Instruction Manual

UltimaSwitch

12/24 V

IB-116 R01 (0502)
The UltimaSwitch is a highly reliable solid state switch which uses no moving mechanical parts or toxic mercury to sense water level and automatically controls a 12V DC or 24V DC bilge pump. The UltimaSwitch automatically adjusts between a 12V DC and 24V DC bilge pump without any adjustments necessary.

Security

Connect an in-line fuse of the appropriate amperage (specied on the pump) Always install the switch according to the wiring diagram on pages 22-25. The wire connections must be sealed with a marine sealant. Insulation of cable sheathings must be placed above the highest bilge water level. The UltimaSwitch is designed for 12 and 24V DC operation only. Do not use any other voltages; do not use AC or AC-DC converted power sources. Failure to use the appropriate fuse and connecting wires according to the instructions provided will void any Johnson Pump warranty and may cause serious damage or personal injury.

Type designation

V DC Max Amp draw 12/24 V 20 A

Part No 34-36303

Operation
See illustration on page 21 1. When the bilge water rises and reaches the second detector cell at 50 mm (2) the switch starts the pump, with a 3 second delay. 2. When the water level has sunk to a level of 20 mm ("), and the rst detector cell is above the water level, the pump is stopped.

Installation

The UltimaSwitch is designed to attach to all Johnson Pump bilge pumps. Just snap in on the T-slot on the base of the pump. When using it with other pump brands, or when installing the switch stand alone please follow these instructions: Mount the UltimaSwitch in a vertical position (mount holes towards the bottom of the vessel), and close to the pump, such that the water level is equal on both pump and the UltimaSwitch. Do not screw the UltimaSwitch directly to the hull of the boat. Either glue the switch to the hull or use a mounting block of marine plywood epoxy glued to the bottom of the hull to fasten the UltimaSwitch.
The bottom of the UltimaSwitch can be mounted higher than the pump, but never lower than the base of the pump.
To test the functionality of the UltimaSwitch hold two ngers over the raised circular areas on the side for approximately 10 seconds. If the wiring is correct the bilge pump will activate. If you remove a nger from the top circle the pump should still be on. On removal of both ngers from the circles, the bilge pump should no longer run after a short delay. Make sure to test the UltimaSwitch with water in the bilge of the vessel to re-afrm that the pump will turn on and off properly.
Electrical installation Warranty
See wiring diagram on page 22-25 Your UltimaSwitch is covered by a 3-year limited warranty
Elektrisk intsallation med Johnson Pump panel Electrical installation with Johnson Pump Panel Elektrischer Anschluss mit Johnson Pump Schalttafel Schma de raccordement avec le tableau de commande Johnson Pump Instalacin elctrica con panel Johnson Pump Schema collegamento elettrico con pannello di controllo Johnson Pump
Panel Panel Schalttafel Tableau de commande Panel Pannello Batteri DC supply DC-Versorgung Batterie Batera Batteria
Lnspump Bilge pump Bilgenpumpe Pompe de cale Bomba de sentina Pompa di sentina
Brun, nr 2 Brown, No 2 Braunes, Nr. 2 Marron, No 2 Marrn, No 2 Marrone, No 2
Brun (+) Brown (+) Braunes (+) Marron (+) Marrn (+) Marrone (+)
Brun/vit, nr 1 Brown/white, No 1 Braunes/weiss, Nr. 1 Marron/blanc, No 1 Marrn/blanco, No 1 Marrone/blanco, No 1 Svart (-) Black (-) Schwarz (-) Noir (-) Negro (-) Nero (-)
Obs: Dessa kablar r redan anslutna Note: These cables are already connected Wichtig: Kabeln schon angeschlossen Important: Ces cbles sont dj raccords Advertencia: Estos cables ya van conectados Nota Bene: Questi cavi sono gi collegati
Elektrisk intsallation utan panel Electrical installation without panel Elektrischer Anschluss ohne Schalttafel Schma de raccordement sans tableau de commande Instalacin elctrica sin panel Schema collegamento elettrico senza pannello di controllo
Lnspump Bilge pump Bilgenpumpe Pompe de cale Bomba de sentina Pompa di sentina Skring Fuse Sicherung Fusible Fusible Fusibile
Batteri DC supply DC-Versorgung Batterie Batera Batteria
Brun, nr 2 Brown, No 2 Braunes, Nr. 2 Marron, No 2 Marrn, No 2 Marrone, No 2 Brun/vit, nr 1 Brown/white, No 1 Braunes/weiss, Nr. 1 Marron/blanc, No 1 Marrn/blanco, No 1 Marrone/blanco, No 1
Svart (-) Black (-) Schwarz (-) Noir (-) Negro (-) Nero (-)

