original one. Color Indication of Appearance Parts Example: KNOB, BALANCE (WHITE). (RED) Parts Color Cabinet's Color Items marked * are not stocked since they are seldom required for routine service. Some delay should be anticipated when ordering these items. The mechanical parts with no reference number in the exploded views are not supplied. Hardware (# mark) list and accessories and packing materials are given in the last of the electrical parts list. MG-25L-136 #1 F781

CHASSIS SECTION 8

#3 #2 A
Front panel assy Ref. No. * 5 * * * * * 9 Part No. 3-042-244-11 X-3370-437-1 3-027-437-51 3-935-003-01 3-033-846-01 3-046-991-01 3-046-990-01 3-040-995-11 A-3326-771-A A-3326-772-A Description SCREW (T) LOCK ASSY DOOR, CASSETTE SPRING, TORSION INSULATED PLATE SPACER (COVER R) SPACER (COVER L) COVER MAIN BOARD, COMPLETE (CA410: AMBER) MAIN BOARD, COMPLETE (CA400/CA410: GREEN) Remark Ref. No. * 12 * * 15 * 20 F781 TU1 Part No. 3-040-998-01 3-224-899-01 3-012-859-01 3-045-878-01 3-045-877-01 Description BRACKET (IC) HEAT SINK (ISO) CAP (25), RUBBER PLATE (TU), GROUND CUSHION (TU) Remark
1-782-381-11 CORD (WITH CONNECTOR) (ISO P&S) (POWER) (South European) 1-777-989-41 CORD (WITH CONNECTOR) (AMP REM/ATT) 3-224-862-01 PANEL, SUB 3-009-813-52 CHASSIS 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) (10A) A-3220-812-A FM/AM TUNER UNIT (TUX-020)

10 * 11

3-376-464-11 SCREW (+PTT 2.6X6), GROUND POINT 3-224-902-01 HEAT SINK (REG)

FRONT PANEL SECTION

not supplied (KEY board) #4
LCD901 not supplied not supplied

Ref. No. * * * 61

Part No.

Description

Remark
Ref. No. * 61 * 62 * * 68 69
Part No. 3-224-871-11 3-224-870-01 3-224-895-01 3-224-861-01 3-225-121-01
Description ILLUMINATOR (LCD) (CA410) PLATE (LCD), LIGHT GUIDE REFLECTOR (LCD) PANEL, FRONT BACK BUTTON (R/CE) (MBP. D)
3-225-123-01 BUTTON (PRESET/CE) (ATT. SENS. AF. 1. 2. 3. 4. 5. 6. TA. PTY. DSPL) 3-225-125-01 BUTTON (RELEASE/CE) (RELEASE) 3-231-816-01 SPRING (RELEASE) 3-224-898-01 PANEL, FRONT (CA400) 3-224-898-11 PANEL, FRONT (CA410) 3-042-504-01 3-225-118-01 3-225-118-11 3-225-127-01 3-225-120-01 EMBLEM (NO.2.5), SONY BUTTON (+/-) (CA400) BUTTON (+/-) (CA410) PLATE (L), LIGHT GUIDE BUTTON (L/CE) (SRC. MODE. SEL)
3-225-124-01 BUTTON (EJECT/CE) (Z) 3-225-128-01 PLATE (R), LIGHT GUIDE 3-225-119-01 BUTTON (S/A) (+ > M. SEEK AMS. m. -) (CA400) 3-225-119-11 BUTTON (S/A) (+ > M. SEEK AMS. m. -) (CA410) 3-225-122-01 BUTTON (OFF)
3-224-896-01 PLATE (LCD), GROUND 1-694-781-11 CONDUCTIVE BOARD, CONNECTION 3-224-871-01 ILLUMINATOR (LCD) (CA400)
70 3-225-117-01 ESCUTCHEON (R) 71 3-225-116-01 ESCUTCHEON (L) LCD901 1-804-298-11 DISPLAY PANEL, LIQUID CRYSTAL
MECHANISM DECK SECTION (MG-25L-136)

164 153

not supplied
Ref. No. 151 * 152 * * 159 160
Part No. A-3291-667-A 3-019-130-01 3-019-131-01 3-020-539-01 3-020-540-01 3-020-542-01 3-341-753-11 3-020-533-01 3-020-532-01 3-020-534-01
Description CLUTCH (FR) ASSY LEVER (LDG-A) LEVER (LDG-B) SPRING (LD-1), TENSION SPRING (LD-2), TENSION GEAR (LOADING FT) WASHER, POLYETHYLENE HOUSING ARM (SUCTION) HANGER

