SERVICE
Whirlpool Europe Customer Services

AWE 6515

Service Information Toploader Washing machine AWE 6515
18050 Last Modication: 02/01/09
Spare Part List Exploded View Technical Data Wiring Diagram Circuit Diagram Program Chart Testprogram Error Codes
This document is only intended for qualied technicans who are aware of the respective safety regulations. Subject to modications

Whirlpool Europe

www.scc-service.com

Spare Part List

Pos No 12NC Description
18050, 02/01/09 page 2 of 24
Flap round GW Hinge ap GW Drip tray assy Door frame inner GW Frame Top+nozzle box KIT Foot Foot rear Front panel WH GW Side panel right GW Side panel left GW Rear panel Hinge bolt lid GW Counter weight Counter weight front Counter weight bottom Shock absorber Pin f. Shock absorber Damper f. Shock absorber Lid outer GW Lid inner GW Lid assembly WH GW Handle cpl. WH GW Door latch GW Door bellow Strap f. bellow Tub 4 x points Cover cpl. Drum soft op., 1000 Drum lifter Belt PV 1207 J4 EL Pulley 298 mm Gasket Control panel AWE 6515 Knob timer EBL WP25 Spring Knob timer Push button 4 Opt. Push button start/reset Push button option Motor MCA 45/64-148/ALB1 Interf.lter 1,00 F Holder RFI Pump,draining Heating element 2050W, 230V + NTC Cable mains 2m SA Strain relief Control unit DOMINO, basic C1 Control unit DOMINO, programmed Valve magnet 1 inlet, 2 outlets
18050, 02/01/09 page 3 of 24

Pos No 993 1

12NC 290 18025
Description Cover for top frame Pressostat 50/25 INVENS. Module E3/4 Opt. Door lock 3P ROLD Light guide PR.FLOW-FULL Light guide 4 Opt. Sensor NTC SC1,OMEGA3,DOMINO Hose inlet EN 11770 Reex Hose valve-dispenser Nozzle box cold cpl. Clamp f. nozzle box Siphon f. softener Clip soap dispenser Soap dispenser cpl. 3 ch. Chamber,air Drainhose Lock eco Filter set pump Hose draining Hose Pressostat Hose Air Exaust Cover of hose Gasket airtrap Clamp hose Clamp to pump Holder hose Clamp hose Clamp hose drain hose Screw,selftap 3,5x14SS Screw 4x14 Screw Screw PT 7x15 Screw M8x35 Nut Push in M 8 Washer Torsions spring Spring Bearing Kit Shaft seal Cover for Motor AC Spacer Cap Transport blocking Fixing mat.set front counter Fixing mat.set bottom Bow Clamp heatingelement

Exploded View

18050, 02/01/09 page 4 of 24
18050, 02/01/09 page 5 of 24

Technical Data

Dimensions + Weight
18050, 02/01/09 page 6 of 24
Product dimensions Height. 85 cm Width. 40 cm Depth.60 cm Weight net. 63 kg

Electrical base data

Voltage. 230 V 10% Frequency. 50 Hz Fuse. 10 A Power Consumption. ~2.3 kW

Drum data

Volume. 42 l Wash speed. 52 rpm Spinning max. 1000 rpm

Pressostat

Level1. 11 - 12/14 Overow. 11 - 16

Door lock

Kind of switch. Switch with PTC heater of bimetal Nominal voltage. 230 (90 - 264) V Locking time. 6 s Unlock time. 37 - 65 s

Inlet valve

Nominal voltage. 220 - 240 V / 50 Hz Rated ow. (1.5 - 5 bar). 8 l/min Pressure range. 0.3 - 10 bar Nominal resistance. (20 C). 3.8 k

Drain pump

Nominal voltage. 220 - 240 V / 50 Hz Total power. 26 W Resistor (coil). 224 Capacity. (0.55 - 1 m). l/min Position of draining hose outlet. 0.9 - 1.25 m

Heating element

18050, 02/01/09 page 7 of 24
Nominal voltage. 230 V + 10 %, -15 % Total power. 2050 W Resistance (20 C). 25 Leakage current. < 0.8 mA NTC sensor Resistance NTC 0 C 30 C 40 C 50 C 60 C 70 C 95 C 35.9 9.8 6.6 4.6 3.2 2.3 1.1 k k k k k k k
Resistance contacts. (20 C) Stator (full eld). 1.8 Rotor. 2.0 Tacho generator. 68.7

Control unit

Type. DOMINO Nominal voltage. 230 V - 240 V Frequency. 50 Hz Output control unit Motor Aquastop In pump step NTC Pump Doorlock Pressostat - empty - full Valve (Rast 2.5) Options M7.6 - DSS3.2 AQ2.2 - DSS3.2 AQ2.1 - DSS3.3 Not measurable DP2.1 - DP2.2 DSS3.1 - DSS3.3 E4 - E2 PR2.1 - E2 PR2.2 - E2 V2.1 - V2.2 Not measurable >40 V 230 V 230 V 230 V 230 V 230 V 230 V 230 V >170 V

SERVICE

Whirlpool Europe Customer Services

AWE 9725

Service Manual
Washing machine Toploader AWE 9725
Model Version AWE Technical data Spare part list Exploded view Wiring diagram Circuit diagram Program chart Text/Legend Family Page 2-5-- - 17 OMEGA
This documentation is only intended for qualied technicians who are aware of the respective safety regulations. Date: 07.11.2006 Subject to modication Document-No.: 26957
07.11.2006 / Page 2 Doc. No: 26957