Qualittsuhren seit 1925 Made in Germany
Erich Lacher Uhrenfabrik Rastatter Strae Pforzheim, Germany Telefon +49 (0) 72 31/15 75-0 Fax +49 (0) 72 31/15 75-11 info@laco.de, www.laco.de Made in Germany
FLIEGER 05/09; Technische nderungen vorbehalten; Subject to technical changes

FLIEGERUHREN

DIE ZEIT IST DAS, WAS WIR DARAUS MACHEN. TIME IS WHAT WE MAKE OF IT.
Mit sehr viel Liebe zum Detail wurde die Laco Fliegeruhr nach dem historischen Original entworfen. Przise, robust und gut ablesbar waren Beobachtungsuhren fr die Fliegerei der 30er und 40er Jahre unerlsslich. Heute, wie damals, sind sie ein verlsslicher Begleiter durch alle Zeit. The contemporary Laco Pilot Watch was designed according to the historic original, taking into account even the smallest detail. Thanks to its high precision, its massive case and its clear dial design the observation watch was an essential instrument in the aviation of the 1930s and 1940s. Today as in the past it is a most reliable companion.
Der Oktant und die Fliegeruhr waren unerlliche Werkzeuge zur Navigation in der Fliegerei.
The Pilot Watch and the Octant were essential tools for navigation in previous aviation.
PERFEKTE LIAISON AUS FUNKTION UND DESIGN. PERFECT COMBINATION OF FUNCTION AND DESIGN.
Die khle Eleganz der Technik und optimale Funktionalitt kennzeichnen die Laco Fliegeruhr. Hchste Przision durch erstklassige Schweizer Uhrwerke garantiert die Qualitt. Die Gestaltung der historischen Beobachtungsuhr folgte klaren Anforderungen. Die heute von uns gefertigten Fliegeruhren verbinden das klassische Design von damals mit den hchsten technischen Ansprchen moderner Uhrmacherkunst. Technical elegance and optimal functions are the distinguishing features of the Laco Pilot Watch. Absolute precision provided by first-class Swiss movements guarantees highest quality. The design of the historic observation watch always had to meet high requirements. Our pilot watches of today combine the classic design of that time with the highest technical standards of the contemporary watchmaking handicraft.
Automatik Ref. 861636, : 36 mm Quarz Ref. 861467, : 36 mm
Automatik Ref. 861637, : 36 mm Quarz Ref. 861641, : 36 mm
Gut ablesbares Zifferblatt mit Leuchtziffern und -zeigern, Striche fr Minuten und Sekunden.
Easy to read dial with luminous hands and luminous minute and hour marks.
Ref. 861636 Automatik Satiniertes Edelstahlgehuse, Durchmesser 36 mm, Hhe 12.50 mm, gewlbtes, entspiegeltes Saphirglas, bis 5 ATM wasserdicht; Anzeige von Stunde, Minute und Zentralsekunde, Schweizer Automatikwerk ETA 2824-2 und braunes Kalbslederband. Preis: Euro 490,00 Ref. 861467 Quarz mit massivem Edelstahlboden Durchmesser 36 mm, Hhe 8.50 mm, Schweizer Quarzwerk Ronda 515 Preis: Euro 300,00 Ref. 861636 Automatik Stainless steel case satin finished, diameter 36 mm, height 12.50 mm, domed sapphire crystal (non-reflecting), water resistant up to 5 ATM; display of hour, minute and centre second, Swiss automatic movement ETA 2824-2 and brown calf leather strap. Price: Euro 490,00 Ref. 861467 Quartz with solid steel back Diameter 36 mm, height 8.50 mm, Swiss Ronda Quartz movement 515 Price: Euro 300,00
Ref. 861637 Automatik Satiniertes Edelstahlgehuse, Durchmesser 36 mm, Hhe 12.50 mm, gewlbtes, entspiegeltes Saphirglas, bis 5 ATM wasserdicht; Anzeige von Stunde, Minute und Zentralsekunde, Schweizer Automatikwerk ETA 2824-2 und braunes Kalbslederband. Preis: Euro 490,00 Ref. 861641 Quarz mit massivem Edelstahlboden Durchmesser 36 mm, Hhe 8.50 mm, Schweizer Quarzwerk Ronda 515 Preis: Euro 300,00 Ref. 861637 Automatik Stainless steel case satin finished, diameter 36 mm, height 12.50 mm, domed sapphire crystal (non-reflecting), water resistant up to 5 ATM; display of hour, minute and centre second, Swiss automatic movement ETA 2824-2 and brown calf leather strap. Price: Euro 490,00 Ref. 861641 Quartz with solid steel back Diameter 36 mm, height 8.50 mm, Swiss Ronda Quartz movement 515 Price: Euro 300,00
Edelstahlgehuse, Saphirglas, verschraubter Edelstahlboden. Stainless steel case, sapphire crystal, screwed case back.
Die edle Verpackung fr unsere Fliegeruhren, inclusive Ersatzband. The noble packaging for our pilot watches, including a spare strap.
Automatik Ref. 861465, : 42 mm Quarz Ref. 861466, : 42 mm
Ref. 861465 Automatik Satiniertes Edelstahlgehuse, Durchmesser 42 mm, Hhe 13 mm, gewlbtes, entspiegeltes Saphirglas, Saphirglasboden, bis 5 ATM wasserdicht; Anzeige von Stunde, Minute, Zentralsekunde und Datum, Schweizer Automatikwerk ETA 2824-2, Kalbslederband in braun. Preis: Euro 490,00 Ref. 861466 Quarz mit massivem Edelstahlboden Durchmesser 42 mm, Hhe 13 mm, Schweizer Quarzwerk Ronda 515 Preis: Euro 350,00 Ref. 861465 Automatic Stainless steel case satin finished, diameter 42 mm, height 13 mm, domed sapphire crystal (non-reflecting), sapphire display back, water resistant up to 5 ATM; display of hour, minute, centre second and date, Swiss automatic movement ETA 2824-2, and brown calf leather strap. Price: Euro 490,00 Ref. 861466 Quartz with solid steel back Diameter 42 mm, height 13 mm, Swiss Quartz movement Ronda 515 Price: Euro 350,00

