Basic Troubleshooting and Service Information

TABLE OF CONTENTS

Safety Denitions.... ii General Safety Precautions.... 1 General Information.... 2 Reviewing The Engine ID Label.... 3 Model Numbering Identication for TecumsehPower's Full Engine Line.. 4 Spark Plug Replacement (4-Cycle).... 5 Spark Plug Replacement (2-Cycle and Europa)... 6 Fuel Recommendations....7-8 TecumsehPower 4-Cycle Lubrication Requirements... 9 4-Cycle Troubleshooting.... 10-11 TecumsehPower 2-Cycle Engine Oil Requirements... 12 2-Cycle Troubleshooting....13-14 4-Cycle Cross Reference for Specication-To-Model Number Designation (Vertical Engines). 15 4-Cycle Cross Reference for Specication-To-Model Number Designation (Horizontal Engines). 16 2-Cycle Cross Reference for Specication-To-Model Number Designation (Vertical and Horizontal Engines).... 16 Repair Manuals.....17
2005, 2009 TecumsehPower Company. All Rights Reserved
The information in this guide is intended to assist individuals who are knowledgeable in basic engine repair and maintenance. If you are unfamiliar with two and four cycle engine operation and maintenance, DO NOT attempt any maintenance or repairs. Contact your local TecumsehPower Servicing Dealer for assistance.
IMPORTANT NOTICE! Safety Denitions
Statements in this manual preceded by the following words and graphics are of special signicance:
TecumsehPower Contact Information
For engine adjustments, repairs or warranty service, contact your nearest Authorized TecumsehPower Servicing Dealer. Find them on our website at www. TecumsehPower.com or call TecumsehPower at 1-800558-5402 or 262-377-2700 if you are located outside the U.S.

WARNING

WARNING indicates a potentially hazardous situation which if not avoided, could result in death or serious injury. NOTE Refers to important information and is placed in italic type. It is recommended that you take special notice of all items discussed on the next two pages and wear the appropriate safety equipment. Before operating an engine it is your responsibility to read the Operators Manual. Follow these basic rules for your personal safety: Keep this manual handy at all times for future reference. Read it carefully and familiarize yourself with operating, maintenance, components and safety instructions.
Notice Regarding Emissions
Engines which are certied to comply with California and U.S. EPA emission regulations for SORE (Small Off Road Equipment), are certied to operate on regular unleaded gasoline, and may include the following emission control systems: (EM) Engine Modication and (TWC) ThreeWay Catalyst (if so equipped).
General Safety Precautions A. Avoid Carbon Monoxide Poisoning
All engine exhaust contains carbon monoxide, a deadly gas. Breathing carbon monoxide can cause headaches, dizziness, drowsiness, nausea, confusion and eventually death.
to store and dispense fuel. TecumsehPower recommends purchasing gasoline in containers with a capacity of 2.5 gallons or less. Small containers are easier to handle and help eliminate spillage during refueling. DO NOT pour fuel from engine or siphon fuel by mouth.
C. Adult Supervision of Operation, Refueling and Maintenance
Not everyone who is allowed to use an engine is capable of safely and responsibly operating, maintaining and/or fueling it. TecumsehPower recommends the following: An adult should fuel the engine. NEVER allow children to refuel an engine. An adult should perform maintenance on an engine. Only allow children to perform maintenance if an adult has determined they are experienced and capable of such operation. An adult should start the engine. Only allow children to start the engine if an adult has determined they are experienced and capable of such operation. To avoid unsupervised operation of the engine, especially by children, NEVER leave it unattended when it is running.
Carbon monoxide is a colorless, odorless, tasteless gas which may be present even if you do not see or smell any engine exhaust. Deadly levels of carbon monoxide can collect rapidly and you can quickly be overcome and unable to save yourself. Also, deadly levels of carbon monoxide can linger for hours or days in enclosed or poorly-ventilated areas. If you experience any symptoms of carbon monoxide poisoning, leave the area immediately, get fresh air, and SEEK MEDICAL TREATMENT. To prevent serious injury or death from carbon monoxide: NEVER run engine indoors. Even if you try to ventilate engine exhaust with fans or open windows and doors, carbon monoxide can rapidly reach dangerous levels. NEVER run engine in poorly-ventilated or partially enclosed areas such as barns, garages, basements, carports, under dwellings, or in pits. NEVER run engine outdoors where engine exhaust can be drawn into a building through openings such as windows and doors.