Ref. No. HP901 M901

Part No. 3-933-346-01 3-933-344-01 3-014-798-01 3-364-151-01 A-3220-811-A 3-017-302-01 3-026-636-01 3-701-437-21 1-500-157-21 A-3291-665-A
Description CATCHER GUIDE (C) SCREW (HEAD), SPECIAL WASHER MECHANISM DECK ASSY
BELT (25) FLYWHEEL (F) WASHER HEAD, MAGNETIC (PLAYBACK) MOTOR ASSY, MAIN (CAPSTAN/REEL)

1/16W 1/16W (CA400) 5% 1/16W (CA410: AMBER) 5% 1/16W (CA410: GREEN) 5% 1/16W (CA400) 5% 1/16W (CA410: GREEN) 5% 1/16W (CA410: AMBER) 5% 1/16W (CA400) 5% 1/16W (CA410: GREEN) 5% 1/16W (CA410: AMBER) 5% 1/16W (CA400) 1/16W (CA410) 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W 1/16W

R952 R952 R953 R953 R953

1-216-812-11 METAL CHIP 1-216-813-11 METAL CHIP 1-216-809-11 METAL CHIP 1-216-812-11 METAL CHIP 1-216-813-11 METAL CHIP

R954 PL902

1-216-809-11 METAL CHIP
1-216-864-11 SHORT 1-216-795-11 RES-CHIP 1-216-795-11 RES-CHIP < SWITCH >

1/16W 1/16W

S901 S902 S903 S904 S905
1-771-884-11 1-771-884-11 1-771-884-11 1-771-884-11 1-771-884-11
SWITCH, TACTILE (OFF) SWITCH, TACTILE (SRC, SOURCE) SWITCH, TACTILE (+ (VOLUME)) SWITCH, TACTILE ( (VOLUME)) SWITCH, TACTILE (MODE o)
S906 1-771-884-11 SWITCH, TACTILE (SEL) S907 1-771-884-11 SWITCH, TACTILE (SEEK AMS m. ) S908 1-771-884-11 SWITCH, TACTILE (SEEK AMS + > M) **************************************************************
1-216-823-11 METAL CHIP 1-216-819-11 METAL CHIP
5% 1/16W 5% 1/16W (CA410: AMBER)