Ref. 861464, : 42 mm

Ref. 861463, : 42 mm

Ref. 861462, : 42 mm

Ref. 861463 Quarz Chronograph Satiniertes Edelstahlgehuse, Durchmesser 42 mm, Hhe 13 mm, gewlbtes, entspiegeltes Saphirglas, bis 5 ATM wasserdicht; Anzeige von Stunde, Minute, kleiner Sekunde, Datum und Stoppuhr, Schweizer Quarzwerk und braunes Kalbslederband. Preis: Euro 450,00
Ref. 861463 Quartz Chronograph Stainless steel case satin finished, diameter 42 mm, height 13 mm, domed sapphire crystal (non-reflecting), water resistant up to 5 ATM; display of hour, minute, small seconds, date and chronograph, Swiss quartz movement and brown calf leather strap. Price: Euro 450,00
Ref. 861464 Handaufzug Satiniertes Edelstahlgehuse, Durchmesser 42 mm, Hhe 13 mm, gewlbtes, entspiegeltes Saphirglas, Saphirglasboden, bis 5 ATM wasserdicht; Anzeige von Stunde, Minute und kleiner Sekunde, Schweizer Handaufzugwerk Unitas 6498, Kalbslederband in braun. Preis: Euro 690,00 Ref. 861464 Manual Winding Stainless steel case satin finished, diameter 42 mm, height 13 mm, domed sapphire crystal (non-reflecting), sapphire display back, water resistant up to 5 ATM; display of hour, minute and small seconds, Swiss manual winding movement Unitas 6498, brown calf leather strap. Price: Euro 690,00
Ref. 861462 Automatik Chronograph Satiniertes Edelstahlgehuse, Durchmesser 42 mm, Hhe 16 mm, gewlbtes, entspiegeltes Saphirglas, Saphirglasboden, bis 5 ATM wasserdicht; Anzeige von Stunde, Minute, kleiner Sekunde, Datum und Stoppuhr, Schweizer Automatik-Chronogaphenwerk Valjoux 7750 und braunes Kalbslederband. Preis: Euro 1.200,00 Ref. 861462 Automatic Chronograph Stainless steel case satin finished, diameter 42 mm, height 16 mm, domed sapphire crystal (non-reflecting), sapphire display back, water resistant up to 5 ATM; display of hour, minute, small seconds, date and chronograph, Swiss automatic chronograph movement Valjoux 7750 and brown calf leather strap. Price: Euro 1.200,00
Die Laco Replika bieten wir in 2 Varianten an: mit und ohne Innenkreis auf dem Zifferblatt.
We are offering the Laco Replica in 2 versions: with and without inner circle on the dial.
DER REIZ DES BESONDEREN. THE CHARM OF THE EXTRAORDINARY.
Im Jahr 2005, dem 80-jhrigen Firmenjubilum, wurde der Plan gefasst, das Laco-Prunkstck neu aufleben zu lassen und eine Replika der Original Fliegeruhr von 1942 zu bauen: In der ursprnglichen Gre, mit detailgetreuem Blatt, Gehuse, Zeigern und einem dem Original nachempfundenen Lederband. Das limitierte Liebhaberstck (500 Stck) ist mit hochwertigem Saphirglas und einem veredelten Schweizer ETA-Werk A07.111 versehen. In the year 2005, the 80th anniversary of the firm, the plan was made to revive the show-piece of Laco and to build a replica of the original pilot watch of 1942: In the original dimensions, with every detail of the dial, casing and hands equal with the original, and with a leather strap resembling the original. The limited edition (500 pieces) of this collectors watch is equipped with a high quality sapphire crystal and a Swiss ETA movement A07.111 with special finish.