D. Stay Away from Rotating Parts
NEVER operate an engine with an unguarded engine shaft. The equipment manufacturer may attach a sprocket and chain or pulley and belt to the engine shaft. If these parts are not properly guarded, or if you are not sure whether they are properly guarded, DO NOT use your engine; contact the equipment manufacturer. Hands, feet, hair, jewelry, clothing, etc. can become entangled in rotating parts, leading to serious injury or death. To avoid serious injury or death, be sure the ywheel guard is in place.

B. Avoid Gasoline Fires

Gasoline (fuel) vapors are highly ammable and can explode. Fuel vapors can spread and be ignited by a spark or ame many feet away from engine. To prevent injury or death from fuel res, follow these instructions: NEVER store engine with fuel in fuel tank inside a building with potential sources of ignition such as hot water and space heaters, clothes dryers, electric motors, etc. NEVER remove fuel cap or add fuel when engine is running. NEVER start or operate the engine with fuel ll cap removed. Allow engine to cool before refueling. NEVER ll fuel tank indoors. Fill fuel tank outdoors in a well-ventilated area. DO NOT smoke while refueling tank. Use only an approved red GASOLINE container

General Information

The following information is being provided to assist you in locating and recording your engine model and specication numbers. This information will be needed to use this book or obtain parts from a local TecumsehPower dealer.
Model Numbering System for TecumsehPowers Full Engine Line Prior to 2004 Production
LOCATING AND READING ENGINE MODEL AND SPECIFICATION
THE FOLLOWING WILL BE NEEDED TO LOCATE PARTS FOR YOUR ENGINE.
Model TVM195 Specication 150288G (DOM) 8150C

ENGINE:

ENGINE MODEL

TVM195

150288G

SPEC NO.

Typical Engine I.D. Label
THIS ENGINE MEETS 1995-1998 CALIF/US EPA PH1 APPLICABLE EMISSION REGULATIONS FOR ULGE ENGINES FUEL REGULAR UNLEADED OIL SAE 30

Tecumseh Power Company

TVM195 150288G (E) STP318U1G2EA C
ENGINE MODEL NUMBER LOCATED UNDER COVER
ENGINE MODEL NUMBER LOCATIONS
Model Numbering System for Current TecumsehPowers Full Engine Line
Reviewing The Engine ID Label
Effective with the 2004 Model Year, we have changes to the engine I.D. label on our products. The following pages will explain the information contained on the label dependent on the age of your product.

Specication Number

The numbers following the model number make up the specication number. Using model LV195EA-361541B, as an example, interpretation is as follows: LV195EA-361541B is the model and specification number.

L V 195 E A - 361541B

Warranty Code Is the specication number used for properly identifying the parts of the engine Indicates a standard power conguration Indicates EPA/CARB compliant Indicates a 195 cc displacement Indicates a vertical shaft conguration Indicates an L-Head, side valve conguration

Date of Manufacture

The Date of Manufacture (D.O.M.) indicates the production date. For this example, 03188BC0010 is the D.O.M. (Date of Manufacture). Day of Year Mfg 188th Facility Individual Serial # 10th unit built
Typical Engine I.D. Label Locations

Year 2003

Assembly Line / Shift
Model Numbering Identication for TecumsehPowers Full Engine Line
(effective 2004 production)

CURRENT CODE

1st Space - Valve Orientation
T = Two Cycle O = Overhead Valve L = L-Head
Prior to 2004 Model Number Conversion Chart 4-Cycle
LEV90 LEV120 HSSK50 HSSK55 VSK90 OHV135 OHV180 TVT691 VTX691 LV148EA LV195EA LH195SA LH195SP LV148SA OV358EA OV490EA OV691EA OV691EP OHH60 OHH65 OHSK70 OHSK75 HMSK90 HMSK110 OHSK110 OHSK130 OHM110 OH195EA OH195EP OH195SA OH195SP LH318SA LH358SA OH318SA OH358SA OH318EA
2nd Space - Crank Orientation
V = Vertical H = Horizontal M = Multi-position
3rd, 4th and 5th Space - Displacement 6th Space - Emissions Class
E = 50 State/Global Emissions Compliant X = Not for sale in California, except exempt applications S = Snow Emission Compliant