XR-CA400/CA410 MAIN

Ref. No. * * Part No. Description Remark Ref. No. C181 C183 C184 C185 C191 C192 C201 C202 C203 C204 C205 C206 C208 C219 C220 C241 C242 C271 C274 C275 C281 C283 C284 C285 C301 C302 C303 C304 C305 C306 C307 C309 C332 C335 C336 C337 C340 C351 C352 C353 C354 C355 C356 C357 C358 C501 C503 C504 C505 C506 C507 C510 C511 C551 C552 C553 C571 C581 Part No. Description 10uF 100PF 0.47uF 0.001uF 0.001uF 470PF 330PF 330PF 0.01uF 0.22uF 0.1uF 1uF 0.001uF 10PF 10PF 1uF 100PF 10uF 0.47uF 0.001uF 10uF 100PF 0.47uF 0.001uF 22uF 10uF 100PF 0.1uF 0.47uF 0.01uF 0.01uF 0.001uF 0.0047uF 10uF 0.01uF 100uF 0.47uF 0.1uF 0.1uF 0.01uF 10uF 22uF 220uF 0.1uF 0.01uF 47uF 10PF 10PF 20PF 22PF 330PF 0.001uF 470PF 0.1F 220uF 0.1uF 1uF 0.01uF 20% 5% 10% 10% 10% 5% 5% 5% 10% 10% 10% 20% 10% 0.5PF 0.5PF 20% 5% 20% 10% 10% 20% 5% 10% 10% 20% 10% 5% 10% 10% 10% 10% 10% 5% 20% 10% 20% 10% Remark 16V 50V 16V 50V 50V 50V 50V 50V 50V 16V 25V 50V 50V 50V 50V 50V 50V 16V 16V 50V 16V 50V 16V 50V 16V 35V 50V 25V 16V 50V 50V 50V 50V 16V 50V 10V 16V 50V 50V 50V 16V 16V 16V 50V 50V 16V 50V 50V 50V 50V 50V 50V 50V 5.5V 16V 25V 50V 50V A-3326-771-A MAIN BOARD, COMPLETE (CA410: AMBER) A-3326-772-A MAIN BOARD, COMPLETE (CA400/CA410: GREEN) ********************** 3-040-998-01 3-224-899-01 3-224-902-01 7-685-647-79 7-685-794-09 BRACKET (IC) HEAT SINK (ISO) HEAT SINK (REG) SCREW +BVTP 3X10 TYPE2 N-S SCREW +PTT 2.6X10 (S) < CAPACITOR > C1 C2 C3 C4 C5 C6 C7 C8 C13 C14 C22 C23 C24 C52 C53 C54 C55 C57 C58 C59 C60 C61 C62 C63 C64 C90 C92 C93 C94 C95 C96 C97 C98 C99 C101 C102 C103 C104 C105 C106 C119 C120 C141 C142 C171 C174 C175 1-163-233-11 1-164-004-11 1-104-664-11 1-163-017-00 1-164-004-11 1-124-589-11 1-107-823-11 1-163-021-11 1-109-982-11 1-109-982-11 1-163-017-00 1-163-037-11 1-163-809-11 1-164-004-11 1-163-227-11 1-163-235-11 1-124-589-11 1-164-004-11 1-163-263-11 1-164-505-11 1-163-135-00 1-164-161-11 1-163-009-11 1-163-133-00 1-164-004-11 1-163-009-11 1-163-009-11 1-163-133-00 1-163-227-11 1-107-823-11 1-163-809-11 1-164-004-11 1-164-004-11 1-163-009-11 1-163-263-11 1-163-263-11 1-163-021-11 1-164-489-11 1-164-004-11 1-126-160-11 1-163-227-11 1-163-227-11 1-126-160-11 1-163-251-11 1-124-233-11 CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT 18PF 0.1uF 47uF 0.0047uF 0.1uF 47uF 0.47uF 0.001uF 1uF 1uF 0.0047uF 0.022uF 0.047uF 0.1uF 10PF 22PF 47uF 0.1uF 330PF 2.2uF 560PF 0.0022uF 0.001uF 470PF 0.1uF 0.001uF 0.001uF 470PF 10PF 0.47uF 0.047uF 0.1uF 0.1uF 0.001uF 330PF 330PF 0.01uF 0.22uF 0.1uF 1uF 10PF 10PF 1uF 100PF 10uF 0.47uF 0.001uF 5% 10% 20% 5% 10% 20% 10% 10% 10% 10% 5% 10% 10% 10% 0.5PF 5% 20% 10% 5% 50V 25V 16V 50V 25V 16V 16V 50V 10V 10V 50V 25V 25V 25V 50V 50V 16V 25V 50V 16V 50V 100V 50V 50V 25V 50V 50V 50V 50V 16V 25V 25V 25V 50V 50V 50V 50V 16V 25V 50V 50V 50V 50V 50V 16V 16V 50V 1-124-233-11 ELECT 1-163-251-11 CERAMIC CHIP 1-107-823-11 CERAMIC CHIP 1-163-009-11 1-163-009-11 1-163-133-00 1-163-263-11 1-163-263-11 1-163-021-11 1-164-489-11 1-164-004-11 1-126-160-11 1-163-009-11 1-163-227-11 1-163-227-11 1-126-160-11 1-163-251-11 1-124-233-11 1-107-823-11 1-163-009-11 1-124-233-11 1-163-251-11 1-107-823-11 1-163-009-11 1-124-234-00 1-131-353-00 1-163-251-11 1-164-004-11 1-107-823-11 1-163-021-11 1-163-021-11 1-163-009-11 1-163-017-00 1-124-233-11 1-163-021-11 1-124-584-00 1-107-823-11 1-165-319-11 1-165-319-11 1-163-031-11 1-124-233-11 1-124-234-00 1-126-934-11 1-165-319-11 1-163-031-11 1-124-589-11 1-163-227-11 1-163-227-11 1-163-234-11 1-163-235-11 1-163-263-11 1-163-009-11 1-163-133-11 1-125-710-11 1-126-934-11 1-164-004-11 1-126-160-11 1-163-021-11 CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT TANTALUM CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP ELECT ELECT ELECT CERAMIC CHIP CERAMIC CHIP ELECT CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP CERAMIC CHIP DOUBLE LAYER ELECT CERAMIC CHIP ELECT CERAMIC CHIP

