FITTING INSTRUCTION
Clamp mark in acc. with ISO PN 1 L 2 + 4 R 5 58R 7 58L Cables joining Left directional lights Rear fog lights Ground Right directional lights Right side parking lights Stoplights Left side parking lights
The instruction of the assembly

M12x1,25x35

Disassemble the bumper. Cut out the fragment of the bumper as shown on the fig. 2.

M12x75 M12x35

4 Fig. 2

M12x35 M12x1,25x35

Fig. 1
This towbar is designed to assembly in following cars: MITSUBISHI GRANDIS, produced since 2004, catalogue no. Z34 and is prepared to tow trailers max total weight 1800 kg and max vertical load 85 kg.
Get lower the back muffler from handles. Unscrew the factory towing eye - will not be assembled again. Fix the main bar of the towbar (pos. 1) to the bottom of the chassis member using bolts M12x1,25x35mm (pos. 8) loosely. 6. Fix left bracket (pos. 5) to the left chassis member and right bracket (pos. 4) to the right chassis member using bolts M12x1,25x35mm (pos. 8) and fix to the main bar of the towbar (pos. 1) using bolts M12x35mm (pos. 7). 7. Install the bumper and hang up the muffler. 8. Fix tow-ball (pos. 2) with socket plate (pos. 3) using bolts M12x75mm (pos. 6) from accessories. 9. Tighten all bolts according to the torque shown in the table. 10. Connect electric wires of 7-poles socket according to the instruction of the car. (Recommend to make at authorized service station). 11. Complete paint layer damaged during installation.

3. 4. 5.

Torque settings for nuts and bolts (8,8): M 8 - 25 Nm M 10 - 55 Nm M 12 - 85 Nm M 14 - 135 Nm

From manufacturer

Thank you for buying our product. Their reliability has been confirmed in many tests. Reliability of towbar depends also on correct assembly and right operation. For this reasons we kindly ask to read carefully this instruction and apply to hints. The towbar should be install in points described by a car producer.
After install the towbar you should get adequate note in registration book (at authorised service station).The car should be equipped with: Indicators Tow mirrors After 1000km check all bolts and nuts. The ball of towbar must be always kept clear and conserve with a grease.

Towbar accessories:

PPUH AUTO-HAK S.J.
Produkcja Hakw Holowniczych Henryk & Zbigniew Nejman 76-200 SUPSK ul. Soneczna 16K tel/fax (059) 8-414-414; 8-414-413 E-mail: office@autohak.com.pl www. autohak.com.pl
Towing hitch (without electrical set)

Class: A50-X

Cat. no. Z34
Designed for: Manufacturer: MITSUBISHI Model: GRANDIS produced since 2004
Technical data: D-value: 9,81 kN maximum trailer weight: 1800 kg maximum vertical cup load: 85 kg
Approval number according to Directive 94/20/EC: e20*94/20*0074*00

Foreword

This towbar is designed according to rules of safety traffic regulations. The towing hitch is a safety component and can be install only by qualified personnel. Any alteration or conversion of the towing hitch is prohibited and would lead to cancellation of design certification. Remove insulating compound and underseal from vehicle (if present) in the area of the matting surfaces of the towing hitch. The vehicle manufacturers specifications regarding trailer load and max. vertical cup load are decisive for driving whereat values for the towing hitch cannot be exceeded. D-value formula: Max trailer weight [kg] x Max vehicle weight [kg] Max vehicle weight [kg] X 9,81 = 1000

www.mitsubishi-cars.co.uk

Page 1 of 3

MITSUBISHI GRANDIS SPECIFICATION
2.4 MIVEC Classic Manual 18,499.00 OTR

ENGINE/ELECTRICS

Engine type Fuel system Displacement cc Bore/stroke mm Compression ratio Max. output kw (bhp) at rpm Max. torque Nm (lb.ft) at rpm Alternator V/A 2.4 Litre 16-valve SOHC (4G69) MPI with MIVEC (Mitsubishi Innovative Valve Timing Electronic Control) x 100 9.5 121(162)/6000 217(159)/4000 12/110
PERFORMANCE DATA/FUEL/CONSUMPTION/EMISSIONS
Maximum speed mph (kph) Acceleration 0-62 mph secs Fuel type Urban mode lts/100km (mpg) Extra urban mode lts/100km (mpg) Combined mode lts/100km (mpg) CO2 emissions g/km 124 (200) 10 Unleaded 12.8 (22.1) 7.4 (38.2) 9.4 (30.1) 223

SUSPENSION AND STEERING

Front axle Rear axle Brakes Front Rear Steering Min. turning circle m (ft) Tyres Wheels McPherson Strut Coil Springs with Stabilizer Bar Semi-Trailing Arm Coil Springs with Stabilizer Bar ABS System with EBD 11.42" Ventilated Disc Brakes (2-pot) 7.48" Solid Drum-in-Disc Brakes Rack & Pinion, Power Assisted 11.6 (38.06) - 17" Wheels 215/55R17 94V 17x7JJ Alloy

DRIVELINE

Type Clutch Clutch Manual Transverse Engine Front/Front Wheel Drive Single, Dry with Diaphragm Spring Hydraulic Operation

TRANSMISSION

http://www.mitsubishi-cars.co.uk/grandis/printpages/specification_prn.asp?strCar1=XA1&. 6/14/2004

Page 2 of 3

Transmission Manual Gear ratios 1st 2nd 3rd 4th 5th Reverse Final gear ratio
Manual 5 Speed Manual 3.583 1.947 1.266 0.970 0.767 3.363 4.312

DIMENSIONS

Cargo room length x width x height, min. Cargo room length x width x height, max. Cargo capacity min. lts VDA (cu.ft.) Cargo capacity max. lts VDA (cu.ft.) Exterior length x width x height mm Ground clearance (unladen) mm Front mm Rear mm Wheelbase mm 440 x 1260 x x 1520 x (11.30) 1545 (54.55) 4765 x 1795 x 2830

WEIGHTS/VOLUMES

Seating capacity Fuel tank capacity lts (imp.galls) Gross vehicle weight kg (lbs) Kerb weight kg (lbs) Braked kg (lbs) (14.3) 2250 (4961) 1645 (3627) 1600 (3528)
SERVICING/INSURANCE/WARRANTY
Service intervals Vehicle Excise Duty (VED) band Warranty Every 9,000 miles or 12 months, whichever occurs first D 3 years unlimited mileage warranty, 6 years anti-corrosion perforation warranty 3 years pan-European roadside Home and accident assistance
OPT - Option at additional cost DFO - Dealer Fitted Option at additional cost - Standard Feature on this model The Commercial Vehicle on the Road Price (CVOTR) quoted for commercial vehicles excludes VAT, but includes the cost of delivery to the dealer's premises, number plates, Government road fund licence for 12 months, and DVLA vehicle first registration fee of 38.00. The right is reserved to change prices and specifications without prior notice. This price list supersedes all previous issues. The On The Road Price (OTR) includes the cost of delivery to the dealer's premises, number plates and VAT @ 17.5%, along with Government road fund licence for 12 months, and DVLA vehicle first registration fee of 38.00.

Page 3 of 3

While we have made reasonable attempts to ensure the information contained in this website has been obtained from reliable sources, we are not responsible for any errors or omissions. All information in this website is provided to you without any guarantee of completeness, accuracy, timeliness and without warranty of any kind, expressed or implied.