2-Cycle

TC300 HSK870 HSK600 AV520 TM049XA TH139SP TH098SA TV085XA
7th Space - Engine Specics
A = Standard (OHH50-60), (OHSK50-70) P = Power Up (OHH65-70, OHSK75-775)

4-Cycle

ECH ECV HHH HHM -
HM HMSK HMXL HS HSSK HXL LAV LEV LH LV OH OHH OH195 OHM OHSK OHV OV OVM -
Exclusive Craftsman Horizontal Exclusive Craftsman Vertical Horizontal Shaft Horizontal Heavy Duty (Cast Iron) Horizontal Heavy Duty (Cast Iron) (Medium Frame) Horizontal Medium Frame Horizontal Medium Frame (Snow King) Horizontal Medium Frame (Extra Life) Horizontal Small Frame Horizontal Small Frame (Snow King) Horizontal (Extra Life) Lightweight Aluminum Frame Vertical Low Emissions Vertical L-Head Horizontal L-Head Vertical Overhead Valve Heavy Duty (Cast Iron) Overhead Valve Horizontal Overhead Valve Horizontal (195 cc's) Overhead Valve Heavy Duty Horizontal (Medium Frame) Overhead Valve Horizontal (Snow King) Overhead Valve Vertical (Medium Frame) Overhead Valve Vertical Overhead Valve Vertical (Medium Frame) 4

OVRM OVXL TNT TVEM TVM TVS TVT TVXL VVH VLV VLXL VM VSK VTX -
Overhead Valve Vertical (Small Frame) (Rotary Mower) Overhead Valve Vertical (Medium Frame) (Extra Life) Toro N TecumsehPower (Toro Exclusive Series) TecumsehPower Vertical European Model TecumsehPower Vertical (Medium Frame) (Replaces V & VM) TecumsehPower Vertical Styled TecumsehPower Vertical Twin TecumsehPower Vertical (Extra Life) Vertical Shaft Vertical Heavy Duty (Cast Iron) Vector Lightweight Vertical Vector Lightweight Vertical (Extra Life) Vertical Shaft (Medium Frame) Vertical Snow King Vertical Twin Two Cycle Horizontal Shaft Two Cycle Multiposition Operation Two Cycle Vertical Shaft

TH TM TV -

Spark Plug Replacement
NOTE: Only models which will continue to be manufactured long term will have an updated Model designation.

4-CYCLE SPARK PLUG

Service Number 35395

RJ19LM

ECV100-120 HMSK70, LH318SA (HMSK80), HMSK90 HSK30-70 HSSK40, LH195SA (HSSK50), LH195SP (HSSK55) LH358SA (HMSK100), HMSK110 LEV80, LV148EA (LEV90), LV195EA (LEV120) LV148SA (VSK90), VSK100 TNT100 TNT120 TVS75-120 TVXL90-120

Service Number 33636

RJ17LM
H30-80 HM70-100 HS40-50 TVM195-220 TVXL195-220 VLV-all

Service Number 34277

H22 H25 HH40-120 HHM80 HMXL70 HT30 HT35 HXL35 LAV25-50 TVM125-170 V40-80 VH40-100 VM70-100

Service Number 34645

OH318EA (OHM90-110) OHM120 OH195EA (OHH60), OH195EP (OHH65) OHH/OHSK40-130 OH195SA (OHSK70), OH195SP (OHSK75) OH318SA (OHSK110), OH358SA (OHSK120-130) OH180 OV195EA OV358EA (OHV110-135), OV490EA (OHV140-180) OV691EP (VTX691, TVT691) OVM120 * OVXL120 * OVXL/C120 * OVXL125 OV195

Service Number 35552

HH140-160 OH120-160
THE SERVICE NUMBERS LISTED BELOW WILL GIVE CORRESPONDING CHAMPION AND AUTOLITE SUBSTITUTIONS. Champion RJ19LM RL82C RL86C RN4C RJ17LM RJ8C Autolite NA 304

33636 34277

Note: * OVXL models with specication nos. below 202700 use RL86C.
OHM120 models with specication nos. below 224000 use RL86C. OHSK110 - 130 models with specication nos. below 223000 use RL86C.
SPARK PLUG AIR GAP ON ALL MODELS IS.030 (.762 mm)

Service Number 34046

OHM120 OH318SA (OHSK110), OH358SA (OHSK120-130) OVM120 * OVXL120 * OVXL/C120 * OVXL125
Note: * OVXL models with specication nos. 202700, 203000 and up, use RN4C.