AWE 972 10057

Whirlpool Europe Customer Service

Technical data

Dimensions Height Width Depth Weight Net weight With package Main Connection Voltage Frequency Power consumption Fuse rating Drum Door wide Volume Wash spin Speed spinning max. Capacity of dry laundry Cotton Cotton short Easy care Daily mixed Super rapid Delicate Handwash Wool Pressostat Kind of switch Type Nominal voltage Water Level Foam level (11 - 12, 14) Switching point Switching back point Overow (21 - 26) Nominal currents Contacts 11 - - - 16 2-level pressoswitch with overow contact B1-V 1.5 1.1 kg kg kg kg kg kg kg kg mm l rpm rpm ~2.V 10% Hz kW A ~62 ~64 kg kg 60 cm cm cm Door lock (5-pole) Type Nominal voltage Nominal current: Contact 4 - 5 Lock time Unlock time Heating element Kind of heating Nominal voltage Nominal power Resistance (20 C) Thermo-fuse (switch OFF temperature) Leakage current (<99 C) NTC sensor Resistance NTC: 0 C 30 C 40 C 50 C 60 C 70 C 95 C Inlet valve Kind of valve Water temperature Rated ow >1 bar Pressure range Nominal current Nominal power Nominal resistance 1-way valve for cold water <60 C 8 l/min 10% 0,2 - 10 bar 40 mA 8.8 VA 10% 3.8 k 10% Tubular heating element with NTC - sensor 230 +10%, -15% V 2050 W 5% 23.9 5% 152 <0.8 C mA BP P/(90 - 264) V 16 (4) A
35.9 9.8 6.6 4.6 3.2 2.3 1.1
k 5.8% k 3.7% k 3.1% k 2.6% k 2.0% k 2.5% k 3.7%

mmWc mmWc

4 (4) 16 (4) 1 (1)

mA A A

Drain pump (synchronous) Type Nominal/max. current Nominal power Rotation speed Resistor (coil) (25 C) Capacity Position of draining hose outlet min. max. Control board Type Timer basic Timer programmed Motor
07.11.2006 / Page 3 Doc. No: 26957
Drum up sensor 68882/292079 0.3/0.5/ A 0.2/0.22 A 30/26 W 3000 rpm 164/ 7% 224 5% l/min 0.9 1.25 m m Nominal voltage Nominal current Poles Resistance Connection Distrubution actuator Motor: Nominal voltage 230 +10% -15% V Nominal current mA Nominal resistance (20 C) 6.5 k 10% Contacts: Nominal current Nominal voltage Display module Type DM LCDE WH03 TL OM 5 V DC 0,5 mA m Wires + RAST 2.5

OMEGA 751 54431

Type Belt ratio
MCA 52/64 - 148/ALE i = 1:13.3 7% 7% 7% 7% W 7% W 7% W 10% W 10%
12NC Programs Push button switch Favorites Easy ironing Eco Pre wash Intensive rinse Rinse hold Selector Temperature +/Spin/Start delay
Resistance contacts (20 C) Stator (full eld) 2.17 Stator (tapped eld) 1.35 Rotor 1.90 Tachogenerator 68.70 Input power (230 V AC) Washing Rinsing Spinning (full eld) Spinning (tapped eld)

320 400

Radio interference supression Rated voltage Rated current Frequency Nominal capacity Nominal inductance Nominal resistance Derivation current (u = 250 V AC) 90 - 250 V 16 A 50/60 Hz 680 nF X1 + 2 x 22 nF Y 20% 2x1 mH-30+50% 680 k 10% 4.15 (2 x 2.075) mA
07.11.2006 / Page 4 Doc. No: 26957

Spare part list

Model Service No. Version Pos. No. 12NC Code 28393 AWE 859397210057 Description Flap round GW Hinge ap GW Drip tray assy Door frame inner, soft opening GW Frame lid outer MH/RFI GW Foot Trolley kit front Foot adjustable rear Front panel GW Side panel right GW Side panel left GW Rear panel Hinge bolt lid GW Counter weight left Counter weight right Shock absorber Stopper Pin f. Shock absorber Damper f. Shock absorber Lid outer GW Lid inner+hook+spring GW Lid cpl. WH/MH GW Handle cpl. WH/MH GW Hook f. Lid GW Door bellow Strap f. Doorbellow Seal Tub f.Drum latch Cover f. Tub Drum soft op. 210mm Kit latch f.drum Drum lifter Drum lifter 54 mm with weight Belt PV 1236 J4 EL Pulley with fastener Gasket Control panel AWE 9725 Insert panel Knob timer EBL Button Start GW Button option with LED GW Button option GW Button temperature Button spinning Display Module 1400 Motor MCA 52/64-148 ALE Interf.lter 1,00 F Holder RFI Pump,draining Heating element 2050W, 230V + NTC Cable mains 2m SA Strain relief Control board OMEGA, programmed Actuator f. Distribution Valve magnet Pos. No. 12NC Code Description Cover f. valve Pressostat single EATON Drum up OMEGA Door lock Sensor NTC SC1,OMEGA3 Hose inlet EN 11770 Reex Hose VALVE-DISPENSER Nozzle box cold cpl. Clamp f. nozzle box Siphon f. softener Siphon f. bleach Clip SOAP DISPENSER Soap dispenser cpl. 4 ch. Distributor System Chamber,air Drainhose Lock eco Filter set pump Hose draining Hose Pressostat Hose Exhaust W/O hole Sponge Gasket Airtrap Clamp hose Clamp to pump Holder Hose Clamp hose Pin Clamp top frame Clamp hose drain hose Screw,selftap 3,5x14SS Screw 4x14 Screw Screw 7x18 Screw M8X 35 Nut Push in M 8 Washer Torsions spring Spring Spring f. Lever Bearing,ball 6203 2Z C3 Bearing,ball kit Shaft seal Ring counterface O-Ring Cover f. Motor Bow Clamp heatingelement+screw