1-216-295-11 SHORT 1-216-296-11 SHORT 1-216-295-11 SHORT < COIL >

L501 L502 L781

1-410-501-11 INDUCTOR 1-410-501-11 INDUCTOR 1-419-476-11 INDUCTOR < TRANSISTOR >

2.2uH 2.2uH 250uH

Q90 Q91 Q171 Q181 Q271 Q281 Q351 Q352 Q353 Q354 Q551 Q571 Q581 Q583 Q601 Q602 Q621 Q622
8-729-027-59 8-729-120-28 8-729-920-21 8-729-920-21 8-729-920-21 8-729-920-21 8-729-015-11 8-729-047-76 8-729-900-53 8-729-106-60 8-729-027-23 8-729-120-28 8-729-900-53 8-729-120-28 8-729-106-60
TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR TRANSISTOR
DTC144EKA-T146 2SC1623-L5L6 DTC314TKH04 DTC314TKH04 DTC314TKH04 DTC314TKH04 2SD1802FAST-TL FMC2A-T148 DTC114EK 2SB1115A-YQ DTA114EKA-T146 2SC1623-L5L6 DTC114EK 2SC1623-L5L6 2SB1115A-YQ DTC114EK DTA114EKA-T146 DTC114EK
8-729-900-53 TRANSISTOR 8-729-027-23 TRANSISTOR 8-729-900-53 TRANSISTOR < RESISTOR >
R1 R2 R3 R8 R9 R12 R13 R21 R51 R52 R53 R54 R55 R56 R59
1-216-025-11 1-216-025-11 1-216-081-00 1-216-025-11 1-216-025-11 1-216-089-11 1-216-097-11 1-216-069-00 1-216-025-11 1-216-025-11 1-216-113-00 1-216-049-11 1-216-081-00 1-216-041-00 1-216-001-00
RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP RES-CHIP METAL CHIP RES-CHIP METAL CHIP METAL CHIP METAL CHIP
22K 47K 100K 6.8K 470K 1K 22K 470 10
5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5%
1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W
1-216-049-11 RES-CHIP 1-216-073-00 METAL CHIP 1-216-073-00 METAL CHIP
Ref. No. R514 R515 R516 R517 R518 R519 R520 R521 R522 R523 R526 R527 R528 R529 R530 R531 R532 R533 R535 R538 R539 R543 R544 R545 R547 R550 R551 R552 R555 R556 R557 R559 R562 R563 R564 R569 R570 Part No. Description 100K 100K 100K 100K 100K 100K 100K 1K 1K 1K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100K 100 47K 100K 100K 10K 10K 100 100K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W Ref. No. R607 R608 R609 R625 R701 R751 R753 R756 R757 R758 R760 R901 R902 R903 R904 Part No. Description 100 1K 10K 1K 1K 1K 1K 0 100K 100K 100K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% Remark 1/4W 1/4W 1/4W 1/10W 1/10W 1/4W 1/4W 1/10W 1/10W 1/10W 1/10W 1-216-097-11 RES-CHIP 1-216-097-11 RES-CHIP 1-216-097-11 1-216-097-11 1-216-097-11 1-216-097-11 1-216-097-11 1-216-049-11 1-216-049-11 1-216-049-11 1-216-097-11 1-216-097-11 1-216-097-11 1-216-097-11 1-216-097-11 1-216-097-11 1-216-097-11 1-216-097-11 1-216-097-11 1-216-033-00 1-216-033-00 1-216-097-11 1-216-295-11 1-216-025-11 1-247-807-31 1-216-089-11 1-216-097-11 1-216-097-11 1-208-806-11 1-208-806-11 1-247-807-31 1-216-097-11 1-208-806-11 1-216-025-11 1-216-025-11 1-216-097-11 RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP SHORT RES-CHIP CARBON RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP CARBON RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP 1-249-399-11 CARBON 1-249-399-11 1-249-397-11 1-216-017-00 1-216-025-11 1-249-417-11 1-249-429-11 1-216-198-00 1-216-198-00 1-216-198-00 1-216-198-00 1-216-295-11 1-216-097-11 1-216-097-11 1-216-097-11 CARBON CARBON RES-CHIP RES-CHIP CARBON CARBON RES-CHIP RES-CHIP RES-CHIP RES-CHIP SHORT RES-CHIP RES-CHIP RES-CHIP < SWITCH > S551 1-692-431-21 SWITCH, TACTILE (RESET) < THERMISTOR > TH501 1-803-350-21 THERMISTOR, POSITIVE < TUNER UNIT > 5% 5% 5% 5% 5% 0.5% 0.5% 5% 5% 1/10W 1/4W 1/10W 1/10W 1/10W 1/10W 1/10W 1/4W 1/10W TU1 A-3220-812-A FM/AM TUNER UNIT (TUX-020) < VIBRATOR > X51 1-579-242-41 VIBRATOR, CRYSTAL (4.332MHz) X501 1-781-294-21 VIBRATOR, CRYSTAL (18.432MHz) X502 1-567-098-41 VIBRATOR, CRYSTAL (32.768kHz) ************************************************************** MISCELLANEOUS ************** 60 F781 HP901 1-782-381-11 CORD (WITH CONNECTOR) (ISO P&S) (POWER) (South European) 1-777-989-41 CORD (WITH CONNECTOR) (AMP REM/ATT) 1-694-781-11 CONDUCTIVE BOARD, CONNECTION 1-532-877-11 FUSE (BLADE TYPE) (AUTO FUSE) (10A) 1-500-157-21 HEAD, MAGNETIC (PLAYBACK)