3/8" 9.525 mm

1/2" 12.700 mm

3/4" 19.050 mm

OHM120 models with specication nos. 224000 and up, use RN4C. OHSK110, OHSK120-130 models with specication nos. 223000 and up, use RN4C.
NOTE: Not all spark plugs have the same heat range or reach. Using an incorrect spark plug can cause severe engine damage or poor performance. TecumsehPower uses all three of the reaches shown.

FOR TWO CYCLE INFORMATION REFER TO NEXT PAGE.
Note: If you need assistance locating your engine model numbers please check page 3 or 4.

2-CYCLE SPARK PLUG

Service Number 611100

TC300 TCH300 TM049XA

AV600 AV520 TVS600 TV085XA

TVS840 TVXL840

Service Number 611049
AH520 AH600 HSK840 HXL840 TC200 TCH200 Type 1500 TH098SA HSK600 HSK635 TH139SA HSK845, 850 TH139SP HSK870
EUROPA MODELS 4-CYCLE SPARK PLUG
LAV Legend Premier 153/173 Prisma Spectra Synergy Vantage
Geotec OHV Premier 45/55 Synergy OHV
All Horizontal Models BV BVL BVS Centura Futura HTL

Centrua OHV Futura OHV

MV100S TVS600

AV85/125 AV520/600

THE SERVICE NUMBERS LISTED BELOW WILL GIVE CORRESPONDING CHAMPION AND AUTOLITE SUBSTITUTIONS. Champion RJ19LM RJ17LM RCJ-6Y RCJ-8Y Autolite NA 2976
1/2" 3/4" 3/8" 9.525 mm 12.700 mm 19.050 mm
Todays fuels have a short shelf life and it is recommended you buy no more than a two week supply at a time. GASOLINE TecumsehPower strongly recommends the use of fresh, clean, unleaded regular gasoline in all TecumsehPower engines. Unleaded gasoline burns cleaner, extends engine life, and promotes good starting by reducing the build-up of combustion chamber deposits. Leaded gasoline, gasohol containing no more than 10% ethanol, premium gasoline, or unleaded gasoline containing no more than 15% MTBE (Methyl Tertiary Butyl Ether), 15% ETBE (Ethyl Tertiary Butyl Ether) or 10% ethanol, can be used if unleaded regular gasoline is not available. Reformulated gasoline that is now required in several areas of the United States is also acceptable. NEVER USE gasoline, fuel conditioners, additives or stabilizers containing methanol, gasohol containing more than 10% ethanol, unleaded regular gasoline containing more than 15% MTBE (Methyl Tertiary Butyl Ether), 15% ETBE (Ethyl Tertiary Butyl Ether) or 10% ethanol, gasoline additives, or white gas because engine/fuel system damage could result. SPECIALTY FUELS Fuels being marketed for use on small engines can have a signicant effect on starting and engine performance. Prior to using any specialty fuel, the Reid Vapor Pressure (RVP) must be determined. Fuels with a rating of less than 50kPa (7psi) should not be used in summer, and fuel with a rating of 85kPa (12psi) should not be used during winter. SHORT TERM STORAGE
WARNING NEVER store the engine with fuel in the fuel tank inside a building with potential sources

Fuel Recommendations

of ignition such as hot water and space heaters, clothes dryers, electric motors, etc.