5% 5% 5%

1/10W 1/10W 1/10W

1-216-097-11 RES-CHIP

10K 0.5% 1/10W 100 5% 1/10W 100 5% 1/10W 100K 5% 1/10W (CA400/CA410: GREEN) 100K 5% 1/10W (CA410: AMBER) 4.7K 47K 4.7K 100K 47K 100K 100 1K 15K 100 10K 10K 1K 47K 100K 2.2K 10K 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 5% 1/10W 1/10W 1/4W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/10W 1/4W 1/4W
R571 R572 R573 R576 R577 R578 R580 R581 R582 R583 R586 R587 R588 R589 R595 R603 R604 R605 R606
1-216-065-00 1-216-089-11 1-249-425-11 1-216-097-11 1-216-089-11 1-216-097-11 1-216-025-11 1-216-049-11 1-216-077-00 1-216-025-11 1-216-073-00 1-216-073-00 1-216-049-11 1-216-089-11 1-216-097-11 1-216-057-00 1-216-073-00 1-249-399-11 1-249-399-11
RES-CHIP RES-CHIP CARBON RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP RES-CHIP RES-CHIP RES-CHIP METAL CHIP METAL CHIP CARBON CARBON
LCD901 1-804-298-11 DISPLAY PANEL, LIQUID CRYSTAL M901 A-3291-665-A MOTOR ASSY, MAIN (CAPSTAN/REEL) TU1 A-3220-812-A FM/AM TUNER UNIT (TUX-020) ************************************************************
Description ************** HARDWARE LIST **************
PARTS FOR INSTALLATION AND CONNECTIONS ************************************** X-3373-602-1 X-3366-405-1 3-225-732-01 3-934-325-01 3-041-000-01 FRAME ASSY SCREW ASSY (EXP), FITTING COLLAR SCREW, +K (5X8) TAPPING SPRING, FITTING

#1 #2 #3 #4 #6

7-685-792-09 7-685-647-79 7-685-794-09 7-685-106-19 7-624-104-04
SCREW +PTT 2.6X6 (S) SCREW +BVTP 3X10 TYPE2 N-S SCREW +PTT 2.6X10 (S) SCREW +P 2X10 TYPE2 NON-SLIT STOP RING 2.0, TYPE -E
#7 7-627-553-17 PRECISION SCREW +P 2X2 TYPE 3 ************************************************************ ACCESSORIES & PACKING MATERIALS ******************************** 3-226-701-11 MANUAL, INSTRUCTION (ENGLISH, FRENCH, GERMAN, DUTCH, ITALIAN) 3-226-701-21 MANUAL, INSTRUCTION (ENGLISH, SPANISH, SWEDISH, PORTUGUESE, GREEK) 3-226-701-31 MANUAL, INSTRUCTION (ENGLISH, POLISH, CZECH, RUSSIAN, TURKISH) 3-226-702-11 MANUAL, INSTRUCTION, INSTALL (ENGLISH, FRENCH, GERMAN, DUTCH, ITALIAN) 3-226-702-21 MANUAL, INSTRUCTION, INSTALL (ENGLISH, SPANISH, SWEDISH, PORTUGUESE, GREEK) MANUAL, INSTRUCTION, INSTALL (ENGLISH, POLISH, CZECH, RUSSIAN, TURKISH) X-3378-490-1 CASE (PANEL) ASSY (for FRONT PANEL) ************************************************************ 3-226-702-31

1-465-459-21 ADAPTER, ANTENNA 1-782-381-11 CORD (WITH CONNECTOR) (ISO P&S) (POWER) (South European) 1-777-989-41 CORD (WITH CONNECTOR) (AMP REM/ATT)

FRAME ASSY 1

SCREW, FITTING 1

BUSHING 1

SCREW ASSY (EXP), FITTING

COLLAR 1

+K 5X8 2

SPRING, FITTING 2

ADAPTER, ANTENNA 1

POWER CORD 1

AMP REM/ATT CORD 1

REVISION HISTORY

Clicking the version allows you to jump to the revised page. Also, clicking the version at the upper right on the revised page allows you to jump to the next revised page. Ver. 1.1 1.0 Date 2001.04 2001.01 Description of Revision Change of Part No. for SPRING (RELEASE) New

(ECN-CSA04437)

Mobile Accessories

1. Remote Commanders

RM-VD1
Features: Remote commander for Cam & DSC

RM-X114

Features: Credit card remote controller for: CDX-CA750, CDX-CA750X, CDX-CA650, CDX-CA650x, CDX-CA650V, CDX-C5000R, NDX-C800REC, MDX-CA680, MDX-CA680X, MDX-CA580, MDX-CA580/1, XR-CA600, XR-CA600X, XRCA600V, XR-L500, XR-500X, XR-L500V

RM-X47

Features: Also for new CDXC580R, CDX-X580RW, CDX-C780R, XRC7200R, XR-C8100R, XR-C8100RW

RM-X4S

Features: Also for new CDX-3180, CDX3183, CDX-4170R, CDX-4180R, CDX-4483ESP, CDX-C570R, CDX-C580R, CDX-C580RW, MDX-C7890R, XR-2803, XR4790, XR-4800, XR-C5080R, XR-C5790R

02131950

36406190

36226950

36206052

2. Changers

XA-10B
Features: 10 CD changer for all 10-CD players for models before 1996

XA-250

Features: 10 CD changer for: CDX-505RF, CDX-605, CDX-705, CDX-715, CDX-805

XA-300

Features: AUX selector
Features: 4 MD changer for: MDX400RDS, MDX-40

95270010 XA-T7

Features: Magazine for 6 CD changer, separate tray for each CD, models: CDX-T68X, CDX-T67

27145010

27149295

X33675811

27149110

3. Cables and Plugs

Features: Feeder cable for high power amplifier
Features: RCA pin cable for 4 channel amplifier
Features: Sony bus line cable for CD/MD chargers 5.5m
Features: Optical cable with lock type connectors 2m

27060210 RC-98

Features: Optical cable with lock type connectors 5m

27090910 XA-18MK2

Features: Interface with Sony bus type dashboard units & older CDX-A

27090810 XA-C30

Features: Selector for car stereo

27091810 XA-D210

Features: Optical cable adapter for MDX-400RDS & CDX-C910RDS

27091910

27093410

27143350

27092510

4. Security Brackets

GMD-303
Features: For use with XR-7200, XR-7201, XR-7202, XR-7307, XR-7400

D Discontinued

GMD-304
Features: For use with XR-7080, XR-7081, XR-7082, XR-7180

GMD-305

D Discontinued Features: For use with CDX-R79, CDX-R79L, CDX-6060, CDX-6061, CDX-6062

GMD-306

Features: For use with XR-7190, XR-7191, XR-7192, XR-7280

91977110 GMD-307

D Discontinued Features: For use with CDX-5080, CDX-5081, CDX-5082, CDX-7560, CDX-7561, CDX-7562, CDX-7580, CDX-7581, CDX-7582

91978410 GMD-309

Features: For use with XR-7070, XR-7071, XR-7072, XR-7077

91978510 GMD-312

Features: For use with XR-7140, XR-7142, XR-7170, XR-7171, XR-7172

27060410 GMD-313

D Discontinued Features: For use with XR-4250, XR-4252, XR-4257, XR-4301, XR-4350, XR-4351, XR-4357, XR-5150, XR-5151, XR-5152, XR-5250

27062310 GMD-314

Features: For use with XR-500, XR-502, XR-A55

27062710 GMD-616

Features: Car compo rack (protects front side against water, sand or dust)

27065410

27065510

27090210

91976710
5. Front Panels: Radio Cassette
XR-1300R XR-1300R XR-1800 XR-1800 XR-1800R XR-1800R XR-1803 XR-3100R XR-3100R XR-3200 XR-3200 XR-3201 XR-3202