If engine fuel stored in the gas tank and/or an approved gas container is to be unused without gasoline stabilizer for more than 15-30 days, prepare it for short term/seasonal storage. TecumsehPower recommends using ULTRA-FRESH or Fuel Saver Plus Gasoline Stabilizer plus Fuel System Cleaner as an acceptable method of minimizing formation of fuel gum deposits during storage. This product is available from your Authorized TecumsehPower Servicing Dealer. Always follow mix ratio found on stabilizer container. Failure to do so may result in equipment damage. It is not necessary to drain stabilized gas from carburetor.
FUEL TREATMENT 1. Add fuel stabilizer according to manufacturers instructions. 2. Run engine at least 10 minutes after adding stabilizer to allow it to reach carburetor. 3. Instead of using a fuel preservative/stabilizer, you can empty the fuel tank as described under "Extended Storage.
Fuel Recommendations - continued
NOTES Clean debris from engine before draining fuel from carburetor. If you have prepared your fuel for short term storage it is not necessary to drain fuel that contains stabilizer from your carburetor. To avoid severe injury or death, DO NOT pour fuel from engine or siphon fuel by mouth. 1. To prevent serious injury from fuel res, empty fuel tank by running engine until it stops from lack of fuel. DO NOT attempt to pour fuel from engine. 2. Run the engine while waiting until the remaining fuel is consumed. NEVER leave the engine unattended when it is running and NEVER run engine in enclosed areas. FUEL ADDITIVES Only fuel additives such as TecumsehPowers fuel stabilizer Part No. 730245A or liquid varieties can be used when mixed properly. For winter applications, Isopropyl alcohol fuel dryers may be used in the fuel system but must be mixed at the proper ratio recommended by the manufacturer. NEVER USE METHANOL BASED FUEL DRYERS. EXTENDED STORAGE
TECUMSEHPOWER 4-CYCLE LUBRICATION
TecumsehPower recommends the use of a high quality, brand name oil with a minimum classication of SL/SJ. Very few air cooled engines have any type of oil ltration system, making regular oil changes critical to remove impurities from the engine and maximize engine life. Consult the operator's or repair manual for the oil change interval and viscosity based on equipment operating temperature.
shown with model names prior to 2004
CLASSIFICATIONS: SL/SJ" DO NOT USE 10W40 CAPACITIES: Engine Model ml All LAV, TVS, LEV, OVRM.. 630 ECV, TNT... 630 V & VH50-70... 810 TVM 125, 140... 810 TVM 170-220.. 960 VM70-100, HHM80.. 960 VH100... 1500 All VLV.. 810 VSK90-100.. 630 OVM120, OVXL120, 125.. 960 OHV11-13 Without Filter.. 960 OHV11-13 With Filter...1170 OHV13.5-17 With Filter.. 1800 OHV13.5-17 Without Filter.. 1650 TVT691 With Filter.. 2150 TVT691 Without Filter.. 1950 H, HSK30-35... 630 HS, HSSK40-50.. 630 H, HH, HSK50-70.. 570 OHH/OHSK50-70.. 630 HMSK, HM70-100.. 720 OHSK80-100.. 720 OHM120, OHSK110*-130.. 840 HH100,120, OH120-180.. 1560

TecumsehPower 4-CYCLE ENGINE OIL
shown with model names 2004 production and later
ml 1950 Engine Model LH195SA, LH195SP LH318SA, LH358SA LV148EA, LV148SA LV195EA OH195EA, OH195EP OH195SA, OH195SP OH318EA OH358SA OV195EA OV358EA With Filter OV358EA Without Filter OV490EA With Filter OV490EA Without Filter OV691EA With Filter OV691EA Without Filter OV691EP With Filter OV691EP Without Filter Oz. 64

Oz. 28 52

EUROPA MODELS *

VERTICALS

Vantage Prisma Synergy Synergy "55" Spectra Futura HTL BVS 630 630
*NOTE: Model OHSK110 with a spec. of 221000 and up, have a capacity of 26 oz. (720 ml).
BH Series Geotec Series 35-50

HORIZONTALS

NOTE: Vertical shaft engines with auxiliary PTO: 26 oz. (700 ml).
Four Cycle Troubleshooting

Preparation

The following is provided as a basic troubleshooting guide. Its use requires a complete review of all conditions and symptoms. Always examine the exterior for clues: leaks, excessive dirt, or obvious damage. Some repairs will require the assistance of a TecumsehPower Servicing Dealer. Before troubleshooting any system problem, see original equipment manufacturers (O.E.M.) instructions. Make your troubleshooting easier by preparing as follows: Work in a clean, well-lighted place. Keep proper tools and materials nearby. Keep an adequate supply of clean petroleum-based solvent. To reduce the risk of serious injury or death from res and/or explosions, NEVER use ammable solvents (e.g., gasoline) to clean serviceable parts. Use a water-based, non-ammable solvent such as TecumsehPower Degreaser Cleaner. CAUTION NEVER use compressed air to clean debris from yourself or your clothing. When using compressed air to clean or dry serviceable parts: Air pressure must not exceed 30psi (206kPa). Shield yourself and bystanders from ying debris.
Wear appropriate eye protection. Use only approved air blow nozzles.

FUEL SYSTEM

Engine Will Not Start
Check if spark plug is wet or dry Wet Dry
Defective spark plug Use Tester 670366
Review with the customer proper priming procedure (3-5 primes, waiting 2 seconds between each prime)
If equipped with a choke, check for full travel. Check throttle cable and control for proper adjustment. Check fuel supply and fuel cap vent Restriction in fuel system (lter) Carburetion problem* (bad bowl gasket) Poor Compression

Restricted air lter

Improper or stale fuel Exhaust ports plugged Carburetion problems due to ooding, over priming, etc.* Ignition System
Should more extensive repair be needed, we recommend you contact a local TecumsehPower Servicing Dealer for repair. Repair manuals are also available from your local dealer or direct from www.TecumsehPower.com. A complete list of the available manuals can be found at the end of this book. NOTE: Refer to Technician's Handbook for a more detailed list of remedies. 10
Four Cycle Troubleshooting - continued
To reduce the risk of serious injury or death from res and/or explosions, NEVER use ammable solvents (e.g., gasoline) to clean serviceable parts. Use a water-based, non-ammable solvent such as TecumsehPower Degreaser Cleaner. CAUTION NEVER use compressed air to clean debris from yourself or your clothing. When using compressed air to clean or dry serviceable parts: Air pressure must not exceed 30psi (206kPa). Shield yourself and bystanders from ying debris.

IGNITION SYSTEM

Check for Spark

Spark No Spark

Check ywheel for correct key, damaged or sheared key Set proper air gap on external coil

Replace spark plug

Isolate engine from all equipment (disconnect wiring harness), repeat test
Set proper point gap, check condensor and timing Test coil for intermittent or weak spark
Equipment problem, check switches, wiring and equipment controls Parasitic load too high
Engine problem, check for shorts or grounds in wiring Test ignition module
Should more extensive repair be needed, we recommend you contact a local TecumsehPower Servicing Dealer for repair. Repair manuals are also available from your local dealer or direct from www.TecumsehPower.com. A complete list of the available manuals can be found at the end of this book. NOTE: Refer to Technician's Handbook for a more detailed list of remedies. 11
TECUMSEHPOWER 2-CYCLE ENGINE OIL
The proper type and ratio of 2-cycle oil is critical to long life and low maintenance of the engine. The use of non-certied oils and improper mix ratios can cause severe engine damage and possibly void warranty consideration. The following is a list of 2-cycle engine oil classications which are certied for use in TecumsehPower 2-cycle engines: National Marine Manufactures Association, (NMMA), TC-WII or TC-W3 American Petroleum Institute, (API), TC Japanese Automobile Standard Organization, (JASO), FB or FC
TWO-CYCLE FUEL/OIL MIX RATIOS 24:1
AV520 Types 670 & 653, TV085 TV085XA (AV600 Type 600-10 & Up) TC200, TCH200, TCH300 TM049XA (TC300) MV100S

TVS600 ALL TYPES AH600

TVS / TVXL HSK840 - 870 - TH139 HSK600 - 635 - TH098
Sears/Craftsman 40:1 2-Cycle Oil has been tested and approved for use in all engines, EXCEPT the TC / TM Models which require a 24:1 Ratio.

SYNTHETIC BLEND

ENGINE OIL WITH FUEL STABILIZER PART NO. 730227D
TecumsehPower 2-CYCLE ENGINE OIL may be used in a variety of 2-cycle engines including: outboards, lawnmowers, snow-blower, string trimmers, and edgers at any fuel/oil mixing ratio up to 50:1. Superior Lubricity Extends engine life by reducing wear Longer Spark Plug life through reduced fouling Reduces Carbon Build-Up extending required service intervals Helps maintain emissions compliance which helps our environment Contains Fuel Stabilizer-Extends fuel life and protects fuel system
32:1 U.S. Gasoline 24:Gallon 2 Gallons 5 Gallons 1 Gallon 2 Gallons 5 Gallons 50:Gallon 2 Gallons 5 Gallons