Partnumber

A3315102A A3315103A F36207956 A3301431A A3301652A A3301654A F36207958 A3301987A A3301986A F27153455 F27153457 F27153456 F27153475 F27801456 F27159755 F27153057 F27153076 F27161055 F27161057 F27161056 F27161075 F27159055 F27159057 F27159056 F27801256 F27801257 F27159075 F27159058 F27801258 F27801355 F27801655 F27167855 F27167856 F36201557

Replacement

Description
Amber Green Amber Green Amber Green Green Amber Green

Discontinued

XR-3208Mk2 XR-3209 XR-3310 XR-3312 XR-3490 XR-3490 XR-3491 XR-3492 XR-3500 XR-3500 XR-3501 XR-3501Mk2 XR-3501Mk2 XR-3502 XR-3503 XR-3503Mk2 XR-3509 XR-3690RDS XR-3700RDS XR-3700RDS XR-3750

Green Amber Green

Amber Green
XR-3753 XR-3758 XR-3758 XR-3759 XR-4200R XR-4300R XR-4300RV XR-4300RX XR-4400 XR-4400 XR-4403
F36201553 F36260557 F36260558 F36260556 A3315019A A3315020A A3315022A A3315024A F27018052 F27018030 F27018080 F27018256 F27018259 F27152958 F27152957 F27017751 F27803055 F27803056 F27802956 F27802955 F36260458 F36260456 F36207255 F36207256 F36207156 F36207155 F36207157 A3301763A A3301720A A3315409A F27010850 F27010870 F27010950 F27010951

Amber Green Green Amber Amber Green Green

XR-C300RDS XR-C33R

Discontinued XR-C33R XR-C350 XR-C350 XR-C353 XR-C370J XR-C410 XR-C410 Discontinued XR-C4100 XR-C4103 XR-C412 XR-C412 XR-C4120 XR-C420RDS XR-C440RDS XR-C453RDS XR-C503 XR-C5080R XR-C5080R XR-C5090R XR-C5100R XR-C5103R XR-C5109R XR-C5110R XR-C5120R XR-C5120RA XR-C5300R XR-C5300RV XR-C5300RX XR-C540RDS XR-C553SP XR-C6090R
Red Amber/Green Amber/Green Red
F36206355 F36206353 F27158470 A3301710A A3301712A F36202456 F36202455 F36202453 F27800655 F36209255 A3301612A F27158370 A3307306A A3315064A A3315065A F27803250 A3220651A A3220650A A3307299A F27803150 F27803151 F27801550 A3220667A A3315299A A3315341A A3315340A A3307728A A3307732A A3307729A A3337064A A3337043A A3337047A
XR-C6100R XR-C6103SP XR-C620RDS XR-C6210R XR-C6220R XR-C650RDS XR-C650RDS XR-C653SP XR-C700RDS XR-C7200R XR-C7203SP XR-C720RDS XR-C7220R XR-C7500R XR-C7500RX XR-C750RDS XR-C8100R XR-C8100RW XR-C8220R XR-C850RDS

Amber/Green Amber/Green

Wood Amber/Green Wood
Discontinued XR-C850RDS XR-C900RDS XR-C9100R XR-CA300 XR-CA310 XR-CA310 XR-CA400 XR-CA410 XR-CA410 XR-CA430X XR-CA430X XR-CA440
Green Amber W. Yellow Green Amber Red Red Green
XR-CA440 XR-CA440X XR-CA600 XR-CA600V XR-CA600X XR-CA630X XR-CA630X XR-CA800 XR-L200 XR-L210 XR-L210 XR-L240 XR-L240 XR-L500 XR-L500V XR-L500X
A3337093A A3337069A A3307753A A3307763A A3307766A A3337050A A3337080A A3307905A A3315305A A3315343A A3315342A A3315467A A3315479A A3307747A A3307765A A3307750A F27017652 F27017651 F27011556 F27011550 F27011551 F27017551 F27011250 F27011451 F27011351 F27017270
Green Red Amber/Green Red Red Red Red
Green Amber Amber Green Amber/Green
XR-U300RDS XR-U301RDS XR-U330 XR-U330 XR-U331 XR-U401RDS XR-U440RDS XR-U551RDS XR-U661RDS XR-U700RDS
6. Front Panels: CD Player
CDX-2500R CDX-2500R CDX-3000 CDX-3002 CDX-3100 CDX-3100 CDX-3103 CDX-3150 CDX-3150 CDX-3160 CDX-3250 CDX-3250 CDX-3900R CDX-4000R CDX-4000RV CDX-4000RX CDX-4100RDS CDX-4100RDS CDX-4150RDS CDX-4180RV CDX-4240R CDX-4250R CDX-4250R CDX-4260 CDX-4270R CDX-5032 CDX-5060 CDX-5070 CDX-5070 CDX-5072 CDX-5090 CDX-5090 CDX-5100RDS CDX-5180 CDX-5181 CDX-5270 CDX-5272 CDX-5290RDS
A3301968A A3301969A F36220355 F36220455 F27137055 F27137075 F27137058 F36221255 F36221276 F36221155 A3301725A A3301777A A3315025A A3315026A A3315030A A3315029A F27136355 F27802055 F36220655 A3301651A A3301728A A3301726A A3301727A A3301929A A3301928A F27134070 F14159551 F27131152 F27131151 F27131170 F27132750 F27132751 F27136255 F27001850 F27001851 F27131250 F27131270 F27133150