2-CYCLE

ENGINE FUEL MIX
U.S. Amount of Oil To Be Added 5 oz. 11 oz. 27 oz. 4 oz. 8 oz. 20 oz. 2.5 oz. 5 oz. 13 oz. METRIC Petrol 4 Liters 8 Liters 20 Liters 4 Liters 8 Liters 20 Liters 4 Liters 8 Liters 20 Liters METRIC Amount of Oil To Be Added 167 ml 333 ml 833 ml 125 ml 250 ml 625 ml 80 ml 160 ml 400 ml
Two Cycle Troubleshooting
Check if spark plug is wet or dry
Wet Dry Review with customer priming or choking procedure (3-5 primes, if equipped, waiting 2 seconds between each prime) If equipped with a choke, check for full travel. Check throttle cable and control for proper adjustment. Carburetion problem* (bad bowl gasket) Check fuel supply and fuel cap vent Restriction in fuel system (lter, screen) Poor compression Damaged reed, port plugs, seals or gaskets

Defective spark plug

Improper fuel mix or stale fuel Sheared or partially sheared ywheel key Carburetion problems due to ooding, over priming, etc.* Ignition System Crankcase seals or gaskets leaking
Should more extensive repair be needed, we recommend you contact a local TecumsehPower Servicing Dealer for repair. Repair manuals are also available from your local dealer or direct from www.TecumsehPower.com. A complete list of the available manuals can be found at the end of this book. NOTE: Refer to Technician's Handbook for a more detailed list of remedies. 13
Two Cycle Troubleshooting - continued
Check ywheel for correct key, damaged key or key adaptor Set proper air gap on external coil
Set proper point gap, check condensor and timing (if equipped) Test coil for intermittent or weak spark Check electric starter if applicable

Should more extensive repair be needed, we recommend you contact a local TecumsehPower Servicing Dealer for repair. Repair manuals are also available from your local dealer or direct from www.TecumsehPower.com. A complete list of the available manuals can be found at the end of this book. NOTE: Refer to Technician's Handbook for a more detailed list of remedies. 14
Cross Reference for Specication - To - Model Number Designation
This cross reference chart allows you to determine an engine Model Number if you only have the Specication Number. VERTICAL 4-CYCLE ENGINES
Specication Number Series Model Number TNT100 TNT120 LAV25, OVRM55 OVRM105 OVRM60 OVRM60 OVRM65, OVRM120 OV195EA (RM) OV195EA (Utility) LAV30 TVS75 LAV35 OVRM905 (Sears Only) OVRM40, OVRM45 (Premier Engine) OVRM40 (High Tech Look) TVS90 TVS90 (Premier Engine) TVS90, TVXL90 TVS90 (High Tech Look) TVS100 TVS100 (Premier Engine) TVS100 TVS90, TVXL90 TVS90 TVS90 V40 LAV40 OVRM50, OVRM55 (Premier Engine) OVRM50, OVRM55 OVRM50, OVRM55 (High Tech Look) TVS105 TVS105 (Premier Engine) TVS105 TVS105 (High Tech Look) TVXL105 TVS105, TVS & TVXL115 TVS105, TVS115 (Premier Engine) TVS115 TVS105, TVS115 (High Tech Look) TVS & TVXL115 TVS115 (Premier Engine) TVS115 TVS115 (High Tech Look) V50, TVM125 TVS & TVXL115 TVS & TVXL115 TVS115 TVS115 LAV50 LAV50 & TVS115 TVS120 TVS120, TVEM120 TVS120 (Premier Engine) TVS120 (High Tech Look) TVS120 TVS120 V60, TVM140 VH40 VH50 VH60 V70 VM70, TVM170 TVXL170 VH70 Specication Number Series Model Number ECV100 ECV105 VH80 VH100 V & VM80, TVM195 TVM & TVXL195 TVM195 ECV110, TVM195 TVM220 ECV120 VM100, TVM220 TVM & TVXL220 TVM220 OVM120 OVXL120, OVXL125 OVXL120 (I/C) OHV11, OHV115 OVXL125 OHV115 OVXL125 (I/C) OHV12, OVXL120 (Tec.1200) OHV125, OVXL125 (Tec1250) OHV13 OVXL125 (Tec.1250I/C), OHV13/135 OHV14/140 OHV145 OHV15/150 OHV16/160 OHV165 OHV155 OHV17/170 OHV175 OHV110 OHV115 OHV120 OHV125 OHV130 OHV135,OV358EA (Sm. Enduro) OHV180,OV490EA (Lg. Enduro) LEV90, LV148EA VSK90, LV148SA LEV100 LEV100 VSK100 LEV100 LEV100 LEV105 LEV105 VSK105 LEV115 LEV115 LEV115 LEV120 VSK120 LEV120, LV195EA (Utility) LEV120, LV195EA (RM) VLV40 ULT, VLV B24, VLXL50, & VLV126 ULT, VLV, VLXL55, & VLV126 ULT, VLV60, VLV65, & VLV126 VLV65, VLV66 TVT691 TVT691, OV691EA (Twin) VTX691, OV691EP (Twin)
This cross reference chart allows you to determine an engine Model Number if you only have the Specication Number. HORIZONTAL 4-CYCLE ENGINES

Specication Number Series 115000 Model Number H22 H25 OHH45 H30 HSK30 H30 H30 H & HT35 HSK35 H35 H35 HXL35 H40 HS & HSSK40 HSK40 H40 H40 HSSK40 H50 HSK50 HS & HSSK50, LH195SA HSSK55, LH195SP OHH50 OHSK50 OHH55 OHSK55 OHH60, OH195EA OHSK60 OHH65 OHH65, OH195EP OHSK65 OHH70 OHSK70, OH195SA (Premium) OHSK75, OH195SP (Premium) H60 HSK60 HH40 HH50 HH60 HH80 HH100 Specication Number Series Model Number HH120 H70 HSK70 HM & HMSK70 HMXL70 HH70 ECH90 H & HM80 HMSK80 HM85 HM & HMSK85 HM90 HMSK90, LH318SA HM & HMSK100, LH358SA HMSK105 HMSK110 HH & OH140 HH150 & 160 OH160 OH120 OH180 HHM80 OHM120 OHSK110 OHSK80 OHSK90 OHSK100 OHSK110 OHSK115, OH318SA (Premium) OHSK120 OHM90 OHM100 OHM110, OH318EA OHSK90 OHSK110 OHSK120 OHSK125 OHSK130, OH358SA (Premium)

VERTICAL 2-CYCLE ENGINES

Specication Number Series Model Number TC300, TM049XA AV520, TV085XA
HORIZONTAL 2-CYCLE ENGINES
Specication Number Series 8700 Model Number HSK635, TH098SA HSK850, TH139SA HSK870, TH139SP

Repair Manuals

Service Number 740043 or 695244A
Service Number 740049 or 692509
ECV100-120 HMSK70, LH318SA (HMSK80), HMSK90, H22 H25 H30-80 HM70-100 HH40-120 HHM80 HMXL70 HT30 HT35 HXL35 HS40-50 HSK30-70 HSSK40, LH195SA (HSSK50), LH195SP (HSSK55) LH358SA (HMSK100), HMSK110 LAV25-50 LEV80, LV148EA (LEV90), LV195EA (LEV120) LV148SA (VSK90), VSK100 TNT100 TNT120 TVS75-120 TVXL90-120 TVM125-170 TVM195-220 TVXL195-220 V40-80 VH40-100 VM70-100 VLV-ALL
OHM120 OH318SA (OHSK110), OH358SA (OHSK120-130) OH318EA (OHM90-110) OHM120 OH195EA (OHH60), OH195EP (OHH65) OHH/OHSK40-130 OH195SA (OHSK70), OH195SP (OHSK75) OH318SA (OHSK110), OH358SA (OHSK120-130) OVM120 OVXL120, OVXL/C120 OVXL125 OV195EA OV358EA (OHV110-135) OV490EA (OHV140-180) OV691EP (VTX691, TVT691) OVM120 OVXL120 OVXL/C120 OVXL125

Service Number 691462A

HH140-160 OH120-180
Service Number 740047 or 692508
AH520 AH600 HSK840 HXL840 TC200 TCH200 Type 1500 TH098SA (HSK600), HSK635 TH139SA (HSK845, 850) TH139SP (HSK870) AV600 TV085XA (AV520) TVS600

Service Number 694988

Service Number 694782

TCH300 TM049XA (TC300)

TecumsehPower Company 900 North Street Grafton, Wisconsin 53024 1-800-558-5402

Form No. 696533

Litho In U.S.A.

R 2/09