Amber Green Green Amber Amber Green Amber Amber Green Amber/Green Red Red Green Amber

Green Amber Green Green

CDX-5460RDS CDX-600DSP CDX-900RDS CDX-C470X CDX-C4840R CDX-C4850R CDX-C4900R
F14159370 F27131370 F14159070 A3337105A A3301731A A3301730A A3315028A F27133355 A3315027A A3315032A A3315031A F36222570 F36225458 F36225358 A3301746A A3307345A F27137650 A3301744A F36222370 F36227550 A3301825A A3315088A F27137450 F36222270 F36227650 A3301914A A3301656A F36222150 A3337073A A3337074A A3337075A A3337076A A3337077A

Amber/Green

CDX-C490RDS CDX-C5000R CDX-C5000RV CDX-C5000RX CDX-C560RDS CDX-C570R CDX-C580R CDX-C5850R CDX-C5850RW CDX-C610RDS CDX-C6850R CDX-C760RDS CDX-C780R CDX-C7850R CDX-C8000RX CDX-C810DSP CDX-C860RDS CDX-C880R CDX-C8850R CDX-C90R CDX-C910RDS CDX-CA400 CDX-CA530X CDX-CA580 CDX-CA600 CDX-CA600

Amber Green Red

Green Red Red Amber/Green Red
CDX-CA650 CDX-CA650V CDX-CA650X CDX-CA700 CDX-CA700X CDX-CA700X CDX-CA750 CDX-CA750X CDX-CA850 CDX-CA900 CDX-CA900X CDX-L350 CDX-L360 CDX-L360 CDX-L400X CDX-L410 CDX-L410 CDX-L420V CDX-L450 CDX-L450X CDX-L550 CDX-L550V CDX-L550X CDX-L600X CDX-M730 CDX-M770 CDX-MP30 CDX-MP30 CDX-MP30X CDX-MP70 CDX-MP70 CDX-U6180RDS CDX-U8001RDS
A3307775A A3307780A A3307777A A3337021A A3337023A A3337052A A3307828A A3307831A A3307872A A3290857A A3290866A A3307745A A3307748A A3307742A A3307998A A3337001A A3307999A A3337003A A3315311A A3307929A A3307773A A3307771A A3307769A A3337014A A3315515A A3315362A A3290928A A3290933A A3315778A A3337058A A3290880A F27130070 F27001551
Amber/Green Red Red Amber/Green Red Amber/Green Red Red Red Red W. Yellow Amber Green Red Green Amber Blue Amber/Green Amber/Green Red Red Red

Red Red Red Red

7. Front Panels: MD Player
F27100950 F27100870 F27101770 A3301828A A3301824A A3301827A A3315051A A3315004A A3315049A F27105250 F27105150 A3301920A A3315149A A3315094A A3220670A A3301906A A3315308A A3307807A A3315272A A3315276A
Discontinued MDX-100RDS(AE) MDX-400RDS MDX-C150RDS MDX-C5960R MDX-C5970R MDX-C5970R/1 MDX-C6400R MDX-C6500R MDX-C6500RX MDX-C7890R MDX-C7900 MDX-C7970R MDX-C800REC MDX-C8500R MDX-C8900R MDX-C8970R MDX-CA580 MDX-CA580/1 MDX-CA680 MDX-CA680X

Only green display

8. Others
MDX-U1RDS XK-R100RDS XTC-102 XTC-C200RDS XTC-C200RDS XTC-U201RDS
F27100370 F11972670 F27000870 F27144150 F27144180 F27001951